1. Производ је готовview
The Rittal 3383500 Top Therm Roof Mounted Air Conditioner is designed for efficient cooling of industrial enclosures. Featuring a comfort controller, this unit provides reliable temperature management for sensitive equipment. It is built for durability and ease of installation, offering a robust solution for thermal management.
Кључне карактеристике:
- Fully wired ready for connection, including drilling templates and assembly hardware.
- Equipped with a nano-coated condenser coil and integrated condensate evaporator.
- Operates on 230 Volt power supply with 50/60 Hertz operating frequency.
- Compact dimensions: 23-1/2" width x 16-21/64" height x 18-11/16" depth.
- Ratings: IP 54, NEMA 12.
- Cooling Capacity: 3688 BTU at 60Hz.
Слика 1: Предња страна view of the Rittal 3383500 Top Therm Roof Mounted Air Conditioner, showcasing its light grey finish and front grille.
2. Подешавање и инсталација
Before beginning installation, ensure the power supply is disconnected. This unit is designed for roof mounting on industrial enclosures.
2.1 Провере пре инсталације:
- Verify the enclosure roof can support the unit's weight (approximately 92.5 lbs).
- Confirm power supply matches unit requirements (230V, 50/60Hz).
- Ensure adequate clearance around the unit for proper airflow and maintenance.
2.2 Упутства за монтажу:
- Use the provided drilling templates to mark and cut the necessary openings on the enclosure roof.
- Carefully position the air conditioner unit over the openings.
- Secure the unit using the supplied assembly hardware. Ensure all fasteners are tightened to prevent vibration and maintain the IP/NEMA rating.
2.3 Електрично повезивање:
- The unit is fully wired ready for connection. Connect the power supply to the plug-in terminal strip.
- Ensure proper grounding according to local electrical codes.
- Recommended pre-fuse: T 10.0 A.
Figure 2: Dimensional drawing of the Rittal 3383500 unit, showing its width (23.5"), height (16.33"), and depth (18.69").
3. Упутство за употребу
The Rittal 3383500 features a comfort controller for easy temperature management.
3.1 Initial Power-Up:
- After installation and electrical connection, restore power to the unit.
- The comfort controller display will illuminate.
3.2 Подешавање температуре:
- The factory setting for the comfort controller is 95°F (35°C).
- The temperature setting range is 68°F to 131°F (20°C to 55°C).
- Refer to the comfort controller's specific manual (if provided separately) for detailed instructions on adjusting the setpoint. Generally, buttons on the controller allow for increasinг или декретasing the desired temperature.
3.3 Operation Modes:
The unit operates automatically to maintain the set temperature within the enclosure. It will cycle on and off as needed to achieve optimal cooling.
4. Одржавање
Regular maintenance ensures optimal performance and extends the lifespan of your Rittal air conditioner. Always disconnect power before performing any maintenance.
4.1 Filter Cleaning/Replacement:
- Inspect air filters regularly (e.g., monthly or quarterly, depending on environment).
- Clean filters using compressed air or mild detergent and water. Ensure they are completely dry before reinstallation.
- Replace filters if they are damaged or cannot be adequately cleaned.
4.2 Condenser Coil Cleaning:
- The unit features a nano-coated condenser coil, which helps reduce dirt buildup. However, periodic inspection and cleaning are still recommended.
- Gently clean the condenser coil fins with a soft brush or vacuum cleaner to remove dust and debris. Avoid bending the fins.
4.3 Condensate Evaporator:
- The integrated condensate evaporator manages condensation. Periodically check for any blockages or excessive water accumulation.
4.4 Општи преглед:
- Check all electrical connections for tightness and signs of wear.
- Inspect the unit for any physical damage or corrosion.
- Ensure proper sealing between the unit and the enclosure to maintain environmental ratings.
КСНУМКС. Решавање проблема
This section provides solutions to common issues. For problems not listed here, contact Rittal customer support.
| Проблем | Могући узрок | Решење |
|---|---|---|
| Јединица се не укључује. | No power supply; Blown fuse/circuit breaker; Loose electrical connection. | Check power source; Inspect and replace fuse/reset breaker; Verify all connections are secure. |
| Unit runs but does not cool effectively. | Dirty air filters; Blocked condenser coil; Incorrect temperature setting; Refrigerant leak (less common). | Clean or replace air filters; Clean condenser coil; Adjust temperature setting; Contact qualified technician for refrigerant issues. |
| Необична бука током рада. | Loose components; Fan obstruction; Motor issue. | Inspect for loose parts and tighten; Clear any obstructions from fans; If noise persists, contact support. |
| Вода цури из јединице. | Blocked condensate drain/evaporator. | Inspect and clear any blockages in the condensate system. |
6. Спецификације
| Параметар | Валуе |
|---|---|
| Број модела | 3383500 |
| Бранд | Риттал |
| Димензије (Ш к В к Д) | 23-1/2" x 16-21/64" x 18-11/16" (59.7 cm x 41.5 cm x 47.5 cm) |
| Тежина | 92.5 фунти (42 кг) |
| Волtage | 230 В |
| Фреквенција | 50/60 Хз |
| Називна струја | 4.3 A (50Hz) / 4.5 A (60Hz) |
| Стартинг Цуррент | 15.5 А |
| Пре-осигурач | Т 10.0 А |
| Cooling Capacity (L35 L35) | 1000 W (3415 BTU) / 1080 W (3688 BTU) |
| Power Consumption (L35 L35) | 550 W (50Hz) / 650 W (60Hz) |
| Расхладно средство | Р134а, 17.6 оз |
| Температурни опсег | 68°Ф до 131°Ф (20°Ц до 55°Ц) |
| Protection Rating (External) | IP 34 (NEMA 2) |
| Protection Rating (Internal) | IP 54 (NEMA 12) |
| Air Displacement (External) | 1036 цфм |
| Air Displacement (Internal) | 259 цфм |
7. Гаранција и подршка
For specific warranty information regarding your Rittal 3383500 air conditioner, please refer to the documentation provided with your purchase or contact Rittal directly. Rittal products typically come with a manufacturer's warranty covering defects in materials and workmanship.
Корисничка подршка:
If you require technical assistance, have questions about operation, or need to arrange service, please contact Rittal customer support. You can often find contact information on the Rittal official website or through your product distributor.
За општа питања, можете посетити Rittal Store on Amazon.
