iControls ROC-2HE-UL Reverse Osmosis System Controller

MAZANO

Mauya.
Ndatenda nekutenga iControls controller.

Iwe wakaita sarudzo yakanaka pakusarudza iControls. Unogona kutarisira makore ebasa risina dambudziko. Iine dhizaini yakavakirwa pamhinduro kubva kuvatungamiriri vari mumunda weRO pamwe neruzivo rwedu pachedu muRO system dhizaini nekugadzira, iControls RO controllers inonyatso mukirasi.

Kunyangwe zvakanaka sevatongi vedu, pane nguva dzose nzvimbo yekuvandudza. Kana uine ruzivo, pfungwa kana kuisa zvakanaka kana zvakaipa tinoda kunzwa kubva kwauri. Zvakare, ndatenda nekutenga kwako. Kugamuchirwa kunharaunda yevashandisi veiControls.

David Spears Mutungamiri, iControls Technologies Inc. david@icontrols.net

Inputs

• Tank level switches: (2) Kazhinji-Yakavharwa. Inogona kushandiswa ne single level switch.
• Inlet pressure switch: Kazhinji-Vhura.
• Pretreat Lockout switch: Kazhinji-Vhura
  Iyo Tangi, Yakaderera Kudzvanya uye Pretreat zvinopinza ndeye 50% duty cycle square wave, 10VDC peak @ 10mA max. The switch inputs are dry contacts chete. Kushandisa voltage kune aya materminal achakuvadza mutongi.
• Controller Power: 110-120/208-240 VAC, 60/50Hz (Range: 110-240 VAC)
• Permeate Conductivity: 0-3000 PPM, 0-6000 µs (standard sensor, CP-1, K=.75)
• Feed Conductivity (kusarudza): 0-3000 PPM, 0-6000 µs (standard sensor, CP-1, K=.75)

Output Circuit Ratings

• Feed Solenoid: 1A. Voltage yakafanana nemota/supply voltage.
• Solenoid Flush: 1A. Voltage yakafanana nemota/supply voltage.
• Motokari: 1.0 HP/110-120V, 2.0 HP/208-240V.

Circuit Protection
Relay Fuse: F1 5x20mm 2 Amp  BelFuse 5ST 2-R
Cherechedza: Iyo fuse inoratidzwa pamusoro ndeyekudzivirira kwekuwedzera chete. Kudzivirirwa kwedunhu rebazi uye nzira dzekubvisa dzinofanirwa kupihwa kunze.
Ona Munda Wiring Dhiyagiramu yeDziviriro yeBazi Circuit.

Zvimwe
Dimensions: 7" kureba, 7" kufara, 4" kudzika. Nema 4X Polycarbonate Hinged Enclosure.
Kurema 2.6 lb.
Environment: etc..) 0-50°C, 10-90%RH (isina-condensing)

Simplified Schematic

Controller Overview

Mutongi Detail: CPU-4

Controller Detail: Terminal Board, TB-1 (Rev D2) (Ona mufananidzo 1 wechirongwa)

Conductivity Probe Installation

Controller Programming. Kuwana mamenu akavanzika

Controller Programming: Menu Navigation

Ichi chikamu view yemamenu emukati. Zvimwe zvinogadziriswa zvinhu zvinosanganisira: Mutauro, Alarm Inonzwika (ON/OFF), WQ Kurasika kweSiginari kuseta, Hardware & Firmware Version nezvimwe.

Controller Programming: ROC-2HE Chirongwa Sarudzo

Iyo controller ine 4 yakaparadzana mushandisi-inosarudzwa maseti ekugadzirisa iyo RO. Iyo fekitori de-fault marongero anoratidzwa pazasi. Zvirongwa zvakafanana kunze kwekusiyana kwemaitiro eku flush.

• Chirongwa 1, High Pressure flush.
• Chirongwa 2, Hapana Flush
• Chirongwa 3, Permeate Flush, (yakaderera kudzvinyirira, inlet valve yakavharwa)
• Chirongwa 4, Low Pressure, feed water flush
• Ona peji yapfuura kuti uwane mirayiridzo yekuti ungawana sei menyu yekusarudza zvirongwa izvi.
• Ona Appendikisi A kuti uwane tsananguro yakadzama yeParameters uye zvazvinoita pamashandiro eRO.

Aya maficha akaremara nekusagadzika nekuda kwekugona kwekuvhiringidzika kune chikamu chevashandisi vekupedzisira mumunda. Dzinogona kugoneswa kana dzichidikanwa kuburikidza neOEM PC programming interface iyo inobvumira shanduko kune ese emhando dzakaratidzwa pamusoro.

Controller Fault Condition Inoratidza

Pazasi pane exampzvinyorwa uye tsananguro dzezviratidziro zvinoperekedza mamiriro ekukanganisa anogoneka paCPU-4. Mamiriro emhosva anogara achiratidza dambudziko reimwe mhando inoda kugadzirisa. izvo zvinoratidzira zvinopa ruzivo rwakakwana kuti ucherechedze kunobva kukanganisa uye chinodiwa chekugadzirisa-chiito chekugadzirisa.

Low Pressure Fault: (Sitimu iri kupindura kune yakaderera kudzvanywa mamiriro pane masisitimu ehurongwa)

• Mutsara wechi1 "Service Fault"
• Mutsara wechi2 “Low Feed Pressure”
• Mutsara wechi3
• Mutsara wechi4 "Tangazve muMM: SS"

Pre Kurapa Mhosva: (Pretreat Switch yakavharwa ichiratidza dambudziko ne pretreat system).

• Mutsara 1 "Kukanganisa Kwebasa"
• Mutsara 2 "Pretreat"
• Mutsara wechi3
• Mutsara wechina "Tarisa Pretreat Sys."

Permeate Conductity Fault: (Permeate conductivity yakakwirira kupfuura alarm setpoint.)

• Mutsara wechi1 "Service Fault"
• Mutsara wechi2 “Permeate TDS xxx ppm” kana “Permeate Cond xxx uS”
• Mutsara wechi3 “Alarm SP xxx ppm” kana “Alarm SP xxx uS”
• Mutsara wechi4 "Kuti Reset Push Off/ON"

Feed Conductivity Fault: (Feed conductivity yakakwirira kupfuura alarm setpoint.)

• Mutsara wechi1 "Service Fault"
• Mutsara wechi2 “Feed TDS xxx ppm” kana “Feed Cond xxx uS”
• Mutsara wechi3 “Alarm SP xxx ppm” kana “Alarm SP xxx uS”
• Mutsara wechi4 "Kuti Reset Push Off/ON"

Conductivity Probe Error messages:

• Mutsara 2 "Kupindira" -Ruzha rwakaonekwa ne conductivity wedunhu, kuyerwa kwakasimba hakugoneke.
• Mutsara 2 "Over-range" -Kuyerwa kuri kunze kwechikamu chedunhu, probe inogona zvakare kupfupikiswa
• Mutsara 2 "Probe shorted" -Ipfupi redunhu yakaonekwa pane tembiricha sensor mune probe
• Mutsara 2 "Probe haina kuonekwa" - Vhura dunhu rinoonekwa pane tembiricha sensor mune probe (chena uye isina-yakadzivirirwa waya)
• Mutsara 2 "Probe Kutanga 1" – Chiratidzo chemukati voltage yakanyanyisa kuyera kuyerwa kwakanaka
• Mutsara 2 "Probe Kutanga 2" – Chiratidzo chemukati voltage yakaderera zvakanyanya kuita kuyerwa kwakakodzera
• Mutsara 2 "Probe Kutanga 3" – Makwiriro emukati voltage yakanyanyisa kuyera kuyerwa kwakanaka
• Mutsara 2 "Probe Kutanga 4" – Makwiriro emukati voltage yakaderera zvakanyanya kuita kuyerwa kwakakodzera

Appendix B. Controller Programming: Programming Interface Overview

Iyo Programming interface ndeye Windows-yakavakirwa chishandiso chekuita shanduko kuROC software. Iyi skrini inoratidza RO marongero aripo. Pane 4 field-selectable sets yezvirongwa zvakachengetwa muCPU-.4

Appendix C. Warranty

iControls Limited Warranty

Izvo waranti inovhara:
iControls inobvumira iyo ROC 2HE kuti ive isina hurema mune zvigadzirwa uye magadzirirwo panguva yehondo-ranty nguva. Kana chigadzirwa chikaratidza kuve chakaremara panguva yewaranti, iControls ichave yega sarudzo yekugadzirisa kana kutsiva chigadzirwa nechigadzirwa chakafanana. Chigadzirwa chinotsiviwa kana zvikamu zvinogona kusanganisira zvakagadziridzwa kana kugadziridzwa zvikamu kana zvikamu.

Inguva yakareba sei waranti inoshanda:
Iyo ROC 2HE inotenderwa kwerimwe (1) gore rezvikamu uye basa kubva pazuva rekutanga kutenga mutengi kana mwedzi gumi nemashanu kubva pazuva rechikepe, chero chinouya chekutanga.
Izvo waranti isingabatanidzi:

1. Kukuvadzwa, kuora kana kusashanda kunokonzerwa ne:
   • a. Tsaona, kushandisa zvisizvo, kuregeredza, moto, mvura, mheni kana zvimwe zviitiko zvechisikigo, gadziriso isina kutenderwa yezvigadzirwa kana kutadza kutevedzera mirairo inopihwa nechigadzirwa.
   • b. Gadzirisa kana kuedza kugadzirisa chero munhu asina mvumo neControls.
   • c. Chero kukanganisa kwechigadzirwa nekuda kwekutumira.
   • d. Zvinokonzera kunze kune chigadzirwa semagetsi emagetsi kuchinja.
   • e. Kushandiswa kwezvinhu kana zvikamu zvisiri kusangana neControls 'zvakatemwa.
   • f. Normal kupfeka uye kubvarura.
   • g. Chero chimwe chikonzero chisingaenderane nekuremara kwechigadzirwa.
2. Mari yekufambisa inodiwa kuti uwane sevhisi pasi pewaranti iyi.
3. Basa kunze kwebasa remufekitari.

Nzira yekuwana sevhisi

1. Kuti uwane sevhisi yewaranti, bata iControls yeReturn Material Authorization (RMA).
2. Iwe unozofanirwa kupa:
   • a. Zita nekero yako
   • b. Tsanangudzo yedambudziko
3. Rongedza mutongi nekungwarira kuti atumire uye udzorere kune iControls, yekutakura prepaid.

Kukamurwa kwezvinoreva waranti
Iko hakuna waranti, inoratidzwa kana kurehwa, inodarika tsananguro iri pano kusanganisira iyo inorehwa waranti yekutengesa uye kusimba kune chimwe chinangwa.

Kusabatanidzwa kwekukuvadza
iControls 'mhosva inogumira kumutengo wekugadzirisa kana kutsiva chigadzirwa. iControls haizove nemhosva ye:

1. Kukuvadzwa kune chimwe chivakwa chinokonzerwa nechero hurema muchigadzirwa, kukuvadzwa kunoenderana nekusagadzikana, kurasikirwa kwekushandisa chigadzirwa, kurasikirwa nenguva, kurasikirwa kwepurofiti, kurasikirwa nemukana webhizinesi, kurasikirwa kwekufarira, kukanganisa hukama hwebhizinesi kana zvimwe zvekutengesa. kurasikirwa, kunyangwe kurairwa nezve mukana kana kukuvara kwakadaro.
2. Chero kumwe kukuvadza, kungave kwakaitika, kwakakosha kana neimwe nzira.
3. Chero chirevo chinopesana nemutengi nemumwe bato.

Mhedzisiro yemutemo wenyika
Waranti iyi inokupa kodzero dzepamutemo, uye unogonawo kuva nedzimwe kodzero dzinosiyana kubva kunyika nenyika. Dzimwe nyika hadzitenderi zvipimo pawaranti inorehwa uye/kana kuti haibvumire kusabatanidzwa kwezvinoitika kana zvinokonzeresa kukuvadzwa, saka zvipimo zviri pamusoro uye kusabatanidzwa zvinogona kusashanda kwauri.

iControls Technologies Inc. 1821 Empire Industrial Court, Suite A Santa Rosa, CA 95403
ph 425-577-8851
www.icontrols.net

Zvinyorwa / Zvishandiso

iControls ROC-2HE-UL Reverse Osmosis System Controller [pdf] User Manual ROC-2HE-UL, Reverse Osmosis System Controller, ROC-2HE-UL Reverse Osmosis System Controller, Osmosis System Controller, System Controller, Controller

References

• User Manual