Empire FLB-NCD-3 Ni-CD 6V 1600mAh Battery Instruction Manual

1. Introduction

This manual provides essential instructions for the safe and effective use of your Empire FLB-NCD-3 Ni-CD 6V 1600mAh battery. This battery is designed as a replacement for compatible Streamlight and GE/Ericsson flashlight batteries. Please read this manual thoroughly before initial use and retain it for future reference.

Figure 1: Empire FLB-NCD-3 Ni-CD 6V 1600mAh Battery

2. Safety Information

Always observe the following safety precautions to prevent injury or damage to the battery and device:

• Do not short-circuit the battery terminals.
• Do not expose the battery to extreme temperatures (above 60°C / 140°F or below -20°C / -4°F).
• Do not incinerate or dispose of the battery in fire.
• Do not disassemble, puncture, or modify the battery.
• Keep the battery away from water and moisture.
• Keep out of reach of children and pets.
• Use only chargers specifically designed for Ni-CD batteries.
• If the battery leaks, avoid contact with skin and eyes. Rinse immediately with water and seek medical attention.

3. Package Contents

Verify that your package contains the following item:

• 1 x Empire FLB-NCD-3 Ni-CD 6V 1600mAh Battery

4. Setup and Installation

Before first use, it is recommended to fully charge the battery. Refer to the 'Charging' section for detailed instructions.

4.1 Battery Installation

1. Ensure your flashlight or compatible device is turned off.
2. Locate the battery compartment on your device. Refer to your device's manual for specific instructions on opening the compartment.
3. Carefully insert the Empire FLB-NCD-3 battery, ensuring the positive (+) and negative (-) terminals align correctly with the device's contacts. The battery features a silver cap on one end (positive) and a green ring on the other (negative).


Figure 2: Positive Terminal (Silver Cap)


Figure 3: Negative Terminal (Green Ring)
4. Close the battery compartment securely.

5. Operating the Battery

Once installed and charged, the battery powers your compatible device. For optimal performance and to mitigate the 'memory effect' common in Ni-CD batteries, it is recommended to fully discharge the battery before recharging it. This helps maintain the battery's capacity over its lifespan.

6. Charging

To charge your Empire FLB-NCD-3 battery:

1. Use a charger specifically designed for Ni-CD batteries with appropriate voltage and current ratings. Using an incompatible charger can damage the battery or pose a safety risk.
2. Follow the instructions provided with your charger for proper connection and charging procedures.
3. Avoid overcharging, as this can reduce battery life. Many modern Ni-CD chargers have automatic shut-off features.
4. The battery may become warm during charging; this is normal. If it becomes excessively hot, discontinue charging immediately.

7. Maintenance

7.1 Storage

Store the battery in a cool, dry place, away from direct sunlight and extreme temperatures. For long-term storage, it is advisable to store Ni-CD batteries in a discharged state and periodically recharge them every few months to prevent deep discharge and maintain cell health.

7.2 Cleaning

Periodically clean the battery terminals with a dry, clean cloth to ensure good electrical contact with your device.

8. Troubleshooting

• Battery not charging: Ensure the battery is correctly inserted into the charger and the charger is plugged into a working power source. Verify the charger is compatible with Ni-CD batteries.
• Short operating time: This could indicate the 'memory effect' in Ni-CD batteries. Try performing a few full discharge/charge cycles. If the issue persists, the battery may be nearing the end of its lifespan.
• Battery does not fit: Double-check the model number and compatibility with your device. Ensure no obstructions are in the battery compartment.

9. Specifications

Figure 4: Battery Label with Part Number and Rating

10. Warranty Information

This Empire FLB-NCD-3 battery comes with a 1-year warranty from the date of purchase. This warranty covers manufacturing defects. It does not cover damage caused by misuse, abuse, unauthorized modification, or normal wear and tear. Please retain your proof of purchase for warranty claims.

11. Disposal Information

Ni-CD batteries contain cadmium, a toxic heavy metal, and must be disposed of responsibly. Do not dispose of this battery in household waste. Please recycle it at an authorized battery recycling facility. Contact your local waste management authority for information on recycling options in your area.

12. Support

For further assistance, technical support, or warranty inquiries, please contact Empire customer service through their official website or the retailer from whom you purchased the product.