Introduction
This manual provides comprehensive instructions for the installation, operation, maintenance, and troubleshooting of your Moen 22174 Stainless Steel Sink Basket Strainer with Drain Assembly. Please read this manual thoroughly before installation and use to ensure proper function and longevity of your product.
Product Overview
The Moen 22174 Sink Basket Strainer with Drain Assembly is designed for stainless steel sinks, offering both drainage and debris collection. Its stainless steel finish complements modern kitchen aesthetics.
- Drain and basket strainer for stainless steel sinks.
- Designed to fit sinks with a standard 2-inch outlet.
- Stainless steel finish for aesthetic coordination.
- Includes a locking nut for secure installation.
- Backed by Moen's Limited Lifetime Warranty.
Figure 1: Moen 22174 Sink Basket Strainer with Drain Assembly, top view.
Setup and Installation
Installation of the Moen 22174 Sink Basket Strainer is generally straightforward. Basic plumbing knowledge and tools are recommended. Ensure the sink opening is a standard 2-inch size.
- Prepare the Sink Opening: Clean the sink drain opening thoroughly, removing any old caulk or debris.
- Apply Plumber's Putty: Roll a thin rope of plumber's putty and apply it around the underside of the strainer's top flange.
- Position the Strainer: Insert the strainer body into the sink opening from above, pressing firmly to create a seal with the putty.
- Install Gasket and Locking Nut: From underneath the sink, slide the rubber gasket onto the strainer body, followed by the locking nut.
- Tighten the Locking Nut: Hand-tighten the locking nut, then use a wrench or pliers to tighten it further until secure. Avoid overtightening.
- Connect to Drain Piping: Attach your existing or new drain piping to the bottom of the strainer assembly. Ensure all connections are tight to prevent leaks.
- Test for Leaks: Fill the sink with water and check for any leaks around the strainer and drain connections. Tighten as necessary.
Figure 2: Underside view of the drain assembly, showing the locking nut and gasket area.
Operation
The Moen 22174 Sink Basket Strainer functions as both a drain and a debris collector. The removable basket allows for easy collection and disposal of food particles and other waste, preventing clogs in your plumbing system.
- Drainage: When the basket is in place, water flows through the perforated bottom and sides, allowing the sink to drain.
- Debris Collection: The basket effectively catches food scraps and other solid waste, preventing them from entering the drain pipe.
- Stopping Water: The basket can be pressed down to create a seal, temporarily stopping water from draining, useful for filling the sink.
Maintenance
Regular cleaning and maintenance will ensure your sink basket strainer remains functional and aesthetically pleasing.
- Daily Cleaning: Remove the basket strainer regularly to empty collected debris. Rinse the basket and the drain opening with warm water.
- Deep Cleaning: For stubborn stains or buildup, use a mild dish soap and a soft brush or sponge. Avoid abrasive cleaners or scouring pads, as these can scratch the stainless steel finish.
- Preventing Mineral Buildup: In areas with hard water, occasional cleaning with a vinegar solution can help prevent mineral deposits.
- Inspection: Periodically check the rubber gasket for signs of wear or damage. Replace if necessary to maintain a watertight seal.
Troubleshooting
| Problem | Possible Cause | Solution |
|---|---|---|
| Water leaks around the strainer. | Loose locking nut, improperly seated gasket, or insufficient plumber's putty. | Tighten the locking nut. Ensure the rubber gasket is correctly positioned. If leaks persist, remove the strainer, reapply plumber's putty, and reinstall. |
| Slow drainage. | Basket strainer is clogged with debris, or the drain pipe is partially blocked. | Remove and clean the basket strainer. If the issue persists, inspect and clear the drain pipe. |
| Strainer basket does not seal properly to hold water. | Debris under the basket rim or a worn-out rubber seal on the basket. | Clean the area under the basket rim. If the seal is damaged, the basket may need replacement. |
Specifications
- Model Number: 22174
- Brand: Moen
- Material: Stainless Steel
- Product Dimensions: 2"W x 2"H (referring to the outlet size)
- Item Weight: 5.1 ounces
- UPC: 026508038314
- Special Feature: Removable Basket
- Included Components: Drain Assembly, Strainer Basket
Warranty Information
The Moen 22174 Stainless Steel Sink Basket Strainer with Drain Assembly is backed by Moen's Limited Lifetime Warranty. For specific terms and conditions, please refer to the official Moen warranty documentation or visit the Moen website.
Support
For further assistance, technical support, or to order replacement parts, please contact Moen Customer Service or visit their official website:
- Website: www.moen.com
- Customer Service: Refer to the Moen website for current contact information (phone numbers, email).
