ENGINE
- Isuzu 4LE1NYGV-03 - naturally aspirated, diesel engine
- Prime - 32 hp @ 1800 rpm
- Standby - 35 hp @ 1800 rpm
- 4 cylinder
- 2.2 L displacement
- Tier IV Interim approved
- Steel, single wall fuel tank
- 106 gal. (401.25 L) capacity
- 45.4 hr. run time - full load
- Fuel tank built into skid of generator set
- Fuel consumption at prime:
- 100% - 1.8 gph (6.8 Lph)
- 75% - 1.4 gph (5.3 Lph)
- 50% - 0.9 gph (3.4 Lph)
- Cooling system capable of operating at 120°F (49°C) ambient
- Low coolant shutdown
- Radiator and oil drains plumbed to exterior
- Rubber vibration dampers isolate engine/generator from frame
- Disposable air filter - paper element
- Air filter restriction indicator mounted on control panel
- 60 Hz engine/generator
- Droop governed
CAN-STANDARD FEATURES
- 60/40 coolant
- Block heater
- Heated fuel filter
- Liquid containment
- *Transport Canada tank not required
GENERATOR
- Marathon Electric
- Brushless
- 4 pole
- Class H insulation
- Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator
SYSTEM OUTPUTS
- 3 position selector switch
- Single phase - 120 / 240V Zig Zag
- Three phase - 120 / 208V Low Wye
- Three phase - 277 / 480V High Wye
- 16 kW / 16 kVA – standby, single phase
- 15 kW / 15 kVA – prime, single phase
- 20 kW / 25 kVA – standby, three phase
- 18 kW / 23 kVA – prime, three phase
SYSTEM CONTROLS
- Microprocessor-based controller
- Backlit, color display
- Thermostatically controlled LCD heater
- -40°F to 185°F (-40°C to 85°C) operating temperature range
- Six LED indicators w/ lamp test
- Alarm / Fault (Red)
- Ready / Manual (Red)
- Running (Green)
- Warning (Yellow)
- Ready / Auto (Green)
- Supplying Load (Green)
- Push buttons for easy operation
- Manual or Auto Start
- Engine Start
- Engine Stop/Reset
- Alarm Cancel and Fault Set
- Scrolling Arrows for Diagnostic Information
- System kW output display
- Line output & frequency display
- Engine diagnostic display
- Oil pressure
- Engine temperature
- Fuel level
- Battery
- System hours
- Running hours
- kW hours
- Time to service
- Alarm list - warnings / shutdowns; 250 event history log – date/time stamp
- Fuel level: warning – 15%; shutdown – 5%
- Over speed protection: shutdown – 115%
- Oil pressure: warning – 25 psi; shutdown – 20 psi
- Coolant temperature: warning – 220°F (104°C); shutdown – 230°F (110°C)
SYSTEM CONTROLS (continued)
- Battery voltage: over – 15VDC; under – 11VDC
- Generator over voltage: warning – 110%; electrical trip – 111%
- Generator under voltage: warning - 87%; electrical trip - 86%
- Generator over frequency: warning – 105%; electrical trip – 110%
- Generator under frequency: warning – 95%; electrical trip – 90%
- Over current shutdown
ELECTRICAL CONTROLS
- Remote start / stop contacts located in lug box
- Lockable control box door with diagnostics window
- Lockable lug box with safety switch
- Trips main breaker when door is opened
- Disables voltage regulator
- 90A main breaker with shunt trip
- Output ground connection lug inside lug box
- Convenience receptacles with individual breakers (restricted use in high wye mode)
- (2) 120V 20 Amp GFCI duplex outlets – (NEMA 5-20R type)
- (2) 125 / 250V 50 Amp, 3 pole, 4 wire twistlock (Non-NEMA 6369)
- Voltage adjustment integrated into Power Zone controller. - +/- 10%
- 720 CCA wet cell battery
ENCLOSURE
- Flip-Hood design - aluminum, sound attenuated enclosure
- Easy access for daily maintenance
- Centralized location for all electrical connections/wiring
- UV & fade resistant, high temperature cured, white polyester powder paint
- Insulated and baffled - 68 dB(A) at 23 feet – prime power
- Fully lockable enclosure including doors and fuel fill
- Stainless steel hinges on doors
- Emergency stop switch located on outside of enclosure
- Central lifting point
- Multi-lingual operating/safety decals
- Document holder with operating manual including AC/DC wiring diagrams
TRAILER
- DOT approved tail, side, brake, and directional lights; recessed rear lights
- Transportation tie downs
- Flip tongue design
- Safety chains with spring loaded safety hooks
- 2" (50.8 mm) ball hitch
- 3500 lb (1588 kg) axle
- 3000 lb (1361 kg) tongue jack with footplate
- P205/75R15 tubeless tires – 6 ply
WEIGHT & DIMENSIONS
Skid mounted
- Dry weight: 2048 lbs (1038 kg)
- Operating weight: 2517 lbs (1222 kg)
- 95 x 35 x 52 in (2.41 x 0.89 x 1.32 m)
Trailer mounted
- Dry weight: 2289 lbs (1147 kg)
- Operating weight: 2758 lbs (1331 kg)
- 150 x 57 x 67 in (3.81 x 1.45 x 1.70 m)
WARRANTY
Engine and generator covered under OEM warranty
CERTIFICATIONS
CSA Certified
