Instruction Manual

Safety Instructions

WARNING:

• To protect against electrical shock, do not immerse cord, charger, transformer, battery, or the product in water or other liquid.
• Only use charging devices, transformer, and battery provided or recommended by the manufacturer.
• For your children's safety, the product should be assembled by an adult.
• This toy is not intended for children under 3 years old.
• Close supervision is necessary when your child is operating this product.
• Disconnect the battery if not used for a long time.
• To reduce the risk of injury, adult supervision is required. Never use in roadways, near motor vehicles, on or near steep inclines or steps, swimming pools or other bodies of water; always wear shoes, and never allow more than 1 rider.
• RISK OF FIRE. Do not bypass fuse. Replace only with original size and type.
• Do not use this product on slippery surfaces.
• Always keep hands, hair, and clothing away from moving parts.
• Maximum user weight for this product is 66 lb / 30 kg.
• Do not change, modify, or add any electrical wiring on this product.
• Avoid using this product in tight environments to prevent damage to the product or injury to the user.
• Do not use this product in the dark. Only operate this product during daytime or in a well-lit area.
• Personal protective equipment such as a helmet is needed when operating this product.

PREVENT FIRE

• Battery handling: Adults only. Battery is heavy, contains sulfuric acid. Dropping can cause serious injury. Never allow children to charge the battery. Never lift or carry the battery by the wires or connector, as this can damage the battery case. Examine battery, charger, and connectors for wear or damage each time you charge. If damage is detected, do not use until replaced.

WARNING:

• Stop operating this product whenever it is stuck under any circumstances.
• Do not drive this vehicle into any puddle or contact with any liquids to avoid electrical shock to the product or user.
• CHOKING HAZARD - Small parts. Not for children under 3 years.
• This toy is to be assembled by an adult. Contains potentially hazardous sharp edges and sharp points, or contains small parts before assembly.

Child Safety Warnings

• Adults supervising children must read and understand this entire manual before allowing any child to use this product.
• Adults must evaluate their own children based on maturity, strength, judgment, and ability to follow safety rules. Published age guidelines are not a substitute for careful evaluation of your own child.
• Adults must teach children about thinking ahead while riding, seeing through the child's eyes, and verbally teaching them about steering and avoiding obstacles in the approved riding area.
• Riding a motorized ride-on toy can be a dangerous activity, even under the best circumstances. Good choices regarding where and when to ride, constant adult supervision, and practice and careful riding by the child can help minimize risk. However, this ride-on toy is intended to move and therefore carries inherent risks that no amount of care, instruction, or expertise can eliminate.
• If this inherent risk is not acceptable, adults should not allow children to ride this ride-on toy.

Safe Riding Warnings

• Not to be used by children under 36 months.
• Do not exceed the maximum weight capacity of 66 lb (30 kg).
• Do not allow more than one (1) rider.

ADULTS AND SUPERVISORS, PLEASE NOTE:

• Always instruct all children on common sense rules and safe practices.
• Do not allow the child rider to operate the ride-on toy near streets, roads, sidewalks, walkways, or any other place where they may encounter other moving vehicles.
• Never leave children unattended with this ride-on toy. Continuous adult supervision is required.
• If necessary, adults and supervisors are always responsible for setting up gates and barriers to ensure a safe riding environment for the child rider.
• Be aware that this ride-on toy does not have braking capabilities. Allowing use in areas that require braking may cause rolls, crashes, serious injury, or death.
• Teach children not to allow other children to use this ride-on toy. Communicate this message to other adults and supervisors of fellow children.
• Sternly alert children that hands, legs, hair, and clothing can potentially get caught in moving parts. Ensure they never place a body part or piece of clothing near a moving part. Avoid loose clothing.
• Instruct children to always wear shoes when using the ride-on toy.
• Do not allow children to touch the battery or charger, or bring any part of the ride-on toy into contact with any part of the ride-on toy while it is charging.
• Firmly instruct children to use the ride-on toy in a safe manner. Unsafe behaviors include, but are not limited to: Traveling at unsafe speeds, not riding in the seated position, riding at night or in low visibility, riding in wet conditions (rain, snow, ice), any kind of stunt riding (jumps, ramps, stairs, hills, sloped surfaces), riding near pools or open water, pushing/pulling/shoving the driver, using the toy without safety covers closed, pulling/hitching with other moving ride-on toys or products.

Battery and Charging Warnings

• Do not mix old and new batteries.
• Do not mix alkaline, standard (carbon-zinc), or rechargeable batteries.

Corrosive Material Warnings

• Battery posts, terminals, and related accessories contain lead and lead compounds (acids) chemicals, which are toxic and corrosive. Never open the battery.
• Contact or exposure to battery leakage (lead acid) may cause serious injury. If contact or exposure occurs with skin or eyes, or if the chemical is swallowed, immediately call 911.

Flammable and Explosive Materials Warnings

• Use of a battery or charger other than the supplied rechargeable battery and charger with the ride-on toy can cause the battery to leak or explode. Using the rechargeable battery and charger for any other product may cause it to malfunction or explode. Avoid direct contact between terminals. Lifting the battery by the wires or charger can damage the battery and may result in a fire or explosion.
• Plug wall charger directly into a wall outlet. Do not use an extension cord.

Electric Shock / Fire Warnings

• Keep liquids away from the battery and keep the battery dry.
• Exposed wiring or circuitry in the charger may cause electric shock or explosion and permanently damage the system. Always keep the charger housing closed.
• Regularly check charger, supply cord, and connector for wear and damage. Look for frayed or kinked wires, exposed inner wires, or missing insulation. If any damage is observed, do not plug in the charger and do not charge the battery.

Specifications

Parts and Features

The 'Parts and Feature' page displays a visual layout of all components included with the ride-on scooter. Each part is numbered and labeled for identification, including the vehicle body, wheels, motor, handle, mirrors, toolbox, and various nuts, bolts, and washers required for assembly.

• Vehicle Body (1x)
• Handle (1x)
• Mudguard (1x)
• Gear Box with motor (1x)
• Driving Wheel (2x)
• Front Wheel (1x)
• Toolbox (1x)
• Rear Mirror (2x)
• Metal Plate (1x)
• Front fork (1x)
• Front axle (1x)
• Key (1x)
• Instruction manual (1x)
• Charger (1x)
• Spanner (2x)
• Rear Axle (1x)
• M8 Nut (4x) (Pre-installed in the rear axle and front axle)
• M10 Washer (7x) (Pre-installed in the rear axle and front axle)
• M10 Big Washer (1x) (Pre-installed in the rear axle)
• M5 x 65 Bolt (1x) (Pre-installed in the handle)
• M5 Nut (1x) (Pre-installed in the handle)
• M3.5 x 12 Screws (4x)
• Wheel Hub (2x)

Assembly Instructions

Estimated Assemble Time: 40 mins

Tools Needed: Screwdriver, pliers, hammer, spanner.

Some parts are small and have sharp edges. Do not let children handle parts or the assembly. This product should be assembled by an adult.

Step 1: Rear Axle Assembly

Disassemble the M8 Nuts and M10 Washers from the rear axle, keeping the M10 Big Washer. Insert the rear axle through the vehicle body. Assemble the gear box with motor, rear wheel, M10 washer, M8 nut, and wheel hub onto the rear axle according to the diagram. Ensure there is a gap between the rear axle screw thread and the rear wheel. Add 2-3 washers if the gap is too large. The wheel should rotate smoothly. Remove excess washers if the wheel is too tight. Do not operate if the wheel is too tight, as this can damage the motor.

Step 2: Front Wheel and Handle Assembly

Insert the front wheel and the mudguard to the front of the vehicle. Assemble the handle onto the front axle, then secure it using the M5 x 65 bolt and M5 nut. Note: The hand brakes on the handle have no actual function.

Step 3: Rear Mirror Installation

Insert the rear mirror into the designated slots on the handle.

Step 4: Seat Installation

Remove the seat from the vehicle. Connect the wire connector plug. Replace the seat and secure it using the bolt that was removed.

Step 5: Toolbox Attachment

Attach the toolbox to the rear of the vehicle body using the M3.5 x 12 screws. Ensure all screws are securely fastened before operating the vehicle.

User Instructions

Charging the Battery

WARNING:

• The battery should only be charged by an adult.
• Only charge the battery for 8 - 12 hours; do not charge for more than 20 hours to prevent overheating.
• Only use the battery and charger provided with the product.
• Do not use the battery and charger for any other product.
• Make sure no water or any other liquid contacts the battery or its components.
• Never pick up the battery or the charger by pulling the wires.
• Battery posts, terminals, and related accessories contain lead and lead compounds, chemicals known to the State of California to cause cancer and reproductive harm. Wash hands after handling.
• Do not open the battery. Battery contains lead acid and materials that are toxic and corrosive.

Charge the battery at least once a month, even if not operating the vehicle, to maximize battery life.

Operating the Vehicle

• To turn on the vehicle, insert the key into the general power switch and turn right; the dashboard light will also turn on.
• To play music, press the music button.
• To activate the horn, press the horn button.
• Forward: Press the direction switch forward and step on the pedal; the headlight turns on.
• Backward: Press the direction switch backward and step on the pedal; the headlight turns on.
• Stop: Release the pedal.

ATTENTION:

Make sure the vehicle is in a complete stop before changing direction to prevent damaging the gear box or the motor.

Note: Remove the key to prevent a child from operating the vehicle by themselves.

Disposal of Battery

• Lead-acid batteries must be recycled or disposed of in an environmentally sound manner. Do not dispose of a lead-acid battery in household trash.
• Return an exhausted battery to your local lead battery recycling station, such as a local seller.

This product conforms to toy safety standards CPSIA and ASTM-F963.

Care and Maintenance

• Check the product regularly and make sure there are no missing or loose parts. Re-tighten any loose parts if necessary.
• Make sure there are no cracked or broken plastic parts.
• Disconnect the battery if the product is not used for a long period of time.
• Clean the plastic parts with a soft cloth. Use a furniture polish to restore shine. Do not use abrasive cleaner.
• Do not wash the product with a hose or immerse any parts in water or other liquid.

Troubleshooting

Importer Information

Importer: ALIGN INC.

Importer Address: City of Industry CA91748 United States

Importer Tel.: 1(800) 946-6151

Limited Term Warranty (One Year from Date of Purchase)

WARRANTY TERMS

KIDZONE warrants that its merchandise are free from manufacturing defects (workmanship and/or material) and will either give credit or replace defective parts for a period of up to one (1) year from the date of purchase in accordance with the conditions set forth below. If a manufacturing defect is found, the retailer must notify KIDZONE within the warranty period, provide proof of purchase (invoice and delivery ticket), and describe the defect. Inspection by a KIDZONE employee or representative may be necessary, or samples may need to be submitted with digital images of the defects. If replacement is required and the material is discontinued or unavailable, KIDZONE reserves the right to supply similar merchandise. This warranty is made solely to the retailer and is not transferable. Retailers must contact KIDZONE with claims; consumers must go through the retailer. Retailers should retain invoices for at least one (1) year. This warranty supersedes implied warranties of merchantability and fitness for a particular purpose. No representative is authorized to assume additional liability for KIDZONE.

ADDITIONAL CONDITIONS

Implied warranties of merchantability and fitness for a particular purpose are limited to one (1) year from the date of purchase. KIDZONE is not liable for indirect, consequential, or incidental damages.

THE FOLLOWING EXAMPLES ARE NOT MANUFACTURER'S DEFECTS:

• Colors may vary slightly from the photo due to photography and printing tolerances.
• Sizes stated in U.S. standard measurements may vary slightly as products are manufactured using the metric system.
• No returns for buyer's remorse.
• No returns, other than stated above, will be accepted.

WARRANTY IS VOID FOR ANY OF THE FOLLOWING CONDITIONS:

• Improper maintenance or improper use resulting in damage.
• Any modification, alteration, or addition to the product by the consumer, retailer, or unauthorized parties will void this warranty.
• Floor samples sold or products designated "AS IS" at the time of purchase are not covered.
• Warranty does not cover minor variations or differences between the product illustrations and your product.
• Cost of packaging and shipping to and from KIDZONE is not covered unless expressly arranged by KIDZONE.
• This warranty covers only articles intended for residential use only; it does not cover any industrial, commercial, institutional, or rental use.
• Dissatisfaction due to buyer's remorse.
• Normal wear and tear.
• Damages incurred during transportation.
• Damages incurred during assembling or maintenance.
• Damage incurred by accidents or abuse.