1. Introduction
This manual provides essential instructions for the safe and effective use of your Stack-On PDS-1800-E Small Drawer Safe. Please read all instructions carefully before operating the safe. Keep this manual for future reference.
2. Safety Information
- Do not store backup keys inside the safe. Always keep backup keys in a secure location away from the safe.
- Ensure the safe is mounted securely to prevent unauthorized removal.
- Keep the electronic keypad dry and clean.
- This safe is designed for security against theft, not fire or water damage, as it is not fire or water resistant.
3. Package Contents
- Stack-On PDS-1800-E Small Drawer Safe
- Backup keys (2)
- Mounting hardware (screws)
- Instruction Manual
4. Setup
4.1. Battery Installation
The electronic lock requires batteries for operation. Locate the battery compartment, typically on the inside of the safe door. Insert the required number of AA batteries, ensuring correct polarity. Close the compartment cover securely.
Image: Front view of the safe, showing the electronic keypad and the manual lock. This is where you will interact with the safe for daily use.
4.2. Initial Code Setting
- With the safe door open, press the red reset button located on the inside of the door. The yellow light on the keypad will illuminate.
- Enter a new 3-8 digit code on the keypad.
- Press the 'A' or '#' button to confirm. The yellow light will turn off, and a green light will flash, indicating the code has been set.
- Test the new code with the door open before closing it.
Image: A detailed view of the electronic keypad, highlighting the numbered buttons and the 'A' (or checkmark) and 'B' (or speaker) buttons used for operation and setting codes.
4.3. Mounting the Safe
The safe features pre-drilled holes for secure mounting. Use the included hardware to fasten the safe to a stable surface, such as inside a drawer, cabinet, or to a desk. Ensure the mounting location is flat and provides adequate support.
Image: The safe positioned inside a drawer, illustrating how it can be discreetly stored and mounted within furniture.
5. Operating Instructions
5.1. Opening with Electronic Lock
- Enter your 3-8 digit personal code.
- Press the 'A' or '#' button. The green light will illuminate.
- Within 5 seconds, turn the knob clockwise to open the safe door.
Image: The safe opened, showing its interior with a soft, foam-padded lining and various items stored inside.
5.2. Opening with Backup Key
In case of forgotten code or battery failure, the safe can be opened using the backup key.
- Remove the cover plate over the manual lock cylinder, usually located in the center of the knob.
- Insert the backup key into the lock cylinder.
- Turn the key clockwise while simultaneously turning the knob clockwise to open the safe.
- Remove the key once the safe is open.
5.3. Changing Your Code
To change your personal code, follow the same steps as '4.2. Initial Code Setting' while the safe door is open.
Image: A close-up of the safe's locking mechanism, showing the two steel live-action bolts that secure the door when closed.
6. Maintenance
6.1. Battery Replacement
When the batteries are low, the red light on the keypad will flash, or the safe may not respond to code entry. Replace all batteries with new AA alkaline batteries. Do not mix old and new batteries.
6.2. Cleaning
Clean the exterior of the safe with a soft, damp cloth. Avoid using abrasive cleaners or solvents that could damage the finish or electronic components.
7. Troubleshooting
| Problem | Possible Cause | Solution |
|---|---|---|
| Safe does not open with code. | Incorrect code entered; low batteries. | Re-enter code carefully; replace batteries; use backup key. |
| Keypad does not respond. | Dead batteries. | Replace batteries. |
| Door will not close properly. | Obstruction in door frame; locking bolts extended. | Clear any obstructions; ensure bolts are retracted before closing. |
8. Specifications
- Model Number: PDS-1800-E
- Brand: Stack-On
- Lock Type: Electronic Combination Lock with Backup Key
- Material: Alloy Steel
- Color: Black
- Product Dimensions (D x W x H): 30" x 8" x 6"
- Item Weight: 17 Pounds
- Special Features: Anti-Theft, Concealed Hinges, Two Steel Live-Action Bolts, Foam-Padded Interior
- Mounting Type: Tabletop / Freestanding (Mounting hardware included)
- Water Resistance Level: Not Water Resistant
9. Warranty and Support
For warranty information or technical support, please refer to the manufacturer's official website or contact their customer service department. Keep your purchase receipt as proof of purchase.