1. Bubuka
This manual provides essential instructions for the safe and efficient operation, maintenance, and troubleshooting of your DEWALT DXH75KT 75,000 BTU Kerosene Forced Air Heater. This rugged heater is designed for use in well-ventilated construction sites, barns, warehouses, and workshops, providing powerful heat output.
Key features include a two-piece split barrel for easier cleaning and maintenance, an ergonomic handle for transport, recessed controls to minimize damage, and continuous electronic ignition for reliable starting.
Image 1.1: DEWALT DXH75KT 75,000 BTU Kerosene Forced Air Heater.
2. Émbaran Kasalametan
WARNING: READ AND UNDERSTAND ALL INSTRUCTIONS BEFORE USING THIS HEATER. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN FIRE, EXPLOSION, SERIOUS INJURY, OR DEATH.
- FOR OUTDOOR USE ONLY OR IN EXTREMELY WELL-VENTILATED AREAS. This heater consumes oxygen and produces carbon monoxide. Adequate ventilation is critical to prevent carbon monoxide poisoning. Never use in enclosed residential spaces, bedrooms, or living rooms.
- Always use Kerosene (K-1) as the fuel. Never use gasoline, benzene, alcohol, or any other highly flammable liquids.
- Jaga jarak anu pas tina bahan anu gampang kaduruk. Tingali labél produk pikeun jarak anu khusus.
- Pernah ninggalkeun manaskeun unattended bari operasi.
- Jauhkeun barudak sareng piaraan jauh tina manaskeun.
- Pastikeun pemanas disimpen dina permukaan anu stabil, rata, sareng henteu gampang kaduruk.
- Ulah ngahalangan liang asupan hawa atanapi knalpot.
- Produk ieu ngandung bahan kimia anu dipikanyaho ku Nagara Bagian California tiasa nyababkeun kanker sareng cacad lahir atanapi gangguan réproduktif anu sanés (Peringatan Proposisi 65).
3. komponén Leuwihview
The DEWALT DXH75KT heater consists of the following main components:
- Heater Barrel: Houses the burner and fan assembly.
- Tangki BBM: Located at the base, holds kerosene fuel.
- Panél kontrol: Features recessed controls for power and temperature adjustment.
- Gagang ergonomis: For easy lifting and transport.
- Kabel listrik: For electrical connection (110 Volts).
Image 3.1: DEWALT DXH75KT Kerosene Heater in a work environment.
4. Setélan
Turutan léngkah ieu pikeun nyetél manaskeun anjeun:
- Buka bungkusan sareng mariksa: Carefully remove the heater from its packaging. Inspect for any shipping damage. If damaged, do not operate and contact customer support.
- Majelis: Some minor assembly may be required, typically attaching the handle. Refer to the included assembly guide for detailed steps.
- Posisi: Place the heater on a firm, level surface in a well-ventilated area. Ensure adequate clearance from walls, ceilings, and combustible materials as specified in the safety warnings.
- Bahan bakar: Unscrew the fuel cap. Using a clean funnel, carefully fill the tank with K-1 Kerosene only. Do not overfill. The fuel gauge will indicate the level. Securely replace the fuel cap.
- Sambungan listrik: Plug the heater's power cord into a grounded 110-Volt electrical outlet. If an extension cord is necessary, ensure it is rated for outdoor use and has sufficient gauge for the heater's power requirements.
Image 4.1: Dimensions of the DEWALT DXH75KT Kerosene Heater.
5. Parentah Operasi
To operate your DEWALT Kerosene Heater:
- Ensure Fuel and Power: Verify the fuel tank is adequately filled with K-1 Kerosene and the heater is properly plugged into a 110-Volt grounded outlet.
- Hurungkeun: Locate the power switch on the control panel and switch it to the 'ON' position. The fan will start, and the continuous electronic ignition system will initiate the burner.
- Saluyukeun Suhu: Use the thermostat control knob to set the desired heat output. The heater will cycle on and off to maintain the set temperature.
- Ngawaskeun: Observe the heater during initial operation to ensure proper functioning. The flame should be stable and consistent.
- Pareuman: To turn off the heater, switch the power switch to the 'OFF' position. Allow the fan to run for a few minutes to cool down the unit before unplugging or moving.
6. Pangropéa
Pangropéa rutin mastikeun kinerja anu optimal sareng umur panjang pemanas anjeun:
- beberesih: The two-piece split barrel design allows for easier access for cleaning. Regularly clean the exterior of the heater and ensure air intake and exhaust areas are free from dust and debris.
- Filter bahan bakar: Periodically check and clean or replace the fuel filter to prevent clogs and ensure consistent fuel flow.
- Inspeksi umum: Before each use, inspect the power cord for damage, check for any fuel leaks, and ensure all components are securely fastened.
- Panyimpenan: When storing the heater for extended periods, ensure the fuel tank is empty and clean. Store in a dry, safe location away from children and flammable materials.
7. Cara ngungkulan
Upami anjeun mendakan masalah sareng manaskeun anjeun, tingal masalah sareng solusi umum ieu:
| Masalah | Mungkin Cukang lantaranana | Solusi |
|---|---|---|
| Heater does not start or ignite. | No power, no fuel, clogged fuel filter, ignition issue. | Check power connection, ensure fuel in tank, clean/replace fuel filter, contact service if ignition fails. |
| Kaluaran panas low. | Low fuel, clogged fuel filter, improper thermostat setting. | Refill fuel, clean/replace fuel filter, adjust thermostat to a higher setting. |
| Excessive smoke or odor. | Incorrect fuel type, poor ventilation, dirty burner. | Ensure K-1 Kerosene is used, improve ventilation, clean burner components. |
For persistent issues or complex repairs, contact qualified service personnel.
8. Spésifikasi
- merek: DEWALT
- model: DXH75KT (also known as F340675)
- Kaluaran panas: 75,000 BTU
- Jenis suluh: Minyak Tanah (K-1)
- Voltage: 110 volt
- Fitur husus: Suhu adjustable
- Pamakéan Indoor/Outdoor: Outdoor (or well-ventilated construction sites, barns, warehouses, and workshops)
- Ukuran produk: 14.25 "D x 32.37" W x 17.12" H
- Tipe Pamasangan: Lantai Gunung
- Cakupan pemanasan: Approximately 1875 square feet
- Tipe Burner: Pancaran
- Setélan Suhu Min: 25 darajat Fahrenheit
- Setélan Suhu Max: 95 darajat Fahrenheit
- Majelis Diperlukeun: Sumuhun
- Komponén Kaasup: Mr. Heater F340675: Dewalt 75,000 Btu Forced Air Kerosene Heater
- Pabrikan: Mr. Heater Corporation
9. Garansi
This DEWALT DXH75KT Kerosene Forced Air Heater comes with a 1-year warranty. Please retain your proof of purchase for warranty claims. For specific terms and conditions, refer to the warranty documentation included with your product or contact the manufacturer.
10. Rojongan
For technical assistance, replacement parts, or any questions not covered in this manual, please contact DEWALT customer support or visit their official website. Always provide your product model number (DXH75KT or F340675) when seeking support.
