BLACK+DECKER Dustbuster Handheld Vacuum

Thank You for Choosing BLACK+DECKER!

Register your new product at www.BLACKANDDECKER.COM/NEWOWNER.

Before returning this product for any reason, please call 1-800-544-6986. Have the catalog number and date code available. For replacement filters, call 1-888-678-7278.

Save this manual for future reference. For household use only.

Important Safeguards

When using electrical appliances, basic safety precautions should always be followed. Please read and understand all instructions before using the unit.

Safety Guidelines - Definitions

The symbols below are used to help you recognize important safety information:

▲DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

▲WARNING: Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.

▲CAUTION: Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.

CAUTION: Used without the safety alert symbol indicates potentially hazardous situation which, if not avoided, may result in property damage.

▲WARNING: Some household dust contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm such as asbestos and lead in lead based paint.

▲WARNING: To reduce the risk of fire, electrical shock or injury:

• Close supervision is necessary when any appliance is used by or near children. Do not allow to be used as a toy.
• To protect against risk of electrical shock, do not put unit or charging base in water or other liquid.
• Do not use Dustbuster dry hand vacs to pick up liquids, toxic substances, flammable or combustible liquids such as gasoline or use in areas where they may be present.
• Do not operate in the presence of explosives and/or flammable fumes or liquids.
• Do not operate any appliance with a damaged cord or charger or after the appliance malfunctions, is left outdoors, dropped into water or is damaged in any manner. Return the appliance to any authorized service facility.
• Do not use Dustbuster dry hand vacs outdoors or on wet surfaces.
• Do not abuse the cord. Never carry the charger or base by the cord or yank to disconnect from an outlet; instead grasp the charger and pull to disconnect. Keep cord away from heated surfaces. Do not pull cord around sharp edges or corners.
• Do not allow the cord to hang over the edge of a table or counter or touch hot surfaces. The unit should be placed or mounted away from sinks and hot surfaces.
• Do not use an extension cord. Plug the charger directly into an electrical outlet.
• Use the charger only in a standard electrical outlet (120V/60Hz).
• Do not attempt to use the charger with any other product; do not attempt to charge this product with any other charger. Use only the charger supplied by the manufacturer to recharge.
• Keep hair, loose clothing, and all parts of body away from openings and moving parts.
• Do not insert accessories when unit is running.
• Do not handle plug or appliance with wet hands.
• Do not put any object into unit openings. Do not use with any openings blocked; keep free of dust, lint, hair, and anything that may reduce air flow.
• Do not vacuum burning or smoking materials, such as lit cigarette butts, matches or hot ashes.
• Do not use on or near hot surfaces.
• Use extra caution when cleaning on stairs.
• This appliance is intended for household use only and not for commercial or industrial use.
• Use only as described in this manual. Use only manufacturer's recommended attachments.
• Unplug the charger from outlet before any routine cleaning or maintenance.
• This product includes rechargeable nickel cadmium batteries. Do not incinerate batteries as they will explode at high temperatures.
• Leaks from battery cells can occur under extreme conditions. If the liquid, which is a 20-35% solution of potassium hydroxide, gets on the skin (1) wash quickly with soap and water or (2) neutralize with a mild acid such as lemon juice or vinegar. If the liquid gets into the eyes, flush them immediately with clean water for a minimum of 10 minutes. Seek medical attention.

Save These Instructions.

Product Features (Refer to Figure A)

Figure A illustrates the main components of the Dustbuster handheld vacuum:

1. On/Off slide switch
2. Bowl release button
3. Dust bowl
4. Wall mountable charging base
5. Charger
6. Charge indicator light
7. Filter cleaning slider

How To Use

Installation Instructions (Refer to Figure B)

Fix the charging base within reach of an electrical outlet using the supplied screws. Plug in and place the product in position. Always mount in an upright (handle up) position. NOTE: Avoid damaging the cord while fixing the base to the wall or when removing or replacing the product from the base.

Recharging (Refer to Figure C)

The charger supplied with this product is intended to be plugged in such that it is correctly orientated in a vertical or floor mount position. From new, the rechargeable cells of the product need a minimum charge time of 16 hours to ensure full power. While charging, the charge indicator light will be illuminated. The switch must be in the off ("O") position. The product will not charge if it is in any other position. While charging, the product may get warm; this is perfectly normal and safe. It can remain on charge indefinitely without damage or danger. It is not possible to "overcharge" the battery cells with the charger provided. Before recharging unit, make sure extension nozzle (from Figure J) is retracted back into the bowl of the unit. This product is for dry pick-up only.

Operation

Ensure that the product is fully engaged on the charging base and the charge indicator light is on.

Switching On and Off (Refer to Figure D)

To start, slide the On/Off switch forward (i.e. "O"= Off, "I" = On). To stop, slide the switch back. Always return the product to the charging base immediately after use so that it will be ready and fully charged for the next use. Ensure that the product is fully engaged on the charging base.

Cleaning the Product (Refer to Figures E-I)

▲WARNING: Never use the Dustbuster without its filters.

NOTE: The filters are re-usable, do not confuse them with disposable dust bags, and do not throw them away when the product is emptied. We recommend that you replace the filters every 6-9 months depending on frequency of use. See "Accessories" for filter catalog numbers.

Figure E: Remove the dust bowl by pressing the dust bowl release button and pulling the bowl down and out. To replace the bowl, place it back onto the handle and click firmly into position. Important: For best vacuum results, empty bowl after every use.

Figure F: Empty the debris from the bowl and wash if necessary (see Figure H).

Filters

NOTE: CHV9608 uses a single filter. CHV1408, CHV1568 and CHV1688 use an inner and outer filter.

Figure G: To remove the filter(s), twist the outer (plastic) filter in a clockwise direction. Shake or lightly brush any loose dust off the outer filter.

Figure G1: (CHV1408, CHV1568 and CHV1688 only) Remove the inner filter and shake, tap or lightly brush outside surface to remove loose dust. Both filters can be rinsed as shown in Figure H. CAUTION: Filter must be dry before re-assembling. Ensure both filters are in place before operating.

Figure G2: If your unit is equipped with a filter cleaning slider as shown in Figure G2, you can achieve more use between filter cleanings by first switching off the vac, and then sliding the cleaning wheel up and down as shown. Make two full cycles for best results.

Figure H: Wash the filters using warm, soapy water and ensure that they are completely dry before using it again. The cleaner the filters are, the better the product will perform. It is very important that the filter is correctly in position before use. The dust bowl can also be washed in warm soapy water. CAUTION: Filters must be dry before re-assembling.

Important: Maximum dust collection will only be obtained with clean filters and an empty dust bowl. If dust begins to fall back out of the product after it is switched off, this indicates that the bowl is full and requires emptying.

Figure I: Never immerse the product in water. A damp cloth and soapy water should be used to clean the exterior of the motor section. Always ensure the product is completely dry before re-use or storing.

Economic Usage

Your product is very economical to charge. While it is charging, it uses less electricity than a typical night light bulb.

When fully charged and with a clean filter, the average effective usage times vary by voltage:

• 7.2 volts: 7-9 minutes
• 9.6-12 volts: 9-11 minutes
• 14.0 volts and higher: 12-15 minutes

Troubleshooting

If the product does not work, check the following:

• That the charge indicator light is on when unit is in base.
• The charger was correctly plugged in for recharge. (It feels slightly warm to the touch.)
• The charger cord is not damaged and is correctly attached to the base.
• The charger is plugged into a working electrical outlet.
• That the switch is in the "OFF" position when charging.

Accessories

A crevice tool is built-in to the nozzle and can be extended as shown in Figure J by pulling the extension piece until it locks into position. The extension can be retracted by depressing the arrow button at the back of the extension and pushing the extension back into the nozzle. Additional accessories are stored on the product (Figure K) and are fitted into the nose of the product for use. NOTE: CHV9608 includes brush only. Accessory use is shown in Figure L.

Note: Replacement filters can be purchased from most local/national retailers that sell vacuums, or by calling 1-888-678-7278.

Look for:

• VF96 filter for catalog number CHV9608
• VF08 filters for catalog numbers CHV1408 and CHV1568
• VF08H HEPA filter for CHV1688

Battery Removal and Disposal (Refer to Figure M)

This product uses nickel-cadmium (Ni-Cd) rechargeable and recyclable batteries. When the batteries no longer hold a charge, they should be removed from the Vac and recycled. They must not be incinerated or composted. The batteries can be taken for disposal to a Black & Decker, Company-Owned or Authorized Service Center. Some local retailers are also participating in a national recycling program (see "RBRC™ Seal"). Call your local retailer for details. If the batteries are brought to a Black & Decker Company-Owned or Authorized Service Center, the Center will arrange to recycle old batteries. Alternatively, contact your local municipality for proper disposal instructions.

To remove the battery pack for disposal:

1. Unlatch bowl from main handle unit.
2. Remove filter(s).
3. Remove the seven screws holding the unit together.
4. Pull the cover half away from the location half.
5. For catalog number CHV9608, lift out the full motor/fan/battery assembly. For catalog numbers CHV1468, CHV1568, CHV1688, prise small cover from filter cleaning slider and remove slider securing screw, then lift out the full motor/fan/battery assembly.
6. Unplug battery assembly from main assembly.

To replace or obtain a new battery pack, contact your local Black & Decker, Company-Owned or Authorized Service Center, or call 1-800-544-6986. Be prepared to provide the Catalog No. of your DustBuster, found on the housing.

Maintenance

Use only mild soap and damp cloth to clean the vac. Never let any liquid get inside the vac; never immerse any part of the vac into a liquid. NOTE: Make sure the vacuum is completely dry before using it.

Important: To assure product safety and reliability, repairs, maintenance and adjustment (other than those listed in this manual) should be performed by authorized service centers or other qualified service organizations, always using identical replacement parts.

The RBRC™ Seal

RECYCLE 1.800.822.8837 The RBRC™ (Rechargeable Battery Recycling Corporation) Seal on the nickel-cadmium battery (or battery pack) indicates that the costs to recycle the battery (or battery pack) at the end of its useful life have already been paid by Black & Decker. In some areas, it is illegal to place spent nickel-cadmium batteries in the trash or municipal solid waste stream and the RBRC program provides an environmentally conscious alternative. RBRC, in cooperation with Black & Decker and other battery users, has established programs in the United States and Canada to facilitate the collection of spent nickel-cadmium batteries. Help protect our environment and conserve natural resources by returning the spent nickel-cadmium battery to an authorized Black & Decker service center or to your local retailer for recycling. You may also contact your local recycling center for information on where to drop off the spent battery, or call 1-800-8-BATTERY.

Service Information

All Black & Decker Service Centers are staffed with trained personnel to provide customers with efficient and reliable power tool service. Whether technical advice, repair, or genuine factory replacement parts are needed, contact the Black & Decker location nearest you. To find your local service location, refer to the yellow page directory under "Tools-Electric" or call: 1-800-544-6986 or visit www.blackanddecker.com.

Full Two-Year Home Use Warranty

Black & Decker (U.S.) Inc. warrants this product for two years against any defects in material or workmanship. The defective product will be replaced or repaired at no charge in either of two ways:

1. Return the product to the retailer from whom it was purchased (provided that the store is a participating retailer). Returns should be made within the time period of the retailer's policy for exchanges (usually 30 to 90 days after the sale). Proof of purchase may be required. Check with the retailer for their specific return policy regarding returns that are beyond the time set for exchanges.
2. Take or send the product (prepaid) to a Black & Decker owned or authorized Service Center for repair or replacement at Black & Decker's option. Proof of purchase may be required. Black & Decker owned and authorized Service Centers are listed under "Tools-Electric" in the yellow pages of the phone directory.

This warranty does not apply to accessories. This warranty gives specific legal rights and you may have other rights which vary from state to state or province to province. Should you have any questions, contact the manager of your nearest Black & Decker Service Center. This product is not intended for commercial use.

Free Warning Label Replacement: If your warning labels become illegible or are missing, call 1-800-544-6986 for a free replacement.

Specifications