Safety Warnings and Precautions
All images in this manual are for illustrative purposes only; please refer to the actual product.
Age and Height Recommendation: 14-60 years old, 130-190cm height.
Protective Gear: Always wear a helmet, knee pads, elbow and wrist guards, and other protective gear while riding the scooter to reduce the risk of injury.
General Warnings
It is important to fully understand your new electric scooter to achieve the best performance, comfort, fun, and safety. Carefully read this operation manual before operating.
Your first ride should be in a safe and controlled manner, away from cars, obstacles, and other riders. Do not ride on highways or public roads where prohibited. Do not ride against traffic. Avoid riding in the rain, slow down, and avoid waterlogged roads.
Electric scooters carry a certain level of risk. Do not use a mobile phone or headphones while riding. Familiarize yourself with local traffic regulations for electric scooters and comply with them at all times. For safety, wear an appropriate helmet before riding. For better protection, it is recommended to wear protective gear such as elbow and knee pads.
Electric scooters may not come with basic mandatory equipment, and requirements vary by location. If you intend to use the electric scooter, ensure you are equipped with the necessary mandatory equipment according to applicable laws and regulations.
This product is intended for personal use only. Do not use it for commercial purposes.
Keep this manual in a safe place for future reference.
Riding Precautions
Before riding, check tire pressure, ensure the handlebar is correctly mounted and tightened, and confirm the battery is fully charged. If the battery runs low during a ride, ride slowly and evenly, and charge it as soon as possible.
Always check the charger, cable, and plug before each charging session. Do not use the charger if it is damaged in any way.
Braking distance is typically longer on wet surfaces than on dry ones. Therefore, brake earlier to stop more safely.
Avoid riding during rain, thunderstorms, or snow. If electrical components (control unit, motor, and battery) get wet or submerged in water, it can cause irreversible damage and potentially lead to battery explosion.
This product is for use by one adult only. Do not carry passengers. Do not ride if you feel unwell or are under the influence of alcohol or drugs.
This scooter is not a toy. Like any activity, there is a risk of falls, collisions, or other dangerous situations. Do not offer the scooter to individuals who do not know how to operate it correctly. If you allow others to ride the scooter, it is your responsibility to ensure all users have read all warnings, cautions, instructions, and safety measures. Ensure they can operate the product safely and responsibly, protecting themselves and others.
Keep electric scooters away from flammable items and open flames.
Scooter Diagram
The noise level of the entire scooter is less than 70 dB.
Components:
- Display Indicator: Shows speed, battery, modes, etc.
- Brake Lever: Left and right levers for braking.
- Hook: For securing the handlebar when folded.
- Quick Release for Lifting: Mechanism for adjusting handlebar height or folding.
- Folding Handle: Part of the folding mechanism.
- Headlight: Front illumination.
- Front Shock Absorber: For cushioning impacts.
- Battery Cover: Protects the battery compartment.
- Rear Shock Absorber: For cushioning impacts.
- Rear Fender: Protects from spray.
- Footrest: Platform for the rider's feet.
- Auxiliary Wheel: (Likely refers to the front wheel or a part of the folding mechanism).
- Electric Machinery: The motor unit.
Specifications
| Item | Details |
|---|---|
| Item Name | KuKirin G2 Pro |
| Dimensions (Folded) | 1170*590*512mm |
| Dimensions (Unfolded) | 1170*590*1300mm |
| Max Speed | < 25 km/h |
| Range | ≤ 58 km |
| Max Incline | < 19° |
| Tires | 9-inch off-road tires |
| Shock Absorption | Spring damping |
| Waterproof Rating | IP54 |
| Brake | Front and rear disc brakes |
| Display Content | Speed, mileage, battery, headlights, etc. |
| Lighting Systems | LED |
| Input Voltage | 100~240V/50~60Hz |
| Battery Voltage/Capacity | 48V/15.6Ah |
| Charger | 54.6V/2A, approx. 8 hours charging time |
| Max Load | 120 kg |
| Net Weight | Approx. 25 kg |
What's in the Box
- Operation Manual *1
- Tire Pump *1
- Tool Kit *1
- Charger *1
Please check carefully to ensure nothing is missing or damaged. If so, please contact us.
Assembly Instructions
Unpacking and Assembly
- Secure the folding device; insert the handlebar tube into the fixed seat and tighten the screws.
- Lock the base with screws, insert the seat into the bracket, and adjust the height.
- Lock the seat latch and check the vehicle.
Folding and Unfolding
- Loosen the hook, lift vertically until the folding elements automatically lock the first lock.
- Fasten the folding elements, lift the seat bracket, pull upwards, and fasten the seat quick release.
- Adjust the seat height and lock the seat latch.
Tips for Beginners
- Wear protective gear, including a helmet, knee pads, wrist guards, and elbow pads.
- Practice riding until you can easily mount, ride forward, turn, stop, and dismount.
- Avoid riding near anything that could get caught or stuck in the wheels.
- Prefer relatively wide roads and avoid riding on slopes, pedestrian surfaces, or obstacles until you are proficient in riding.
Operation Instructions
Controls Overview
Left Brake Lever: Controls the front brake.
Right Brake Lever: Controls the rear brake.
Handlebar Cover: Houses various controls.
Headlight Switch: Turns the headlight on/off.
Horn: Sounding device.
Power Switch: Turns the scooter on/off.
Accelerator Pedal: Controls speed (throttle).
Electric Lock: Likely for securing the scooter or battery.
Display Functions
The display shows:
- Speed: Current riding speed.
- Left Turn / Right Turn: Turn signal indicators.
- Braking Sign: Indicates when brakes are applied.
- Zero Start / Single Drive: Indicates starting mode and drive configuration.
- Voltage: Current battery voltage.
- Energy Bar: Battery level indicator.
- Headlight Symbol: Indicates headlight status.
- Mode: Riding mode indicator (e.g., Eco, Standard, Sport).
- Speed Unit: Displays speed in Km/h or mph.
- Mileage / Error Codes: Shows trip distance, odometer (ODO), or error codes.
- Cruise Control Sign: Indicates if cruise control is active.
Basic Operations
- Power On/Off: Long press the power button.
- Mode Switching: Short press the power button once to cycle through three riding modes.
- Settings Menu: Short press the power button three times to enter the menu settings. The display will show P01, P02, P03, P04, P05, P06, P08, PA, PB.
Settings Menu (P-settings)
- P01: Kilometer/Mile selection (default is kilometer).
- P02: Voltage level setting (36V/48V/52V/60V/72V, default is 48V).
- P03: Wheel diameter setting in inches (adjustable from 080-160, default is 100).
- P04: Magnetic pole number range for speedometer (1-100, default is 30).
- P05: Cruise control selection (0 means no cruise control, 1 means cruise control enabled, default is disabled).
- P06: Zero start/Non-zero start setting (0 means zero start, 1 means non-zero start, default is zero start).
- P08: Hibernation time limit setting (0 means no hibernation, other numbers indicate hibernation time in minutes, default is 5 minutes).
- PA: Starting force adjustment (1-5, where 1 is minimum and 5 is maximum).
- PB: Braking force adjustment (0-5, where 0 is off, and 1-5 increases braking force gradually).
Troubleshooting
| Fault | Code | Remedy |
|---|---|---|
| Rear motor failure | E001 | Replace the rear motor/controller and try again. |
| Accelerator failure | E002 | Replace the accelerator and try again. |
| Controller failure | E003 | Replace the controller and try again. |
| Phase imbalance | E005 | The battery is discharged; charge it and try again. |
| Instrumentation failure | E006 | Replace the meter/controller and try again. |
| Instrumentation failure | E007 | Replace the meter/controller and try again. |
Charging Instructions
Note: The charger indicator light is red while charging and turns green when fully charged.
- Connect the charger to the scooter's charging port.
- Open the charging port flap before connecting.
Maintenance
Lubrication
Every six months, add a small amount of white grease or lubricant to the folding parts for maintenance. Every three months, check the scooter for loose screws and tighten them if necessary.
Battery Care
Turn off the power when charging or when the scooter is not in use. If the scooter will not be used for an extended period, store it in a safe place and charge it at least once every 3 months.
Storage
Do not leave the scooter in hot sunlight or other highly humid places for extended periods. Keep the scooter clean.
Warranty Information
Warranty Description
Within the warranty period from the date of receipt, if the product malfunctions or is damaged, it can be serviced free of charge after testing and confirmation by the KuKirin after-sales service center. For repair, replacement, or return services, please contact the product seller and follow their instructions. Provide accurate, complete, and valid purchase information or invoice.
| Warranty Item | Warranty Period |
|---|---|
| Controller, meter, motor, battery, charger | Half year |
| Frame, front body, rear wheel hub, brakes, folding mechanism, body lever, front fork, brake system, accelerator trigger, etc. | One year |
Warranty Card
When servicing the product, please fill in the following information completely and legibly.
User Information
- Name:
- Email:
- Correspondence Address:
- Phone Number:
Product Information
- Product Name:
- Product Standard:
Seller Information
- Name: Shenzhen Miasto KuKirin Technologia Sp., z o.o.
- Address: 4F4913, Shenzhou Computer Headquarters, Lady Curie Avenue, Vanke District, Bantian Street, Longgang District, Shenzhen City, China.
Kukirin
