Black & Decker HHVK320J Cordless Vacuum Owner's Manual

Introduction

Thank you for choosing BLACK+DECKER!

For questions or problems with your BLACK+DECKER purchase, visit: www.blackanddecker.com/instantanswers

If you cannot find an answer or do not have internet access, call 1-800-544-6986 (Mon.-Fri., 8 a.m. - 5 p.m. EST) to speak with an agent. Please have the CATALOG NUMBER ready.

To register your new product, visit www.BlackandDecker.com/NewOwner

Safety Instructions

Definitions: Safety Alert Symbols and Words

This manual uses the following safety alert symbols and words to alert you to hazardous situations and your risk of personal injury or property damage:

• [DANGER]: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.
• [WARNING]: Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
• [CAUTION]: Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.
• [NOTICE]: Indicates a practice not related to personal injury which, if not avoided, may result in property damage.

Important Safety Instructions

When using an electrical appliance, basic precautions should always be followed, including:

• Read all instructions before using this appliance.
• [WARNING]: Failure to follow warnings and instructions may result in electric shock, fire, and/or serious injury.
• [WARNING]: Some household dust contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm (e.g., asbestos, lead in paint).
• [WARNING]: Do not attempt to modify or repair the appliance.
• [WARNING]: Do not charge the battery at ambient temperatures below 39°F (4°C) or above 104°F (40°C). Follow charging instructions and do not charge outside specified temperature range. Improper charging may damage the battery and increase fire risk.
• [WARNING]: To reduce the risk of fire, electrical shock, or injury:
• • Shock Hazard: Do not put charging base in water or other liquid.
  • Do not allow to be used as a toy. Close attention is necessary when used by or near children.
  • Use only as described in this manual. Use only manufacturer's recommended attachments.
  • Do not use with damaged cord or plug. If appliance malfunctions, has been dropped, damaged, left outdoors, or dropped into water, return it to a service center.
  • Do not pull or carry by cord, use cord as a handle, close a door on cord, or pull cord around sharp edges or corners. Keep cord away from heated surfaces.
  • Do not unplug by pulling on cord; grasp the plug, not the cord.
  • Do not handle charger, plug, or terminals with wet hands.
  • Do not put any object into openings. Keep openings free of dust, lint, hair, and anything that may reduce airflow.
  • Keep hair, loose clothing, fingers, and body parts away from openings and moving parts.
  • Use extra care when cleaning on stairs.
  • Do not use to pick up flammable or combustible liquids (e.g., gasoline) or use in areas where they may be present.
  • Do not pick up anything burning or smoking (e.g., cigarettes, hot ashes).
  • Do not use without dust bag and/or filters in place.
  • Do not charge the unit outdoors.
  • Use only the charger supplied by the manufacturer.
  • Do not incinerate the appliance, even if severely damaged; batteries can explode in a fire.
  • This appliance is intended for household use only.
  • Do not allow cord to hang over edge of table/counter or touch hot surfaces. Place unit away from sinks and hot surfaces.
  • Plug charger directly into an electrical outlet.
  • Use charger only in a standard electrical outlet (120V/60Hz).
  • Unplug charger before cleaning or maintenance.
  • Do not look into air vents when unit is on, as debris may be discharged.
  • Battery Leakage: If liquid (20-35% potassium hydroxide solution) contacts skin, wash with soap and water or neutralize with mild acid (lemon juice/vinegar). If it contacts eyes, flush immediately with clean water for at least 10 minutes. Seek medical attention.

Additional Safety Warnings

• a) Prevent unintentional starting: Ensure switch is OFF before handling.
• b) Recharge only with the manufacturer-specified charger.
• c) Do not use a damaged or modified battery pack or appliance.
• d) Do not expose battery pack or appliance to fire or excessive temperatures (above 266°F/130°C).
• e) Have servicing performed by qualified personnel using identical replacement parts.
• f) For use with chargers HHVK320J: S010QU1400040/SSC-140040US, HHVK515J: S010QU2300040/SSC-230040US.

SAVE THESE INSTRUCTIONS

Symbols

The label on your tool may include the following symbols:

• V: Volts
• A: Amperes
• Hz: Hertz
• W: Watts
• min: Minutes
• AC: Alternating Current
• DC: Direct Current
• n₀: No Load Speed
• Class I Construction (grounded)
• Earthing terminal
• Safety alert symbol
• Class II Construction (double insulated)
• /min or rpm: Revolutions or reciprocation per minute
• Wh: Watt Hours

Product Overview & Operation

Intended Use

This BLACK+DECKER lithium-ion cordless vacuum cleaner is designed for light, dry vacuum cleaning purposes for household use only.

Charging the Battery

[WARNING]: For use only with the supplied charger.

[WARNING]: Before charging, ensure the appliance is empty and thoroughly dry to prevent damage.

1. Before first use, charge the battery for at least 5 hours.
2. Ensure the appliance is switched OFF.
3. Fig. B: Plug the jack plug (9) of the jack plug charger (8) into the charging port (7) of the vacuum.
4. Plug the charger into a standard 120 Volt 60 Hz electrical outlet.

NOTE: The charger may become warm during charging; this is normal. The appliance can remain connected to the charger indefinitely.

[WARNING]: Do not charge the battery at ambient temperatures below 39°F (4°C) or above 104°F (40°C).

Charging Indicator LED

While charging, the white LEDs on the charger (8) will flash and increase in sections. When charging is complete, the white LEDs will turn off.

Switching On (Fig. C)

1. To turn the appliance ON, press the On/Off switch (1).
2. Press the On/Off switch (1) again to engage boost mode.
3. Press the On/Off switch (1) to turn the vacuum OFF.

State of Charge Indicator

The appliance features a state of charge indicator (2) with three white LED lights (10) that show the remaining battery charge. This feature is active only when the vacuum is powered on.

The LED battery indicator displays the remaining charge and warns when the battery is low. The final LED will flash continuously when only 1 minute of runtime remains. All LEDs will flash when the unit is discharged.

NOTE: The state of charge indicator is an approximate indication of battery charge and does not reflect tool functionality. It may vary based on product components, temperature, and user application.

Extendable Crevice Tool

1. To extend the crevice tool (4), pull it from the vacuum nozzle (3) until it clicks into place.
2. To collapse the crevice tool (4), push it into the vacuum nozzle (3) until it clicks into place.

Dry Pick Up

For everyday spills of dry material. Do not fill the dust bowl (5) beyond the end of the filter.

Optimizing Suction Force

To maintain optimal suction force, filters must be cleaned regularly during use.

Maintenance & Cleaning

Emptying and Cleaning the Product

[WARNING]: The filter is reusable and should be cleaned regularly.

1. Hold the dust bowl over a trash can and press the dust bowl release button (6) to open the dust bowl access door (11) (Fig. E).
2. While holding the dust bowl over the trash can, lightly shake to empty the dust bowl (5).
3. Lift the pre-filter (12) out of the dust bowl (5) (Fig. F).
4. Lift the filter (13) out of the dust bowl (5).
5. Empty the dust bowl (5).
6. Install the filter (13) into the dust bowl (5), then install the pre-filter (12) into the dust bowl (5).
7. Close the dust bowl access door (11) until it clicks firmly into place.

[WARNING]: Never use the appliance without filters. Optimum dust collection requires a clean filter.

Cleaning the Dust Bowl and Filter

The pre-filter (12) and filter (13) can be washed in warm, soapy water. The dust bowl (5) can be wiped clean with a dry cloth.

1. Ensure the filter (13), pre-filter (12), and dust bowl (5) are dry before reinstalling.

Replacing the Filters

Filters should be replaced every 6 to 9 months, or when worn or damaged. Replacement filters are available from BLACK+DECKER dealers. Visit www.blackanddecker.com to find dealers.

• Remove old filters as described in "Cleaning the Filters".
• Install new filters as described in "Cleaning the Filters".
• (Cat. no: HHVKF10) These fit all units. Dispose of used filters at a local recycling center.

Maintenance

Use only mild soap and a damp cloth to clean the vacuum. Never allow liquid inside the vacuum or immerse any part of it in liquid.

[WARNING]: Ensure the vacuum is completely dry before use.

Troubleshooting

If the product does not work, check the following:

• Charger was correctly plugged in (may feel slightly warm).
• Charger cord is not damaged and is correctly attached.
• Charger is plugged into a working electrical outlet.

For assistance, visit www.blackanddecker.com or call the BLACK+DECKER help line at 1-800-544-6986.

Accessories

Recommended accessories are available from your local dealer or authorized service center. For assistance, call 1-800-544-6986.

[WARNING]: Use of any accessory not recommended for this appliance may be hazardous.

Service Information

BLACK+DECKER Service Centers are staffed with trained personnel for efficient and reliable service. For technical advice, repair, or genuine factory replacement parts, contact your nearest BLACK+DECKER location. Find your local service location by calling 1-800-544-6986 or visiting www.blackanddecker.com.

Recycling & Warranty

RBRC® Seal

The RBRC® Seal on batteries indicates that BLACK+DECKER has paid for the recycling costs of these batteries at the end of their useful life. The Call 2 Recycle® program offers an environmentally conscious alternative for disposing of batteries, as it is illegal in some areas to place them in municipal waste.

Two-Year Limited Warranty

Black & Decker (U.S.) Inc. warrants this product against defects in material or workmanship for two (2) years from the date of purchase, provided it is used in a home environment. This warranty does not cover failures due to abuse, accidental damage, or unauthorized repairs. Defective products meeting warranty conditions will be replaced or repaired at no charge. For warranty service, return the product to the retailer or send it (prepaid) to an authorized BLACK+DECKER Service Center. Proof of purchase may be required. This warranty gives you specific legal rights, which may vary by state. This product is not intended for commercial use, which will void the warranty. All other guarantees, express or implied, are disclaimed.

LATIN AMERICA: This warranty does not apply to products sold in Latin America. Refer to packaging or contact the local company for country-specific warranty information.

Company Information

Imported by Black & Decker (U.S.) Inc., 701 E. Joppa Rd., Towson, MD 21286

BlackandDecker.com | 1-800-544-6986