mailto:info@vodaland.ca
Installation Guide for VODALAND models including: MONO 100, MONO 100 4 Inch Polymer Concrete Trench Drain, 4 Inch Polymer Concrete Trench Drain, Polymer Concrete Trench Drain, Concrete Trench Drain, Trench Drain, Drain
Specs and Installation Library | Vodaland Canada
File Info : application/pdf, 2 Pages, 587.91KB
DocumentDocumentINSTALLATION SPECIFICATION MONO 100 (SPORT) SYSTEM - LOAD CLASS 250 EXPOSED ASPHALT PAVEMENT INSTALLATION 4" (100mm) MONO POLYMER CONCRETE TRENCH DRAIN Technological joints G) As halt concrete avement CD 3/8"(10mm) Bitumen- ol mer ta e 3/B"x3/4"x( 1 0x20mm) Steel installation tool Notes 3------,.,,......,...-.,..._,..,..,.....,.....,...,.....,.,.._,,.....,..,.-.,.....,.....,.....,,,.....iv 4-------,,...,....,......,...,,.., 5-----=;W=-:;w:::;f/77777//-:Wt,W/7)'7/} Trench drain 1 Concrete encasement 2 Vapour seal foil 3 Beddin la er h=4" 100mm 4 Soil 5 PARAMETER CONRETE ENCASEMENT DEPTH (A), in CONRETE ENCASEMENT WIDTH (C), in LOAD CLASS CLASS A CLASS B CLASS C 4" (100mm) 4" (100mm) 6" (150mm) 4" (100mm) 4" (100mm) 6" (150mm) NOTES: 1. SPECIFIER IS RESPONSIBLE FOR CONCRETE ENCASEMENT AND REINFORCING BASED UPON APPLICATION AND LOCAL CODES. 2. EXPANSION AND CONTRACTION CONTROL JOINTS AND REINFORCEMENT ARE RECOMMENDED TO PROTECT CHANNEL AND CONCRETE SURROUND. ENGINEERING ADVICE MAY BE REQUIRED. 3. THIS INSTALLATION SCHEME IS A RECOMMENDATION. CONSULT WITH THE MANUFACTURER FOR INSTALLATION INSTRUCTIONS. 4. IF TRENCH DRAIN SYSTEM HAS A VERTICAL OUTLET AT THE END OF THE RUN, IT IS NECESSARY TO ADD AN ADDITIONAL 4" (100mm) OF CONCRETE ENCASEMENT AFTER THE END CAP. 5. THE FINISHED LEVEL OF CONCRETE SURROUND SHOULD BE 1/8" - 3/16" (3-5mm) ABOVE THE TOP OF THE CHANNEL EDGE. GENERAL: THE TRENCH DRAIN SHALL BE VODALAND CANADA MONO 100 (SPORT) AS MANUFACTURED BY VODALAND OR APPROVED EQUAL. SPECIFICATION: CHANNELS SHALL BE 39.4" (1000MM) LONG AND THE NOMINAL CLEAR OPENING SHALL BE 4" (100MM) WITH 5.5" (140MM) OVERALL WIDTH AND BUILT IN NEUTRAL SLOPE AS PER SPECIFIER'S REQUIREMENTS. EACH UNIT WILL FEATURE A FULL RADIUS IN THE TRENCH BOTTOM AND FEATURE MALE-TO-FEMALE INTERLOCKING JOINTS. GRATE OPENING SHALL BE MONOLITHICALLY CAST AS A PART OF THE TRENCH DRAIN BODY AS A SINGLE PIECE. CHANNELS AND GRATE SHALL WITHSTAND A REQUIRED EN1433 LOAD CLASS. MATERIALS: MONO 100 (SPORT) TRENCH DRAIN SHALL BE MANUFACTURED FROM POLYMER CONCRETE WITH THE FOLLOWING APPROXIMATE PROPERTIES: COMPRESSIVE STRENGTH FLEXURAL STRENGTH TENSILE STRENGTH WATER ABSORPTION FROST PROOF DILUTE ACID AND ALKALI RESISTANT SALT PROOF 14,000 PSI 4,000 PSI 1,500 PSI 0.05% YES YES YES THE COMPLETE DRAINAGE SYSTEM SHALL BE BY VODALAND CANADA INC. ANY DEVIATION OR PARTIAL SYSTEM DESIGN AND/OR IMPROPER INSTALLATION WILL VOID ANY AND ALL WARRANTIES PROVIDED BY VODALAND CANADA INC. REVISED: 2024 Vodaland Canada Inc. 1-5900 Ambler Dr, Mississauga, ON L4W 2N3 · Phone: 905-238-1771 · Email: info@vodaland.ca INSTALLATION SPECIFICATION MONO 100 (SPORT) SYSTEM - LOAD CLASS 250 EXPOSED ASPHALT PAVEMENT INSTALLATION 4" (100mm) MONO POLYMER CONCRETE TRENCH DRAIN CHECK AND SPECIFY APPROPRIATE OPTIONS: Name 4" MONO polymer concrete endcap H7.9" (end) 4" MONO polymer concrete endcap H7.9" (beginning) Article 67019-5K 67019-5N , in 7.9 7.9 H, mm 200 200 Vodaland Canada Inc. 1-5900 Ambler Dr, Mississauga, ON L4W 2N3 · Phone: 905-238-1771 · Email: info@vodaland.ca REVISED: 2024