WM SYSTEMS WM-E LCB IoT Load Control switch

ZOTHANDIZA

• Magetsi - Kuyika kwamagetsi a AC, 2-pini terminal block
• Relay 1..2 - relay latching, 16A 250V AC, masinthidwe amitundu: NO, NC, COM, terminal block
• Relay 3..4 - relay latching, 16A 250V AC, switch mode: NC, COM, terminal block
• Zolumikizira za RJ45:
  • Efaneti - 10/100MBit, doko la RJ45, ndi chingwe cha UTP Cat5
  • RS485 - pazida zakunja ndi chingwe chooneka ngati Y
  • P1 mawonekedwe - anzeru mamita ndi chingwe chooneka ngati Y
• LED1..LED4/WAN - Mawonekedwe a LED
• SIM - Kankhani kagawo ka SIM khadi (mini SIM, lembani 2FF) kagawo kakang'ono ka SD khadi - pama memori khadi (max. 32 GByte)
• Internal LTE Antenna - zomatira, zokwera pamwamba

TSOPANO & NTCHITO / ZOGWIRITSA NTCHITO

• Mphamvu yamagetsi: ~ 100-240V AC, +10% / -10%, 50-60Hz +/- 5%
• Kugwiritsa ntchito: Zochepa: 3W / Avereji: 5W / Max: 9W (0.25A)
• Zosankha zamagawo am'manja:
  • LTE Cat.1: Telit LE910C1-EUX (LTE Cat.1: B1, B3, B7, B8, B20, B28A / 3G: B1, B3, B8 / 2G: B3, B8)
  • LTE Cat.M / Cat.NB: Telit ME910C1-E1 (LTE M1 & NB1 B3, B8, B20)
• Kutentha kwa ntchito / kusungirako: pakati pa -40'C ndi +85'C, 0-95% rel. chinyezi
• Kukula: 175 x 104 x 60 mm / Kulemera: 420gr
• Pansi: Pulasitiki ya IP52 ABS yokhala ndi chivundikiro chowonekera, imatha kukwera panjanji / mpaka khoma

  

SCHEMATIC FIGURE OF INTERFACES, PINOUT

CHENJEZO! OSALUMIKIZANI ~ 100-240V AC POWER SOURCE ku pigtail AC CONNECTOR (24) KAPENA NTCHITO YA MPHAMVU (12) YA CHIKWANGWANI mpaka simunathe ndi waya!
PAMENE ATATSULUKA ZOPHUNZITSIRA, ONANI NTHAWI ZONSE KUTI PCB SIKULUMIKIZANA NDI MPHAMVU SOURCE ndipo ma supercapacitors atopa (Zizindikiro za LED ZOSAVUTA) Musanakhudze PCB!

ZOCHITA ZOYENERA

1. Chotsani pulasitiki, chotchinga chapamwamba cha doko chowonekera (1) potulutsa wononga (3) pamwamba pa mpanda.
2. Tembenukirani mbali ya pulasitiki (1) mosamala m'munsi mwa tsinde (2), kenako chotsani chivundikiro chapamwamba (1).
3. Tsopano mutha kumasuka kulumikiza mawaya ndi zingwe kumadoko ndi zolumikizira. Mosamala tsegulani ndowe zapulasitiki (12) za mpanda wapansi (2) ndi screwdriver.
4. Tsopano maziko apulasitiki amatha kuwoneka ndi PCB (4) yosonkhanitsidwa mkati. Tsegulani PCB (4) ndikuchotsa pansi (2), kenako tembenuzani PCB mozondoka. Tsopano inu mukhoza kuwona pansi mbali ya PCB.
5. Ikani SIM khadi yaying'ono (yoyendetsedwa ndi APN) mu chosungira SIM (23). Onani chithunzi patsamba lotsatira: m'mphepete mwa SIM wodulidwa uyenera kulunjika ku PCB ndipo SIM chip imayang'ana pansi. Lowetsani ndikukankhira SIM mpaka itakhazikika (mumva kumveka phokoso).
6. Mutha kugwiritsa ntchito khadi ya Micro-SD ngati mukufuna (ngati mukufuna). Kenako ikani memori khadi mu kagawo kakang'ono ka SD khadi (22) ndikukankhira mpaka itamangidwa bwino.
7. Tsopano tembenuzani PCB ndikuyikanso m'munsi mwa mpanda (2).
8. Yang'anani pa PCB kuti chingwe cha LTE (16) chalumikizidwa ndi cholumikizira cha Mlongoti RF (15).
9. Bwezerani gawo lapamwamba la pulasitiki la ABS lochotseka kumunsi (2) - onetsetsani kuti mbedza (12) zikutseka.
10. Chitani mawaya malinga ndi zosowa - kutengera chithunzi cha schematic (pamwambapa).
11. Lumikizani ma AC power chord (AC pigtailed connector) mawaya (24) ku mapini awiri oyambirira (5) a chipangizocho (kuchokera kumanzere kupita kumanja): zakuda kupita ku N (neutric), zofiira mpaka L (mzere).
12. Lumikizani mawaya a relay unit (25) ya bokosi la kabati yowunikira mumsewu - pazotulutsa zofunikira (6).
    Dziwani kuti RELAY 1..2 ndi latching relays, zomwe zimathandiza NO, NC, COM kugwirizana ndi kusintha modes, pamene RELAY 3..4 kukhala ndi NC, COM kugwirizana ndi kusintha mode.
13. Lumikizani chingwe cha UTP chooneka ngati Y (27) - cha Efaneti / RS485 / P1 - kapena chingwe chachindunji cha UTP (26) - cha Efaneti chokha - kudoko la RJ45 (7) - malinga ndi zosowa. Mbali ina ya chingwe cha Efaneti iyenera kulumikizidwa ndi PC yanu kapena chipangizo chakunja chomwe mukufuna kulumikiza.
    Zindikirani, kuti mawaya a mawonekedwe a RS485 / P1 ndi mawaya oyimilira m'manja (28).

    

14. Lumikizani RS485 ku chipangizo chakunja. Mawonekedwe a P1 akupezeka polumikiza mita yamagetsi / modemu yanzeru.
15. Bweretsani chophimba chapamwamba cha pulasitiki chowonekera (1) kumunsi (2).
16. Chipangizocho chili ndi mitundu iwiri yokhazikika, yomwe imayenera kukwera njanji kapena kugwiritsa ntchito zomangira za 3-point ndi zomangira, kapena kugwiritsa ntchito mbedza (popachikidwa pakhoma / mu bokosi la kabati yowunikira).
17. Lumikizani magetsi a 100-240V AC ku cholumikizira cha pigtail cha chingwe chamagetsi cha AC (24) ndi gwero lamagetsi lakunja / pulagi yamagetsi.
18. Chipangizocho chili ndi dongosolo lokhazikitsidwa kale. Momwe chipangizochi chilili panopa chikuwonetsedwa ndi magetsi ake a LED (11).
    • NYAYA ZA LED - Onani Kukhazikitsa Buku kuti mudziwe zambiri.
    • REL.1: Relay#1 (mode: NO, NC, COM) SET/RESET zilipo
    • REL.2: Relay#2 (mode: NO, NC, COM) SET/RESET zilipo
    • REL.3: Relay#3 (mode: NC, COM) palibe pini ya RESET, SET yonyansidwa
    • REL.4: Relay#4 (mode: NC, COM) palibe pini ya RESET, SET yonyansidwa
    • LED ya WAN: pa intaneti (ntchito ya LAN/WAN)
      Zindikirani, kuti chipangizocho chili ndi gawo la supercapacitor mkati, lomwe limapereka kutseka kotetezeka ngati kuli ndi mphamvutage. Pankhani ya mphamvu utage - chifukwa cha supercapacitors - ali ndi mphamvu zokwanira kuti apereke kutsekedwa kotetezeka ndi kutsekedwa (ma supercapacitors asanathe).
      Supercapacitor imatha kutopa pambuyo pa outage kapena ngati mumasunga chipangizo kwa miyezi popanda kulumikiza mphamvu. Iyenera kulipitsidwa musanaigwiritse ntchito

      

KUYAMBIRA CHIDA

1. Mukayika mphamvu pa chipangizocho, recharge ya supercapacitor idzayambika yokha. Dongosolo la chipangizocho lidzayamba kokha pambuyo pomaliza kulipira.
2. Lumikizani chingwe cha Efaneti (UTP) pakati pa mawonekedwe a chipangizocho cha RJ45 kapena adaputala yake yooneka ngati Y ndi doko la Efaneti la PC yanu. (Chida cha RS485 chiyenera kulumikizidwa ndi doko lina la chingwe chofanana ndi Y.)
3. Konzani mawonekedwe a Efaneti pa PC yanu ya protocol ya TCP/IPv4 kuti mukhazikitse IP adilesi: 192.168.127.100 ndi subnet mask: 255.255.255.0
4. Yambitsani chipangizocho powonjezera mphamvu ya AC kuzinthu zamagetsi (5).
5. Ma LED onse anayi adzakhala opanda kanthu kwa masekondi angapo - ake abwino. (Ngati chipangizocho sichinagwiritsidwe ntchito kuyambira nthawi yayitali, ma supercapacitor ayenera kulipiritsidwa ma microcontroller asanayambe chipangizocho.)
6. Pambuyo pa masekondi angapo kokha WAN LED idzakhala ikuwunikira mosalekeza ndi wofiira mpaka ma supercapacitors adzayimbidwa (chipangizocho sichinayambe). Zitha kutenga pafupifupi mphindi 1-4.
7. Malire akamaliza, chipangizocho chidzayambika. Idzasindikizidwa ndi kuunikira kofiira kwa ma LED onse a relay (REL.1..4) kwa masekondi a 3 ndi WAN LED yomwe ikuwunikira ndi zobiriwira posachedwa. Izi zikutanthauza kuti chipangizocho chayambika.
8. Posachedwapa, pamene WAN LED idzakhala yopanda kanthu ndipo ma LED onse a relay (REL.1..4) adzakhala akuwunikira mosalekeza ndi wofiira *, zikutanthauza kuti chipangizochi chikuyambanso. Zimatenga pafupifupi mphindi 1-2.*Kumbukirani, ngati mwalumikiza kale chingwe chopatsirana, chimenecho chidzasaina momwe mawotchiwo alili panopa ndi malo ake oyenera (ofiira amatanthauza KUZIMITSA, njira zobiriwira zayatsidwa).
9. Kumapeto kwa ndondomeko ya boot chipangizochi chikhoza kufika pazitsulo zake (LAN ndi WAN) ngati zidakonzedwa kale. Ngati mawonekedwe a netiweki apano alipo, amasainidwa ndi chizindikiro cha WAN LED.
10. Chipangizocho chikapezeka pa mawonekedwe a LAN okonzedwa, WAN LED idzaunikira mosalekeza ndi zobiriwira. (Ngati ikunyezimira mwachangu, imasainira zochitika zapaintaneti pamawonekedwe.)
    • Pamene mawonekedwe a WAN anali atakonzedwa kale, ndi APN yolumikizidwa, WAN LED idzawunikira ndi kufiira. (Ngati ikuthwanima mwachangu, imawonetsa zochitika zapaintaneti.)
    • Ngati LAN ndi WAN zilipo, WAN LED idzagwira ntchito ndi bi-color (yofiira NDI yobiriwira nthawi imodzi), mwachiwonekere ndi yachikasu. Zowunikira zowunikira pa netiweki.

KUSINTHA CHIDA

1. Tsegulani chipangizo chapafupi webtsamba mu msakatuli wa Mozilla Firefox, pomwe zokhazikika web mawonekedwe ogwiritsa ntchito (LuCi) pa doko la Ethernet ndi: https://192.168.127.1:8888
2. Lowani ndi Username: root , Password: wmrpwd ndikukankhira ku Lowani batani.
3. Konzani makonda a APN a SIM khadi: tsegulani menyu Network / Interfaces, mawonekedwe a WAN, Sinthani batani.
4. Lembani SIM #1 APN (APN seti ya SIM khadi yanu). Ngati muli ndi PIN code pa SIM khadi yomwe mukugwiritsa ntchito, onjezani PIN yolondola apa. (Funsani Opaleshoni Yanu Yam'manja.)
5. Dinani pa Save & Ikani batani kuti musunge zosintha ndikusintha gawo la ma cellular. Posachedwa (~ masekondi 10-60) gawo la ma cellular lidzakonzedwa potengera zosintha zatsopano.
6. Ndiye chipangizo adzayesa kulumikiza ndi kulembetsa SIM kwa maukonde. Kupezeka kwa netiweki yam'manja kudzasainidwa ndi WAN LED (kuwalitsa / kung'anima ndi zobiriwira - pamodzi ndi Efaneti LED, apperently yellow (red + wobiriwira LED ntchito pa nthawi yomweyo). idzakhala ndi kuchuluka kwa data pamawonekedwe a WAN - onani pamitengo ya Rx/Tx.view menyu, Gawo la Network kuti mumve zambiri.
7. Kuti mukonze makonda a RS485, werengani Buku Logwiritsa Ntchito.

ZOKHUDZA NDI THANDIZO

Zolembazo zitha kupezeka pazogulitsa webtsamba: https://m2mserver.com/en/product/wme-lcb/
Ngati mukufuna chithandizo chamankhwala, funsani thandizo lathu pa iotsupport@wmsystems.hu imelo kapena onani thandizo lathu webwebusayiti kuti mupeze mwayi wolumikizana nawo chonde: https://www.m2mserver.com/en/support/

Chogulitsachi chimakhala ndi chizindikiro cha CE malinga ndi malamulo aku Europe.
Chizindikiro cha bin chodutsa chimatanthawuza kuti chinthucho kumapeto kwa moyo wake chiyenera kutayidwa ndi zinyalala zapakhomo mkati mwa European Union. Ingotayani zinthu zamagetsi/zamagetsi munjira zosiyanasiyana zosonkhanitsira, zomwe zimathandizira kubwezeretsanso ndi kukonzanso zinthu zomwe zili mkatimo. Izi sizikutanthauza mankhwala okha, komanso zipangizo zina zonse zolembedwa ndi chizindikiro chomwecho.

Zolemba / Zothandizira

WM SYSTEMS WM-E LCB IoT Load Control switch [pdf] Kukhazikitsa Guide WM-E LCB IoT Load Control switch, WM-E LCB, IoT Load Control switch, Load Control switch, Control switch, switch

Maumboni

• Buku Logwiritsa Ntchito