B-Tech BT8546 XL Interactive Touchscreen Trolley
Installation Guide
- Recommended for screens from 65″ – 110″
- Max screen weight: 125kg (27Slbs)
- Designed for displays with VESA® fixings up to 1000 x 800mm
- Max shelf load: Skg (l2Ibs)
- Non-marking braked castors included
- Integrated cable management
- Trolley dimensions: H.l778mm W.l24Smm 0.772mm, (H.70″ W.49″ D.30.4″)
Safety Instructions
Caution
This mount is intended for use only with the maximum weights indicated. Use with equipment heavier than the maximum indicated may result in instability causing possible injury.
Do not attempt to install this product until all instructions and warnings have been read and properly understood. Please keep these instructions for future reference.
Please check carefully to make sure there are no missing or defective parts – defective parts must never be used. B-Tech AV Mounts, its distributors and dealers are not liable or responsible for damage or injury caused by improper installation, improper use or failure to observe these safety instructions. In such cases, all guarantees will expire.
General
B-Tech AV Mounts recommends that a professional AV installer or other suitably qualified person install this product. Great care must always be taken during installation as most AV equipment is of a fragile nature, possibly heavy and easily damaged if dropped. If you do not fully understand the instructions or are not sure how to install this product safely, then please consult a professional for advice and/or to install this product for you. Failure to mount this product correctly may cause serious injury or death both during installation and at any time thereafter. Do not mount any AV equipment that exceeds the specific weight limit of the product you are installing. This weight limit will be clearly stated on each product and its packaging and will vary from product to product.
Trolley Operation
Warning: The trolley can tip over which may lead to serious injury. Only adults should push this trolley, do not allow children under 76 to move the trolley. Push the trolley on the narrow side, never pull the trolley. Do not push at the top of the trolley, push near the middle. Move the trolley slowly. Always park on level ground, never leave the trolley on an incline. Apply the brakes when the trolley is stationary, release the brakes when pushing the trolley
Product location
Please pay careful attention to where this product is located, some locations are not suitable for installation. For indoor use only. Install stand on level ground. When verifying the stability of the structure, consider the following external factors: The strength of the floor, exposure to sudden and severe wind and danger arising from contact with people and/ or objects (eg installations in passageways, emergency exits), if located in a public or frequently populated area ensurethat the product is out of the immediate reach of people.
Fixing hardware
It is highly recommended that all fixing screws be used where supplied and that the purpose of all other fixing hardware is fully understood. In some cases more AV equipment fixing hardware will be supplied to accommodate different models of equipment and set up configurations. The installer must be satisfied that any supplied fixing hardware is suitable for each specific installation. The fixing kit supplied with the product may not be suitable for all walls. If any fixing screws or included hardware are deemed not sufficient for a safe installation then please consult a professional or your local hardware store.
Hazard limitation
When routing cables take advantage of any built in cable management features that the product might provide and ensure that all cables are tidy and secure. Check to see that any moving aspect of the product can do so unhindered by any cabling. Some products have moving parts and the potential to cause injury through the crushing or trapping of fingers or other body parts. Particular attention to the nature of moving parts is required especially when assembling installing and adjusting during set up. Immediately after installation double-check that the work done is safe and secure. Double-check all necessary fixings are present and are of ample tightness. It is recommended that periodic inspections of the product and its fixing points are made as frequently as possible (no more than 6 months apart) to ensure that safety is maintained. If in doubt consult a professional AV installer or other suitably qualified person.
B-Tech AV Mounts recommends that this product be installed by a qualified AV technician or other suitably qualified person. B-Tech AV Mounts, its distributors and dealers are not liable or responsible for damage or injury caused by improper installation, improper use or failure to observe these safety instructions. In such cases, all guarantees will expire. This product must be mounted on a suitable surface and may only be used up to the specified maximum weight.
Parts List
| Item | Description | Qty |
| 1 | Right Leg | 1 |
| 2 | Left Leg | 1 |
| 3 | Horizontal Support | 3 |
| 4 | Interface Arm | 2 |
| s | Shelf | 1 |
| 6 | MS x 70mm Screw | 13 |
| 7 | MS Washer | 13 |
| s | MS Spring Washer | 9 |
| 9 | 3″ (7Smm) Castor | 4 |
| 70 | Cable tie | 6 |
| 11 | SAF Hex Key | 1 |
| 12 | 19mm Spanner | 1 |
| Screen Fixings | ||
| A | M6 x 16mm Screw | 4 |
| B | M6 x 25mm Screw | 4 |
| C | M6 x 40mm Screw | 4 |
| D | MS x 16mm Screw | 4 |
| E | MS x 25mm Screw | 4 |
| F | MS x 50mm Screw | 4 |
| G | M6Washer | 4 |
| H | MS x 5mm Spacer | 4 |
| I | MS x 15mm Spacer | 4 |
| J | MS x 25mm Spacer | 4 |
Installation Tools Required
Screwdriver
Suitable for loads up to 125kg (275Ibs)
Warning
- Can tip over which may lead to serious injury
- Do not allow children under 16 to move the trolley
- Move the trolley slowly
Installation Instructions
- FIX Castors To Legs
- With the brakes app 1. ie d screw item into items 7 & 2.
- With the brakes app 1. ie d screw item into items 7 & 2.
- Assemble Bars To Legs
- Connect tern 3 to items 7 & 2, using items 6, 7 & 8.
- Connect tern 3 to items 7 & 2, using items 6, 7 & 8.
- Fix Shelf Onto Bar
- Attach item 5 to the bottom item 3, using items 6, 7 & 8.
Note: The shelf (item 5} can be mounted across the horizontal bar (item 3) depending on the installation requirements.
- Attach item 5 to the bottom item 3, using items 6, 7 & 8.
- Fix Interface Arms To Screen
- Fix item 4 to the back of the screen using the screen fixing kit (itemsA-J).
Note: Ensure the arms are facing the correct way round and the same holes are used on both arms.
Note: Use spacers (items H, I J) on screens with recessed fixings.
- Fix item 4 to the back of the screen using the screen fixing kit (itemsA-J).
- Mount Screen Onto Trolley
- Hook screen onto item 3.
Note: Ensure castors (item 9) are braked.
- Hook screen onto item 3.
- Secure Screen To Trolley
- Use items 6 & 7 to secure item 4 to item 3.
- Use items 6 & 7 to secure item 4 to item 3.
- Cable Management
- Use the provided cable ties (item 70) to tidy and secure any cables to the trolley.
- Use the provided cable ties (item 70) to tidy and secure any cables to the trolley.
Dimensions
These instructions are intended as a guide only and B-Tech accepts no liability for the accuracy of the information contained in this document.
Contact
©2024 B-Tech AV Mounts Corporation Ltd. All rights reserved.
B-Tech AV Mounts is a division of B-Tech AV Mounts Corporation Ltd.
B-Tech AV Mounts and the B-Tech logo & Momentum are registered trademarks.
All B-Tech images and symbols are exclusive property of B-Tech AV Mounts Corporation Ltd.
All other brands and product names are trademarks of their respective owners.
Any reproduction, retransmission or republication of any part of this manual is strictly prohibited, unless prior written permission has been granted by B-Tech AV Mounts Corporation Ltd. Photographs are for illustrative purposes only. E&OE
AMA-BT8546-Vl.l-1224-44 Made in the P.R.C.
Documents / Resources
 |
B-Tech BT8546 XL Interactive Touchscreen Trolley [pdf] Installation Guide BT8546 XL Interactive Touchscreen Trolley, BT8546 XL, Interactive Touchscreen Trolley, Touchscreen Trolley, Trolley |