Wahl Cordless Lithium-Ion Trimmer 8171L Operating Manual

FCC Compliance Information

For Products Marked with an FCC Approval:

1. This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.
2. Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate this device.
3. NOTE: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses, and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:
   
   • Reorient or relocate the receiving antenna.
   • Increase the separation between the equipment and receiver.
   • Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
   • Consult the dealer or an experienced radio/TV technician for help.

(This section is also provided in Spanish: "Para Productos Marcados con Aprobación de la FCC")

Important Safeguards

When using your electrical appliance, basic precautions should always be followed, including the following:

READ ALL INSTRUCTIONS AND SAFEGUARDS BEFORE USING THIS APPLIANCE.

DANGER

To reduce the risk of death or injury by electric shock:

1. Do not reach for an appliance that has fallen into water. Unplug immediately from the outlet. Note: Some electrical parts inside the appliance are electrically live, even with the switch “OFF.”
2. Do not use while bathing or in a shower.
3. Do not place or store appliance where it can fall or be pulled into a tub or sink. Do not place in or drop into water or other liquid.
4. Always unplug this appliance before cleaning.
5. Except when charging, always unplug this appliance from the electrical outlet immediately after using.

WARNING

To reduce the risk of burns, electrical shock or injury to persons:

1. This appliance can be used by children aged from 14 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction, by a person responsible for their safety, concerning the use of the appliance in a safe way and understand the hazards involved. Children should be supervised to ensure that they do not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision.
2. Use this appliance only for its intended use as described in this manual. Do not use attachments not recommended by the manufacturer.
3. Never operate this appliance if it has a damaged cord or plug, if it is not working properly, if it has been dropped or damaged, or if it has been dropped into water. Return the appliance to Wahl Clipper Corporation for examination and repair.
4. Keep the cord away from heated surfaces.
5. Never operate the appliance with the air openings blocked or while on a soft combustible surface, such as a bed or couch, where air openings may be blocked. Keep the air openings (if any) free from lint, hair or the like.
6. Do not use outdoors or operate where aerosol (spray) products are being used or where oxygen is being administered.
7. Never drop or insert any object into any opening.
8. Do not use this appliance with a damaged or broken comb nor with teeth missing from the blades, as injury may occur. Before use, make certain blades are aligned properly. (See Clipper or Trimmer Care Instructions. May not be applicable for all appliances.)
9. During use, do not place or leave the appliance where it is expected to be subject to damage by an animal, or exposed to weather.
10. To disconnect, turn all controls to “OFF,” then remove plug or charger from outlet.
11. Turn all controls to “OFF” before placing on or removing blades or attachments.
12. An appliance with a permanently attached cord should never be left unattended when plugged in.
13. Keep this appliance dry.

For an appliance that has a rechargeable battery:

1. Do not crush, disassemble, heat above 100°C (212°F), or incinerate the appliance, due to risk of fire, explosion, or burns.
2. Use only the charger supplied by the manufacturer to recharge.
3. This charger is intended to be correctly orientated in a vertical or floor mount position.
4. Always attach plug to appliance first, then to outlet.
5. Use charge stand with Wahl products and power supplies only.

SAVE THESE INSTRUCTIONS

THIS APPLIANCE IS FOR COMMERCIAL USE ONLY

(Full safety instructions are also provided in Spanish and French.)

Trimmer Use

Using Rechargeable Cord/Cordless Trimmers

If battery power is low, the power cord can attach directly to the unit for continued use as a corded unit.

Corded Operation

• Attach power cord plug into trimmer first, then to outlet. If your battery is completely run down, allow the unit to charge for 1 minute (switched OFF) before using as a corded unit. [See Figure 1]
• If the cord is left attached to the trimmer when not in use, the cord will automatically charge the trimmer when left in the OFF position.

Recharging Options

• For units without a recharge stand: Attach power cord plug into trimmer first, then to outlet. Be sure trimmer is switched OFF when charging. [See Figure 1]
• For units with a recharge stand: Place trimmer in recharge stand so nameplate faces forward. [See Figure 2] Attach power cord plug into recharge stand first, then to outlet. [See Figure 3]

Charging the Battery

Before the equipment is used for the first time, it should be charged for 45 minutes to an hour. For recharging information, refer to Trimmer Use Recharging Options.

Recommendation: The batteries should only be recharged when the performance of the equipment has deteriorated noticeably.

DO NOT RUN TRIMMER CORDED WITH A FULLY CHARGED BATTERY.

Battery Operation

Switch ON the unit using the ON/OFF switch and, after use, switch it OFF again. When the battery is fully charged, the unit can be used for up to 100 minutes.

LED Indicator

• Solid: LED will be fully lit in use or when the battery has reached full charge.
• Flashing: The battery has approximately 20% charge remaining.
• Pulse: While charging, LED will pulse until battery is fully charged. The LED will change to solid when the battery has a full charge.

Quick Charge

• For a one minute charge: Average use is 4 minute run time.
• For a five minute charge: Average use is 14 minute run time.

Trimmer Care

Blade Care and Oiling

To ensure maximum life and performance, oil the trimmer blades daily. To oil properly:

• Hold the trimmer so the blades are in a downward position.
• Place one drop of Wahl oil in the center of the movable top blade.
• Place one drop of oil on each end of the top blade.
• Turn the trimmer switch ON and run for a few seconds to distribute the oil.
• Turn the trimmer OFF and wipe off excess oil with a soft cloth.
• Periodically oil the heel of the blade to reduce friction. [See Diagram: "PERIODICALLY OIL HEEL OF BLADE"]
• (USE WAHL OIL ONLY)

Wipe off excess oil so it does not run into the motor compartment, as this can lead to poor motor performance. Blades should be oiled after using disinfectant or sanitizing solution.

DO NOT DIP OR SOAK the trimmer or blades in any type of cleaning solution, disinfectant, or oil. Excess liquid can damage plastic components and affect motor life and performance.

Unit Care

Use a clean cloth (dry or dampened with water). DO NOT USE bleach, benzene, or thinner to clean the unit.

Cord Care

Never use the cord to pull the trimmer. Maintain freedom of movement. Keep the cord untwisted and undamaged. When stored, coil the cord neatly in a dry place.

Lithium-Ion Battery Replacement, Trimmer Disposal and Recycling

• This unit uses a Lithium-Ion battery. For battery replacement, send the entire, intact unit to: Wahl Service Center, 3001 North Locust Street, Sterling, IL 61081.
• Do not attempt to remove the battery. Lithium-Ion batteries can explode, catch fire, and/or cause burns if disassembled, damaged, or exposed to water or high temperatures.
• If you choose not to send the appliance for battery replacement, the entire intact unit must be disposed of properly. Do not attempt to remove the battery for disposal. Lithium-Ion batteries may be subject to local disposal regulations. Check your local laws and regulations.
• For recycling, contact a government recycling agency, waste disposal service, retailer, or visit online recycling sources such as www.batteryrecycling.com or www.rbrc.org.

Troubleshooting

If your rechargeable cord/cordless trimmer does not seem to be operating or charging properly, please check the following:

• Check the outlet’s current by plugging another appliance (one you know is in proper working condition) into the outlet.
• Make sure the unit is not connected to a power source that turns itself off when lights are turned off.
• Ensure the unit and recharging transformer contacts are clean and free of hair or other contaminants.
• Verify that the blade assembly moves freely and is mounted properly.

If you still encounter problems, send your unit and recharging transformer to Wahl Clipper Corporation with a note explaining the problem.

Wahl Clipper Corporation offers a limited warranty on this product. Please visit our website for full warranty terms.