OMEGA FTB300 Series Flow Verification Sensor Tus neeg siv phau ntawv

Qhov ntsuas ntsuas no yog tsim los tso saib tus nqi ntws thiab ntws tag nrho ntawm rau tus lej LCD zaub. Lub 'meter' tuaj yeem ntsuas ob-directional ntws hauv qhov ntsug lossis kab rov tav mounting orientation. Muaj rau qhov dej ntws thiab plaub qhov kev xaiv cov yeeb nkab thiab cov yeeb nkab txuas. Pre-programmed calibration K-factors tuaj yeem raug xaiv rau qhov sib thooj ntawm cov dej ntws los yog cov kev cai hauv cheeb tsam calibration tuaj yeem ua rau qhov raug siab dua ntawm tus nqi ntws tshwj xeeb. Lub 'meter' yog lub Hoobkas programmed rau qhov tseeb K-qhov tseeb ntawm lub cev loj nrog lub ntsuas.

Nta

Plaub txoj kev sib txuas muaj: 1/8 "F / NPT, 1/4" F / NPT, 1/4" OD x .170 ID Tubing & 3/8 "OD x 1/4"
ID Tubing qhov ntau thiab tsawg.
Rau lub cev loj / ntws ntau yam kev xaiv muaj:
30-300 ml / min, 100-1000 ml / min, 200 txog 2000 ml / min,
300-3000 ml / min, 500-5000 ml / min, 700 txog 7000 ml / min.

3 qauv zaub variations:
FS = Sensor mounted zaub
FP = Vaj huam sib luag mounted zaub (suav nrog 6′ cable)
FV = No display. Sensor nkaus xwb. 5vdc tam sim no-sinking tso zis
6 tus lej LCD, mus txog 4 tus lej lej.
Qhia ob tus nqi ntawm kev ntws thiab tag nrho cov dej ntws.
Qhib collector tswb setpoint.
Cov neeg siv xaiv tau los yog kev cai programmable K-factor.
Flow units: Gallons, Litres, ounces, milliliters
Sijhawm units: feeb, teev, hnub

Volumetric teb calibration programming system.
Non-volatile programming thiab khaws cia txaus.
Tag nrho rov pib ua haujlwm tuaj yeem raug kaw.
Opaque PV DF chemical resistant lens.
Huab cua-resistant Valox PBT enclosure. NEMA 4 X

Specifications

Max. Ua haujlwm siab: 150 psig (10 bar) @ 70 ° F (21 ° C)
PVDF lens Max. Cov dej kub: 200 ° F (93 ° C) @ 0 PSI
Tag nrho qhov tseeb
Kev nkag siab lub zog: +/- 6%
Lub sensor tsuas tso zis cable: 3-xaim shielded cable, 6ft
Pulse tso zis teeb liab: Digital square yoj (2-hlau) 25ft max.
Voltage high = 5V de,
Voltage qis <.25V de
50% ua haujlwm lub voj voog
Cov zis ntau zaus: 4 txog 500Hz
Alarm tso zis signal:
NPN Qhib collector. Active qis saum toj no
lub programmable tus nqi teev point.
30V ntawm qhov siab tshaj plaws, 50mA max load.
Active qis <.25V de
2K ohm rub-up resistor xav tau.
Enclosure: NEMA hom 4X, (IP56)
Kwv yees shipping wt: 1 lb. (.45 kg)

Kub thiab siab txwv

Qhov kub siab tshaj plaws vs

Qhov ntev

Hloov qhov chaw

Kev teeb tsa

Kev Txuas Txuas Txuas

Nyob rau hauv lub sensor-mounted units, cov zis teeb liab xov hlau yuav tsum tau ntsia los ntawm lub vaj huam sib luag rov qab siv ib tug thib ob kua-tite connector (suav nrog). Txhawm rau nruab lub connector, tshem tawm lub voj voos tawm. Txiav ntug yog tias xav tau. Nruab qhov ntxiv kua-tite connector.
Nyob rau hauv vaj huam sib luag los yog phab ntsa-mounted units, thaiv tej zaum yuav raug ntsia los ntawm lub enclosure hauv qab los yog los ntawm lub vaj huam sib luag rov qab. Saib hauv qab no.

Kev sib txuas ntawm Circuit Board

CEEB TOOM: Txhawm rau rov pib dua lub rooj tsav xwm hauv Circuit Court: 1) Tshem tawm lub zog 2) Siv lub zog thaum nias ob lub khawm hauv ntej.

Flow Verification Output Signal

Thaum txuas nrog cov khoom siv sab nraud xws li PLC, cov ntaub ntawv logger, lossis lub ntsuas ntsuas lub twj tso kua mis, cov khoom siv hluav taws xob tuaj yeem siv los ua cov cim ntsuas dej ntws. Thaum siv cov twj ntsuas ntsuas, txuas qhov zoo (+) lub davhlau ya nyob twg ntawm lub rooj tsav xwm hauv Circuit Court rau lub twj tso kua mis lub teeb liab daj input hlau thiab qhov tsis zoo (-) davhlau ya nyob twg rau cov hlau nkag dub.

Vaj huam sib luag los yog phab ntsa mounting

Kev ua haujlwm

Txoj kev ua haujlwm

Lub flowmeter yog tsim los ntsuas tus nqi ntws thiab sau tag nrho cov ntim ntawm cov kua. Chav tsev muaj lub log paddle uas muaj rau (6) los ntawm lub qhov kom tso cai rau lub teeb infrared hla dhau, lub teeb pom kev hauv Circuit Court, thiab LCD-duab hluav taws xob Circuit Court.
Raws li cov kua dej dhau los ntawm lub 'meter' lub cev, lub paddlewheel tig. Txhua lub sij hawm lub log tig lub DC square nthwv dej tawm ntawm lub sensor. Muaj rau (6) tag nrho DC cycles induced rau txhua lub kiv puag ncig ntawm paddlewheel. Qhov zaus ntawm cov teeb liab no yog proportional rau qhov tshaj tawm ntawm cov kua hauv cov kav dej. Cov teeb liab generated ces xa mus rau hauv hluav taws xob Circuit Court kom ua tiav.

Lub 'meter' yog lub Hoobkas programmed rau qhov tseeb K-qhov tseeb ntawm lub cev loj nrog lub ntsuas.
Lub flowmeter muaj cov nram qab no nta:

Qhia txog tus nqi ntws los yog cov dej ntws tag nrho.
Muab lub teeb liab pulse tso zis uas yog proportional rau tus nqi ntws.

Muab ib qho qhib collector tswb tso zis teeb liab. Active qis ntawm tus nqi ntws siab tshaj tus neeg siv-programmed tus nqi.
Muab cov neeg siv xaiv tau, Hoobkas preset calibration k-factors.
Muab cov txheej txheem calibration rau kev ntsuas kom meej dua.
Pem hauv ntej vaj huam sib luag programming tuaj yeem cuam tshuam los ntawm Circuit Board jumper pin.

Tswj Vaj Huam Sib Luag

Enter Button (txoj cai xub)

Xovxwm thiab tso tawm – Toggle ntawm tus nqi, Tag Nrho, thiab Calibrate cov ntxaij vab tshaus hauv hom khiav. Xaiv cov ntxaij vab tshaus hauv qhov program hom.
Nias thiab tuav 2 vib nas this – Nkag mus thiab tawm txoj haujlwm hom. (Tsis siv neeg tawm qhov kev pab cuam hom tom qab 30 vib nas this tsis muaj inputs).
Clear/Cal (saib xub)

Nias thiab tso tawm - Tshem tag nrho hauv hom kev khiav. Scroll los ntawm thiab xaiv cov kev xaiv hauv hom kev pab cuam.

CEEB TOOM: Txhawm rau rov pib dua lub rooj tsav xwm hauv Circuit Court: 1) Tshem tawm lub zog 2) Siv lub zog thaum nias ob lub khawm hauv ntej.

Flow kwj xav tau

Lub flowmeter tuaj yeem ntsuas cov dej ntws hauv ob qho tib si.
Lub 'meter' yuav tsum tau mounted kom lub paddle qag nyob rau hauv ib tug kab rov tav txoj hauj lwm - mus txog 10 ° tawm ntawm kab rov tav yog tau.
Cov kua yuav tsum muaj peev xwm dhau lub teeb infrared.
Cov kua dej yuav tsum tsis muaj khib nyiab. Lub lim 150-micron tau pom zoo tshwj xeeb tshaj yog thaum siv lub cev me me (Sl), uas muaj 0.031 "los ntawm-qhov.

Khiav hom zaub

Khiav hom kev ua haujlwm

FLOW RATE DISPLAY - Qhia tus nqi ntws, S1 = lub cev loj / ntau #1, ML = units tso tawm hauv milliliters, MIN = lub sij hawm units hauv feeb, R = flow rate displayed.
FLOW TAG NRHO DISPLAY - Qhia tag nrho cov dej ntws, S1 = lub cev loj / ntau #1, ML = units tso tawm hauv milliliters, T = tag nrho cov dej ntws tso tawm.

Viewhauv K-factor (pulses per unit)

thaum nyob rau hauv txoj kev khiav, Nias thiab tuav ENTER ces nias thiab tuav CLEAR los tso saib K-factor.
Tso ENTER thiab CLEAR kom rov qab mus rau kev khiav haujlwm.

Lub Cev Loj	Kev khiav hauj lwm ntau (ml / min)	Pulses per Gallon	Pulses ib liter
1	30-300 : kuv	181,336	47,909
2	100-1000 : kuv	81,509	21,535
3	200-2000 : kuv	42,051	13,752
4	300-3000 : kuv	25,153	6,646
5	500-5000 : kuv	15,737	4,157
6	700-7000 : kuv	9,375	2,477

Cov qauv siv tau zoo

60 IK = tus nqi ntsuas ntsuas
tus nqi ntsuas qhov ntsuas x Hz = ntws tus nqi hauv ntim ib feeb
1 / K = total scale factor total scale factor xn pulses = tag nrho cov ntim

Programming

Lub flowmeter siv K-factor los xam tus nqi ntws thiab tag nrho. K-factor yog txhais raws li tus naj npawb ntawm pulses tsim los ntawm paddle ib ntim ntawm cov kua dej ntws. Txhua tus ntawm rau qhov sib txawv ntawm lub cev muaj qhov sib txawv ntawm kev khiav hauj lwm sib txawv thiab txawv K-factors. Lub 'meter' yog lub Hoobkas programmed rau qhov tseeb K-qhov tseeb ntawm lub cev loj nrog lub ntsuas.
Qhov ntsuas tus nqi thiab tag nrho cov lus qhia tuaj yeem tsim nws tus kheej los tso saib units hauv milliliters (ML), ounces (OZ), gallons (gal), lossis litres (LIT). Tus nqi thiab tag nrho tuaj yeem pom nyob rau hauv txawv units ntawm kev ntsuas. Lub Hoobkas programming yog nyob rau hauv milliliters (ML).
Lub ntsuas ntsuas tus nqi tuaj yeem tsim nws tus kheej los ua kom pom cov sijhawm teev sijhawm hauv feeb (Min), Teev (Hr), lossis Hnub (Hnub). Lub Hoobkas programming yog nyob rau hauv feeb (Min).
Rau qhov raug ntau dua ntawm tus nqi ntws tshwj xeeb, lub 'meter' tuaj yeem ua teb cali brated. Cov txheej txheem no yuav cia li hla lub Hoobkas K-factor nrog cov naj npawb ntawm cov pulses sau thaum lub sij hawm calibration txheej txheem. Lub Hoobkas pib teeb tsa tuaj yeem rov xaiv dua txhua lub sijhawm.

Teb Calibration

Txhua tus loj / ntau tuaj yeem ntsuas qhov ntsuas. Calibration yuav suav rau hauv koj daim ntawv thov tshwj xeeb cov kua dej, xws li viscosity thiab ntws tus nqi, thiab ua kom qhov tseeb ntawm qhov ntsuas hauv koj daim ntawv thov. Lub Cev Loj/Range yuav tsum tau teem caij rau "SO" kom pab tau hom calibration. Ua raws li cov lus qhia hauv kev ua haujlwm ntawm nplooj ntawv 10 & 11 kom rov pib dua Lub Cev Loj / Ntau thiab ua cov txheej txheem calibration.

Programming rau lub cev loj / ntau txawm tias S6 -

Nias thiab tuav ENTER los pib lub programming hom.

Teb calibration loj/ntau qhov chaw SO

- Kev txuas ntxiv ntawm cov programming ua ntu zus thaum ntau yam "SO" raug xaiv.
Lub 'meter' yuav tsum tau muab ntsia raws li npaj rau hauv daim ntawv thov.
Tus nqi ntawm cov kua uas ntws los ntawm lub 'meter' thaum lub sij hawm calibration txheej txheem yuav tsum tau ntsuas nyob rau hauv lub kawg ntawm cov txheej txheem calibration.
Cia lub ntsuas ntsuas ua haujlwm ib txwm, hauv daim ntawv thov npaj, rau lub sijhawm. Lub sijhawm sim tsawg kawg yog ib feeb yog pom zoo. Nco tseg - qhov siab tshaj plaws ntawm cov pulses tau yog 52,000. Pulses yuav sau nyob rau hauv cov zaub. Tom qab lub sij hawm xeem, Nres qhov ntws los ntawm lub 'meter'. Lub ntsuas pulse yuav nres.
Txiav txim siab tus nqi ntawm cov kua uas dhau los ntawm lub 'meter' siv lub tog raj kheej kawm tiav, ntsuas, lossis lwm txoj kev. Tus nqi ntsuas yuav tsum tau nkag mus rau hauv qhov ntsuas ntsuas #4 "MEASURED VALUE INPUT."
Nco tseg:

WARRANTY/DISCLAIMER

OMEGA ENGINEERING, INC. lav lub tsev no kom tsis muaj qhov tsis xws luag hauv cov ntaub ntawv thiab kev ua haujlwm rau lub sijhawm 13 lub hlis txij li hnub ntawm kev yuav khoom. OMEGA's WARRANTY ntxiv ib qho ntxiv (1) lub hlis kev tshav ntuj rau qhov ib txwm muaj (1) xyoo cov khoom lag luam lav kom them rau kev tuav thiab sijhawm xa khoom. Qhov no ua kom ntseeg tau tias OMEGA cov neeg siv khoom tau txais kev pabcuam siab tshaj plaws ntawm txhua yam khoom.
Yog hais tias chav tsev malfunctions, nws yuav tsum tau xa rov qab mus rau lub Hoobkas rau kev ntsuam xyuas. OMEGA Lub Chaw Pabcuam Cov Neeg Siv Khoom yuav muab tus lej Tso Cai Rov Qab (AR) tam sim ntawd thaum xov tooj lossis sau ntawv thov. Thaum kuaj xyuas los ntawm OMEGA, yog tias lub tsev tau pom tias muaj qhov tsis zoo, nws yuav raug kho lossis hloov pauv yam tsis tau them nqi. OMEGA's WARRANTY tsis siv rau cov teeb meem uas tshwm sim los ntawm ib qho kev txiav txim ntawm tus neeg yuav khoom, suav nrog tab sis tsis txwv rau kev siv tsis raug, kev cuam tshuam tsis raug, kev ua haujlwm sab nraud ntawm kev txwv tsim, kho tsis raug, lossis kev hloov pauv tsis raug cai. Qhov kev lav phib xaub no yog VOID yog tias lub tsev qhia pom tias muaj pov thawj ntawm tampered nrog los yog qhia cov pov thawj ntawm kev puas tsuaj los ntawm kev xeb ntau dhau; los yog tam sim no, cua sov, noo noo, los yog kev co; tsis tsim nyog specification; kev siv tsis raug; siv tsis raug, lossis lwm yam kev ua haujlwm sab nraud ntawm OMEGA kev tswj hwm. Cheebtsam uas hnav tsis tau lees paub, suav nrog tab sis tsis txwv rau cov ntsiab lus tiv tauj, fuses, thiab triacs.
OMEGA txaus siab los muab cov lus qhia txog kev siv nws ntau yam khoom. Txawm li cas los xij, OMEGA tsis lees paub lub luag haujlwm rau ib qho kev tsis lees paub lossis kev ua yuam kev lossis tsis lees paub txog kev puas tsuaj uas tshwm sim los ntawm kev siv nws cov khoom raws li cov ntaub ntawv muab los ntawm OMEGA, hais lus lossis sau ntawv. OMEGA lav tsuas yog tias cov khoom tsim los ntawm lub tuam txhab yuav ua raws li tau teev tseg thiab tsis muaj qhov tsis xws luag. OMEGA TSIS TXAUS SIAB RAU LUB TSEV KAWM NTAWV UAS YUAV TSUM TAU TXAIS KEV PAB CUAM THIAB KEV PAB CUAM THIAB KEV PAB CUAM THIAB KEV PAB CUAM TSHUAJ TIV THAIV THIAB KEV PAB CUAM TSHUAJ TIV THAIV THIAB TSEEM CEEB LIMITATION OF LIABILITY: Cov kev kho mob ntawm tus neeg yuav khoom tau teev tseg hauv no tshwj xeeb, thiab tag nrho kev lav phib xaub ntawm OMEGA hais txog qhov kev txiav txim no, txawm tias raws li daim ntawv cog lus, lav, tsis saib xyuas, kev them nyiaj, kev lav ris nruj, lossis lwm yam, yuav tsum tsis pub tshaj tus nqi yuav khoom ntawm cov khoom raws li kev lav phib xaub. Nyob rau hauv tsis muaj qhov xwm txheej yuav tsum OMEGA yuav tsum lav rau qhov tshwm sim, xwm txheej, lossis kev puas tsuaj tshwj xeeb.
TSEEM CEEB: Cov khoom siv uas muag los ntawm OMEGA tsis yog npaj los siv, thiab yuav tsum tsis txhob siv: (1) raws li "Basic Component" nyob rau hauv 10 CFR 21 (NRC), siv nyob rau hauv lossis nrog ib qho kev teeb tsa nuclear lossis kev ua haujlwm; los yog (2) hauv kev kho mob los yog siv rau tib neeg. Yog tias ib qho khoom siv tau siv los yog nrog kev teeb tsa nuclear lossis kev ua ub no, daim ntawv thov kev kho mob, siv rau tib neeg, lossis siv tsis raug, OMEGA tsis muaj lub luag haujlwm raws li tau teev tseg hauv peb cov lus WARANTY / DISCLAIMER, thiab, ntxiv rau, tus neeg yuav khoom yuav them nyiaj rau OMEGA thiab tuav OMEGA yam tsis muaj kev lav phib xaub lossis kev puas tsuaj txhua yam tshwm sim los ntawm kev siv cov khoom zoo li no.

NYEEM NTXIV / NQA

Qhia txhua qhov kev lees paub thiab kho cov lus thov / nug rau OMEGA Lub Chaw Pabcuam Cov Neeg Siv Khoom. Ua ntej xa txhua yam khoom (S) rau OMEGA, tus neeg yuav khoom yuav tsum tau txais daim ntawv tso cai rov qab (AR) tus lej los ntawm OMEGA'S CUSTOMER SERVICE DEPARTMENT (Yuav kom zam dhau qhov kev ua haujlwm qeeb). Tom qab ntawd tus lej AR uas tau muab rau yuav tsum raug cim rau sab nraud ntawm pob khoom xa rov qab thiab ntawm ib qho kev sau ntawv.
Tus neeg yuav khoom yog lub luag haujlwm rau cov nqi thauj khoom, thauj khoom, kev tuav pov hwm, thiab ntim khoom kom zoo los tiv thaiv kev tawg hauv kev thauj mus los.
YUAV UA LI CAS YUAV TSUM TAU TXAIS, thov kom muaj cov ntaub ntawv hauv qab no ua ntej hu rau OMEGA:

Kev yuav khoom tus lej raws li qhov khoom tau yuav,
Qauv thiab serial tooj ntawm cov khoom nyob rau hauv warranty, thiab
Kho cov lus qhia thiab / lossis cov teeb meem tshwj xeeb ntsig txog cov khoom.

Rau kev kho tsis yog-WARRANTY, sab laj OMEGA rau cov nqi kho tam sim no. Muaj cov ntaub ntawv hauv qab no ua ntej hu rau OMEGA:

Kev yuav khoom tus lej los them tus nqi ntawm kev kho,
Qauv thiab tus naj npawb ntawm cov khoom, thiab
Kho cov lus qhia thiab / lossis cov teeb meem tshwj xeeb ntsig txog cov khoom.

OMEGA txoj cai yog ua kom muaj kev hloov pauv, tsis yog hloov qauv, thaum twg muaj kev txhim kho. Qhov no ua rau peb cov neeg siv khoom tshiab tshaj plaws hauv tshuab thiab engineering.
OMEGA yog lub npe lag luam ntawm OMEGA ENGINEERING, INC.
© Copyright 2016 OMEGA ENGINEERING, INC. All rights reserved. Cov ntaub ntawv no yuav tsis raug theej, theej, luam tawm, rov ua dua, txhais, lossis txo qis rau ib qho khoom siv hluav taws xob lossis lub tshuab nyeem tau, tag nrho lossis ib feem, yam tsis muaj ntawv tso cai ua ntej ntawm OMEGA ENGINEERING, INC.

Kuv Yuav Nrhiav Txhua Yam Kuv Xav Tau rau Kev Ntsuas thiab Tswj Xyuas Qhov Twg?
OMEGA… Tau kawg!
Khw hauv online ntawm omega.com sm

KUB
Thermocouple, RTD & Thermistor Probes, Connectors, Vaj Huam Sib Luag & Sib dhos
Hlau: Thermocouple, RTD & Thermistor
Calibrators & Ice Point References
Recorders, Controllers & Process Monitors
Infrared Pyrometers

NTXIV, STRAIN, THIAB FORCE
Transducers & Strain Gages
Load Cells & Pressure Gages
Transducers Instrumentation & Accessories

FLOW/LEVEL
Rotameters, Gas Mass Flowmeters & Kab Computers
Cua Velocity Indicators
Turbine / Paddlewheel Systems
Totalizers & Batch Controllers

pH/kev ua haujlwm
pH electrodes, Testers & Accessories
Benchtop / Laboratory Meters
Controllers, Calibrators, Simulators & Pumps
Industrial pH & Conductivity Equipment

DAIM NTAWV QHIA
Communications-Based Acquisition Systems
Data Logging Systems
Wireless Sensors, Transmitters, & Receivers
Teeb Liab Tshuab
Data Acquisition Software

TSO CUA SOV
Cua sov Cable
Cartridge & Sawb Heaters
Immersion & Band Heaters
Hloov cov cua sov
Laboratory Heaters

ENVIRONMENTAL MONITORING THIAB CONTROL
Metering & Control Instrumentation
Refractometers
Pumps & Tubing
Cua, Av & Dej Saib Xyuas
Industrial Dej & Kev Kho Dej Wastewater
pH, Conductivity & Dissolved Oxygen Instruments

Yuav khoom online ntawm
omega. COV
e-mail: yog info@omega.com
Rau cov khoom siv tshiab tshiab:
www.omegamanual.info

ua otnega.com yog info@omega.com
Kev Pabcuam North America:
Teb Chaws Asmeskas Headquarters:
Omega Engineering, Inc.
Tus xov tooj hu dawb: 1-800-826-6342 Ib (Tebchaws USA & Canada xwb)
Kev Pabcuam Cov Neeg Siv Khoom: 1-800-622-2378 Ib (Tebchaws USA & Canada xwb)
Engineering Service: 1-800-872-9436 Ib (Tebchaws USA & Canada xwb)
Tel: 203-359-1660 Ib
Fax: 203-359-7700 Ib
e-mail: yog info@omega.com
Rau Lwm Qhov Chaw Mus Saib omega.com/worldwide

Cov ntaub ntawv / Cov ntaub ntawv

OMEGA FTB300 Series Flow Verification Sensor [ua pdf] Cov neeg siv phau ntawv qhia
FTB300, Series Flow Verification Sensor

Cov ntaub ntawv

Cov neeg siv phau ntawv

Taw qhia

Nta