1. Important Safety Information
Read all instructions before using this appliance. Follow all safety precautions to reduce the risk of fire, electric shock, or injury.
- Electrical Safety: Ensure the freezer is connected to a properly grounded 110-volt, 60 Hz electrical outlet. Do not use extension cords or adapter plugs.
- Ventilation: Maintain adequate clearance around the freezer for proper air circulation and cooling efficiency.
- Flammable Materials: Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
- Child Safety: Supervise children to ensure they do not play with the appliance. Old freezers can be dangerous if children get trapped inside. Remove the door or take other precautions before disposing of an old unit.
- Handling: Use caution when moving the freezer to avoid damage to the refrigeration system.
WARNING: This product can expose you to chemicals including Di(2-ethylhexyl)phthalate (DEHP), which is known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov.
2. Setup and Installation
2.1 Unpacking
Remove all packaging materials, including foam and adhesive tape. Inspect the freezer for any shipping damage. Report any damage to the retailer immediately.
2.2 Location Requirements
- Place the freezer on a strong, level floor capable of supporting its weight when fully loaded.
- Ensure at least 5 inches (12.7 cm) of space between the back and sides of the freezer and any adjacent walls for proper ventilation.
- Avoid direct sunlight or heat sources (e.g., stove, heater) that could increase energy consumption.
- The ambient temperature should be between 50°F (10°C) and 110°F (43°C).
2.3 Electrical Connection
Plug the freezer into a dedicated 110-volt, 60 Hz, 15-amp grounded electrical outlet. Do not use a two-prong adapter or an extension cord. If the power cord is damaged, it must be replaced by a qualified service technician.
2.4 Door Reversal
This freezer features a reversible door. Instructions for reversing the door swing are provided in a separate diagram or can be found on the manufacturer's website. This process typically involves removing the top hinge, transferring the door, and reattaching the hinges to the opposite side.
2.5 Initial Cleaning
Before first use, clean the interior and exterior of the freezer with a mild detergent and warm water. Rinse thoroughly and dry with a soft cloth.
Figure 1: Front view of the Danby DUF167A3WDD Upright Freezer, showing its white finish and handle.
3. Operating Instructions
3.1 Temperature Control
The temperature control dial is located inside the freezer compartment. Turn the dial to adjust the temperature. A setting of '4' or '5' is generally recommended for optimal freezing. Allow the freezer to operate for several hours before placing food inside to ensure it reaches the desired temperature.
3.2 Loading the Freezer
Do not overload the freezer. Allow space between items for cold air to circulate. Avoid placing hot food directly into the freezer; allow it to cool to room temperature first. The freezer is equipped with multiple shelves and door bins for organized storage.
Figure 2: Interior view of the Danby DUF167A3WDD Upright Freezer, showing the empty shelves and door storage.
Figure 3: Interior view of the Danby DUF167A3WDD Upright Freezer, demonstrating how various frozen food items can be organized on the shelves and in the door bins.
3.3 Automatic Defrost
This freezer features an automatic defrost system, which eliminates the need for manual defrosting. Frost buildup on the interior walls is normal and will be periodically melted and drained. Ensure the drain pan (if accessible) is clear of obstructions.
3.4 Power Failure
In the event of a power failure, keep the freezer door closed to maintain the internal temperature for as long as possible. Most frozen foods will remain frozen for 24-48 hours if the door is not opened. Discard any food that has thawed completely.
4. Maintenance
4.1 Cleaning
- Interior: Unplug the freezer before cleaning. Wash the interior surfaces, shelves, and door bins with a solution of two tablespoons of baking soda to one quart of warm water. Rinse and dry thoroughly.
- Exterior: Clean the exterior with a mild detergent and warm water. Wipe dry with a soft cloth.
- Door Gasket: Clean the door gasket regularly to ensure a proper seal. Use a soft cloth and mild soap.
4.2 Power Cord Inspection
Periodically inspect the power cord for any signs of damage. If the cord is damaged, discontinue use and contact a qualified service technician for replacement.
4.3 Long-Term Storage
If the freezer will not be used for an extended period, unplug it, empty all contents, clean the interior thoroughly, and leave the door ajar to prevent odors and mold growth.
Figure 4: Close-up view of the door shelves in the Danby DUF167A3WDD Upright Freezer, highlighting their design for storing smaller frozen items.
5. Troubleshooting
Before contacting service, review the following common issues and solutions:
| Problem | Possible Cause | Solution |
|---|---|---|
| Freezer does not operate | No power to the unit; circuit breaker tripped; power cord unplugged. | Check power supply, circuit breaker, and ensure cord is securely plugged in. |
| Freezer not cold enough | Temperature control set too warm; door opened too frequently; excessive food load; poor ventilation. | Adjust temperature setting; minimize door openings; allow space for air circulation; ensure proper clearance around unit. |
| Excessive noise | Freezer not level; items vibrating inside; fan obstruction. | Level the freezer using adjustable feet; rearrange items; check for obstructions near the fan. |
| Door does not close properly | Door gasket dirty or damaged; freezer not level; items obstructing door. | Clean or replace gasket; level the freezer; remove obstructions. |
| Water on floor | Drain pan overflowing or dislodged; drain tube clogged. | Check and reposition drain pan; clear any clogs in the drain tube. |
6. Specifications
| Feature | Detail |
|---|---|
| Brand | Danby |
| Model Name | DUF167A3WDD |
| Capacity | 16.7 Cu.Ft. |
| Color | White |
| Product Dimensions (D x W x H) | 28.4 x 29.95 x 67.3 inches (approx.) |
| Installation Type | Freestanding |
| Voltage | 110 Volts |
| Defrost Type | Automatic |
| Door Hinges | Reversible |
| Shelves | 6 |
| Certification | Energy Certified |
7. Warranty and Support
This Danby appliance is covered by a limited warranty. For specific warranty terms, registration, or technical support, please refer to the warranty card included with your product or visit the official Danby website. Keep your proof of purchase for warranty claims.
For further assistance, please contact Danby Customer Service:
- Website: www.danby.com
- Phone: Refer to your product documentation for regional support numbers.
