SANYO FXD-RS60RM/XE Service Manual

Full Panel Detachable High Power FM/MW/LW Stereo Receiver Compact Disc Player

FILE NO. 114782740

Model: FXD-RS60RM

Front panel view of the SANYO FXD-RS60RM/XE unit, showing controls for SEL/SET, VOLUME, EQ, IR, OPEN, POWER, DISP, MP3, AS/PS, 1 PAU, 2 SCN, 3 RPT, 4 SHF, 5 DISC, 6 DISC, PTY, AF, TA, MODE SW, and a display area labeled "RISEON" with "FO CLASSICS", "RES LOC", "LOUD", "TP TA PTYAF", and "DIR" indicators. The unit also features a CD slot and a SANYO logo.

Specifications: 2
Disassembly Instructions: 3
Disassembly Diagram: 4
Operation Check: 5
Block Diagram: 6
Alignment Locations: 7
Alignment Procedures: 8
Printed Circuit Boards: 9
Service Part List: 20
Exploded View (Panel): 21
Exploded View Parts List (Panel): 22
Exploded View (Cabinet): 23
Exploded View Parts List (Cabinet): 24
Exploded View (Deck): 26
Exploded View Parts List (Deck): 27
Schematic Diagrams: 29
Electrical Parts List: 33

REFERENCE NO: SM-0600009

SPECIFICATIONS

Category	Parameter	Value
FM TUNER	Frequency Range	FM 87.5 - 108.0 MHz (50 KHz Step)
	Sensitivity	FM 3 µV (S/N=30 dB)
	Stereo Separating (FM)	30 dB (at 1kHz)
	Signal to noise ratio (FM)	Better than 50 dB
AM TUNER	Frequency Range	MW 522 - 1620 kHz (9 KHz Step)
	Sensitivity	MW 32 dBµ (S/N=20 dB)
	Signal to Noise Radio	More than 45 dB
LW TUNER	Frequency Range	LW 144 - 288 kHz
	Sensitivity	LW 35 dBµ (S/N=20 dB)
CD PLAYER	Frequency Response	20Hz - 20,000Hz
	Signal to Noise Radio	More than 65 dB
	Channel Separation	More than 60 dB
	T. H. D.	Less than 0.30%
AUDIO AMPLIFIER & GENERAL	Output Power	4 X 50 W
	Speaker Output Impedance	4 ohm
	Power Source	DC 12V, Negative ground.

Specifications are subject to change without notice.

DISASSEMBLY INSTRUCTIONS

Using the unlock key that came with the unit or a similar tool, unlock the Mounting Box and remove toward the rear of the unit.
Remove two screws (A) located on the rear of the side bracket then remove the Bottom Cover.
Remove two screws (B) located on the rear of the side bracket then remove the Bottom Cabinet.
Take out the Panel and the Ring. Remove the screw (C) from on the front of the base.
Remove two screws (D) from on the left side of the side bracket. Remove two screws (E) from on the right side of the side bracket then remove the Deck.
Remove two screws (F) from each side of the base then remove the Base.
Remove two screws (G) from on the left side of the side bracket then remove Spring Sheet. Remove five screws (H) from on the left side of the side bracket then remove the Heat Sink.
Remove the screw (I) from on the back of the side bracket then remove the ISO Antenna Socket /Short W /Holder.
Remove the screw (J) from on the back of the side bracket and remove two screws (K) from on the main board then remove the Heat Sink (7809/DB435).
Remove the screw (L) from on the back of the side bracket then remove the 36PIN ISO Socket.
Remove three screws (M) from under the main board then remove the Main Board.

DISASSEMBLY DIAGRAM

Exploded view diagram illustrating the disassembly sequence of the SANYO FXD-RS60RM/XE unit. Key components are labeled with letters (A-M) corresponding to the disassembly instructions. Components shown include: Top Cabinet (A), Bottom Cabinet (B), Panel, Ring (C), Base (F), Deck (E), Spring Sheet (G), Heat Sink (H), Side Bracket (L), Mounting Box, ISO Antenna Socket/Short W/holder (I), 36PIN ISO Socket (D), Main Board (K), and FM/AM Tuner (J).

OPERATION CHECK

GENERAL SPECIFICATIONS OF SIGNAL

Parameter	Frequency/Value	Modulation/Level
Standard frequency FM	98.1 MHz (87.5, 108 MHz)
Standard frequency MW	1000 kHz (522, 1620 kHz)
Standard frequency LW	200 kHz (144, 288kHz)
Signal output FM	1mV
Signal output MW	5 mV
Signal output LW	5 mV
Modulation MW		400 Hz 30% MOD.
Modulation FM Stereo		1 kHz 75kHz DEV. 46% for L only or R only pilot level 8%
AF output level	FM/MW/LW
Power source voltage	DC 14.0V (Backup voltage is the same as this)
AF load impedance	4 ohm pure resistance
Balance	Center position of level
Tone	Center position

The signal strength read in this section is voltage on the antenna.

Test Diagram

Diagram showing connections for operation check. It illustrates the main unit connected to 2-SPEAKER and 4-SPEAKER outputs (FRONT SPK, RL. SPR., RR. SPK., FL. SPK., FR. SPE.), ACC (DV14.4V), BACK UP (14.4V), GROUND, and POWER ANTENNA. External test equipment includes a DISTORTION METER, VTVM, DUMMY ANTENNA, MPX STEREOS MODULATOR, AM SG, and FM SG, with various connections to the main unit.

BLOCK DIAGRAM

Functional block diagram of the SANYO FXD-RS60RM/XE. Key blocks include: FM/AM Tuner (FAE-347-A29), Main UCOM (OP6244-001), Power Amp (TDA7560), CD Mecha Deck and Servo (CDM-1683EUR), LCD Driver (LC75823ED), Key Board, RDS Demodulator (SAA6579), Audio Pre-Amp (KIA-4558F), and various oscillators (16.934MHz, 4.33MHZ, 7.2MHZ). Connections are shown for ANT, ISO Socket, AUX IN, CDC CON, LINE OUT, S.WOODFER OUT, and power rails (+5V, +8V, +9V, +12V).

ALIGNMENT LOCATIONS

FM/MW/LW TUNER

Diagram indicating the locations of alignment points on the FM/MW/LW Tuner board. These include variable resistors (VR1, VR2, VR3) and transformers (T1, T2, T3, T4, T5) used for tuning and signal adjustments.

ALIGNMENT PROCEDURES

FM ADJUSTMENT

Equipment Required

AM/FM IF/RF signal generator
Solid-state voltmeter (SSVM)
Regulated DC power supply
2-CH voltmeter
Distortion meter

FM Alignment Using FM Signal Generator

Note: Press the radio power switch to on the radio. Signal generator output must be kept as low as possible to avoid overload and clipping.

Step	Generator Coupling	Generator	Display Setting	Adjustment	Remarks
Stereo Separation	Signal Generator to antenna receptacle	98.1 MHz Int. 1 kHz Dev. 75 kHz L+R = 90 % pilot = 10%	98.1 MHz	VR1	Adjust AF output power at maximum separating more than 30 dB
FM SNC Adjustment	98.1 MHz Dev. 75 kHz L+R=90% Int. 1 kHz 60dBµV output	98.1 MHz @ 40 dBµ	98.1 MHz	VR2	Stereo Separation 25 dB (± 5 dB)
Stop SENS.	Signal Generator to antenna receptacle	98.1 MHz Mod. 1kHz Dev 75kHz	98.1 MHz	VR3	Adjust AF to stop station.

Note: The tuner module is well-adjust and adjustment is not recommended.

PRINTED CIRCUIT BOARDS

MAIN BOARD (TOP VIEW)

Top view of the Main Printed Circuit Board, showing the layout of various components including integrated circuits (e.g., IC801, IC802A, IC804), transistors, resistors, capacitors, and connectors (e.g., CON801, CON301). Key sections like the TUNER, TEL-MUTE, and various power and signal lines are indicated. The board is labeled '11-02911-025 SIDE-B VER.C'.

MAIN BOARD (BOTTOM VIEW)

Bottom view of the Main Printed Circuit Board, showing the solder side and component traces. Various resistors and capacitors are visible, along with the outlines of integrated circuits. The board is labeled '11-02911-025 SIDE-A VER.C'.

ISO PCB BOARD (TOP VIEW)

Top view of the ISO PCB Board, labeled '11-01000-435 SIDE-B VER.A'. It shows connections for +B BUS, AG, L, R, C-GND, SWOUT, AUX-R, FL, RL, A-G, CDCON, SW-G, AUX-G, NC, TEL-MUT, AUX-L, RGND, FR, RR, RL+, RL-, FR+, FR-, RR+, RR-, B+IN, B+OUT, GND, ACC, and ANT.

KEY BOARD (TOP VIEW)

Top view of the Key Board, labeled '11-02910-308 LCD SIDE-B VER:A'. It displays the layout of various LEDs (LED1-LED22) and control buttons such as SEL, EQ, POWER, DSP, AMS, M1/PAU, M2/SCN, M3/RPT, M4/SHF, M5/DN, M6/UP, PTY, MODE/FUNC, AF(MUTE), TA(LOC), BAND/LOUD, SEEK/DN, SEEK/UP, and VOLUME1 (VR1). An LCD display area is also indicated.

KEY BOARD (BOTTOM VIEW)

Bottom view of the Key Board, labeled '11-02910-308 LCD SIDE-A VER:A'. It shows the traces and component pads for the various keys and LEDs, along with resistors and connections to the main unit via CON1.

CD SERVO BOARD (TOP VIEW)

Top view of the CD Servo Board, labeled '12-14311-120 REV-0'. It features integrated circuits (U1, U2, U5), various resistors and capacitors, and connectors (J101, J201, J202, J203, J204, J205) for signals like FEO, LD, SVCC, LDG, LPD, GND-S, TEQ, TR-, FO-, TRA, VREF, SP+, SP-, FEED+, FEED-, ADSW, SL-, SL+, EJEND, LDST, RO AND LO.

CD SERVO BOARD (BOTTOM VIEW)

Bottom view of the CD Servo Board, showing the underside traces and component pads. It includes components like X301 and X201.

REMOTE BOARD (TOP VIEW)

Top view of the Remote Board, labeled '11-17020-505 SIDE-B RC06 CD1702(X3.6.3) VER-A'. It shows the layout of buttons for POWER, MOD/7, VOL+, SEL, TUN-/8, TUN+/9, BND/EN, VOL-, AMS/M3/EQ, 1/PAU, 2/SCN, 3/RPT, DSP/0/MUTE, 4/SHF, 5/CD-, and 6/CD+.

REMOTE BOARD (BOTTOM VIEW)

Bottom view of the Remote Board, labeled '11-17020-505 SIDE-A RC06 CD1702(X3.6.3) VER-A'. It displays the IC500 (UPD6121G-001), a transistor (Q500), resistors (R501, R502, R506, R507), capacitors (C500, C501, C502), and a ceramic resonator (CF501), along with connections for BATTERY 3V, GND, and B+3V.

FRONT & DETACHABLE BOARD (TOP VIEW)

Top view of the Front & Detachable Board, labeled '11-02910-345 SIDE-B VER:D'. It shows a LED, resistors (R5), a transistor (Q1), and connections for DTH, RESET, and LAMP.

FRONT & DETACHABLE BOARD (BOTTOM VIEW)

Bottom view of the Front & Detachable Board, labeled '1-02910-345 SIDE-A VER:D'. It shows various resistors (R1, R2, R3, R4, R7, R8, R9, R10) and connections for ACC, GND, LP+, COL2, COL3, DI, KEY1, CLK, KEY2, CE, END, HNI, REM, +5V, VEE, NC, RES, F1, F2, EJ, ED.

SERVICE PARTS LIST

Panel Assembly Parts List

Ref. No.	Description	Parts No.
1	PANEL ASSEMBLY	RP60RM/XE-PA
2	CD MECHANISM ASSEMBLY	RP60RM -CDMECH
3	MAINBOARD ASSEMBLY	RP60RM-MB
4	RC ASSEMBLY	RP60RM/XE-RC
5	TRIM RING	RP51-16227-80D

Exploded View Parts List (Panel)

*Following part list is only for reference, not supplied as service parts

Ref. No.	Description	RS Part No.
1	Lens; (Mirror Effect) RDS FXD-RS60RM	RP53-29135-011
2	T. Panel (S. OPC1202) FXD1 W/SW	RP51-29121-810
3	Panel Bottom	RP51-29122-00
4	Sensor Lens (PMS 433C)	RP53-29136-11W
5	Left Panel (S. OP1202)	RP52-29123-80
6	Right Panel (S. OP1202)	RP52-29124-82B
7	Encoder (E-Silver)	RP52-29126-90E
8	Decorative Ring	RP52-29134-00
9	Ring Inside Encoder	RP52-29127-00
10	Open Key (S. OP1202)	RP52-29125-80
11	TUN BND Knob Spring	RP36-34601-00
12	SEL/SET Knob (L-Up) (S. OPC1202)	RP52-29131-82
13	EQ Key (L-Up) (S. OPC1202)	RP52-29130-81
14	Power/DISP/6Discs Key (L-Up) (S. OPC1202)	RP52-29129-83
15	PTY-MODE Key (L-Up) (S. OP1201)	RP52-29128-82
16	BAND/NANU/-SKIP Key (L-Up) (S. OPC1202)	RP52-29132-81
17	Key Board	RP11-02910-308
18	Encoder SRGP200200 (ALPS)	RP18-00163-00
19	LCD Cover	RP39-E2104-01
20	CD158 LCD TN NEG Blue MASK PIN Type	RP27-01580-12Y
21	LED B.L. QB02002-09 23.5X99 WHT	RP02-A1560-09
22	Axis Post	RP34-24601-00
23	Right Side Block	RP52-E2128-00
24	Contact Spring	RP36-78008-00
25	Left Side Block	RP52-E2129-00
26	E-Ring Ø1.5X4X0.4MM	RP35-00001-00
27	Screw Ø2X8 BH/ST Black	RP40-12008-01

Exploded View (Cabinet)

Exploded view diagram illustrating the assembly of the SANYO FXD-RS60RM/XE cabinet and internal components. Numbered parts indicate various brackets, covers, the CD mechanism, main board, mounting box, and other structural elements.

Exploded View Parts List (Cabinet)

*Following part list is only for reference, not supplied as service parts

Ref. No.	Description	RS Part No.
1	Panel	RP51-16227-80D
2	Ring (S. OPC1202)	RP51-16227-80D
3	Base (Reset + FLASHING LED)	RP51-E2125-01
4	Side Bracket (ISO)	RP61-E2003-01
5	CD MECH. CDM-1683EUK W/O Bracket (143A)	RP94-01683-11
6	Heat Sink (ISO)	RP61-E2004-00
7	Top Cabinet	RP61-B0105-01
8	Bottom Cabinet (ISO)	RP61-B0106-01
9	Main Fiber	RP35-B0101-00
10	Main Board	RP11-02911-025
11	Mounting Box (072)	RP61-07211-03
12	Shade	RP81-69005-02
13	CD Windows Sheet	RP43-E2001-00
14	Hook Shaft	RP34-D2101-00
15	Hook Spring	RP36-E2101-00
16	Hook	RP52-E2127-00
17	Push Out Spring	RP36-E2102-00
18	Panel Pole	RP52-E2126-00
19	Base B.L.	RP52-29138-00
20	Front Board	RP11-02910-345
21	20PIN Socket	RP25-F0217-20
22	EJ Knob (L-Up) (S. OPC0000)	RP52-29139-01
23	Eject Board	RP11-02910-345
24	Right Bracket	RP39-E2101-01
25	Damper Gear ASS'Y /19-24 T/Q	RP93-12246-01
26	Middle Gear (F)	RP52-E2130-00
27	Left Bracket	RP39-E2102-01
28	Deck Front Bracket	RP39-E2105-00
29	Deck Rear Bracket	RP39-B0101-00
30	FM Cover	RP39-D0507-00
31	MITSVMI Tuner FAE-347-A29	RP29-00347-02
32	36PIN ISO Socket W/RCA/CDC/AUXIN (SANYO)	RP25-12246-36
33	Spring Sheet	RP39-B0102-00
34	Heat Sink (7809/DB435) W/O Shaft	RP39-B0113-01
35	Screw Ø5X18 HH	RP40-05018-04
36	Spring Washer M5	RP35-50001-00
37	Hexagon Nut M5	RP35-40005-00
38	ISO Antenna Socket/Short W/Holder	RP39-24613-00
39	Antenna Bracket	RP52-24625-00
40	Screw Ø2X3 CH/MA Black	RP40-12003-09H

Exploded View (Deck)

Exploded view diagram detailing the components of the CD Deck mechanism. Numbered parts illustrate various gears, shafts, rollers, sensors, motors, and springs that comprise the CD playback and loading system.

Exploded View Parts List (Deck)

*Following part list is only for reference, not supplied as service parts

Ref. No.	Description	Parts No.	Q'ty
1	SENSOR	RPST-23G	2
2	SENSOR PCB	RPFR	1
3	SCREW	RPCA/H 0" TT 2*3	12
4	COVER-UPPER	RPSECC T1.0 1	1
5	LEVER DISC	RPPOM (F20-03) 1	1
6	GUIDE UP	RPPOM (F20-03) 2	1
7	BUSHING ROLLER	RPPOM (F20-03) 3	2
8	ROLLER DISC	RPSLICON	2
9	SHAFT ROLLER	RPSUS 303	1
10	PIN ROLLER	RPSUM24L-NI 1	1
11	PVC CAP	RPPVC	2
12	B/K ROLLER	RPSECC T1.0 2	1
13	PIN PULLEY	RPSUM24L-NI 2	1
14	PIN IDLE	RPSUM24L-NI 3	1
15	GEAR IDLE	RPPOM (F20-03) 4	1
16	GEAR PULLEY	RPPOM (F20-03) 5	1
17	BELT PULLEY	RPCR-WRT	1
18	GEAR ROLLEY	RPPOM (F20-03) 6	1
19	LOCKER (L)	RPPOM (F20-03) 7	1
20	CAM (L)	RPPOM (F20-03) 8	1
21	S/P CAM (L)	RPSUS304WPB 1	1
22	S/P RACK	RPSUS304WPB 2	1
23	CAM (R)	RPPOM (F20-03) 9	1
24	LOCKER ®	RPPOM (F20-03) 10	1
25	GEAR RACK	RPPOM (F20-03) 11	1
26	GEAR LOAD ®	RPPOM (F20-03) 12	1
27	GEAR LOAD (D)	RPPOM (F20-03) 13	1
28	GEAR LOAD (B)	RPPOM (F20-03) 14	1
29	GEAR LOAD (A)	RPPOM (F20-03) 15	1
30	PIN LOAD	RPSUM24L-NI 4	4
31	B/K GEAR	RPSECC T1.0 3	1
32	MOTOR	RPFF-050SH-11190	1
33	GEAR WORM	RPPOM(F20-03) 16	1
34	SERVO PCB ASSY	RPGLASS EPOXY	1
35	SPECIAL SCREW	RPP/H TTS 2*2	4
36	S/P RO (L)	RPSUS304WPB 3	1
37	SUPPORT DAMPER	RPPOM (F20-03) 17	3
38	S/P RO®	RPSUS304WPB 4	1
39	CHASSIS MAIN	RPSEEC T1.0 4	1

Exploded View Parts List - Continued (Deck)

*Following part list is only for reference, not supplied as service parts

Ref. No.	Description	Parts No.	Q'ty
40	CLAMP DISC	RPPOM (F20-03) 18	1
41	HOLD CLAMPER	RPSECC T1.0 5	1
42	S/P CLAMPER	RPSUS304WPB 5	1
43	TURN TABLE	RPABS G/F 20%	1
44	BASE PU	RPPOM (F20-03)	1
45	PIN SIDE (A)	RPSUM24L-NI 5	2
46	SCREW	RPCA/H 0" M/S	2
47	PIN SIDE (B)	RPSUM24L-NI 6	2
48	DAMPER	RPBUTHYL	1
49	S/P BASE	RPSUS304WPB 6	2
50	MOTOR	RPRF400CA12265	1
51	GEAR PU (B)	RPHYTRELL 5526	1
52	GEAR PU (A)	RPPOM(F20-03) 19	1
53	SCREW	RPCA/H0" M/S 2*2	6
54	MOTOR	RPFF-050SH	1
55	HOUSING GEAR	RPPOM(F20-03) 20	1
56	SHAFT PU	RPKNN11 (PCD18)	1
57	SCREW	RPR/H(W/W)TTB2*5	1
58	4P CONT WIRE	RP1007 #28	1
59	SPRING TENSION	RPSUS304WPB 7	1
60	GEAR PU ®	RPPOM (F20-03) 21	1
61	LEAD SCREW	RPBSBM	1
62	SWITCH	RPSW-110	1
63	SCREW	RPB/H TTB1.7*8	1
64	PICK UP	RPSF-C99	1
65	FPC WIRE	RPPOLY AMIDE	1
66	SPRING PU	RPSUS T0.2	1
67	FIBER PAPER	RP---------	1
68	S/P CAM®	RP0.55	1
69	TRANSIT SCREW	RP4.5*18	2
70	INSULATOR COVER	RPPE	1
71	SWITCH	RPSW-111	1
72	WASHER PE	RPPE	2
73	S/P BASE ®	RPSUS304WPB 8	2

SCHEMATIC DIAGRAMS

SCHEMATIC DIAGRAM (MAIN BOARD)

Detailed schematic diagram of the Main Board, illustrating the electrical connections and components. Key functional blocks include the MITSUMT TUNER (FAE-347-A29), MAIN UCOM (OP6244-001), POWER AMP (TDA7560), E.VOL/BASS/TRE/FAD (PT2312), RDS DEOMDULATOR (SAA6579), and various power supply sections. Connections to external interfaces like ANT, ISO SOCKET, AUX IN, CDC CON, and LINE OUT are shown, along with internal signal paths and power distribution.

SCHEMATIC DIAGRAM (KEY BOARD)

Schematic diagram of the Key Board, showing the connections between the various buttons, LEDs, the LCD display, and the LC75823 IC. It details the resistor networks for key sensing and LED control, as well as the interface to the main unit via CON1.

SCHEMATIC DIAGRAM (REMOTE BOARD)

Schematic diagram of the Remote Board, featuring the IC500 (UPD6121G-001) microcontroller, which processes button presses and controls the infrared LED (LD1) for remote transmission. It shows the battery input, resistors, capacitors, and the matrix of buttons (POWER, MOD/7, VOL+, SEL, TUN-/8, TUN+/9, BND/EN, VOL-, AMS/M3/EQ, 1/PAU, 2/SCN, 3/RPT, DSP/0/MUTE, 4/SHF, 5/CD-, 6/CD+).

SCHEMATIC DIAGRAM (CD SERVO BOARD)

Detailed schematic diagram of the CD Servo Board, outlining the control and signal processing for the CD mechanism. Key integrated circuits include U1 (SIL9226), U2 (S5L9276), and U5 (KA9259D), responsible for servo control, data processing, and motor drivers. It shows connections for the pick-up unit, various motors (SLED, SPINDEL, FEED), and interfaces to the main board for data and control signals.

ELECTRICAL PARTS LIST

*Following part list is only for reference, not supplied as service parts

PC BOARD ASSY, MAIN BOARD

Ref. No.	Part No.	Description	Q'ty
Q810	RP01-00435-00S	TR. BD435 TO-126 SAMSUNG	1
Q4,104,603,802,TEL-Q1	RP01-00812-00	TR. 2SA812	5
Q812	RP01-01240-00	TRANSISTOR B1240	1
Q3,105~7,601,610,801/3~6/8,811/3/4,820	RP01-03875-07	TRANSISTOR 2SC3875G	16
IC804	RP01-07805-00	IC-REGULATOR 78L05	1
ZD601/2	RP02-00062-07	E.S.D. DIODE NNCD6.2G (5PIN)	2
D802/4/7	RP02-04001-00	DIODE IN4001	3
D1,601,624/6,632/6,647,803/5/6/8/9~14,TEL-D1	RP02-04148-00A	DIODE 1N-4148 AT. (TAPPING)	19
D801	RP02-15230-01R	DIODE 1.5KE 30A	1
ZD803	RP02-50100-00A	ZENER DIODE 10V 0.5W AT. TAPE ±2%	1
IC601	RP03-02312-00	I.C. PT2312	1
IC701/2	RP03-04558-16	I.C. BA-4558F	2
IC602	RP03-06244-00	IC OP6244-001 RDS (MP3+ESP)	1
IC802	RP03-07201-00	IC NJU7201 U50 (SOT-89) 5V	1
IC801	RP03-07560-00	IC TDA7560 (4X50W) “Y2”	1
IC803	RP03-07818-00	REGULATOR LC-78L18	1
IC101	RP03-09256-01	I.C. TC-9256F	1
XT601	RP04-00072-01	CRYSTAL HC-49U/S 7.2MHZ	1
C140,603/4,805~8	RP05-63102-01	CHIP 1000PF ±10% X7R 0603 SMT	7
C207	RP05-63103-01	CHIP 0.01µF ±10% X7R 0603 SMT	1
C108,110/1,607,811/8,833,840/2	RP05-63104-01	CHIP 0.1µF ±10% X7R 0603 SMT	9
C119,124	RP05-63220-00	CHIP CAP 22PF ±5% NPO 0603 SMT	2
C101/5/9,112/3,605,817,C1	RP05-63223-01	CHIP 0.022µF ±10% X7R 0603 SMT	8
C1,620~3	RP05-63224-01	CHIP 0.22µF ±10% X7R 0603 SMT	5
C601	RP05-63270-00	CHIP CAP 27PF ±5% NPO 0603 SMT	1
C615/6	RP07-63272-01	CHIP 2700PF ±10% X7R 0603 SMT	2
C602	RP05-63300-00	CHIP CAP 30PF ±5% NPO 0603 SMT	1
C814.	RP05-63474-02	CHIP CAP 0.47µF ±20% X7R 0603 SMT	1
C3	RP06-00473-11	PANASONIC GOLD CAP EECSOHD473H	1
C2	RP06-10106-02	E. CAP 10µF 10V (Ø4X5MM) SUP MINI	1
C836	RP06-10107-01	E. CAP 100µF 10V (Ø5X7MM MINI)	1
C107,123,606,617,838	RP06-10107-02	E. CAP 100µF 10V (6X5) SUPER MINI	5
C834/5	RP06-10227-01	E. CAP 220µF 10V (Ø6MM MINI)	2
C702	RP06-10227-02	E. CAP 220µF 10V (Ø8X5MM)	1
C102,125,308,813,837/9	RP06-10476-03	E. CAP 47µF 10V (6X5)	6
C106,809,812	RP06-16106-02E	E. CAP 10µF/16V (Ø4X5MM RC3)	3
C701,837	RP06-16107-04	E. CAP 100µF/16V (Ø6X5MM)	2
C122,618	RP06-16226-02	E. CAP 22µF 16V (Ø5X5MM)	2
C636	RP06-16336-02	E. CAP 33µF 16V (Ø6.3X5MM)	1
C810	RP06-16338-00S	E. CAP 3300µF/16V 105°C	1
C819,841	RP06-16475-02	E. CAP 4.7µF 16V (Ø3.5X5MM)	2
C116/7,610,801~5	RP06-50105-03	E. CAP 1µF 50V (Ø4X5 MM)	8
C611/4/9,609,624~7,703~6	RP06-50225-02	E. CAP 2.2µF 50V (4X5)	12
C612/3	RP06-50334-03	E. CAP 0.33µF 50V (Ø4X5MM)	2
R640	RP07-05022-10	RES. 2.2Ω 1/2W	1
R854	RP07-05100-00	RES. 10Ω 1/4W	1
R134,600,620,857	RP07-05100-16A	RES. 10Ω 1/16W (TAPPING)	4
R651	RP07-05101-00	RES. 100Ω 1/4W	1
R118	RP07-05101-16A	RES. 100Ω 1/16W (TAPPING)	1
R653	RP07-05102-16A	RES. 1KΩ 1/16W(TAPPING)	1
R837	RP07-05103-16A	RES. 10KΩ 1/16W(TAPPING)	1
R645/6	RP07-05220-16A	RES. 22Ω 1/16W (TAPPING)	2
R1	RP07-05472-16A	RES. 4.7kΩ 1/16W (TAPPING)	1
R701,828/9,RA02~7,	RP07-63000-00	CHIP RES. 0Ω ±5% 0603 SMT	9
R103,140	RP07-63100-00	CHIP RES. 10Ω ±5% 0603 SMT	2
RA01	RP07-63101-00	CHIP RES. 100Ω ±5% 0603 SMT	1
R101,120,601/3,643,716~9,831,852	RP07-63102-00	CHIP RES. 1kΩ ±5% 0603 SMT	11
R4,7,102/9,110/9,623/5,631/2/6,801~4,838,841~4,851/3,TEL-R1/3,	RP07-63103-00	CHIP RES. 10kΩ ±5% 0603 SMT	23
R12,819,822	RP07-63104-00	CHIP RES. 100kΩ ±5% 0603 SMT	3
R612/3/6/7/9	RP07-63105-00	CHIP RES. 1MΩ ±5% 0603 SMT	5
R818	RP07-63152-00	CHIP RES. 1.5KΩ ±5% 0603 SMT	1
R827	RP07-63154-00	CHIP RES. 150kΩ ±5% 0603 SMT	1
R1,814~7	RP07-63184-00	CHIP RES. 180kΩ ±5% 0603 SMT	5
R121,633/4,827	RP07-63222-00	CHIP RES. 2.2KΩ ±5% 0603 SMT	4
R702/3,805~8,813,863/4	RP07-63223-00	CHIP RES. 22kΩ ±5% 0603 SMT	9
R614,626,860	RP07-63224-00	CHIP RES. 220kΩ ±5% 0603 SMT	3
R704/9,710/5	RP07-63273-00	CHIP RES. 27KΩ ±5% 0603 SMT	4
R108,846	RP07-63331-00	CHIP RES. 330Ω ±5% 0603 SMT	2
R113/4,605,629/30,827	RP07-63332-00	CHIP RES. 3.3KΩ ±5% 0603 SMT	6
R849	RP07-63333-00	CHIP RES. 33KΩ ±5% 0603 SMT	1
R607	RP07-63334-00	CHIP RES. 330kΩ ±5% 0603 SMT	1
R627/8	RP07-63394-00	CHIP RES. 390kΩ ±5% 0603 SMT	2
R3	RP07-63470-00	CHIP RES. 47Ω ±5% 0603 SMT	1
R850,TEL-R2	RP07-63471-00	CHIP RES. 470Ω ±5% 0603 SMT	2
R122/9,130,602/4/6,611,840	RP07-63472-00	CHIP RES. 4.7kΩ ±5% 0603 SMT	8
R2,124~6,608,641,706/7,712/3,820/1/3/5,830/5,845,861/2/6	RP07-63473-00	CHIP RES. 47kΩ ±5% 0603 SMT	20
R622	RP07-63512-00	CHIP RES. 5.1k	1

ELECTRICAL PARTS LIST - CONTINUED

*Following part list is only for reference, not supplied as service parts

PC BOARD ASSY, MAIN BOARD SUB-W SECTION

Ref. No.	Part No.	Description	Q'ty
Q901/2	RP01-03875-07	TRANSISTOR 2SC3875G	2
Q904	RP01-08050-03	TR. 8050C TO-92-B	1
D613,901	RP02-04148-00A	DIODE 1N-4148 AT. (TAPPING)	2
IC901	RP03-04558-16	I.C. BA4558F	1
C903/7	RP05-63683-01	CHIP 0.068µF ±10% X7R 0603 SMT	2
C902/5	RP06-10107-02	E. CAP 100µF 10V (6X5) SUPER MINI	2
C906	RP06-16106-02E	E. CAP 10µF/16V (Ø4X5MM RC3)	1
C904	RP06-16107-04	E. CAP 100µF 16V (Ø6X5MM)	1
C901	RP06-50105-03	E. CAP 1µF 50V (Ø4X5MM)	1
R902	RP07-05224-16A	RES. 220kΩ 1/16W (TAPPING)	1
R914	RP07-63100-00	CHIP RES 10Ω ±5% 0603 SMT	1
R913	RP07-63102-00	CHIP RES 1KΩ ±5% 0603 SMT	1
R906/8,915	RP07-63103-00	CHIP RES 10KΩ ±5% 0603 SMT	3
R910	RP07-63222-00	CHIP RES 2.2KΩ ±5% 0603 SMT	1
R901/3/4	RP07-63224-00	CHIP RES 220kΩ ±5% 0603 SMT	3
R920	RP07-63331-00	CHIP RES 330Ω ±5% 0603 SMT	1
R905/7/9	RP07-63393-00	CHIP RES 39KΩ ±5% 0603 SMT	3
R912/6,921	RP07-63473-00	CHIP RES 47KΩ ±5% 0603 SMT	3
R911	RP07-63681-00	CHIP RES 380Ω ±5% 0603 SMT	1

PC BOARD ASSY, MAIN BOARD FM TUNER SECTION

Ref. No.	Part No.	Description	Q'ty
Q101~3,204	RP01-03875-07	TRANSISTOR 2SC3875G	4
D101,641	RP02-04148-00A	DIODE 1N-4148 AT. (TAPPING)	2
IC102	RP03-06579-00	IC SAA-6579T	1
XT101	RP04-00433-00M	C. 4.332MHZ HC-49U 30PPM 22PF	1
C120/1,132	RP05-63103-01	CHIP 0.01µF ±10% X7R 0603 SMT	3
C128,131	RP05-63223-01	CHIP 0.022µF ±10% X7R 0603 SMT	2
C126	RP05-63330-00	CHIP CAP 33PF ±5% NPO 0603 SMT	1
C127	RP05-63470-00	CHIP CAP 47PF ±5% NPO 0603 SMT	1
C130	RP05-63681-00	CHIP CAP 680PF ±5% NPO 0603 SMT	1
C114/5	RP05-63682-01	CHIP 6800PF ±10% X7R 0603 SMT	2
C118	RP06-50224-02	E. CAP 0.22µF 50V (Ø3X5MM)	1
C133	RP06-50225-02	E. CAP 2.2µF 50V (4X5)	1
R104	RP07-05101-16A	RES. 100Ω 1/16W (TAPPING)	1
R141	RP07-05222-16A	RES. 2.2KΩ 1/16W (TAPPING)	1
R132/3	RP07-63100-00	CHIP RES 10Ω ±5% 0603 SMT	2
R131	RP07-63101-00	CHIP RES 100Ω ±5% 0603 SMT	1
R105,117	RP07-63102-00	CHIP RES 1KΩ ±5% 0603 SMT	2
R106	RP07-63151-00	CHIP RES 150Ω ±5% 0603 SMT	1
R107	RP07-63471-00	CHIP RES 470Ω ±5% 0603 SMT	1
R204	RP07-63473-00	CHIP RES 47KΩ ±5% 0603 SMT	1
R111/2	RP07-63562-00	CHIP RES 5.6KΩ ±5% 0603 SMT	2
TUNER	RP29-00347-02	MITSUMT TUNER FAE-347-A29	1

PC BOARD ASSY, MAIN BOARD AM TUNER SECTION

Ref. No.	Part No.	Description	Q'ty
Q203	RP01-00812-00	TR. 2SA812	1
Q201/2	RP01-03875-07	TRANSISTOR 2SC3875G	2
D641/6	RP02-04148-00A	DIODE 1N-4148 AT. (TAPPING)	2
C208	RP05-16225-00	TAN CAP. 2.2µF 16V	1
C206	RP05-63103-01	CHIP 0.01µF ±10% X7R 0603 SMT	1
C201~3	RP05-63223-01	CHIP 0.022µF ±10% X7R 0603 SMT	3
C204	RP06-16106-02E	E. CAP. 10µF/16V (4X5MM RC3)	1
R209	RP07-05100-16A	RES 10Ω 1/16W (TAPPING)	1
R205/7/8	RP07-63102-00	CHIP RES 1KΩ ±5% 0603 SMT	3
R201/3	RP07-63103-00	CHIP RES 10KΩ ±5% 0603 SMT	2
R202	RP07-63331-00	CHIP RES 330Ω ±5% 0603 SMT	1
R206	RP07-63822-00	CHIP RES 8.2KΩ ±5% 0603 SMT	1
L201	RP09-70470-04	M. INDUCTOR AL03TO4R7 (AXIAL)	1

PC BOARD ASSY, KEY BOARD

Ref. No.	Part No.	Description	Q'ty
Z1	RP02-00062-07	E.S.D. DIODE NNCD6.2G (5PIN)	1
LED7	RP02-01112-02F	SMD LED BR1112H RED "STANLEY"	1
LED1~6,8~22	RP02-01112-05M	SMD LED BL-HW135A 0805 PURE GREN	21
IC2	RP03-75823-00	IC LC75823ED	1
C1,4	RP05-63104-01	CHIP 0.1µF ±20% X7R 0603 SMT	2
C2	RP05-63681-01	CHIP 680P ±5% NPO 0603 SMT	1
R11,39	RP07-05221-00	RES 220Ω 1/4W	2
R18,25~8	RP07-63102-00	CHIP RES 1KΩ ±5% 0603 SMT	5
R33/4/6/8	RP07-63121-00	CHIP RES 120Ω ±5% 0603 SMT	4
R19	RP07-63152-00	CHIP RES 1.5KΩ ±5% 0603 SMT	1
R3	RP07-63153-00	CHIP RES 15KΩ ±5% 0603 SMT	1
R1,13	RP07-63181-00	CHIP RES 180Ω ±5% 0603 SMT	2
R24	RP07-63183-00	CHIP RES 18KΩ ±5% 0603 SMT	1
R2,14,32	RP07-63221-00	CHIP RES 220Ω ±5% 0603 SMT	3
R8,20	RP07-63222-00	CHIP RES 2.2KΩ ±5% 0603 SMT	2
R7	RP07-63223-00	CHIP RES 22KΩ ±5% 0603 SMT	1
R35,43/5	RP07-63273-00	CHIP RES 27KΩ ±5% 0603 SMT	3
R15	RP07-63331-00	CHIP RES 330Ω ±5% 0603 SMT	1
R21	RP07-63332-00	CHIP RES 3.3KΩ ±5% 0603 SMT	1
R4	RP07-63470-00	CHIP RES 47Ω ±5% 0603 SMT	1
R16	RP07-63471-00	CHIP RES 470Ω ±5% 0603 SMT	1
R22	RP07-63472-00	CHIP RES 4.7KΩ ±5% 0603 SMT	1
R31	RP07-63473-00	CHIP RES 47KΩ ±5% 0603 SMT	1
R9	RP07-63513-00	CHIP RES 51KΩ ±5% 0603 SMT	1
R6	RP07-63562-00	CHIP RES 5.6KΩ ±5% 0603 SMT	1
R5,17	RP07-63681-00	CHIP RES 680Ω ±5% 0603 SMT	2
R23	RP07-63822-00	CHIP RES 8.2KΩ ±5% 0603 SMT	1
R30	RP07-63823-00	CHIP RES 82KΩ ±5% 0603 SMT	1
KB	RP11-02910-308	CD291 LCD KB D/S 1.2X42.5X182.8MM	1
AM(MUTE),AMS,BAND/LOUD,DSP,EQ,M1/PAU,M2/SCN,M3/RPT,M4/SHF,M5/DN,M6/UP,MODE,POWER	RP16-01107-00K	TACT SW. DCT/1101 4.3MM 2 PIN	18
VR1	RP18-00163-00	ENCODER SRGP200200 (ALPS)	1
CON1	RP25-M0217-20	20PIN PLUG	1
LCD	RP27-01580-12Y	CD158 LCD TN NEG BLUE MASK PIN TYPE	1
REM	RP29-01201-00	IR RECEIVER GP1UM261XK (SHARP)	1

PC BOARD ASSY, SDK/CD SERVO BOARD

Ref. No.	Part No.	Description	Q'ty
Q2~6,8	RP01-00103-000	TR. KRC103S	6
Q305	RP01-00435-00S	TR BD435S NPN TO-126 FAIRCHLD	1
Q1,302/4	RP01-00812-00	TR. 2SA812	3
Q7	RP01-01225-13	TRANSISTOR 2SD1225M	1
Q301/3	RP01-03875-07	TRANSISTOR 2SC3875G	1
D1,2	RP02-00144-00	IR LED MIE 144A1MC	2
D301	RP02-04001-00	DIODE IN4001	1
D5,6	RP02-04148-02	DIODE CHIP RLS4148 1206 ROHM	2
D302/3,635,611 (MP3+ESP)	RP02-04148-00A	DIODE IN-4148 AT. (TAPPING)	4
ZD302	RP02-50033-00A	ZENER DIODE 3.3V 0.5W AT.	1
D4	RP02-50036-00	ZENER DIODE 3.6V ±5% 0.5W	1
D3	RP02-50051-00	ZENER DIODE 5.1V ±5% 0.5W	1
ZD301	RP02-50091-00	ZENER DIODE 9.1V ±5% 0.5W AT.	1
D7	RP02-50151-00	5.1V ZENER DIODE (SMD1206)	1
U1	RP03-09226-00	IC SIL 9226	1
U5	RP03-09259-00	IC KA9259D	1
U3	RP03-09276-00	IC S5L 9276X01-EORN	1
U2	RP03-09291-00	IC S5L9291X01-EORO (CDRW+MP3+ESP)	1
U4	RP03-M0404-04	IC 4X4 DRAM SI17400B (FUJITSU DICE)	1
X301	RP04-00169-00	CRYSTAL HC-49/US 16.934MHZ	1
C10,126,223/4,235/7/9	RP05-16106-10	TAN CAP 10UF 16V ±10% (4.5X7)	7
C129	RP05-63020-00	CHIP CAP 2PF ±5% NPO 0603 SMT	1
C127,214	RP05-63102-01	CHIP 1000PF ±10% X7R 0603 SMT	2
C102,113/6/7,130,140/1,219,229	RP05-63103-01	CHIP 0.01µF ±10% X7R 0603 SMT	9
C100/3/6/8,119,122/4/5,131/2/4/6~8,211~3/5/7,222/7/8,231/4/6/8,240~9,253,300/2~6/8	RP05-63104-01	CHIP 0.1µF ±10% X7R 0603 SMT	44
C225/6	RP05-63152-01	CHIP 1500PF ±10% X7R 0603 SMT	2
C139	RP05-63153-01	CHIP 0.015µF ±10% X7R 0603 SMT	1
C104	RP05-63220-00	CHIP CAP 22PF ±5% NPO 0603 SMT	1
C107,123	RP05-63222-01	CHIP 2200PF ±10% X7R 0603 SMT	2
C307	RP05-63223-01	CHIP 0.022µF ±10% X7R 0603 SMT	1
C220/1	RP05-63330-00	CHIP CAP 33PF ±5% NPO 0603 SMT	2
C121	RP05-63333-01	CHIP 0.033µF ±10% 0603 SMT	1
C105,111	RP05-63391-00	CHIP 390PF ±5% NPO 0603 SMT	2
C128	RP05-63472-01	CHIP 4700PF ±10% X7R 0603 SMT	1
C120,232/3	RP05-63474-00	CHIP CAP 0.47µF ±5% (+80/-20%)	3
C115	RP05-63683-01	CHIP 0.068µF ±10% 0603 SMT	1
C216	RP05-63821-00	CHIP 820PF ±5% 0603 SMT	1
C303,832	RP06-10107-02	E. CAP 100µF 10V (6X5) SUPER MINI	2
C101,202/9,218,301/9,310/1	RP06-16107-54	E. CAP CHIP 100µF 16V Ø6.3X5.5	8
C135,142	RP06-16476-54	E. CAP CHIP 47µF 16V Ø5X5.5	2
C301/2	RP06-50225-02	E. CAP 2.2µF 50V (4X5)	2
R301	RP07-05047-00	RES. 4.7Ω 1/4W	1
R305	RP07-05103-16A	RES. 10KΩ 1/16W (TAPPING)	1
R102,120,204~7,213/6,244,251/2/6/8,303	RP07-63000-00	CHIP RES 0Ω 0603 SMT	14
R236,255,264,304	RP07-63015-00	CHIP RES 1.5Ω 0603 SMT	4
R105	RP07-63100-00	CHIP RES 10Ω ±5% 0603 SMT	1
R210,222/3	RP07-63102-00	CHIP RES 1KΩ ±5% 0603 SMT	3
R129/30,136/7,217/8,306,321/2	RP07-63103-00	CHIP RES 10KΩ ±5% 0603 SMT	9
R122/3,224/5	RP07-63104-00	CHIP RES 100KΩ ±5% 0603 SMT	4
R202,235	RP07-63105-00	CHIP RES 1MΩ ±5% 0603 SMT	2
R125/6,134,201,221,243	RP07-63153-00	CHIP RES 15KΩ ±5% 0603 SMT	6
R231	RP07-63181-00	CHIP RES 180Ω ±5% 0603 SMT	1
R131	RP07-63203-00	CHIP RES 20KΩ ±5% 0603 SMT	1
R302,314,323	RP07-63221-00	CHIP RES 220Ω ±5% 0603 SMT	3
R303/4/9	RP07-63222-00	CHIP RES 2.2KΩ ±5% 0603 SMT	3
R100/1,124,135	RP07-63224-00	CHIP RES. 220KΩ ±5% 0603 SMT	4
R246	RP07-63272-00	CHIP RES. 2.7KΩ ±5% 0603 SMT	1
R128	RP07-63274-00	CHIP RES. 270KΩ ±5% 0603 SMT	1
R220	RP07-63333-00	CHIP RES 33KΩ ±5% 0603 SMT	1
R260,308	RP07-63334-00	CHIP RES. 330KΩ	2
R301/2,324	RP07-63392-00	CHIP RES 3.9KΩ ±5% 0603 SMT	3
R211/2	RP07-63393-00	CHIP RES 39KΩ ±5% 0603 SMT	2
R263,300	RP07-63471-00	CHIP RES 470Ω ±5% 0603 SMT	2
R132,226~30,245~50/3/4/9,261,310~3/5~9	RP07-63472-00	CHIP RES 4.7KΩ ±5% 0603 SMT	24
R103/4/8,127,307,320	RP07-63473-00	CHIP RES. 47KΩ ±5% 0603 SMT	6
R107	RP07-63683-00	CHIP RES. 68KΩ ±5% 0603 SMT	1
R133,209,237~42	RP07-63822-00	CHIP RES. 8.2KΩ ±5% 0603 SMT	8
R214/9	RP07-63823-00	CHIP RES 82KΩ ±5% 0603 SMT	2
R109	RP07-63913-00	CHIP RES. 91KΩ ±5% 0603 SMT	1
SW101	RP16-00033-01	MICRO SWITCH MPU10371MLBO (MIC)	1

PC BOARD ASSY, REMOTE BOARD

Ref. No.	Part No.	Description	Q'ty
Q500	RP01-01781-18	TR. 2SD1781K-R "ROHM"	1
LD1	RP02-00334-00	INFRARED LED Ø3MM MIE-334A4	1
D500/1	RP02-04148-00	DIODE IN-4148	2
IC500	RP03-00101-00	IC S0101 (SGNEC)	1
C504	RP05-03105-10M	CHIP CAP KC20E1C105M-TS	1
C501/2	RP05-03121-06	CHIP CAP. 120PF (NPO)	2
R501	RP07-05022-54	CHIP RES. 2.2Ω 1/10W	1
R502	RP07-05102-54	CHIP RES 1KΩ 1/10W	1
CF501	RP09-50455-05J	CER RESONATOR ZTB455E	1
PCB	RP11-17020-505	CD1702 RC06 D/S 1.2X80.3X51.5 SANYO	1

PC BOARD ASSY, MAIN BOARD LINE OUT SECTION

Ref. No.	Part No.	Description	Q'ty
C707~10	RP06-50105-03	E.CAP 1µF 50V (Ø4X5MM)	4
R721~4	RP07-63000-00	CHIP RES. 0Ω ±5% 0603 SMT	4

PC BOARD ASSY, MAIN BOARD TONE SECTION

Ref. No.	Part No.	Description	Q'ty
D634	RP02-04148-00A	DIODE IN-4148 AT. (TAPPING)	1
C403/4	RP05-63152-01	CHIP 1500PF ±10% X7R 0603 SMT	2
C401/2	RP06-50225-02E	E.CAP 2.2µF/50V (4X5MM RC03)	2
R403/4	RP07-63182-00	CHIP RES. 1.8KΩ ±5% 0603 SMT	2
R401/2	RP07-63222-00	CHIP RES. 2.2KΩ ±5% 0603 SMT	2

PC BOARD ASSY, MAIN BOARD JB/GIB SECTION

Ref. No.	Part No.	Description	Q'ty
ZD501	RP02-50056-00A	ZENER DIODE 5.6V 0.5W AT. ±2%	1
ZD502	RP02-50068-00A	ZENER DIODE 6.8V 0.5W AT. ±2%	1
IC501	RP03-03121-06	IC BA3121F SOP8 ROHM	1
C505	RP06-10226-02	E. CAP 22µF 10V (Ø5X5MM)	1
C502	RP06-16106-02E	E. CAP 10µF/16V (4X5MM RC3)	1
C501	RP06-16107-04	E. CAP 100µF 10V (Ø6X5MM)	1
C503/4/6/7	RP06-50105-03	E. CAP 1µF 50V (Ø4X5MM)	4
R507	RP07-05101-16A	RES 100Ω 1/16W (TAPPING)	1
R501	RP07-63102-00	CHIP RES 1KΩ ±5% 0603 SMT	1
R618	RP07-63105-00	CHIP RES 1MΩ ±5% 0603 SMT	1
R505/6	RP07-63222-00	CHIP RES 2.2KΩ ±5% 0603 SMT	2
R503/4	RP07-63332-00	CHIP RES 3.3KΩ ±5% 0603 SMT	2
R502	RP07-63471-00	CHIP RES 470Ω ±5% 0603 SMT	1
R508/9	RP07-63682-00	CHIP RES 3.8KΩ ±5% 0603 SMT	2
	RP25-00080-08	RAINBOW WIRE #30 8PIN 80MM	1
	RP25-14368-01	ISO CDC SOCKET 8PIN 200MM	1

PC BOARD ASSY, FRONT & DETACHABLE BOARD

Ref. No.	Part No.	Description	Q'ty
Q1	RP01-08050-03	TR. 8050C TO-92-B	1
LED	RP02-01112-05M	SMD LED BL-HW135A 0805 PURE GREN	1
	RP02-30703-40J	PLAMP 3V 40MM 3X7KT	1
R5	RP07-05101-00	RES 100Ω 1/4W	1
R6,10	RP07-63000-00	CHIP RES 0Ω ±5% 0603 SMT	2
R2,3	RP07-63103-00	CHIP RES 10KΩ ±5% 0603 SMT	2
R7	RP07-63393-00	CHIP RES 39KΩ ±5% 0603 SMT	1
R8,9	RP07-63821-00	CHIP RES 820Ω ±5% 0603 SMT	2
EJ	RP16-01140-04A	TACT SW KPS-1107SW TAPPING	1
RESET	RP16-05001-00	TACT SW TS-065001-150 H=5MM	1
DTH	RP16-51377-00K	PUSH SW. SPPB51377A (DS-20) KONEX	1
	RP25-00100-08	RAINBOW WIRE #30 8PIN 100MM	2
	RP25-32145-02	RAINBOW WIRE #32 145MM 2PIN	1
	RP25-F0217-20	20PIN SOCKET	1

	SANYO MCD-Z120/MCD-Z120F Portable CD Radio Cassette Recorder Service Manual This comprehensive service manual provides detailed technical specifications, adjustment procedures, exploded views, and parts lists for the SANYO MCD-Z120 and MCD-Z120F portable CD radio cassette recorder systems. Essential for technicians and repair professionals.
	SANYO DC-SLIM1600/AU CD Audio System Service Manual This Service Manual for the SANYO DC-SLIM1600/AU CD Audio System provides comprehensive technical specifications, detailed exploded views for assembly, extensive parts lists for various components (including electrical, mechanical, and PCB parts), and schematic and wiring diagrams for repair and maintenance. It is an essential guide for technicians servicing the DC-SLIM1600 series.
	Sanyo TP1030 Stereo Turntable Service Manual Comprehensive service manual for the Sanyo TP1030 Stereo Turntable, detailing specifications, adjustments, repair procedures, parts lists, and schematic diagrams.
	SANYO DC-DA2000 Micro Component System Service Manual Comprehensive service manual for the SANYO DC-DA2000 Micro Component System, providing detailed technical information, troubleshooting guidance, adjustment procedures, parts lists, and schematics for service technicians.
	Sanyo Split System Air Conditioner Service Manual: 24K12W, 30K12W, 36K12W This service manual provides detailed specifications, installation instructions, troubleshooting, and parts lists for Sanyo Split System Air Conditioners, models 24K12W, 30K12W, and 36K12W. It covers electrical data, component specifications, and operating ranges for these units.
	SANYO DC-F210 Mini Component System Instruction Manual Instruction manual for the SANYO DC-F210 Mini Component System, covering setup, operation of CD player, tuner, amplifier, and cassette deck, recording, dubbing, timer functions, maintenance, and technical specifications. Includes important safety precautions and warranty information.
	SANYO LCD Television Service Manual for Models LCD-32S10, LCD-42S10, and LCD-42S10-HD This comprehensive service manual provides detailed instructions and specifications for SANYO LCD Televisions, including models LCD-32S10, LCD-42S10, and LCD-42S10-HD. It covers safety precautions, product specifications, chassis block diagrams, CPU diagrams, on-screen service menu operations, service adjustments, and mechanical disassembly procedures.
	SANYO LCD Television Service Manual for Models LCD-32S10, LCD-42S10, and LCD-42S10-HD This comprehensive service manual provides detailed instructions and specifications for SANYO LCD Televisions, including models LCD-32S10, LCD-42S10, and LCD-42S10-HD. It covers safety precautions, product specifications, chassis block diagrams, CPU diagrams, on-screen service menu operations, service adjustments, and mechanical disassembly procedures.

Contents

SPECIFICATIONS

DISASSEMBLY INSTRUCTIONS

DISASSEMBLY DIAGRAM

OPERATION CHECK

GENERAL SPECIFICATIONS OF SIGNAL

Test Diagram

BLOCK DIAGRAM

ALIGNMENT LOCATIONS

FM/MW/LW TUNER

ALIGNMENT PROCEDURES

FM ADJUSTMENT

Equipment Required

FM Alignment Using FM Signal Generator

PRINTED CIRCUIT BOARDS

MAIN BOARD (TOP VIEW)

MAIN BOARD (BOTTOM VIEW)

ISO PCB BOARD (TOP VIEW)

KEY BOARD (TOP VIEW)

KEY BOARD (BOTTOM VIEW)

CD SERVO BOARD (TOP VIEW)

CD SERVO BOARD (BOTTOM VIEW)

REMOTE BOARD (TOP VIEW)

REMOTE BOARD (BOTTOM VIEW)

FRONT & DETACHABLE BOARD (TOP VIEW)

FRONT & DETACHABLE BOARD (BOTTOM VIEW)

SERVICE PARTS LIST

Panel Assembly Parts List

Exploded View Parts List (Panel)

Exploded View (Cabinet)

Exploded View Parts List (Cabinet)

Exploded View (Deck)

Exploded View Parts List (Deck)

Exploded View Parts List - Continued (Deck)

SCHEMATIC DIAGRAMS

SCHEMATIC DIAGRAM (MAIN BOARD)

SCHEMATIC DIAGRAM (KEY BOARD)

SCHEMATIC DIAGRAM (REMOTE BOARD)

SCHEMATIC DIAGRAM (CD SERVO BOARD)

ELECTRICAL PARTS LIST

PC BOARD ASSY, MAIN BOARD

ELECTRICAL PARTS LIST - CONTINUED

PC BOARD ASSY, MAIN BOARD SUB-W SECTION

PC BOARD ASSY, MAIN BOARD FM TUNER SECTION

PC BOARD ASSY, MAIN BOARD AM TUNER SECTION

PC BOARD ASSY, KEY BOARD

PC BOARD ASSY, SDK/CD SERVO BOARD

PC BOARD ASSY, REMOTE BOARD

PC BOARD ASSY, MAIN BOARD LINE OUT SECTION

PC BOARD ASSY, MAIN BOARD TONE SECTION

PC BOARD ASSY, MAIN BOARD JB/GIB SECTION

PC BOARD ASSY, FRONT & DETACHABLE BOARD

Related Documents