DIAMOND SYSTEMS E3825 Processor Single Board Computer User Manual

DIAMOND SYSTEMS logo

SAMSON
PC/104 Single-Board Computer
with E3825/E3845 Processor

User Manual

Rev 2.0

DIAMOND SYSTEMS E3825 Processor Single Board Computer


Diamond Systems Corporation
Sunnyvale, CA 94086 USA
© 2025 Diamond Systems, Corp. All rights reserved.
Diamond Systems logo is a trademark of Diamond Systems, Corp.

Technical Support Request Form
Tel: 1-650-810-2500

VERSION 2.0 – 03/08/2025

Important Safe Handling Information

Warning! - ESD-Sensitive Electronic EquipmentWARNING!

ESD-Sensitive Electronic Equipment
• Observe ESD-safe handling procedures when working with this product.
• Always use this product in a properly grounded work area and wear appropriate ESD-preventive clothing and/or accessories.
• Always store this product in ESD-protective packaging when not in use.

Safe Handling Precautions

The Osbourne carrier board contains a high number of I/O connectors with connections to sensitive electronic components. This creates many opportunities for accidental damage during handling, installation, and connection to other equipment.

This section provides critical, best practice suggestions to avoid damage to your products. It includes descriptions of many common causes of damage – all of which can void your warranty.

Please follow these guidelines to be aware of common causes of damage and take the necessary precautions to prevent damage to your Diamond Systems’ (or any vendor’s) embedded computer boards.

Damage from incorrect handling or storage

  • Physical and electronic damage can occur from mishandling. The following are frequent scenarios.
  • An electrostatic discharge (ESD) causes a board to malfunction or stop working entirely. If ESD occurs, typically there is no visual sign of damage. While it is often difficult to identify faulty component(s), if the fault is identified there is a good chance that the board can be repaired.
  • A screwdriver slips during installation, causing a gouge in the PCB surface and cutting signal traces or damaging components.
  • A board is dropped, causing damage to the circuitry near the point of impact. Most of our boards are designed with at least 25 mils clearance between the board edge and any component pad, and ground / power planes are at least 20 mils from the edge. These design rules can minimize but cannot always prevent damage from impact.
  • A short occurs when a metal screwdriver tip slips, or a screw drops onto a board while it is powered on. This can cause overvoltage or power supply problems described below.
  • A storage rack with slots to hold boards can damage components near the board edge. Many boards have components that are close to the board edge, which are subject to damage in racks.
  • Connector pins are bent by improperly dis-assembling attached boards or ribbon cables from a pin header, or from physical impact or improper storage. Typically, bent pins can be repaired one at a time with needle-nose pliers. Severely bent or frequently repaired pins may require the replacement of the connector.

Best Practices to avoid damage during handling or storage

  • To prevent ESD damage, always follow proper ESD-prevention practices when handling any electronic components.
  • To prevent physical damage from impact, handle all boards with care and work in a safe, spacious environment.
  • To prevent short circuit damage from a metallic tool or dropped screw, perform assembly operations ONLY when the system is powered off.
  • To prevent damage to fragile components and connector pins in storage, always store boards in individual ESD-safe sleeves in sturdy bins with dividers between boards. Do NOT use racks with slots, or stack boards in a pile or in close proximity.
  • To prevent damage to connector pins during assembly or dis-assembly, use caution to align connectors and especially when force is needed to disassemble components and wires. Do not ‘rock’ connectors back and forth or pull any component at the wrong angle.

Damage due to incorrect voltage or connections

Power supply wired backwards

Diamond Systems power supplies and boards are not designed to withstand a reverse power supply connection. Reverse power will destroy nearly every IC that is connected to the power supply. Reverse power damage is rarely repairable. Check twice before applying power!

Board not installed properly in PC/104 stack

If a PC/104 board is accidentally shifted by 1 row or 1 column (of pins) it is possible for power and ground signals on the bus to contact the wrong pins. For example, this can damage components attached to the data bus because it puts the ±12V power supply lines directly on data bus lines.

Overvoltage on analog input

If a voltage applied to an analog input exceeds the design specification of the board, the input multiplexor and/or parts behind it can be damaged. Most of our boards will withstand an erroneous connection of up to ±35V on the analog inputs, even when the board is powered off, but not all boards, and not in all conditions.
Overvoltage on analog output

If an analog output is accidentally connected to another output signal or a power supply voltage, the output can be damaged. On most of our boards, a short circuit to ground on an analog output will not cause trouble.

Overvoltage on digital I/O line

If a digital I/O signal is connected to a voltage above the maximum specified voltage, the digital circuitry can be damaged. On most of our boards the acceptable range of voltages connected to digital I/O signals is 0-5V, and they can withstand about 0.5V beyond that (-0.5 to 5.5V) before being damaged. However, logic signals at 12V and even 24V are common, and if one of these is connected to a 5V logic chip, the chip will be damaged, and damage may extend past that chip to others in the circuit.

Best Practices to avoid damage due to incorrect voltage or connections

  • Ensure all power supply connections are correct and not reversed!
  • Ensure all pins are aligned properly before and after assembling boards and components!
  • Ensure proper voltage is supplied to all analog inputs!
  • Ensure all analog voltage outputs do not connect to another signal output or power supply output!
  • Ensure all voltages for digital I/O lines are proper and with range, and that higher voltage signals (24V or 12V) are not supplied to lower voltage circuits (12V or 5V)!

IMPORTANT! Always check twice before Powering Up!

Notices

Technical Support
Please use the Technical Support Request form to request assistance with a product you have already purchased.

Product and Sales Inquiry
Please use the Sales Inquiry form to request assistance with selecting a product for your application, or to obtain further information about products and service.

Limited Warranty
Diamond Systems Corporation provides a Limited Warranty for all items in this guide that it manufactures and sells, pursuant to terms provided in the Diamond Systems Corporation Limited Warranty. No other warranty, express or implied, is included. Please download the warranty for additional information.

Trademarks
All trademarks, logos and brand names are the property of their respective owners.

Document Version
Please ensure that you have downloaded the latest version of this document from the Diamond Systems Support documentation library.

Version  Date   Changes  
1.0  01/15/2025  Ver 1.0 – Initial publication.  
2.0  03/04/2025  Ver 2.0 – Added new and revised images and illustrations, added installation instructions, revised connectors section, revised text for introduction and jumper configuration. 
1. Introduction

Samson provides a low-cost medium-performance solution for customers seeking to develop PC104-based embedded computers as well as extend the lifetime of their existing PC104-based platforms. The long-life Bay Trail Atom processor with 4GB RAM provides ample performance to support Windows and Linux operating systems.

Samson features a fanless design, ensuring efficient operation without the need for active cooling. It supports the Intel® Atom™ E3800 family of processors, offering powerful performance for embedded applications. Dual Gigabit Ethernet ports provide high-speed network connectivity, while the board also includes LVDS and Analog RGB ports, enabling versatile display options. It supports dual independent displays for enhanced visual performance.

Samson’s wide temperature -40 to +85C performance allows it to be used with confidence in almost any embedded application, including stationary indoor applications as well as harsh environmental situations.

A wide array of modern I/O allows Samson to interface to the most commonly used embedded computer peripherals. The PC104 connector enables use of existing PC104 boards to simplify I/O expansion for new products and avoid costly redesign for existing systems.

This product may be considered as a possible replacement for customers with applications designed around Diamond’s Rhodeus (RDS800-LC or RDS800-XT) product.

DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 1-1
Figure 1-1: SAMSON PC/104 SBC – Top View

DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 1-2
Figure 1-2: Samson PC/104 SBC – Bottom View with SODIMM RAM

DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 1-3
Figure 1-3: Samson with PC/104 I/O module installed underneath

1.1. Samson Ordering Guide

The table below lists the available models of Samson SBC. Contact Diamond Systems sales for assistance.

As the board can work with multiple COMs. New COMs are tested and added regularly. Check the Diamond website for currently available SBC processor options. In general, when a new COM is added, OS support will also be available for the current versions of Windows and Ubuntu Linux.

Model  Features 
SAM-E3825-4G-XT  Samson PC104 SBC with E3825 dual-core processor and 4GB SODIMM RAM installed, -40 to +85C 
SAM-E3845-4G-XT  Samson PC104 SBC with E3845 processor and 4GB SODIMM RAM installed, -40 to +85C 
CK-SAM-01  Cable Kit, includes the following: 
1 x SATA cable 
1 x Audio cable 
4 x COM port cables 
1 x KB & MS cable 
1 x USB cable 
1 x VGA cable 
2 x LAN cables 
1x GPIO cable 
1x Utility Cable 
2. Features and Specifications Table

The following are the features and specifications for the Osbourne OSB-BB01 carrier board.

Feature  Specification 
CPU  • Soldered onboard Intel® Atom™ processor E3825 dual-core 1.33GHz / E3845 quad-core 1.91GHz 
Memory  • 1 x DDR3L SO-DIMM socket populated with 4GB 1333 MT/s SDRAM (8GB Max) 
BIOS  • Insyde BIOS 
Watchdog Timer  • 1 ~ 255 levels reset 
I/O Chipset  • Fintek F81866 
USB 3.0 

• 1 

USB 2.0 

• 2 

Serial  • 2x RS-232 
• 2 x RS-232/422/485 selectable 
KB/MS  • 6-pin wafer connector for PS/2 keyboard and mouse via Y-cable 
Expansion Bus  • PC/104 interface & Mini-card socket 
Storage  • 1 x Serial ATA port with 300MB/s HDD transfer rate 
• 1 x mSATA socket (Socket shared and BIOS selectable with Mini PCIe card) 
Ethernet Chipset  • 2 x RTL8111H PCIe GbE controllers 
Digital I/O  • 8-bit programmable 
Audio  • Realtek ALC888S HD Audio CODEC, Mic-in/ Line-in/Line-out 
Graphics Chipset  • Integrated Intel® HD Graphics 
Graphics Interface  • Analog RGB supports resolution up to 2048 x 1536 
• LCD: Dual Channel 24-bit LVDS 

Operating System Support

Linux Kernel version 4.4.38; Ubuntu 20.04 

Windows 10, 64-Bit  

Mechanical, Electrical and Environmental Properties

Power Requirement  +5V (Additional +12V might be required for LCD panel) 
Power Consumption  1.81A@5V with E3825 (Typical)
2.24A@5V with E3845 (Typical) 
Operating Temp.  -40 ~ 85ºC (-40 ~ 185ºF) 
Operating Humidity  10%~95% @ 85C (non-condensing) 
Dimension (L x W)  90 x 96 mm (3.55” x 3.775”) 
3. Block Diagram and Mechanical Drawings

Key functional blocks of the Samson PC/104 Single-Board Computer.

SAMSON SBC Block Diagram

Rev 1.0 DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 3-1
Figure 3-1: Samson PC/104 CPU Module Block Diagram

4. Board Dimensions

The illustrations below provide primary and secondary side dimensions of the Samson SBC. Dimensions are in “inches.”

DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 4-1
Figure 4-1: Samson PC/104 board dimensions – primary side

  1. PRIMARY SIDE
  2. I/O CONNECTIONS MAY OVERHANG WITHIN THESE REGIONS (INCLUDES MATING CONNECTOR)

DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 4-2
Figure 4-2: Samson PC/104 board dimensions – secondary side

  1. Secondary Side
5. Jumper and Connector Locations

The following images display the location of connectors and jumper blocks on both sides of the carrier board.

DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 5-1
Figure 5-1: Top view (heat sink omitted)

DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 5-2
Figure 5-2: Bottom view showing mSATA/Minicard and SODIMM sockets

6. Jumper Configuration

The board included three jumper blocks to alter the hardware configuration. These are configured as follows:

Jumper  Description  Connector 
JP1  Set LCD inverter voltage  2.00mm pitch, 1×3-pin header jumper 
JP2  Set LCD panel voltage  2.00mm pitch, 1×3-pin header jumper 
JP3  The voltage selection of LCD panel  2.00mm pitch, 1×3-pin header jumper 
JP4  (Do not use. For service / testing only.) 

 

6.1. JINV1

Use the JP1 jumper to set the LCD inverter voltage as needed for your LCD panel. This jumper sets the voltage for pin 1 of the INV1 connector. Configure the voltage as follows:

  • Pins 1-2: +12V
  • Pins 2-3: +5V (default setting)
6.2. JLVCD1

Use the JP2 jumper to set the LCD panel voltage as needed for your LCD panel. This jumper determines the voltage for pins 1 and 2 of the LVCD1 connector. Configure the voltage as follows:

  • Pins 1-2: +5V
  • Pins 2-3: +3.3V (default setting)
6.3. JBAT1

Use the JP3 jumper to “keep” or “clear” the CMOS memory.
To reset (clear) the CMOS set the jumper to pins 2-3 for a few seconds. After the CMOS is clear, move the jumper back to pins 1-2.

  • Pins 1-2: Keeps CMOS (default setting)
  • Pins 2-3: Clear CMOS
7. Connector Pinout Specifications
7.1. USB1

The USB1 connector is a USB 3.0/2.0 Type A connector, designed to support both USB 3.0 and 2.0 devices.
The pin assignments follow the industry-standard specifications, ensuring compatibility with a wide range of USB peripherals. Industry-standard Type A cables can be used with this connector.

Description: USB Type A right-angle 3.0/2.0 Connector

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a1

7.2. LAN1 & LAN2

The Ethernet connectors use a 2.00mm pitch 2×5-pin wafer connector. The pin assignments are as follows:

TX_MDI0- 

2 

1 

TX_MDI0+ 
MDI2+ 

4 

3 

RX_MDI1+ 
RX_MDI1- 

6 

5 

MDI2- 
MDI3- 

8 

7 

MDI3+ 
N/C 

10 

9 

N/C 

Connector: JST part no. B10B-PHDSS
Connector Type: 2.00mm pitch 2×5-pin wafer connector
Mating connector: JST part no. PHDR-10VS
Mating Cable: DSC no. 6989032

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a2

7.3. USB2

The board supports 2 USB2.0 ports with a 2×5 connector. The pin assignments are as follows:

+5V-  2  1  +5V 
USBP1-  4  3  USBP0- 
USBP1+  6  5  USBP0+ 
GND  8  7  GND 
N/C  10  9  GND 

Connector: JST part no. B10B-PHDSS
Connector Type: 2.00mm pitch 2×5-pin wafer connector
Mating connector: JST part no. PHDR-10VS
Mating Cable: DSC no. 6989033

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a2

7.4. AUDIO1

The AUDIO1 connector is a 2.00mm pitch 2×5-pin connector. The pin assignments are as follows:

Line In R  2  1  Line In L 
Gnd3  4  3  Gnd1 
N/C  6  5  Mic 
Gnd4  8  7  Gnd2 
Line Out R  10  9  Line Out L 

Connector: JST part no. B10B-PHDSS
Connector Type: 2.00mm pitch 2×5-pin wafer connector
Mating connector: JST part no. PHDR-10VS
Mating Cable: DSC no. 6989030

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a2

7.5. DIO1

The Digital I/O lines operate with 5V logic levels and are individually configurable for input or output. These DIO lines are controlled with a C language programming library available for free download. The library provides functions for direction configuration, input, and output operations.

DIO 0  1  2  DIO 1 
DIO 2  3  4  DIO 3 
DIO 4  5  6  DIO 5 
DIO 6  7  8  DIO 7 
5V  9  10  GND 

Connector: JST part no. B10B-PHDSS
Connector Type: 2.00mm pitch 2×5-pin wafer connector
Mating connector: JST part no. PHDR-10VS
Mating Cable: DSC no. 6989036

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a2

7.6. VGA1

VGA availability is dependent on the installed COM. The pin assignments are as follows:

1 

VSync 

2 

HSync 

3 

GND 

4 

SCL 

5 

SDA 

6 

GND 

7 

BLUE 

8 

GND 

9 

GREEN 

10 

GND 

11 

RED 

12 

GND 

13 

VCC 

Connector PN: ACES 86801-13 or Amphenol 10114829-11113LF
Connector Type: 1×13-pin 1.25mm 4-wall connector
Mating part no.: Amphenol 10114826-00013LF
Mating Cable: DSC no. 6989035

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a3

7.7. KBMS1

The connector for keyboard and mouse uses a 1×6-pin 1.25mm 4-wall connector. The pin assignments are as follows:

1  KB_DATA 
2  KB_CLK 
3  GND 
4  PS2_VCC 
5  MS_DATA 
6  MS_CLK 

Connector PN: Cvilux CI4406P1V00-LF or AdamTech 125SH-A-06-TS
Connector Type: 1×6-pin 1.25mm 4-wall connector
Mating connector: AdamTech 125CH-A-06
Mating Cable: DSC no. 6989034

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a4

7.8. COM1 to COM4

The board supports four COM ports on 4 connectors.

  • Serial ports 1 and 2 support RS-232, RS-422, and RS-485 protocols. The connector pinout for each protocol is shown below.
  • Serial ports 3 and 4 support RS-232 only. The connector pinout for RS-232 protocol is shown below.

 

Serial Ports 3 & 4 

N/A  N/A 

Serial Ports 1 & 2  

PIN 

RS-232  RS-422  RS-485 
1 

DCD# 

TX-  D- 
2  DSR# 

 

 

3  RX  TX+  D+ 
4  RTS# 

 

 

5  TX  RX+ 

 

6  CTS# 

 

 

7  DTR#  RX- 

 

8  RI# 

 

 

9  GND  GND  GND 

Connector PN: ACES 86801-09 or AdamTech 125SH-A-09-TS
Connector Type: 1×9-pin1.25mm 4-wall connector
Mating connector: AdamTech 125CH-A-09
Mating Cable: DSC no. 6989031

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a5

7.9. JFRT1 (Utility)

The connector for reset, power LED, HDD LED, and speaker uses a 2.54mm pitch 1×8-pin header. The pin assignments are as follows:

1  Reset 
2  Gnd 
3  Power LED+ 
4  Gnd 
5  HD LED+ 
6  HDD LED- 
7  Speaker+ 
8  Speaker- 

Connector type: Industry standard 1×8 .1” single-row vertical pin header
Mating Cable: DSC no. 6989037

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a6

7.10. SATA1

The Serial ATA (SATA) connector supports high-speed data transfer rates of up to 300MB/s. This connector type is designed for fast and reliable data transfer, ideal for hard drives and SSDs, conforming to the SATA interface standard for modern storage solutions. The pin assignments are as follows:

1  Ground 
2  Transmit + 
3  Transmit – 
4  Ground 
5  Receive – 
6  Receive + 
7  Ground 

Connector Type: Industry-standard SATA 7-pin vertical connector
Mating Cable: Generic; DSC cable no. 6989102 may be used

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a7

7.11. LVDS1

The LCD panel connector is a DF-13-30DP-1.25V type connector. This connector is specifically designed for LCD panel connections, providing a reliable interface with a 1.25mm pitch to support the required signal and power connections for the display. The pin assignments are as follows:

VDD 5V/3.3V  1  2  VDD 5V/3.3V 
TX1CLK+  3  4  TX2CLK+ 
TX1CLK-  5  6  TX2CLK- 
GND  7  8  GND 
TX1_D0+  9  10  TX2_D0+ 
TX1_D0-  11  12  TX2_D0- 
GND  13  14  GND 
TX1D1+  15  16  TX2_D1+ 
TX1D1-  17  18  TX2_D1- 
GND  19  20  GND 
TX1D2+  21  22  TX2D2+ 
TX1D2-  23  24  TX2D2- 
GND  25  26  GND 
TX1D3+  27  28  TX2D3+ 
TX1D3-  29  30  TX2D3- 

Connector PN: Hirose DF13-30DP-1.25V

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a8

7.12. BAT1

The Battery Connector is a 2-pin connector. The pin assignments are as follows. Replaement batteries may have alternate wiring polarities. Note the color coding of the wires in the photo. If the battery is replaced, make sure the + (red) and – (black) wires are in the same positions as in the photo.

1  Power + 
2  GND 

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a9

7.13. INV1

The LCD Inverter Connector uses a 1×6-pin CVILUX 1.25mm CI4406P1V00-LF 4-wall connector. The pin assignments are as follows:

1  INV_VCC 
2  INV_VCC 
3  BKLT_EN 
4  BKLT_CTRL 
5  GND 
6  GND 

Connector PN: CVILUX 1.25mm CI4406P1V00-LF
Connector Type: 1×6-pin 4-wall connector

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a4

7.14. PWR1

The input power is provided by a 5-position screw terminal block.

Although two terminals are provided for both 5V input and Ground, the individual terminal rating exceeds the power requirements for Samson, so just a single +5V wire and a single Ground wire is sufficient.

1  VCC  12V Backlight power input, not required for SBC operation 
2  GND  Common connection for all input voltages 
3  GND  Common connection for all input voltages 
4  VCC 5V  Main power input for SBC operation 
5  VCC 5V  Main power input for SBC operation 
7.15. FAN1

FAN1 is not used. For reference only. 1.25mm pitch 1×3-pin wafer connector. Pin1 GND. Pin2 5V. Pin3 N/C.

The heat sink on Samson is sufficient for operation up to 85C in a free air environment. If a PC104 board is installed on the top side however, the upper temperature limit may be reduced.

7.16. PCIe Minicard / mSATA – CON3

(On the bottom of the board.) The bord contains a dual-use PCIe Minicard / mSATA 52-Pin full-size socket. The pin assignments conform to the industry standard. A single mounting standoff is provided for a full-size card.
Half-size cards can be used with an extender, which may be included with the half-size module or is easily obtainable.

Connector PN:
Connector Type: 52-pin Minicard Socket

DIAMOND SYSTEMS E3825 Processor Single Board Computer - a10

7.17. PC104 Bus

The PC/104 bus is essentially identical to the ISA Bus except for the physical design. It specifies two pin and socket connectors for the bus signals. A 64-pin header J1 incorporates the 62-pin 8-bit bus connector signals, and a 40-pin header J2 incorporates the 36-pin 16-bit bus connector signals. The additional pins on the PC/104 connectors are used as ground or key pins. The female sockets on the top of the board enable stacking another PC/104 board on top of the board, while the male pins on the bottom enable the board to plug into another board below it.

In the pinout figures below, the tops correspond to the left edge of the connector when the board is viewed from the primary side (side with the CPU chip and the female end of the PC/104 connector) and the board is oriented so that the PC/104 connectors are along the bottom edge of the board.

View from Top of Board

J2: PC/104 16-bit bus connector

Ground 

D0 

C0 

Ground 

MEMCS16- 

D1  C1  SBHE- 

IOCS16- 

D2  C2  LA23 

IRQ10 

D3  C3  LA22 

IRQ11 

D4  C4  LA21 

IRQ12 

D5  C5  LA20 

IRQ15 

D6  C6  LA19 

IRQ14 

D7  C7  LA18 

DACK0- 

D8  C8  LA17 

DRQ0 

D9  C9  MEMR- 

DACK5- 

D10  C10  MEMW- 

DRQ5 

D11  C11  SD8 

DACK6- 

D12  C12  SD9 

DRQ6 

D13  C13  SD10 

DACK7- 

D14  C14  SD11 

DRQ7 

D15  C15  SD12 

+5V 

D16  C16  SD13 

MASTER- 

D17  C17  SD14 

Ground 

D18  C18 

SD15  

Ground 

D19 

C19 

Key (pin cut) 

J1: PC/104 8-bit bus connector

IOCHCHK- 

A1 

B1 

Ground 

SD7 

A2  B2 

RESET 

SD6 

A3  B3 

+5V 

SD5 

A4  B4 

IRQ9 

SD4 

A5  B5 

-5V 

SD3 

A6  B6 

DRQ2 

SD2 

A7  B7 

-12V 

SD1 

A8  B8 

0WS- 

SD0 

A9  B9 

+12V 

IOCHRDY 

A10  B10 

Key (pin cut) 

AEN 

A11  B11 

SMEMW- 

SA19 

A12  B12 

SMEMR- 

SA18 

A13  B13 

IOW- 

SA17 

A14  B14 

IOR- 

SA16 

A15  B15 

DACK3- 

SA15 

A16  B16 

DRQ3 

SA14 

A17  B17 

DACK1- 

SA13 

A18  B18 

DRQ1 

SA12 

A19  B19 

Refresh- 

SA11 

A20  B20 

SYSCLK 

SA10 

A21  B21 

IRQ7 

SA9 

A22  B22 

IRQ6 

SA8 

A23  B23 

IRQ5 

SA7 

A24  B24 

IRQ4 

SA6 

A25  B25 

IRQ3 

SA5 

A26  B26 

DACK2- 

SA4 

A27  B27 

TC 

SA3 

A28  B28 

BALE 

SA2 

A29  B29 

+5V 

SA1 

A30  B30 

OSC 

SA0 

A31  B31 

Ground 

Ground 

A32  B32 

Ground 

8. PC/104 I/O Board Installation

Samson supports a PC/104 (ISA bus) I/O expansion board in either 8-bit or 16-bit configuration.

Each PC/104 board has its own address range. The lowest address of this range is called the base address. Most PC/104 boards will have information on how to select the base address. No two boards may overlap their address ranges, otherwise the system will not operate correctly.

Many PC/104 boards also use interrupts, or IRQs. If so, these may also be configurable. The PC/104 standard allows for multiple boards to share the same interrupt level. Information on interrupt level selection and interrupt sharing will be found in the board’s user manual.

8.1. Installation

PC/104 I/O boards can be installed either above or below the Samson board. The following photos depicts the clearance available in either (above or below) configuration.

The preferred installation position is below the board, so that the heat sink has free exposure to air for convection cooling. If a PC/104 board is installed on top of Samson, it will block the heat sink, reducing its effectiveness. The maximum operating temperature may be reduced in this scenario.

DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 8-1
Figure 8-1: Samson with PC/104 board mounted below (preferred position)

DIAMOND SYSTEMS E3825 Processor Single Board Computer - Figure 8-2
Figure 8-2: Samson with PC/104 board mounted above (may reduce upper temperature limit)

Installation Steps

  1. Check that the PC/104 connectors are compatible. The PC/104 standard specifies two key pins on the connectors, numbered B10 and C19. On the top socket side, these pins should be plugged, and on the bottom side, they should be cut away. This helps to prevent misalignment during installation. Not all vendors adhere to both the plugged sockets and cut pins. In the case that you are installing a board without cut pins onto a board with plugged sockets, you can either pull out the plugs on the top side or cut the interfering pins on the bottom side. These pins have no function on the PC/104 bus, so they can be cut without any adverse impact on performance.
  2. Install PC/104 spacers (4-40 0.6” length or M2.5/M3 15.24mm length) in the 4 corners to maintain the proper distance and parallel positioning. Spacers should always be used in all 4 corners for reliability and to avoid damage. Align the two boards, then press down carefully to connect them. Push straight down until the boards are fully seated.

Removal Steps

  1. To remove a PC/104 board, grab the two boards to be separated so that the thumb of each hand is on one of the boards at the PC/104 connector side. Rock the two boards back and forth carefully along the axis of the PC/104 connectors, using a very limited range of motion (about 5-10 degrees maximum rotation).

Rock back and forth multiple times while gently pulling the boards apart. After 10-15 rocking motions, the boards should eventually come apart.

Be very careful to pull the boards apart evenly across the length of the connectors to avoid bending the PC/104 pins. If the pins become bent by accident, needle-nose pliers can generally be used to straighten them out again.


Samson PC104 SBC User Manual Ver 2.0       www.diamondsystems.com

Documents / Resources

DIAMOND SYSTEMS E3825 Processor Single Board Computer [pdf] User Manual
E3825, E3845, E3825 Processor Single Board Computer, E3825, Processor Single Board Computer, Single Board Computer, Board Computer, Computer

References

Leave a comment

Your email address will not be published. Required fields are marked *