CAT Mining Dump Truck

Owner's Manual

Model: KT1421TG

Important Safety Information

WARNING: This manual contains important safety and use information. Keep this manual for future reference.

An adult must read this entire manual.
Adult supervision is required at all times.

Product Specifications:

Age: 3-7 years
Weight Capacity: Maximum 130 lbs (59 kg)
Maximum Speed: 2.5 MPH and 5 MPH
Battery: 12 volt

Styles and colors may vary. Made in China.

Safety

Child Safety Warnings

Adults supervising children must read and understand this entire manual before allowing any child to use this product. Adults must evaluate their own children's maturity, strength, judgment, and ability to follow safety rules. Age guidelines are not a substitute for careful evaluation of your child. Adults must teach children about thinking ahead while riding, as this may be their first time controlling a motorized ride-on toy. Verbally teach them about steering and avoiding obstacles in the approved riding area.

Riding a motorized ride-on toy is a dangerous activity. While good choices regarding where and when to ride, constant adult supervision, and practice can minimize risk, it is possible for the rider to lose control, fall off, or get into dangerous situations. If this inherent risk is not acceptable, do not allow children to ride this ride-on toy.

Safe Riding Warnings

Do not use if the rider is younger than three (3) years or older than seven (7) years.
Do not exceed the maximum weight capacity of 130 lbs (59 kg).
Do not allow more than two (2) riders.

ADULTS AND SUPERVISORS, PLEASE NOTE:

Always instruct children on common sense rules and safe practices.
Flat, hard surfaces provide the safest experience.
Do not allow operation near streets, roads, sidewalks, walkways, or any place with moving vehicles.
Never leave children unattended. Continuous adult supervision is required.
Use gates and barriers to ensure a safe riding environment.
This ride-on toy does not have braking capabilities. Avoid areas requiring braking to prevent rolls, crashes, serious injury, or death.
Instruct children not to allow other children to use the ride-on toy. Communicate this to other adults and supervisors.
Alert children that hands, legs, hair, and clothing can get caught in moving parts. Ensure they never place body parts or clothing near moving parts. Avoid loose clothing.
Instruct children to always wear shoes.
Confirm children do not have access to charging equipment or contact with the ride-on toy while charging.
Instruct children to use the ride-on toy safely. Unsafe behaviors include: traveling at unsafe speeds, not riding in the seated position, riding at night or in low visibility, riding in wet conditions (rain, snow, ice), stunt riding (jumps, ramps, stairs, hills, slopes), off-road riding (rough terrain, dirt, mud, gravel), riding near pools or open water, pushing/shoving the driver, operating without safety covers closed, pulling/hitching with other moving toys.

Battery and Charging Warnings

WARNING: The following safety hazards may result in serious injury or death.

Corrosive Material Warnings: Battery posts, terminals, and accessories contain lead and lead compounds (acids) which are toxic and corrosive. Never open the battery. Contact or exposure to battery leakage may cause serious injury. If contact occurs, immediately call 911. Contact between terminals may cause fire or explosion. Always lift the battery by its case or handles, not by wires or charger.
Electric Shock / Fire Warnings: Liquids on the battery may cause fire or electric shock. Keep battery dry. Tampering with the electric circuit system may cause shock, fire, or explosion. Always keep the charger housing closed. Regularly check charger, supply cord, and connector for wear and damage. Do not use if damaged.
Flammable and Explosive Materials Warnings: Use only the supplied rechargeable battery and charger. Do not charge near heat or flammable materials. Using the battery and charger for other products may cause overheating, fire, or explosion.
Product Warning: This product can expose you to chemicals including lead, known to the State of California to cause cancer and birth defects or other reproductive harm. Visit www.P65Warnings.ca.gov for more information.
Assembly Warnings: The ride-on toy must be assembled by an adult who has read and understands the instructions. Keep small children away during assembly. Remove and dispose of all packaging before assembly.

If you have questions regarding assembly or use, contact Pacific Cycle Consumer Relations at 877-741-6154.

Pre-Ride Safety Checklist

To be performed by a supervising adult. Before every ride, check the following. Do not ride if not in proper working condition. Replace worn or broken parts.

Steering and Control

Steering wheel/handlebars are tightened and secured.
Steering wheel/handlebars are positioned for easy operation and steering.
Steering wheel/handlebars are aligned with front wheels.

Wheels

Wheels are securely attached and in good condition. Slight lateral movement is acceptable.
Wheels have no holes, are not worn down, and traction strips are intact.
Drive wheel is securely fastened to the gear box/motor.

Ride-on

For all electrical components, ensure:

Battery is fully charged.
Charging cord is NOT attached.
All connectors are securely snapped in place.
No wiring is exposed, worn, or detached; motor is not hot.
All electrical buttons (power, accelerator, lights, sounds) work properly.
If any electrical components show damage or are missing, DO NOT RIDE until corrected.

Make sure the ride-on is:

Clean, dry, and in good condition.
All plastic pieces (fenders, seat, footrests, steering wheel, etc.) are securely attached.
No cracks or structural problems.
If any damage or missing parts are present, DO NOT RIDE until corrected.
All safety labels are in place, readable, and understood by the rider.

Parts

Before beginning assembly, check that all parts listed are present.

Number	Part Name	Quantity	Tools Required
1	Dump truck body	1	Wrench (2 included)
2	Wheel	4
3	Hubcap	4
4	Small wheel washer	4
5	Wheel nut	4
6	Large wheel washer	2
7	Battery charger	1
8	Wrench	2

Hardware:

4 x Small wheel washer

4 x Wheel nut

2 x Large wheel washer

Assembly

Follow the assembly steps in the order listed below.

Attach Rear Wheels: Slide the wheel onto the rear axle and fit it over the gear. Insert hubcap tabs into the wheel and snap into place. Slide a washer onto the end of the rear axle. Fasten the nut onto the end of the rear axle and tighten.
Attach Front Wheels: Slide a washer onto the front axle until it meets the stop. Slide the wheel onto the front axle. Insert hubcap tabs into the wheel and snap into place. Slide a washer onto the end of the rear axle. Fasten the nut onto the end of the rear axle and tighten.
Charge the Battery: Refer to the "Charge the Battery" section and warnings on page 8.
Connect Battery to Motor: Use a flat-head screwdriver to unlock the battery compartment. Connect the battery to the motor.

To tighten the wheel bolts, place a wrench on each wheel bolt and simultaneously turn the wrenches in opposite directions until the bolts are tight.

Use

Controls and Functions

Lights
Sounds
Megaphone
On/Off Switch
Dump Lever
Gear Shift (Forward/Reverse)
Speed Selector (Low/High)
Foot Pedal: Press to accelerate, lift foot off to stop.

Speeds: 2.5 MPH and 5 MPH

Charge the Battery

WARNING: The battery contains hazardous material. Only an adult who understands the warnings and instructions should handle, connect, or charge the battery. Contact Pacific Cycle at 1-877-741-6154 with any questions.

WARNING: Charging the battery more than 24 hours could cause explosion or ignition. Do not charge for more than 24 hours. Disconnect from charger after charging. Disconnect charger from wall when indicator light turns green.

NOTICE: The average charge time is 10-12 hours. Failure to follow charging instructions may result in permanent battery damage and void the warranty. The product will not turn on while plugged into the charger; remove from charger before turning on. The battery may be damaged if allowed to drain completely; always keep the battery charged.

Charge Times:

First Charge: 18 hours
Regular Charge: 12-18 hours
No more than 24 hours

Watch for the LED light to turn green to indicate charging is complete.

Maintenance

Battery Replacement and Disposal

The battery will eventually lose its ability to hold a charge (1-3 years depending on use). Recycle the dead battery responsibly. Lead acid batteries must be disposed of properly and legally. Take it to a federal or state-approved recycler, authorized service center, or local automotive battery retailer. Do not dispose of in household trash.

This ride-on toy contains a sealed lead acid NON SPILLABLE BATTERY. This battery must be recycled.

Care

Check for damage, missing, or worn parts before each use.
Check fastener tightness before each use.
Check wheel tightness before each use.
Ensure the battery is securely in place before each use.
Store the ride-on toy indoors or cover it with a tarp to protect it from wet weather. Keep away from heat sources.
Do not leave the vehicle in the sun for long periods; store in shade or cover.
Do not wash the vehicle with a hose, soap, or water. Water can damage the motor, electrical system, and battery.
Clean the vehicle with a soft, dry cloth. Use non-wax furniture polish to restore shine to plastic parts. Do not use car wax or abrasive cleaners.

Service

Do not return this product to the place of purchase. For service, repairs, or replacement parts, contact:

Pacific Cycle Consumer Relations
Hours: 8:00 am – 5:00 pm (CST) Monday - Friday
Phone: 877-741-6154
Email: customerservice@kidtraxtoys.com

For a list of replacement parts, contact Pacific Cycle Consumer Relations. Have the model and serial number available (found under the seat on the battery cover).

FCC Statement

Unauthorized modifications may void the user's authority to operate the equipment. This equipment complies with Class B digital device limits under Part 15 of the FCC Rules, designed to provide reasonable protection against harmful interference in residential installations. If interference occurs, try reorienting/relocating the antenna, increasing separation between equipment and receiver, connecting to a different circuit, or consulting a dealer/technician.

Warranty

One Year Limited Warranty | Six-Month Limited Warranty on Battery

Pacific Cycle, Inc. (PC) warrants this product to the original retail purchaser for one year from the date of original purchase against defective materials or workmanship. The battery is warranted for six months. An original receipt is required. PC may provide replacement parts or replace the product. PC reserves the right to substitute discontinued parts or models.

To make a warranty claim, contact PC via www.kidtraxtoys.com, fax 1-800-858-2800, mail to Kid Trax Consumer Relations Department, P.O. Box 344 Olney, IL 62450, or call 1-877-741-6154 (8 am-5 pm CST, Mon-Fri). Proof of purchase is required; shipping charges are the consumer's responsibility.

Warranty Limitations

This warranty does not cover damages from accident, misuse, abuse, neglect, or causes not arising from defects in materials or workmanship. It also does not cover service by unauthorized centers. This warranty is for personal use only, not commercial. The original owner pays labor charges for repairs/replacements. This limited warranty does not include shipment costs to/from authorized repair centers.

Limitation of Damages

Warranties and remedies are exclusive. PC or the dealer are not liable for any damages, including incidental or consequential damages, arising from the use or inability to use this product. Some states may not allow these limitations.

Limitations of Warranties and Warranty Terms

Implied warranties (merchantability, fitness for a particular purpose) are limited to the duration of this express written warranty. This warranty grants specific legal rights, and other rights may vary by state.

Neither PC nor the dealer authorizes anyone to create other warranties or obligations for this product.