1 Package Contents
- Car Refrigerator
- User Manual
- 12/24V DC Power Cord
- 110/220V AC Power Adapter
2 Safety Instructions
⚠️ WARNING! Failure to obey these warnings could result in the malfunction of your device and possible injury to yourself and other users.
- Do not operate the device if it is visibly damaged.
- Do not block the gaps of the device with small items like pins, wires, etc.
- Do not expose the device to rain or soak it in water.
- Do not place the device near naked flames or other heat sources (heaters, direct sunlight, gas ovens etc.)
- Do not store explosive substances like spray cans with flammable propellants in the device.
- Before starting the device, ensure that the power supply line and the plug are dry.
- Check if the voltage specification on the nameplate matches the power supply voltage specification.
- Before starting the device, it must be left horizontal for more than 12 hours.
- Make sure that the device stays horizontal when it is running. The tilt angle must be less than 5° for a long time running and less than 45° for short time running.
- The refrigerator must be well-ventilated for heat dissipation and make sure to keep some space around it (Back Space 200mm, Side Space 100mm).
- The device may only be repaired by Qualified personnel. Improper repairs can lead to safety hazards. If the power cable is damaged, it must be replaced by the manufacturer, customer service, or a similarly Qualified person in order to prevent safety hazards.
ℹ️ NOTICE!
- The device can be used by children aged eight years and over, as well as by persons with reduced physical, sensory or mental abilities or lack of experience and knowledge. However, they must be supervised during use or they must have been adequately taught how to use the fridge safely and have been made aware of the risks involved before using it.
- Children must be supervised to ensure that they do not play with the device.
- Disconnect the device or switch it off when you turn off the engine. Otherwise, you may discharge the battery.
❗ CAUTION!
- Food is suggested to be stored in its original packaging or in suitable containers.
- Set a suitable temperature for food stored in the device. Refer to the recommended temperature for common food on Page11.
3 Preparing Before Use
- Unpackage and take out the accessories, and let the device stand for 12 hours.
- Before using it for the first time, clean the inside and outside of the car refrigerator with a damp cloth and wait until it gets dry.
- Place your refrigerator in a proper position which depends on your use scenario (car, truck, RV, camper, Van, Jeep, SUV, boat, home, etc.)
- According to your use scenario, please choose the right power cord (AC cord or DC cord) for the right power supply. Please read the next part carefully for the details.
4 Product Introduction
4.1 Product Features
- High-efficiency DC compressor and conversion module.
- CFC free and great heat insulation.
- Fast cooling to -20°C / -4°F (based on 25°C / 77°F room temperature).
- LCD digital display for temperature setting.
- Dual compartments with individual temperature control.
- Three stage battery protection system prevents vehicle run out of battery.
4.2 Product Size
Capacity: 37Quart / 35L
Dimensions:
- With handle: 28*18.1*17.4 in (71.1*46*44.1cm)
- Without handle: 23.6*15.7*17.4 in (60*40*44.1cm)
- Big zone: 12.2*10.6*13.5 in (30.9*26.9*34.3cm)
- Small zone: 12.2*7.9*6.6 in (30.9*20*16.7cm)
- N.W.: 40.7lb(18.44kg)
Capacity: 48Quart / 45L
Dimensions:
- With handle: 28*18.1*19.9 in (71.1*46*50.6cm)
- Without handle: 23.6*15.7*19.9 in (60*40*50.6cm)
- Big zone: 12.2*10.6*16.1 in (30.9*26.9*40.8cm)
- Small zone: 12.2*7.9*9.1 in (30.9*20*23.2cm)
- N.W.: 42.3lb(19.19kg)
Capacity: 59Quart / 55L
Dimensions:
- With handle: 28*18.1*22.5 in (71.1*46*57.1cm)
- Without handle: 23.6*22.5*19.9 in (60*40*57.1cm)
- Big zone: 12.2*10.6*18.6 in (30.9*26.9*47.3cm)
- Small zone: 12.2*7.9*11.7 in (30.9*20*23.2cm)
- N.W.: 43.2lb(19.61kg)
Capacity: 37Quart / 35L
Dimensions:
- With handle: 25.5*15.7*17.4 in (64.7*40*44.1cm)
- Without handle: 23.6*15.7*17.4 in (60*40*44.1cm)
- Big zone: 12.2*10.6*13.5 in (30.9*26.9*34.3cm)
- Small zone: 12.2*7.9*6.6 in (30.9*20*16.7cm)
- N.W.: 35.6lb(16.14kg)
Capacity: 48Quart / 45L
Dimensions:
- With handle: 25.5*15.7*19.9 in (64.7*40*44.1cm)
- Without handle: 23.6*15.7*19.9 in (60*40*50.6cm)
- Big zone: 12.2*10.6*16.1 in (30.9*26.9*40.8cm)
- Small zone: 12.2*7.9*9.1 in (30.9*20*23.2cm)
- N.W.: 36.4lb(16.5kg)
Capacity: 59Quart / 55L
Dimensions:
- With handle: 25.5*15.7*22.5 in (64.7*40*44.1cm)
- Without handle: 23.6*22.5*19.9 in (60*40*57.1cm)
- Big zone: 12.2*10.6*18.6 in (30.9*26.9*47.3cm)
- Small zone: 12.2*7.9*11.7 in (30.9*20*23.2cm)
- N.W.: 37.9lb(17.2kg)
4.3 Product Structure
Model: CR03512/ CR04512/ CR05512
- Door latch
- Cutting board
- Left compartment
- LED control panel
- Telescoping handle
- Button
- Footpad
- Machine compartment
- Sealing strip
- Right compartment
- Bottle opener
- Detachable battery (NOT INCLUDE)
- Charging port
- Wheel
If you need the BougeRV battery, please search for it on Amazon or bougerv.com.
*There are buttons on both sides of the telescoping hand, which can be pressed at the same time to pull the rod.
Model: CR03512/ CR04512/ CR05512
- Door latch
- Cutting board
- Left compartment
- LED control panel
- Handle
- Footpad
- Machine compartment
- Sealing strip
- Right compartment
- Bottle opener
- Detachable battery (NOT INCLUDE)
- Charging port
Note: The package does not include the battery. If you are interested, please search "BougeRV battery" on Amazon or bougerv.com.
*Removable battery: Press the left and right to remove/insert the battery; it will be heavy in your hand, which is recommended to be held with care and taken out gently.
*The cutting board can be moved by turning the knob on the top cover; it is suggested to clean and dry it after every use.
4.4 Reverse Door Opening Direction
The door opening direction can be changed according to actual needs, please follow the instructions below:
Door Disassembly:
- Open the door at a 90° angle.
- Take off the door from one side.
- Take off the door from the other side.
Door Installation:
- Reverse the door opening direction.
- Align the door shaft with the hole on one side and insert it.
- Fix the door on the other side; installation finished.
5 Operation Instruction
5.1 Power Supply: Connect to 12V/24V DC power, 100-240V AC power (using the adapter), or use a backup lithium battery which can be recharged by solar (12~50V).
5.2 Display Screen Initialization: Connect to the power supply, the buzzer will make a long beep, and the display will be on for 2 seconds then enter the normal operating mode.
5.3 Turn On/Off: Short press [ON/OFF] to turn it on; Press and hold [ON/OFF] for 3 seconds to turn it off.
5.4 Temperature Setting
5.4.1 Temp adjustment of the left compartment: When both left and right compartments are set in running state, press [+] or [-] to enter the left compartment temperature setting, press [+] to increase temperature, and press [-] to decrease temperature.
5.4.2 Temp adjustment of the right compartment: Press [+] or [-] to switch left/right compartment. When the temperature on the left flashes, press [+] or [-] to adjust the temp. The setting will be saved after stopping operating for four seconds. (Note: The temperature displayed is the current temperature of the compartments; it will take a while to reach the set temperature.)
5.4.3 Compartment ON / OFF: Under the running state, long press [+] and [⚙️] at the same time for three seconds to switch ON/OFF the left compartment, long press [-] and [⚙️] at the same time for three seconds to switch ON/OFF the right compartment. Two compartments cannot be switched off at the same time.
5.5 MAX/ECO Mode Switching: Under the running state, press [⚙️] to switch MAX (fast cooling) and ECO (Energy saving Mode). (*Factory setting is MAX.)
5.6 Temperature Unit Setting: Switch off the fridge, long press [⚙️] for three seconds until E1 displays, then switch to E5 by pressing [⚙️] again. Under E5 mode, press [+] or [-] to select Celsius or Fahrenheit. (*Factory setting is °F.)
Reset: Switch off the fridge, long press [⚙️] for three seconds until E1 displays, under E1 mode, and long press [+] and [-] at the same time for three seconds to reset it.
5.7 Car Battery Protection Setting H/M/L
Under the running state, long press [⚙️] for three seconds until the screen flashes, then press [⚙️] again to select protection mode H (High), M (Middle), and L (Low). (*Factory setting is H.)
6 Car Battery Protection(H/M/L) Voltage Reference
Due to the different output voltages between vehicles, H should be set when the product is connected to car power, and M or L should be set when it is connected to a portable power station or other backup battery.
The battery gear should be set from H to M or from M to L if there is a voltage protection code F1 shown on the panel. The battery gear should be set to H if the product keeps working after turning off the car engine, or the product may drain the battery.
Voltage Reference:
| MODE | DC 12V CUT OUT | DC 12V CUT IN | DC 24V CUT OUT | DC 24V CUT IN |
|---|---|---|---|---|
| L | 9.0V | 10.9V | 21.3V | 22.7V |
| M | 10.1V | 11.4V | 22.3V | 23.7V |
| H | 11.1V | 12.4V | 24.3V | 25.7V |
*The voltage is theoretical value; there may be a deviation in different scenarios.
*USB output: +5V DC/1A, suitable for small devices like mobile phones, tablets, etc.
7 Error Code Problems and Troubleshooting
| Issues | Suggestions |
|---|---|
| Refrigerator does not work | Check if the switch is on. Check if the plug and socket are connected well. Check if the fuse has been burnt. Check if the power supply has malfunctioned. |
| Refrigerator compartments are too warm | Switching on/off the fridge frequently may cause a start delay of the compressor. The door is opened frequently. A large amount of warm or hot food was stored recently. Wait for the refrigerator to reach its selected temperature. |
| Food is frozen | The refrigerator has been disconnected for a while. The temperature was set too low, please increase the temperature. |
| A "water flow" noise from inside the fridge | It's a normal phenomenon, caused by the flow of refrigerant. |
| There are waterdrops around the refrigerator casing or door gap. | It's a normal phenomenon, the moisture will condense to water when it touches the cold surface of the refrigerator. |
| The compressor is slightly noisy when starting | It's a normal phenomenon, the noise will be reduced after the compressor works stably. |
| Code F1 displayed | Possible cause: low voltage to the fridge. Adjust the battery protection from H to M or from M to L. |
| Code F2 displayed | Possible cause: condenser fan is overloaded. Disconnect power to fridge for 30 minutes & re-start. |
| Code F3 displayed | Possible cause: the compressor starts too frequently. Disconnect power to fridge for 30 minutes & re-start. |
| Code F4 displayed | Possible cause: compressor not kicking in. Disconnect power to fridge for 30 minutes & re-start. |
| Code F5 displayed | Possible cause: overheating of the compressor & electronics. Disconnect power to fridge for 30 minutes & re-start. |
| Code F6 displayed | Possible cause: no parameter can be detected by the controller. Disconnect power to fridge for 30 minutes & re-start. |
| Code F7 or F8 displayed | Possible cause: temperature sensor is faulty. Contact manufacturer for service. |
8 Cleaning and Storage
Cleaning
- Unplug the device first to avoid electric shock.
- Use a wet cloth to clean the device and dry it.
- Remove the cover and drain from the hole at the bottom of the device.
- Do not soak the device in water and do not wash it directly.
- Do not use abrasive cleaning agents as these can damage the device.
Storage
If the device will not be in use for a long time, please follow the steps:
- Turn off the power and remove the plug.
- Remove all the items stored in the device.
- Remove the cover and drain from the hole, wipe off excess water with a soft rag.
- Leave the lid slightly open to prevent odors from forming.
- Put the device in a cool and dry place.
Defrosting
Humidity can form frost in the interior of the cooling device or on the evaporator, which will affect the cooling performance. Defrost the device regularly to avoid this.
- Switch off the device.
- Take out the contents of the device.
- Keep the lid open.
- Remove the cover and drain from the hole.
- Wipe off the defrosted water.
⚠️ Never use hard or sharp tools to remove ice or to loosen objects which have frozen in place.
9 FAQ
- Q1: Is there a cover for this refrigerator?
- A1: Yes, there is. You could search for "BougeRV 37/48/59 quart fridge cover" on Amazon.
- Q2: Does it come with a battery installed?
- A2: No, this refrigerator does not come with a battery. Our batteries are sold separately. You can search "BougeRV battery" on Amazon or bougerv.com.
- Q3: How to connect the APP?
- A3: First Step: Turn on the Bluetooth on your smart device; start the APP and click "Search" to find nearby fridges. Second Step: Click the fridge icon for Bluetooth pairing (the APP will prompt you to pair the fridge by pressing the set button on the fridge's control panel when connecting the fridge for the first time). After pairing, the APP will switch to the main interface allowing you to control the fridge.
- Q4: How much is the power consumption of the refrigerator?
- A4: It is divided into ECO and MAX. The ECO mode is 45W; the MAX mode is 60W.
- Q5: What's the Outside temperature range this can be safely used?
- A5: Temperature range: 50°F~122°F.
- Q6: What is the adjustable temperature range of the refrigerator?
- A6: -4 ~68°F.
- Q7: How long does it take to cool down to the lowest temperature?
- A7: The cooling rate depends on whether the refrigerator is empty or loaded. It usually takes about an hour and a half for the empty box to reach the lowest temperature. The more things in the refrigerator, the slower the cooling speed.
- Q8: Does the fridge have to be plugged in for use?
- A8: Yes, it must.
- Q9: How long can the temperature be maintained after unplugging?
- A9: Depends on the ambient temperature around it. If the compartments are filled, it will take longer to warm. If it's empty, it's quick to warm.
- Q10: How long can this continuously be run safely?
- A10: As long as the power supply is maintained, our portable refrigerators can work 24 hours/a day, just like home refrigerators.
- Q11: Will it keep ice cream frozen?
- A11: Yes. By setting the temperature below 0°F, you can keep the ice cream frozen.
- Q12: Can I make ice with ice cube trays?
- A12: Yes. The internal temperature of this portable refrigerator is adjustable from -4°F to 68°F. You can get ice cubes by setting the temperature below 32°F.
- Q13: Can I get a new replacement if the parts of my refrigerator malfunction?
- A13: Sure, we provide a 2-year warranty.
- Q14: How can I register for the warranty on my refrigerator?
- A14: You can contact our email "service@bougerv.com / bougerv@gmail.com", and we will give you the corresponding solution according to your problem.
10 Warranty and Maintenance
Warranty
BougeRV PORTABLE CAR REFRIGERATOR comes with a 2-year warranty that commences from the date of purchase on BougeRV Amazon Store or BougeRV Official Website, except the following situations:
- Contrived damage.
- Damage caused by force majeure such as earthquake, conflagration, etc.
- Damage from inappropriate use or violating this instruction.
- Damage or malfunction caused by disassembling.
- 24-month limited warranty
- Lifetime technical support
Customer Service
If there is any problem with the operation or use of the product, please feel free to contact us via:
Amazon:
- Email: service@bougerv.com
- Phone (CHN): +1 699 232 7427 (9AM-6PM UTC+8 Monday-Friday)
- Phone (US): +1 408 656 8402 (9AM-6PM PT Monday-Friday)
BougeRV Website:
- Email: support@bougerv.com
- Phone (CHN): +1 408 429 4149 (9AM-6PM UTC+8 Monday-Friday)
- Phone (US): +1 408 656 8402 (9AM-6PM PT Monday-Friday)
VIP Service & Extra 1-year Warranty
- Search "QR Code" on your FB.
- Scan the QR Code beside.
- Join "BougeRV Car Refrigerator Club".
- You become a VIP and get a 3-year warranty.
11 Specification
| Model | CR03512 | CR04512 | CR05512 |
|---|---|---|---|
| Rated Voltage | DC 12V/24V, AC100~240V(using the adapter) | ||
| Rated Power Input | 60W | ||
| Capacity | 35L/37QT/1.3cu.ft. | 45L/48QT/1.6cu.ft. | 55L/59QT/2.0cu.ft. |
| Noise Emission | ≤45dB | ||
| Climate Type | T/ST/N/SN | ||
| Temperature Range | -20°C ~ 20°C (-4°F ~ 68°F) | ||
| Dimensions (D*W*H) | 711*460*441mm (28.0*18.1*17.4in.) | 711*460*506mm (28.0*18.1*19.9in.) | 711*460*571mm (28.0*18.1*22.5in.) |
| Weight | 18.4kg/40.7lbs | 19.2kg/42.3lbs | 19.6kg/43.2lbs |
| Model | CR03513 | CR04513 | CR05513 |
|---|---|---|---|
| Rated Voltage | DC 12V/24V, AC100~240V(using the adapter) | ||
| Rated Power Input | 60W | ||
| Capacity | 35L/37QT/1.3cu.ft. | 45L/48QT/1.6cu.ft. | 55L/59QT/2.0cu.ft. |
| Noise Emission | ≤45dB | ||
| Climate Type | T/ST/N/SN | ||
| Temperature Range | -20°C ~ 20°C (-4°F ~ 68°F) | ||
| Dimensions (D*W*H) | 647*400*441mm (25.5*15.7*17.4in.) | 647*400*506mm (25.5*15.7*19.9in.) | 647*400*571mm (25.5*15.7*22.5in.) |
| Weight | 16.1kg/35.6lbs | 16.5kg/36.4lbs | 17.2kg/37.9lbs |
*Due to product improvement, the technical information might be different from the actual information, please refer to the rating label on the product.
Disposal:
Place the packaging material in the appropriate recycling waste bins wherever possible. If you want to eventually dispose of the product, ask your local recycling center or specialty distributor for details on how to do so in accordance with the applicable disposal regulations.
12 APP Control
First Step: Turn on the Bluetooth on your smart device; start the APP and click "Search" to find nearby fridges.
Second Step: Click the fridge icon for Bluetooth pairing (the APP will prompt you to pair the fridge by pressing the set button on the fridge's control panel when connecting the fridge for the first time). After pairing, the APP will switch to the main interface allowing you to control the fridge.
App Features:
- MENU
- Current temperature
- Current voltage
- Target temperature
- Switch Left/Right compartment
- SET
- ON/OFF
- Current battery
- Temperature control
- ECO(Energy-saving) / MAX(Fast-cooling)
- Lock / Unlock
- Celsius / Fahrenheit
- Unpairing the device and return to search
- Battery protection mode: High/Medium/Low
Note: *Click the lock icon [?] on the APP to lock/unlock the control panel on the fridge; if locked, the fridge can only be controlled by the APP.
Downloading the "CAR FRIDGE FREEZER" Application
Scan the QR code on the left or search for the "CAR FRIDGE FREEZER" APP in the iTunes APP Store (for Apple devices) or Google Store (for Android devices).
Explore more from BougeRV
- Instagram: @bougerv
- Facebook: @Bougervofficial
- Website: BougeRV
Portable Fridges | Solar Panels | Power Stations | ACs – BougeRV
