AMEWI Conquer Race Truggy 1:16 & Gantry Cross-Country Truck 1:16

Welcome to AMEWI

AMEWI Trade GmbH is an international import and wholesale company specializing in RC models and toys, based in Borchen, Germany. With over 10,000 items in its product range, AMEWI offers a wide selection of remote-controlled cars, helicopters, boats, and tank models, along with extensive accessories and spare parts. Their sales network spans over 700 specialist dealers and online retailers across Europe.

AMEWI Trade GmbH operates exclusively as a wholesaler, selling directly to retailers. If you are an end consumer purchasing AMEWI products, your contract is with the retailer. For any warranty claims, please contact your dealer.

AMEWI Trade GmbH
Nikolaus-Otto-Str. 18
33178 Borchen
Service Hours: Tuesday 9:30 AM – 12:00 PM | Thursday 2:00 PM – 4:30 PM
Phone: +49 180 5009821
Support: https://amewi.com

Declaration of Conformity

This model has been manufactured according to current technical standards and complies with applicable European and national guidelines. CE conformity has been proven. AMEWI Trade GmbH hereby declares that this product meets the basic requirements and other relevant provisions of Directive 2014/53/EU (RED). The full text of the Declaration of Conformity can be found at: https://amewi.com/Konformitaetserklaerungen

For further questions regarding the product and conformity, please contact: AMEWI Trade GmbH Nikolaus-Otto-Str. 18, 33178 Borchen, Germany, or visit the website https://amewi.com.

CE

Security and Hazard Warnings

Failure to follow this manual may void the warranty. AMEWI is not liable for consequential damages. AMEWI assumes no liability for material or personal damage caused by improper handling or disregard of safety instructions.

For safety and approval reasons (CE), unauthorized modification or alteration of the device is not permitted. Do not disassemble the model.

• ⚠️ Caution: Small Parts. Risk of suffocation or injury from small parts.
• The product is not a toy and is not suitable for persons under 14 years of age.
• The product must not get moist or wet.
• The product is only allowed to be used on flat and clean surfaces.
• Even a drop from a small height can cause damage to the product.

Battery Notice & Disposal

Batteries/rechargeable batteries are not toys and should not be handled by children. Battery replacement must be performed by an adult. Never mix rechargeable batteries with non-rechargeable batteries, or mix batteries of different charge levels or capacities. Never attempt to charge dry batteries. Ensure correct polarity. Defective batteries must be disposed of as special waste. Never leave a charging battery unattended. For charging time inquiries, consult the manual or the manufacturer.

Read the safety instructions and warnings before using or charging the LiIon battery. Stop use or charging immediately if the battery leaks, exceeds 70°C, or exhibits any unusual behavior.

Use only a qualified and specific Li-Po/LiIon charger. Never charge the battery unattended. Do not charge if the voltage exceeds 4.2V per cell. Do not charge with a current exceeding 2C. Using an unqualified charger may cause a fire.

Do not discharge the battery with a current exceeding its maximum discharge current, as this can lead to overheating, bursting, fire, or explosion. Never disassemble, puncture, drop, short-circuit, or throw the battery into a fire. Improper use can lead to explosions or fires.

Keep batteries in a safe place out of reach of children. The user assumes full responsibility for the outcome of battery usage.

Disposal Information

AMEWI Trade GmbH is registered under WEEE Reg. No. DE93834722 and Batt-Reg. No. DE 77735153 with Stiftung EAR and properly recycles all used electronic components. Electrical and electronic devices must not be disposed of in household waste. Dispose of the product at the end of its lifespan according to applicable legal regulations. As a consumer, you are legally obligated (Battery Ordinance) to return all used batteries and rechargeable batteries; disposal via household waste is prohibited!

Batteries/rechargeable batteries containing hazardous substances are marked with symbols indicating the prohibition of disposal in household waste. Additional notations for critical heavy metals are Cd=Cadmium, Hg=Quicksilver, Pb=Lead (labels are found on batteries, e.g., below the trash bin symbol).

The RoHS marking confirms that the manufacturer has adhered to all limit values during manufacturing.

Batteries marked with the recycling symbol can be disposed of in any used battery collection container (available at most supermarkets near the checkout). They are not allowed in residual or household waste.

AMEWI Trade GmbH participates in the dual system for sales packaging via Landbell AG. Used packaging is collected from private consumers (households, yellow bag, yellow bin) by partner companies (disposal contractors), sorted, and properly utilized. Participation in a dual system contributes to CO2 savings.

Thank You

Thank you for purchasing the AMEWI Conquer Race Truggy or Gantry Cross-Country Truck. Please read this instruction manual carefully and keep it for future reference.

Important Warnings

• This remote-controlled model is not a toy. It consists of many small parts and is not suitable for children under 14 years of age.
• For the remote control, 4x AA batteries are required (not included). For the vehicle, a 2S 7.4V LiPo battery or a 7.2V NiMH Pack is used (included).
• Always keep your fingers away from the drive parts and other moving parts to avoid injury.
• The model's motor gets very hot. To avoid burn injuries, allow the motor to cool for 10-15 minutes after use before touching it.
• Please use only the supplied charger or special multi-function model chargers to avoid damaging the battery.
• Do not look directly into the LED lights.

On Inappropriate Use of the Product

Please do not disassemble or modify the model in any way. Please do not use this product improperly or illegally and do not operate it in a manner that could endanger others or yourself.

Precautions

Please read the following safety information before using the model:

• Do not use the model in an environment that you cannot see.
• Signal interference can cause the model to go out of control. Please do not use the model in the following places:

• Near a radio tower, mobile phone masts, or other locations with active radio waves.
• Near crowds or in public places.
• Near rivers, ponds, or lakes.
• Near electricity pylons or other transmission towers.

• Please do not operate the model if you are tired or unwell, have drunk alcohol or taken drugs – this may cause injury to yourself or others.
• To avoid burns, never touch drive parts and motors during or immediately after use as they can be very hot.
• Incorrect operation of the transmitter can cause injury to you or others. Be sure to familiarize yourself with the operation before using the model.
• Check the model and the remote control before use. Check screws to make sure they are tight.
• When you have finished using the model, always switch off the model first and then the remote control. Otherwise, the model may get out of control.
• Stay within the model's range; if it goes out of range, it may lose control. Keep the transmitter close to the model.

Maximum Transmitting Power Data

Remote Control

The remote control is a 2.4GHz Digital Proportional R/C System.

Components:

• 1. Power Button: Turns the remote control on/off.
• 2. Steering Wheel: Controls steering.
• 3. Throttle Trigger: Controls acceleration and braking.
• 4. Throttle Trim: Adjusts the neutral throttle position.
• 5. Status LED: Indicates power or connection status.
• 6. Steering Trim: Adjusts the neutral steering position.
• 7. Max. Speed (30% - 100%): Adjusts the maximum speed limit.
• 8. Steering Reverse: Reverses the steering direction.
• 9. No Function
• 10. No Function

Insert Batteries

Insert three AA batteries into the transmitter, paying attention to the polarity. If the remote control will not be used for an extended period, remove the batteries to prevent leakage.

Operation

Switch on Transmitter and Car

Slide the switch to the "ON" position to turn on the remote control. Press and hold the button on the ESC for 2-3 seconds to turn on the vehicle.

Throttle Test

Pulling the throttle trigger accelerates the vehicle forward. Pushing the throttle trigger applies the brakes. Releasing the trigger and then pushing it again makes the car drive backward.

Steering Trim

If the vehicle does not drive straight, use the "ST.TRIM" control to correct the wheel position. Turn the potentiometer to straighten the wheels.

Max Speed

The maximum speed can be set using the "SPEED" potentiometer. Turning the knob left limits the speed to approximately 30-40% of maximum. Turning it right sets the speed to 100%.

Servo Direction

If turning the steering wheel left causes the vehicle to steer right, toggle the "ST.REV:" switch to reverse the servo's rotation direction.

Switch off Car and Transmitter

When finished using the vehicle, be sure to turn off the vehicle first, then the remote control. To do this, press the button on the ESC for 2-3 seconds, then slide the switch on the remote control to "OFF". Disconnect the battery from the ESC when not using the vehicle.

Maintenance

• Before each journey, check the vehicle for loose screws, especially the motor mounting screws. Tighten them if necessary.
• Screws screwed directly into metal should be secured with thread locker to prevent them from coming loose during driving. Screws into plastic or composite material do not require thread locker.
• Check the transmitter batteries before each ride.
• Over time, dirt and debris can accumulate on the chassis. Clean these with a soft brush and compressed air.
• Check the suspension and steering system to ensure smooth operation.
• Check the electronics (steering servo, ESC/receiver, motor, wiring) for signs of damage.
• Periodically check the bonding between the tires and rims. If tire separation occurs, re-glue the tire to the rim using a high-quality tire adhesive.

Charging Battery

Please remove the battery from the vehicle before charging it. To do this, press down on the tab indicated in Figure 1, remove the battery cover, and take out the battery.

• Children must NOT charge the battery without adult supervision.
• Charging must be done in a safe and spacious area protected from heat and moisture.
• Never charge the battery unattended or overnight.

Charging Procedure:

Connect the battery's white balance plug to the USB charging cable socket. Then connect the USB plug to a USB socket on a PC or a smartphone charger (5V 2A).

• Charging time is approximately 3.5-4 hours on a PC, and about 2.5-3 hours on a USB power supply (5V 2A).
• During charging, the red LED on the USB plug is continuously lit, and the green LED glows. Once charging is complete, the green LED will be continuously lit, and the red LED will turn off.

Cautions for the Battery

• Please fully charge the battery before each use.
• As soon as you notice the vehicle slowing down, stop it as quickly as possible to charge the battery. Allow the battery to cool down before charging.
• If you do not use the vehicle for a longer period, we recommend charging the battery to approximately 50%. Charge for about half the charging time (1.5-2 hours on PC, 1-1.5 hours with a 2A smartphone power supply).

Troubleshooting

A. If the vehicle does not work:

1. Ensure the remote control and vehicle are switched on, the remote control batteries are new, and the vehicle battery is charged.
2. Check if any parts, cables, or plugs are damaged. Repair or replace them if necessary.
3. The vehicle battery is empty. Charge it.

B. If the vehicle is driving slowly:

1. The vehicle battery is empty. Charge it.
2. Check if the gears are dirty or worn. Clean or replace them.
3. Check if the backlash between the motor pinion and the main gear is set correctly (a paper thickness is optimal).
4. Check for any blocked moving parts.

C. If throttle/brake works but steering does not:

1. Check if the servo is stuck.
2. Check if the servo linkage is loose or if the servo is defective. Repair or replace if possible.

D. If the vehicle steers but does not accept throttle:

1. Check the entire driveline for damage.
2. Check the batteries in the remote control and the vehicle battery.
3. Check the motor. Replace if necessary.

E. If the vehicle is louder than normal:

1. Check the backlash between the motor pinion and the main gear (one paper thickness is optimal).
2. Check if the gears are dirty or worn.
3. Check if any parts of the drive train are damaged.

F. If the vehicle does not turn in both directions equally:

1. If the wheels cannot be centered using the trim control, you can manually adjust the neutral position. Loosen the servo horn and fix it so that the wheels are straight.

G. If the battery cannot be charged:

1. If the battery is too deeply discharged (due to prolonged use or forgetting to disconnect it from the controller), replace it.
2. If the battery or the charger are damaged, replace them.

Assembly / Installation

This section details the assembly of various components. Part numbers are provided for reference.

Center Drive Shaft Assembly

Components: 014-6045, 014-6046, 014-6022, 014-6036

Servo Saver Assembly

Components: 014-6024, 014-6050

Motor Mount Assembly

Components: 014-6100, 014-6037, 014-6049

Front/Rear Drive Shafts

Components: 014-6028, 014-6029

Chassis

Components: 014-6103, 014-6020, 014-6101, 014-6023, 014-6001

ESC/Receiver

Components: 014-6101, 014-6047, 014-6103

Steering Assembly

Components: 014-6106, 014-6013, 014-6018, 014-6039, 014-6101, 014-6002, 014-6104

Steering Hubs / Rear Hubs

Components: 014-6046, 014-6025, 014-6026

Front Suspension Assembly

Components: 014-6108, 014-6111, 014-6025, 014-6028, 014-6040, 014-6041, 014-6018, 014-6014, 014-6015

Rear Suspension Assembly

Components: 014-6043, 014-6029, 014-6026, 014-6016, 014-6025, 014-6040, 014-6017, 014-6042, 014-6043, 014-6029

Front/Rear Bumper

Components: 014-6103, 014-6008, 014-6101, 014-6038, 014-6102, 014-6009, 014-6042

Front/Rear Shocks

Components: 014-6105, 014-6027

Wheels

Components: 014-6058, 014-6044, 014-6034, 014-6035

Body

Components: 014-6107, 014-6101, 014-6230, 014-6231

Find spare parts at amewi.com.