AREBOS Rewinder with Compressed Air Hose

1. Safety Instructions

1.1 Explanation of the symbols

[no-household-waste-symbol] This product must not be disposed of with household waste!

CE marking: Indicates compliance with European legal standards for trade within the European Community.

[warning-symbol] Warning! Read the safety instructions carefully. Failure to follow the safety precautions could result in serious injury or damage. Keep the operating instructions in a safe place.

[gloves-symbol] Warning! Wear protective gloves!

[safety-glasses-symbol] Warning! Wear safety glasses!

[ear-protection-symbol] Warning! Wear ear protection!

1.2 Safety Instructions

Please read the following safety and warning instructions carefully and completely before you install and commission the rewinder. This is for your own safety! For damages and injuries caused by disregard of the safety instructions, AREBOS assumes no liability!

Attention - danger of suffocation!

• Small parts and packaging materials can pose an acute danger of suffocation to small children and pets if improperly handled.

Attention - danger of explosion!

• Never use air tools with flammable gases.
• Do not use pneumatic tools near highly flammable materials.

Attention - Not suitable for children

• Children under 16 years of age must not use the compressed air hose reel.
• Product may only be used by persons who are familiar with the handling of the devices and are informed about possible dangers.

Attention - Danger of damage

• Installation site must have sufficient load-bearing capacity.
• Installation site must be free of hidden cables and pipes.
• Operate compressed air hose reel only with compressed air, never with liquids.
• Use compressed air hose without exception with compressor, never with compressed air bottles.
• Use only with accessories in perfect condition.
• Never exceed the maximum working pressure of the drum or air tools.
• Only connect to lines where the maximum permissible pressure is prevented (e.g., by a pressure reducer, by more than 10%).
• Keep the compressed air hose away from sharp objects, pointed edges, high heat and highly flammable materials.
• Keep housing and hoses free of dust and dirt.
• Do not allow moisture to penetrate the inside of the hose reel.
• Never use sharp, pointed or scratching cleaning utensils for cleaning.
• Do not clean with aggressive chemicals or abrasive cleaners.
• Do not make any changes to the product.
• Only use the goods in perfect condition.
• Repair work may only be carried out by qualified personnel.

Attention - Risk of injury

• Install the hose reel permanently on a wall or ceiling.
• Swaying compressed-air hoses can cause serious injuries.
• An uncontrolled rolling up of the hose bears a high risk of injury.
• Compressed air hoses lying around are a potential tripping hazard.
• Never direct compressed air hoses against people or animals.
• Always disconnect the compressed air hose reel from the compressed air supply.

2. Intended use

The compressed air hose reel is exclusively designed to supply power to compressed air tools and applications in combination with a compressor. The hose reel is suitable for transporting compressed air without exception. Liquids such as water must not be transported with the article.

The hose reel must be mounted on a suitable wall or ceiling. Without such a fastening the use of this compressed air unit is not permitted.

The article is only designed for private persons from the hobby and do-it-yourself sector. The compressed-air hose reel is not suitable for use in commercial, industrial and handicraft areas.

The intended use of this article also includes:

• Only use accessories that are suitable for this compressed air hose reel.
• All persons using the equipment must be familiar with the handling of the equipment and informed about possible dangers.
• When using the unit, all applicable accident prevention regulations must be strictly observed.
• Also follow all regulations from the occupational medicine and safety regulations area.

3. Place of installation

Use of the reel without mounting it poses a great danger to persons and objects in the vicinity of the drum. For this reason, non-assembly use is not permitted. Mount the unit on a suitable ceiling or wall.

Select the installation location so that the compressed air hose reel is not in the way and does not present an obstacle to you. To ensure that you can walk under the unit without any problems, you should ensure that the mounting height is at least 2.5 metres when mounting the unit on the ceiling.

Before drilling, make sure that no hidden lines or pipes run along the installation site. Use a detector to detect pipes and cables. Alternatively, you can also seek professional help.

Also make sure that the wall or ceiling has sufficient load-bearing capacity and carries the compressed air hose reel. If this is not the case, the Compressed air hose reels must never be attached at this point.

4. Assembly

The compressed-air hose reel may only be mounted in places where sufficient load-bearing capacity is guaranteed and where neither lines nor pipes run along it. If in doubt, consult a specialist who will check the ceiling or wall for the necessary requirements.

Take great care when installing the reel. Take sufficient time and work concentrated. Improper installation of the drum endangers product safety and can result in personal injury and damage to property.

Only use certified tools from specialist dealers for assembly. Observe the safety and warning instructions of these tools.

Always wear suitable protective clothing during installation.

4.1 Parts List

Version 10m

Versions 15m / 20m / 30m

4.2 Mounting to a wall

Depending on the variant, the fixing wing is used as a template for the drill holes. Plan the position so that the reel can be connected to a compressor. Mount the rewinder approx. 80cm above the floor. The hose to the reel must reach a compressor.

Diagram shows a hose reel mounted on a wall, with an arrow indicating approximately 80cm from the floor. Text below reads '*Product may vary due to variety'.

5. Use

5.1 Notes on correct use

The compressed air hose reel is only suitable for the transport of compressed air. The device must not be used with liquids or flammable gases. There is a risk of explosion with flammable gases.

The compressed air hose reel may only be used with a compressor. Use with compressed air cylinders is not permitted.

Never exceed the maximum working pressure of the compressed air hose reel or the compressed air tool operated with it. Without exception, attach the compressed air hose reel to compressed air lines where exceeding the maximum permissible pressure by more than 10 percent is prevented, e.g. by a pressure reducer).

The compressed air hose reel is equipped with a locking and return mechanism that makes it easy to pull out and return the hose. Nevertheless, always make sure that you let the hose snap back in a controlled manner. Uncontrolled rewinding of the hose can cause serious injury. If the rewind mechanism is damaged, the hose reel must be taken out of operation immediately. Have the unit repaired by a qualified technician before operating the unit again.

The locking mechanism produces a creaking sound when the hose is rolled up and unrolled. This is therefore not a fault or damage. After numerous applications or if there are problems with the mechanism, or this noise changes, a specialist should be consulted immediately.

Check the hose carefully for holes and other damage before each use. They reduce the performance of the appliance and pose a risk of injury. To prevent holes and damage, always keep the compressed air hose away from sharp or pointed objects.

Also keep open fires and other sources of heat and easily flammable materials such as oil away from the compressed air hose.

When disconnecting the compressed air hose from the compressed air source or the air tool from the compressed air hose reel. The hose can whip around and cause serious injury to you and people in the immediate vicinity. You should therefore always have a firm grip on the hose.

5.2 Use

• Slowly pull the hose out of the drum. The hose has 2 - 3 locking positions per meter.
• Do not continue to pull on the hose when it is already fully extended. Observe the markings.
• Hold the end of the hose while it is being rewound into the drum to prevent it from being pulled back uncontrollably.

6. Cleaning

Dirt not only looks unattractive; it also has a negative effect on material properties and functionality. For this reason, AREBOS recommends the device be cleaned thoroughly after each use.

Keep the housing and hose as free of dust and dirt as possible by wiping them regularly with a clean cloth or blowing away the dirt with compressed air at low pressure. Take care that no moisture gets inside the hose reel.

Before you put the hose back into the housing after work is done, you should clean the hose thoroughly. Use a soft cloth and mild soapy water for this.

Never use sharp, pointed or scratching cleaning utensils for cleaning. Do not use aggressive chemicals or abrasive cleaners. These attack the plastic and damage it over time.

7. Maintenance

The compressed air hose reel and accessories must be checked for damage at regular intervals. If any damage is discovered, the unit must not be used again until the damage has been repaired.

To avoid danger, necessary repair work should not be carried out by the user. Always have damage repaired by a qualified specialist workshop. Use original spare or replacement parts from the manufacturer without exception.

Before starting any maintenance or repair work, the compressed air hose reels must be disconnected from the compressed air supply.

8. Troubleshooting

The hose cannot be retracted automatically after the hose has been completely pulled out. The reason may be that the end of the hose is locked and there is no additional hose that can be pulled out for unlocking.

There is the following possibility to solve this problem: Hold the hose by the yellow mark and pull it out with a jerking motion. Move the hose until it retracts.

9. Technical data

10. Storage

If you want to store the compressed air hose reel, clean the hose and the drum beforehand. Allow the reel to dry thoroughly before storing it in a dry, dark and frost-free place. Make sure that the air in the room can circulate well so that moisture cannot accumulate and mold can grow.

11. Environmentally friendly disposal

Warning Danger of suffocation! Packaging material is dangerous for children. Never let children play with packaging material.

11.1 Disposal and packaging

The packaging of your device is made of materials necessary to guarantee effective protection during transport. These materials are fully recyclable and thus reduce the environmental impact. Dispose of the packaging in a bin for recyclable materials.

11.2 Disposal of waste equipment

Waste equipment must be disposed of in accordance with the guidelines and regulations of local waste disposal. Contact your local administration via the address of the nearest recycling centre and deliver your device there.

[crossed-out-waste-bin-symbol] Waste equipment must be disposed of in accordance with local regulations. Collection points for WASTE electrical and electronic equipment are available for free returns. Visit www.arebos.de for more information.

The separate collection of WEEE is intended to prevent reuse, recycling or other forms of recovery of WEEE, as well as the negative consequences of disposal on the environment and human health.

Our customer service number: Tel. +44 208 068 5604

fax: +49 (0) 931 4523 2799 / e-mail: info@arebos.de

Office address: Canbolat Vertriebs GmbH • Gneisenaustraße 10-11 • 97074 Würzburg

Return address can be found in the imprint: https://www.arebos.de/impressum/

EU Declaration of Conformity

We, the Canbolat Vertriebs GmbH, Gneisenaustraße 10-11, 97074 Würzburg, Germany, hereby declare that the equipment described below, by virtue of its design and construction and in the versions placed on the market by us, complies with the relevant essential health and safety requirements of the EU directives.

Product name: AREBOS Rewinder with compressed air hose

Model number: AR-HE- DA10/15/20/30M

Article number:

Should the appliance be modified without our consent, this declaration of conformity will lose its validity.

Tested acc. to: 2006/42/EC

EU Standard: EN ISO 12100: 2010

Date/Manufacturer Signature/Location: Würzburg, February 3, 2022

Signature: Dipl.-Inform. (Univ.) Korhan Canbolat, Managing Director

Representative of these instructions for use/technical data: Dipl.-Inform. (Univ.) Korhan Canbolat, Managing Director

Office address: Canbolat Vertriebs GmbH Gneisenaustraße 10-11 D-97074 Würzburg

Return address can be found in the imprint: https://www.arebos.de/impressum/

VAT identification number: DE 263752326

Court of the Commercial Register is Würzburg, HRB 10082

WEEE Reg.-No. DE 61617071