Ride-on Jeep Willys MB Army

General Information and Warnings

JAMARA e.K. is not liable for any damage caused to the product itself or through this, provided this is due to improper operation or handling errors. The Customer alone bears the full responsibility for the proper use and handling, including without limitation, the assembly, the charging process, the use and choice of the operation area. Please refer to the operating and user instructions, it contains important information and warnings.

Age Recommendation: Suitable for children over 3 years.

Warning: Not suitable for children under 36 months. RISK OF SUFFOCATION! Contains small parts which can be swallowed. Keep away necessarily from children. Due to its top speed this toy is not suitable for children under 3 years!

Before playing, remove all protective films from all parts.

This product is not intended for use by individuals (including children) with reduced physical, sensory or mental capabilities or lack of experience and / or knowledge. Depending on development, a minimum age of 4 years could be appropriate.

Maximum weight: < 30 kg

Before assembly: Adult required for assembly. Keep children away while assembling. Tools (not included) needed for assembly: screwdriver.

Safety Instructions

To prevent accidents and injuries, DO NOT leave your Child unattended during operation of the vehicle. Never let your Child out of your sight while driving a vehicle.

DO NOT use the vehicle on public roads or places or other dangerous locations. ONLY operate the Ride On Car in places such as private parking, private land or other safe locations. Make sure that no person or animal is endangered.

The model stops after releasing the accelerator, independently on a horizontal surface. The vehicle has no brake or parking brake. Do not operate the vehicle uphill or downhill, and secure it when parking.

General Driving Rules:

• Always sit tight, do not get up during the ride.
• Never take additional Children for a ride. (The vehicle is only suitable for 1 person)
• Hold tight.
• Never drive without shoes.
• Never drive in the dark.
• To be used with protective equipment.
• Keep hands, hair, loose clothing and any other item away from any rotating parts.
• The Model should not be used in rooms or halls with high humidity, in the rain or on wet surfaces. Risk of malfunction or damage to electronics and housing.
• The model is not water- or splash-proof. Only operate on asphalted surfaces (such as paving stones). The model is not suitable to be operated in grass or loose soil.

Assembly Warning: The kit in unmontiertem Zustand darf nicht in die Hände von Kleinkindern gelangen, da dieser verschluckbare Kleinteile enthält. Die Montage sollte ausschließlich von einem Erwachsenen durchgeführt werden.

Only use in direct supervision of an adult! To control the vehicle a minimum skill level and caution is needed. Make sure you are familiar with the operation of the model and its characteristics. The model is heavy. This is an increased risk of injury and damage in the event of loss of control. Avoid any kind of intentional or unintentional collisions with objects or hazards to persons.

Assembly Instructions

Refer to the diagrams for part numbers and assembly steps.

Key Assembly Steps:

1. Front Bumper: Place the bumper (2) on the front of the car body and fix with 6 x M4*12 mm screws.
2. Front Wheels: Remove nuts and washer from the front axle. Mount wheel (5) and washer (6), secure with nut (7). Attach wheel cover (4). Repeat for the other side.
3. Gearbox and Rear Wheels: Mount gearbox (3) onto the rear axle, connect motor cable plug. Mount wheel (5) and washer (6), secure with nut (7). Attach wheel cover (4). Repeat for the other side.
4. Steering Wheel: Connect steering wheel cable to dashboard cable. Insert steering wheel (14) into the slot and secure with retaining screw and nut.
5. Seat: Place seat cushion (9) in the car body slot and fix with 4 x M4x12 mm screws.
6. Backrest: Slide backrest (10) into position.
7. Windshield and Rearview Mirrors: Press windshield (8) and rearview mirrors (13) into position until they lock.
8. Toy Shovel Fastener and Shovel: Fix shovel fastener (12) to the rear box plate with M4*12mm screw. Clamp toy shovel (11) into the fastener.
9. Battery Connection: Open cover under seat, connect connectors. Ensure correct polarity. Close cover.
10. Charging: The vehicle must be switched OFF during charging. Connect charger to socket. LED on charger is red while charging, green when fully charged. Charge time is 6 hours. Do not charge more than once within 24 hours. Charger and battery may heat up.

Important Charging Warnings:

• The charger is not a toy. Only use the supplied charger.
• Battery charging must be supervised by an adult.
• Do not short-circuit terminals.
• Regularly check charger for damage. Do not use if damaged.
• Allow the model to cool after each use before recharging.
• Disconnect model from charger immediately after charging. Disconnect charger from power supply immediately after disconnecting model. Failure to do so can cause damage or fire hazard.
• Use charger only in dry rooms.

Functions and Operation

Control Panel:

• 1. Horn
• 2. Soundboard
• A. USB: Insert USB stick to play MP3 files.
• B. Bluetooth/Music: Press once to turn on Bluetooth, press again for music.
• C. Song Button
• D. Music/V-: Previous track / Volume down (long press).
• E. Music/V+: Next track / Volume up (long press).
• F. Voltage Indicator
• 3. ON/OFF Switch: Starts and stops the vehicle.
• 4. Light Button
• 5. Speed Control: High speed / Low speed buttons.
• 6. Gear Lever: Set to Forward, Stop, or Backward. Vehicle must be stationary before changing direction.
• 7. Foot Pedal: Press to move forward/backward. Release to brake.

Caution: Always switch off the model immediately after each use. Disconnect the battery immediately after each use. Leaving the model on or the battery connected can lead to deep discharge, damaging the battery or causing a fire hazard. Never attempt to charge or discharge deeply discharged batteries. Ensure battery voltage does not fall below 11.9V. Fully charged battery is approx. 13V. Recharge intact batteries within 12 hours after use. If storing the battery, check voltage and charge/dispose as needed every 3 months.

Troubleshooting

Problem: No function

Cause: Battery not connected or incorrectly connected.

Solution: Connect battery (see instructions).

Problem: Can be switched on but does not drive.

Cause: ON/OFF switch defective.

Solution: Check or replace switch.

Problem: Can be switched on but does not move, or only in one direction.

Cause: Motor cable incorrectly connected or not connected.

Solution: Check and connect motor cable (see instructions).

Problem: Can be switched on but only travels in one direction.

Cause: Gas or direction switch defective.

Solution: Check or replace switch.

Problem: Directional switch defective.

Cause: Directional switch defective.

Solution: Check or replace switch.

Problem: The active fuse blows and switches the unit off for a few seconds. You will hear a single click at the beginning.

Cause: Overload or electrical short circuit.

Solution: Do not overload or have the unit checked.

Problem: No sound function on the steering wheel/handlebar.

Cause: The cable was torn or crushed during assembly.

Solution: Check or replace the steering wheel.

Problem: Vehicle has very high wear on switches.

Cause: Dirt and moisture damage the switches.

Solution: Do not drive in moisture or dirt such as meadows, gravel, sand, etc.

Problem: The rubber tyres come loose on the wheels.

Cause: Ridden on too hot a surface or in dirt.

Solution: Change tyres and avoid hot surfaces and dirt.

Problem: Wheel keeps falling off the axle.

Cause: Mounted incorrectly.

Solution: Check that the wheel is properly engaged (see instructions).

Disposal Information

Batteries and accumulators must not be disposed of in domestic waste. You are obliged to dispose of batteries (separate collection) appropriately. After use, you can return batteries free of charge to the retail store. As batteries contain substances that can be irritant, can cause allergy and are highly reactive, separate collections and proper recycling is important to the environment and to your health. If the batteries are marked with a chemical symbol Hg, Cd or Pb below the crossed-out waste bin on wheels, it refers to that more than 0.0005% of mercury (Hg), more than 0.002% of cadmium (Cd) or more than 0.004% Lead (Pb) is included.

Electrical appliances must not be disposed of in domestic waste and must be disposed of separately. You are obliged to take out the batteries, if possible, and to dispose of the electrical equipment at the communal collection points. Should personal data be stored on the electrical appliance you must remove them by yourself.