CHEST FREEZER

ECN 1147

Operating and Installation Manual

Model Number: 1293310

Country Code: GB

Serial Number Reference: 820 41 70 61

A line drawing depicting a chest freezer.

Important Safety Instructions

These warnings are provided in the interests of your safety. Ensure that you understand them all before installing or using this appliance. Your safety is of paramount importance. If you are unsure about any of the meanings or these warnings contact the Customer Care Department.

Prior to Installation

• Check the appliance for transport damage. Under no circumstances should a damaged appliance be installed. In the event of damage please contact your retailer.

Installation

• This appliance is heavy. Care should be taken when moving it.
• It is dangerous to alter the specifications or attempt to modify this product in any way.
• Ensure that the appliance does not stand on the electrical supply cable.
• Important: If the supply cable is damaged, it must be replaced by authorised service or qualified personnel using a special cable of the same type.
• Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person.
• Parts which heat up should not be exposed. Whenever possible, the back of the appliance should be close to a wall, but leaving the required distance for ventilation, as stated in the installation instructions.
• The appliance should be left for 2 hours after installation before it is turned on, in order to allow the refrigerant to settle.

Refrigerant

• The refrigerant isobutane (R 600a) is contained within the refrigerant circuit of the appliance, a natural gas with a high level of environmental compatibility, which is nevertheless flammable.
• During transportation and installation of the appliance, be certain that none of the components of the refrigerant circuit become damaged.
• If the refrigerant circuit should become damaged: - avoid open flames and sources of ignition. - thoroughly ventilate the room in which the appliance is situated.

Child Safety

• Do not allow children to tamper with the controls or play with the product.
• There is a risk of suffocation! Keep packaging material away from children!

General Safety

• This appliance contains hydrocarbons in its cooling unit; maintenance and recharging must therefore only be carried out by authorised technicians.
• Take utmost care when handling your appliance so as not to cause any damages to the cooling unit with consequent possible fluid leakages.
• The appliance must not be located close to radiators or boilers.
• Avoid prolonged exposure of the appliance to direct sunlight.
• Do not use other electrical appliances (such as ice cream makers) inside of refrigerating appliances.

During Use

• This appliance is designed for domestic use only, specifically for the storage of edible foodstuffs. It is not intended for commercial or industrial use.
• Containers with flammable gases or liquids can leak at low temperatures. Do not store any containers with flammable materials, such as spray cans, fire extinguisher refill cartridges etc. in the refrigerator.

Maintenance and Cleaning

• Before cleaning, always switch off the appliance and disconnect from the electrical supply.
• When unplugging always pull the plug from the mains socket, do not pull on the cable.

Servicing

• This product should be serviced by an authorised engineer and only genuine spare parts should be used.
• Under no circumstances should you attempt to repair the appliance yourself. Repairs carried out by inexperienced persons may cause injury or serious malfunctioning. Contact your local Service Force Centre.

At the end of the Appliance Life

• When disposing of your appliance use an authorised disposal site.
• Check with your local Council or Environmental Health Officer to see if there are facilities in your area for recycling the appliance.
• Remove the plug and ensure that any locks or catches are removed, to prevent young children being trapped inside.

Guide to Use the Instructions

• ! Safety instructions
• ➡️ Step by step instructions for an operation
• ? Hints and Tips

Description of the Appliance

Diagram showing the appliance components: A indicates the freezer calendar for recommended frozen food storage times, B points to the freezer controls, and C highlights frozen food storage times.

Operation

Before Use

• Remove all packaging and securing tapes. Wash inside the appliance with lukewarm water and bicarbonate of soda (5ml to 0.5 litre of water). Do not use soap or detergent as the smell may linger. Dry thoroughly.

Starting the Appliance

• Insert the plug into the wall socket. The green pilot light will illuminate to show that the appliance is switched on.

Temperature Control

• The temperature within the freezer is controlled by the thermostat situated on the lower front of the cabinet.
• To operate the freezer, proceed as follows: When you first start the freezer we suggest that you turn the thermostat to a medium setting ie 3-4. The correct setting can be found by measuring the temperature of the top middle package in the freezer. This should not have a temperature higher than -18°C.
• 1 = Lowest setting, minimum cold
• 7 = Highest setting, maximum cold
• Allow the freezer to run for several hours before placing food inside.
• Do not fill the freezer to more than 5mm below the top edge.

Diagram illustrating the thermostat knob with settings from 0 to 7, and a green pilot light indicator.

Opening/Closing the Lid

• The lid is fitted with a tightly closing sealing strip to prevent moisture entering the freezer, increasing the amount of frost formed.
• When the lid is opened the air inside the freezer becomes slightly warmer and expands. When the lid is closed again the air is cooled immediately. This may lead to the creation of a vacuum which makes it hard to open the lid again immediately. This is quite normal.
• Wait for a few minutes until the vacuum has equalised and then open gently. Never use excessive force on the handle.

Freezing Fresh Food

• It is important that fresh food placed in the freezer is frozen quickly and that the food already in the freezer is heated as little as possible.
• If more than 3-4kg of food is to be frozen: 1. Turn the thermostat control knob to the highest setting ("7"). The freezer will now run continuously creating a sufficient reserve of the temperature required. 2. Turn the thermostat control knob up 6-24 hours before placing new food in the freezer depending on how much food is to be frozen. 3. Place the food in the freezer and leave the thermostat set at "7" for a further 24 hours. 4. Then turn the thermostat control knob back again. The freezer will return to normal storage temperature.
• If you forget to turn the thermostat control knob back, the freezer will not be damaged, but energy will be wasted.

Capacity

• The freezing capacity of the freezer is stated in the rating plate (kg/24 hours). Do not exceed the amount stated - if you do, the freezing time will be extended. The rating plate is located inside the lid.

A graphic representing freezing capacity, with placeholder text for model, product number, class, and serial number, and a capacity value in kg/24h.

Important Notes

• Do not put carbonated liquids in the freezer.
• Ice lollies, if consumed immediately after removal from the freezer can cause a low temperature skin burn.
• Do not remove items from the freezer if your hands are damp/wet, as this could cause skin abrasions or frost/freezer burns.
• In the event of a power cut, do not open the lid. The food in the freezer will not be affected if the power cut is short and the freezer is full. Should the food begin to thaw it must be consumed quickly and must not be re-frozen. (See Hints and Tips)

Thawing

• Frozen food, prior to being used, can be thawed in the fridge or at room temperature, depending on the time available. Small food items may even be cooked from frozen, in this case cooking will take longer.
• Any frozen food which is allowed to thaw accidentally should either be eaten as soon as possible, or thrown away. Alternatively, if the food is uncooked and has not been completely defrosted it can be cooked and then refrozen.
• Defrosted cooked food must never be refrozen.

Frozen Food Storage

• When first starting the freezer or if the freezer has been out of use for some time, we advise you to run your appliance for at least 2 hours before storing frozen food.
• Do not exceed the storage period indicated by the manufacturer.
• Do not open the lid frequently or leave it open longer than is necessary.
• If you wish to freeze food several days in a row, please observe a maximum capacity of only 2/3 to 3/4 of that on the rating plate. The quality of the food is best preserved when it is frozen right through to the core as quickly as possible.

Baskets

• The baskets are designed for the storage of food which has already been frozen. The handles can be placed in two positions, as shown.
• The baskets can either be placed inside the freezer or hung on the edge of the casing.
• Spare baskets can be obtained from your local Service Force Centre.
• The following illustrations show how many baskets can be placed in various freezer models.
• The number above each illustration shows the width of the freezer in millimetres.

Illustrations showing how baskets can be placed inside the freezer or hung on the edge of the casing. The diagrams display various freezer widths in millimeters (300, 595, 795, 935, 1050, 1190, 1325, 1600) and how baskets labeled 'A' and 'B' fit within them.

Hints & Tips

Normal Operating Sounds

• You may hear faint gurgling or bubbling sounds when the refrigerant is pumped through the coils or tubing.
• When the compressor is on, the refrigerant is being pumped round and you will hear a whirring sound or pulsating noise from the compressor.
• A thermostat controls the compressor and you will hear a faint 'click' when the thermostat cuts in and out.

Food Storage

• To obtain the best performance from your freezer:
• Do not store warm food or evaporating liquid.
• Avoid buying frozen food if you cannot store it straight away. The use of an insulated container is advisable. When you arrive home, place the frozen food in the freezer immediately.
• Do not push food together too much, try to allow air to circulate around each item.
• Do not store food uncovered.
• Ensure that food placed in the freezer is dated and labelled and used in date order to ensure that food is consumed at its best.
• Lean food keeps better and longer than fatty food, salt reduces the storage time.
• Wrap the food in polythene or aluminium freezing bags or foil so that they adhere to the food and provide an airtight seal.
• Packaging which is swollen or has traces of refrozen water droplets on the pack could indicate that the product has not been kept at a suitable temperature and that it may have lost its original quality. Partially thawed food must not be refrozen, it must be consumed within 24 hours. Never exceed the storage times indicated by the manufacturer.

Energy Saving Advice

• Do not install the appliance close to sources of heat, such as a boiler or radiator.
• Locate the appliance in a cool well ventilated room and make sure that the air openings of the appliance are not obstructed.
• Avoid unnecessary frosting in the cabinet by packing all foodstuffs into airtight packages before placing them in the freezer.
• Food which is to be frozen (when cool) should be placed in the fridge before being transferred to the freezer.
• Try to avoid keeping the lid open for long periods or opening the lid too frequently as warm air will enter the cabinet and cause the compressor to switch on unnecessarily often.
• Ensure there are no obstructions preventing the lid from closing properly.

In the Event of a Power Failure

• If there is a power failure during the storage of frozen foods, keep the lid closed. If the temperature within your freezer should rise, do not refreeze the food without checking its condition. The following guidelines should assist you:
• Ice Cream: Once thawed should be discarded.
• Fruits & Vegetables: If soft should be cooked and used up.
• Breads & Cakes: Can be refrozen without danger.
• Shellfish: Should be refrigerated and used up quickly.
• Cooked Dishes: i.e. casseroles should be refrigerated and used up.
• Large Pieces of Meat: Can be refrozen providing there are still ice crystals remaining within them.
• Small Joints: Should be cooked and can then be refrozen as cooked dishes.
• Chicken: Should also be cooked and refrozen as a fresh dish.

Defrosting

• The freezer compartment will become progressively covered with frost. This should be removed with the special plastic scraper provided whenever the thickness of frost exceeds 1/4".
• During this operation it is not necessary to switch off the power supply or to remove the foodstuffs.
• However, when the ice becomes very thick on the inner liner, complete defrosting should be carried out and it is advisable to perform this operation when the appliance is empty.

To carry out complete defrosting:

• It is advisable to disconnect the appliance from the electrical supply. If the plug is inaccessible, turn the thermostat to '0'.
• Remove any stored food, wrap in several layers of newspaper and store in a cool place.
• Leave the lid open.
• To accelerate the defrosting process place a bowl of hot (not boiling) water inside the freezer and close the lid.
• When defrosting is completed, clean and dry the interior thoroughly.
• Turn the thermostat control back to a medium setting between 3-4 and leave to run for at least 2 hours.
• Replace the previously removed food.

Important

• A temperature rise of the frozen food packs during defrosting may shorten their safe storage life.
• Never use sharp metal tools to scrape off frost from the evaporator as this could damage the appliance beyond repair.

Maintenance and Cleaning

Internal Cleaning

• Clean the inside and accessories with warm water and bicarbonate of soda (5ml to 0.5 litre of water). Rinse and dry thoroughly.
• NEVER use detergents, abrasive powders, highly perfumed cleaning products or wax polishes to clean the interior as these will damage the surface and leave a strong odour.

External Cleaning

• Wash the outer cabinet with warm soapy water.

When the Appliance is not in Use

• When the appliance is not in use for long periods, disconnect from the electricity supply, empty all foods and clean the appliance, leaving the lid open to prevent unpleasant smells.

Something Not Working

Troubleshooting

• Before contacting your local Service Force Centre, check the following points.
• IMPORTANT: If you call out an engineer to a fault listed below, or to repair a fault caused by incorrect use or installation, a charge will be made even if the appliance is under guarantee.

Service Advice

• If after all above checks there is still a fault, call your local Service Force Centre.
• In-guarantee customers should ensure that the above checks have been made, as the engineer will make a charge if the fault is not a mechanical or electrical breakdown.
• Please note that proof of purchase is required for any in-guarantee service calls.

Service and Spare Parts

• In the event of your appliance requiring service, or if you wish to purchase spare parts, please contact your local Electrolux Service Force Centre by telephoning: 0870 5 929929
• Your telephone call will be automatically routed to the Service Force Centre covering your post code area. The addresses are listed on the following pages.
• Before calling out an engineer, please ensure you have read the details under the heading "Something Not Working."
• When you contact the Service Force Centre you will need to give the following details: 1. Your name, address and post code 2. Your telephone number 3. Clear and concise details of the fault 4. The model and serial number of the appliance (found on the rating plate) 5. The purchase date

Customer Care Department

• For general enquiries concerning your Electrolux appliance or for further information on Electrolux products, please contact our Customer Care Department by letter or telephone at the address below or visit our website at www.electrolux.co.uk
• Customer Care Department
• Electrolux
• 55-77 High Street
• Slough
• Berkshire
• SL1 1DZ
• Tel.: 08705 950950 (*)
• * calls to this number may be recorded for training purposes.

Guarantee Conditions

• We, Electrolux undertake that if within 12 months of the date of the purchase this Electrolux appliance or any part thereof is proved to be defective by reason only of faulty workmanship or materials, the company will, at our option repair or replace the same FREE OF CHARGE for labour, materials or carriage on condition that:
• The appliance has been correctly installed and used only on the electrical supply stated on the rating plate.
• The appliance has been used for normal domestic purposes only, and in accordance with the manufacturer's instructions.
• The appliance has not been serviced, maintained, repaired, taken apart or tampered with by any person not authorised by us.
• All service work under this guarantee must be undertaken by a Electrolux Service Force Centre.
• Any appliance or defective part replaced shall become the Company's property.
• This guarantee is in addition to your statutory and legal rights.
• Home visits are made between 8.30am and 5.30pm Monday to Friday. Visits may be available outside these hours in which case a premium will be charged.

EXCLUSIONS

• This Guarantee does not cover: Damage or calls resulting from transportation, improper use or neglect, the replacement of any light bulbs or removable parts of glass or plastic.
• Costs incurred for calls to put right an appliance improperly installed or calls to appliances outside the United Kingdom.
• Appliances found to be in use within a commercial environment, plus those which are the subject of rental agreements.
• Products of Electrolux manufacture which are not marketed by Electrolux.

EUROPEAN GUARANTEE

• If you should move to another country within Europe then your guarantee moves with you to your new home subject to the following qualifications:
• The guarantee starts from the date you first purchased your product.
• The guarantee is for the same period and to the same extent for labour and parts as exists in the new country of use for this brand or range of products.
• This guarantee relates to you and cannot be transferred to another user.
• Your new home is within the European Community (EC) or European Free Trade Area
• The product is installed and used in accordance with our instructions and is only used domestically, i.e. a normal household.
• The product is installed taking into account regulations in your new country.
• Before you move please contact your nearest Customer Care Centre, listed below, to give them details of your new home. They will then ensure that the local Service Organisation is aware of your move and able to look after you and your appliances.
• France: Senlis +33 (0)3 44 62 22 22
• Germany: Nurenberg +49 (0)911 323 2600
• Italy: Pordenone +39 (0)1678 47053
• Sweden: Stockholm +46 (0)20 78 77 50
• UK: Slough +44 (0)1753 219898

Local Service Force Centre Contact Information

To contact your local Service Force Centre telephone: 08705 929 929

Detailed addresses for Service Force Centres across various regions (Channel Islands, Scotland, North East, North West, Northern Ireland, Wales, Midlands, London & East Anglia, South East, South West) are provided in the original document.

Technical Specifications

Compliance

• This appliance complies with the following EC Directives:
• 73/23/EEC of 19.02.1973 - Low-Voltage Directive
• 89/336/EEC of 03.05.1989 (including Amendment Directive 92/31/EEC - EMC Directive.
• Some of the models are not available in all countries.
• Testing has been carried out in accordance with ISO 5155 regarding the determination of freezer capacity, energy consumption and hold-over time.
• Information for test institute: A plan of the positioning of test packages may be obtained directly from the manufacturer.

Installation

Positioning

• Place the freezer horizontally on a firm surface, resting on all four wheels. Use a wooden block or similar object to compensate for any bumps/holes in the floor's surface.
• The room should be dry and adequately ventilated.
• If the room temperature exceeds 32°C, or falls below freezing point, the freezer will not function as it should.
• Do not place the freezer close to sources of heat, radiators, chimneys, etc. and do not place the freezer in direct sunlight.
• If the freezer has been handled standing on end, it should be allowed to stand in the normal position for about 12 hours before switching it on.
• Ensure that the appliance is installed where it is easily accessible for the engineer in the event of a breakdown.

Diagram illustrating recommended clearances for freezer placement: a minimum of 5 cm on the sides and rear, and a minimum of 2 cm at the front.

Electrical Connection

Safety Precautions

• Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person.
• This appliance must be earthed.
• The manufacturer declines any liability should these safety measures not be observed.

Electrical Requirements

• Before switching on, make sure the electricity supply voltage is the same as that indicated on the appliance rating plate.
• The appliance is supplied with a 13amp plug fitted. In the event of having to change the fuse in the plug supplied, a 13amp ASTA approved (BS1362) fuse must be used.
• Should the plug need to be replaced for any reason, the wires in the mains lead are coloured in accordance with the following code:
• Green and Yellow: Earth
• Blue: Neutral
• Brown: Live
• The wire coloured green and yellow must be connected to the terminal marked with the letter "E" or by the earth symbol ? or coloured green and yellow.
• The wire coloured blue must be connected to the terminal "N" or coloured black.
• The wire coloured brown must be connected to the terminal marked "L" or coloured red.
• Upon completion there must be no cut, or stray strands of wire present and the cord clamp must be secure over the outer sheath.

Diagram of a 13A plug showing wire connections: Green and Yellow to Earth (E), Blue to Neutral (N), and Brown to Live (L). It also shows the cord clamp.