SECTION 1: Identification of the substance/mixture and of the company/undertaking
1.1 Product identifier
Product name (code): LC11M (LK3638001, LK4691001), LC16M (LK3534001, LK4711001), LC38M (LK3662001, LK4197001), LC39M (LK5406001), LC60M (LK5730001), LC61M (LK3367001, LK4298001), LC67M (LK3670001, LK4223001), LC975M (LK5671001), LC980M (LK3375001, LK4049001), LC985M (LK4622001, LK5402001), LC990M (LK4462001), LC1100M (LK3573001, LK3986001), LC65HYM (LK3292001, LK4331001), LC67HYM (LK3532001, LK4278001), LC990HYM (LK3533001, LK4482001), LC1100HYM (LK3531001, LK4022001)
1.2 Relevant identified uses of the substance or mixture and uses advised against
Relevant Identified Use(s): These products are dark red ink in a cartridge for Brother Industries, Ltd. inkjet multifunction devices and fax receivers. The cartridge should be used as supplied by Brother and for use in the products stated. Information provided on this SDS is only consistent with the use specified by Brother.
1.3 Details of the supplier of the safety data sheet
Manufacturer: Brother Industries, Ltd.
15-1 Naeshiro-cho, Mizuho-ku, Nagoya 467-8561, Japan
Telephone (for information): +81-52-824-2735
Importer (USA): Brother International Corporation
200 Crossing Boulevard, Bridgewater, NJ 08807, USA
Telephone (for information): +1-877-276-8437
Importer (Canada): Brother International Corporation (Canada) Ltd.
1 Hotel de Ville, Dollard des Ormeaux, Quebec, H9B 3H6, Canada
Telephone (for information): +1-514-685-0600
Importer (Europe): Brother International Europe Ltd.
Brother House, 1 Tame Street, Guide Bridge, Audenshaw, Manchester M34 5JE, UK
Telephone (for information): +44-161-330-6531
Importer (Australia): Brother International (Aust.) Pty. Ltd. ACN 001 393 835
Level 3, Building A, 11 Talavera Road, Macquarie Park, NSW 2113, Australia
Telephone (for information): +61-2-9887-4344
E-mail Address: sds.info@brother.co.jp
1.4 Emergency telephone number
Emergency Telephone (24 hours): CHEMTREC
+1-703-527-3887 (International)
+1-800-424-9300 (North America)
+61-290372994 (Australia)
For France only: Antipoison Center telephone number: ORFILA +33-1-45-425-959
SECTION 2: Hazards identification
2.1 Classification of the substance or mixture
Classification according to Regulation (EC) No 1272/2008: Not classified as hazardous
Classification according to OSHA GHS: Not classified as hazardous
Australia Classification: Not classified as hazardous according to the criteria of NOHSC
2.2 Label elements
Labelling according to Regulation (EC) No. 1272/2008:
Hazard pictograms: None
Signal Word: None
Hazard Statements: EUH208 - Contains water soluble heterocyclic magenta azo dye compounds, 1,2-benzisothiazol-3(2H)-one. May produce an allergic reaction.
Precautionary statements: None
2.3 Other hazards
This product contains no substance considered to be persistent, bioaccumulating nor toxic (PBT). This product contains no substance considered to be very persistent nor very bioaccumulating (vPvB).
SECTION 3: Composition/information on ingredients
3.2 Mixtures
Description of the mixture: Water based inkjet ink (Mixture).
Chemical Name | CAS-No | EC-No | w/w% | Classification (67/548/EEC) | Classification (EU Reg. 1272/2008) |
---|---|---|---|---|---|
Glycerol | 56-81-5 | 200-289-5 | 10-20 | Not classified | Not classified |
Diethylene glycol | 111-46-6 | 203-872-2 | 1-5 | Xn; R22 | Acute Tox. 4 (H302) |
Magenta Dye 1 (FJM-001B) | * | * | <2 | Xi; R36 - R43 N; R51/53 | Eye Irrit. 2 (H319) Skin Sens. 1 (H317) Aquatic Chronic 2 (H411) |
Magenta Dye 2 | * | * | <2 | N; R51/53 | Aquatic Chronic 2 (H411) |
Water | 7732-18-5 | 231-791-2 | 65-75 | Not classified | Not classified |
1,2-benzisothiazol-3(2H)-one | 2634-33-5 | 220-120-9 | < 0.05 | Xn; R22 Xi; R41 Xi; R38 R43 N; R50 | Acute Tox. 4 (Oral), H302 Skin Irrit. 2, H315 Eye Dam. 1, H318 Skin Sens. 1, H317 Aquatic Acute 1, H400 |
For the full text of R-phrases and H-Statements see Section 16
* Registered
SECTION 4: First aid measures
4.1 Description of first aid measures
General advice: If symptoms persist, obtain medical attention.
Inhalation: Obtain medical attention. In case of accident by inhalation remove casualty to fresh air and keep at rest.
Skin contact: Remove contaminated clothing immediately and wash affected skin with plenty of water or soap and water.
Eye contact: Obtain medical attention. If substance has got into the eyes, immediately wash out with plenty of water for at least 15 minutes.
Ingestion: Obtain immediate medical attention. Wash out mouth with water and give 100-200 ml of water to drink.
4.2 Most important symptoms and effects, both acute and delayed
Skin contact: Repeated and/or prolonged skin contact may cause irritation. May produce an allergic reaction.
Eye contact: May cause eye irritation.
Ingestion: Ingestion may cause irritation of the gastrointestinal tract. Unlikely route of exposure.
Inhalation: Unlikely route of exposure.
4.3 Indication of any immediate medical attention and special treatment needed
Treat symptomatically.
SECTION 5: Firefighting measures
5.1 Extinguishing media
Suitable Extinguishing Media: Extinguish preferably with dry chemical, carbon dioxide, water spray, foam.
Unsuitable Extinguishing Media: None.
5.2 Special hazards arising from the substance or mixture
Thermal decomposition of organic components may result in occurrence of oxides of carbon. Toxic gases may be formed upon combustion and represents a hazard to firefighters. Combustion products: See Section: 10.
5.3 Advice for firefighters
Use appropriate respirator for carbon monoxide and carbon dioxide. Wear positive pressure self-contained breathing apparatus (SCBA) during the attack phase of firefighting operations and during cleanup in enclosed or poorly ventilated areas immediately after a fire. Personnel not having suitable respiratory protection must leave the area to prevent significant exposure to toxic combustion gases from any source.
SECTION 6: Accidental release measures
6.1 Personal precautions, protective equipment and emergency procedures
Ensure adequate ventilation. Avoid contact with eyes.
6.2 Environmental precautions
Prevent substance entering sewers. Washings must be prevented from entering surface water drains.
6.3 Methods and materials for containment and cleaning up
Wipe up with absorbent towel. Wash with water to remove remaining traces of ink.
6.4 Reference to other sections
For personal protection: See section 8.
For disposal considerations: See section 13.
SECTION 7: Handling and storage
7.1 Precautions for safe handling
Keep out of the reach of children. Avoid contact with skin and eyes.
7.2 Conditions for safe storage, including any incompatibilities
Keep away from oxidizing agents.
7.3 Specific end use(s)
These products are dark red ink in a cartridge for Brother Industries, Ltd. inkjet multifunction devices and fax receivers. This cartridge should be used as supplied by Brother and for use in the products stated.
SECTION 8: Exposure controls/personal protection
8.1 Control Parameters
Occupational Exposure Limits
Chemical Name | CAS-No | ACGIH TLV | OSHA PEL | European Union The United Kingdom | Germany | Denmark | Austria | Switzerland | Poland | Ireland | |
---|---|---|---|---|---|---|---|---|---|---|---|
Glycerol | 56-81-5 | TWA: 10 mg/m³ mist | TWA: 15 mg/m³ mist, total particulate TWA: 5 mg/m³ mist, respirable fraction | STEL: 30 mg/m³ TWA: 10 mg/m³ | TWA: 50 mg/m³ Ceiling / Peak: 100 mg/m³ | TWA: 10 mg/m³ | TWA: 20 mg/m³ | STEL: 100 mg/m³ TWA: 50 mg/m³ | TWA: 10 mg/m³ | TWA: 10 mg/m³ | TWA: 15 mg/m³ |
Diethylene glycol | 111-46-6 | STEL: 69 ppm STEL: 303 mg/m³ TWA: 23 ppm TWA: 101 mg/m³ | TWA: 10 ppm TWA: 44 mg/m³ | Ceiling / Peak: 40 ppm Ceiling / Peak: 176 mg/m³ | TWA: 2.5 ppm TWA: 11 mg/m³ | STEL 40 ppm STEL 176 mg/m³ TWA: 10 ppm TWA: 44 mg/m³ | STEL: 40 ppm STEL: 176 mg/m³ TWA: 10 ppm TWA: 44 mg/m³ | TWA: 10 mg/m³ | TWA: 23 ppm TWA: 100 mg/m³ |
8.2 Exposure controls
Appropriate engineering controls: Good general ventilation should be sufficient under normal use.
Personal protective equipment: Not normally required. For use other than in normal operating procedures (such as in the event of large spill), the following should be applied:
- Eye Protection: Safety goggles.
- Hand Protection: Protective gloves.
- Skin and body protection: Long sleeved clothing and long pants.
- Respiratory protection: Large spillages: Wear suitable respiratory protective equipment.
Environmental Exposure Controls: Avoid release to the environment.
SECTION 9: Physical and chemical properties
9.1 Information on basic physical and chemical properties
Appearance:
Physical state: Liquid
Color: Dark red
Odor: Slight
Odor Threshold: No information available
pH: 7 - 9
Melting point/freezing point: < -5 °C
Initial boiling point and boiling range: > 100 °C
Flash Point: Does not flash >93.3°C (Tag closed cup; Cleveland open cup)
Evaporation rate: No information available
Flammability (solid, gas): Not applicable
Upper/lower flammability or explosive limits: No information available
Vapor pressure: No information available
Vapor density: No information available
Relative density: 1.0-1.1 (H2O=1)
Partition coefficient: n-octanol/water: Soluble (water)
Solubility(ies): No information available
Auto-ignition temperature: >400 °C
Decomposition temperature: No information available
Viscosity: 1-5 mPa-s
Explosive properties: Not explosive
Oxidizing properties: No information available
9.2 Other information
No information available.
SECTION 10: Stability and reactivity
10.1 Reactivity
No information available.
10.2 Chemical stability
Stable.
10.3 Possibility of hazardous reactions
No information available.
10.4 Conditions to avoid
No information available.
10.5 Incompatible materials
Strong oxidizing agents.
10.6 Hazardous decomposition products
Contains: Carbon monoxide (CO). Carbon dioxide (CO2).
SECTION 11: Toxicological information
11.1 Information on toxicological effects
Acute toxicity
Inhalation: No information available.
Eye contact: No information available.
Skin contact: No information available.
Ingestion: LD50 > 2000 mg/kg (Method OECD#420)
Skin corrosion/irritation: Non-irritant. (Method: OECD#404)
Serious eye damage/irritation: Minimal irritant to the eye. (Method: OECD#405)
Respiratory or skin sensitisation: It is not a skin sensitizer. (Method: OECD#429)
Mutagenicity: Negative. (Method: OECD#471)
Carcinogenicity: Ingredients of this product have not been classified as carcinogens according to IARC monographs, NTP and OSHA
SECTION 12: Ecological information
12.1 Toxicity
Chemical Name | Toxicity to algae | Toxicity to fish | Toxicity to daphnia and other aquatic invertebrates |
---|---|---|---|
Glycerol 56-81-5 | LC50: 5157 mL/L 96 h static (Oncorhynchus mykiss) | EC50: >500 mg/L 24 h (Daphnia magna) | |
Diethylene glycol 111-46-6 | LC50: 75200 mg/L 96 h flow-through (Pimephales promelas) | EC50: 84000 mg/L 48 h (Daphnia magna) |
12.2 Persistance and degradability
No information available.
12.3 Bioaccumulative potential
Chemical Name | log Pow |
---|---|
Glycerol | -1.76 |
Diethylene glycol | -1.98 |
12.4 Mobility in soil
No information available.
12.5 Results of PBT and vPvB assessment
This product contains no substance considered to be persistent, bioaccumulating nor toxic (PBT). This product contains no substance considered to be very persistent nor very bioaccumulating (vPvB).
12.6 Other adverse effects
No information available.
SECTION 13: Disposal considerations
13.1 Waste treatment methods
Dispose of in accordance with Federal, State, and local regulations.
SECTION 14: Transport information
Not classified according to the United Nations "Recommendations on the Transport of Dangerous Goods"
14.1 UN Number: None
14.2 UN proper shipping name: None
14.3 Transport hazard class(es): None
14.4 Packing Group: None
14.5 Environmental hazards: None
14.6 Special precautions for user: None
14.7 Transport in bulk according to Annex II of Marpol 73/78 and the IBC Code: Not applicable
Not regulated under DOT, IMDG, IATA.
SECTION 15: Regulatory information
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
EU: Not classified as dangerous for supply/use. (1999/45/EC)
But ink has to bear the inscription: "Contains water soluble heterocyclic magenta azo dye compounds. May produce an allergic reaction"
USA: All chemical substances contained in this product are and had been listed on the TSCA Chemical Substances Inventory, and none is subject to any of the following TSCA requirements: section 4 test rules; proposed or final section 5(a)(2) significant new use rules; section 5(e) consent orders; section 8(a) preliminary assessment information rules; and section 8(d) health and safety data reporting rules.
Canada: WHMIS: Not applicable. (Manufactured article)
15.2 Chemical Safety Assessment
No.
SECTION 16: Other information
Full text of R-phrases referred to under sections 2 and 3
- R22 - Harmful if swallowed
- R36 - Irritating to eyes
- R41 - Risk of serious damage to eyes
- R38 - Irritating to skin
- R43 - May cause sensitization by skin contact
- R50 - Very toxic to aquatic organisms
- R51/53 - Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment
Full text of H-Statements referred to under sections 2 and 3
- H302 - Harmful if swallowed
- H315 - Causes skin irritation
- H318 - Causes serious eye damage
- H317 - May cause an allergic skin reaction
- H319 - Causes serious eye irritation
- H400 - Very toxic to aquatic life
- H411 - Toxic to aquatic life with long lasting effects
Additional information
The information relates only to this product. It may not be valid, if used in combination with any other materials or in any other process, and it is based on our best knowledge as of the date of preparation (revision).
Revision Note
SECTION 1, 2.
References:
- U.S. 29CFR Part 1910
- ACGIH Threshold Limit Values for Chemical Substances and Physical Agents and Biological Exposure Indices
- IARC Monographs on the Evaluation Carcinogenic Risks to Humans World Health Organization
- EU Directive 91/322/EEC and 2000/39/EC
- NTP 11th Report on Carcinogens
Abbreviations:
- ACGIH: American Conference of Governmental Industrial Hygienists
- DOT: Department Of Transportation (US)
- IARC: International Agency for Research on Cancer
- IATA: International Air Transport Association
- IMDG: International Maritime Dangerous Goods
- NOHSC: National Occupational Health and Safety Commission (Australia)
- NTP: National Toxicology Program (US)
- OSHA: Occupational Safety and Health Administration (US)
- PEL: Permiss ble Exposure Limit
- STEL: Short Term Exposure Limit
- TLV: Threshold Limit Value (ACGIH)
- TSCA: Toxic Substances Control Act (US)
- TWA: Time Weighted Average
- WHMIS: Workplace Hazardous Material Information System (Canada)