POLAR-LOGO

POLAR CU636 Countertop Display Fridge

POLAR-CU636-Countertop-Display-Fridge-PRODUCT

Product Usage Instructions

  • Remove the appliance from the packaging, ensuring all protective plastic film and coatings are removed.
  • Maintain a minimum clearance of 2.5cm between the unit and walls, with a 20cm clearance on the top. Avoid placing near heat sources.
  • Clean shelves and interior with soapy water before first use.
  • Located below the doors on the rear of the appliance. To manually defrost, press and hold the button for 6 seconds.
  • Store food items in the designated compartments of the appliance.
  • Close the doors, connect to power supply, and press the button to turn the light On or Off as needed.
  • Press the SET button, adjust the temperature using the arrow buttons, then press SET to save temperature settings.
  • Clean regularly using soapy water, ensuring no debris clogs the drain hole. Wipe external condensation with a cloth. Replace the interior lamp carefully after allowing it to cool.

FAQ

  • Q: What should I do if I notice external condensation on the appliance?
  • A: Wipe down the surface with a cloth to remove external condensation caused by operating outside of the recommended temperature range or placing it near a heat source.
  • Q: How often should I clean the appliance?
  • A: Clean the appliance regularly with soapy water to maintain optimal performance and hygiene.

Safety Instructions

  • Position on a flat, stable surface.
  • A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components or service panels on this product.
  • Consult Local and National Standards to comply with the following:
    • Health and Safety at Work Legislation
    • BS EN Codes of Practice
    • Fire Precautions
    • IEE Wiring Regulations
    • Building Regulations
  • DO NOT use jet/pressure washers to clean the appliance.
  • DO NOT use the appliance outside.
  • DO NOT use this appliance to store medical supplies.
  • DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs.
  • DO NOT store products on top of the appliance.
  • Bottles that contain a high percentage of alcohol must be sealed and placed vertically in the refrigerator.
  • Always carry, store and handle the appliance in a vertical position and move by holding the base of the appliance
  • Always switch off and disconnect the power supply to the unit before cleaning.
  • Keep all packaging away from children. Dispose of the packaging in accordance with the regulations of local authorities.
  • If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified technician to avoid a hazard.
  • Children should be supervised to ensure that they do not play with the appliance.
  • POLAR recommends that this product is connected to a circuit protected by an appropriate RCD (Residual Current Device).
  • This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience or knowledge unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety.
  • POLAR recommends that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity and Functional Testing.

Caution: Risk of Fire

  • Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.

Warning: Keep all ventilation openings clear of obstruction. Unit should not be boxed in without adequate ventilation.

  • Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
  • Warning: Do not damage the refrigerant circuit.
  • Warning: Do not use electrical appliances inside the food storage compartments of the appliance.

Introduction

  • Please take a few moments to carefully read through this manual.
  • Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product.

Pack Contents

  • Polar Countertop Food Display Fridge – 100Ltr
  • Shelves x 2
  • Instruction manual

POLAR prides itself on quality and service, ensuring that at the time of unpacking the contents are supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR dealer immediately.

Installation

Not for use in vans or trailers, food trucks or similar vehicles.
If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before operation. If in doubt allow to stand.

  1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces.
  2. To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between the unit and walls and other objects, with a minimum 20cm clearance on the top. NEVER LOCATE NEXT TO A HEAT SOURCE.

Note: Before using the appliance for the first time, clean the shelves and interior with soapy water then dry well.

Operation

Control Panel

  • The control panel is located below the doors on the rear of the appliance.

POLAR-CU636-Countertop-Display-Fridge-FIG-1

Turn On

  1. Close the doors of the appliance.
  2. Connect the appliance to a mains power supply.
  3. Press thePOLAR-CU636-Countertop-Display-Fridge-FIG-2 button to turn the light On or Off as required.

Setting the Operating Temperature

  1. Press the SET button. The display will flash.
  2. Press thePOLAR-CU636-Countertop-Display-Fridge-FIG-3 buttons to display the required temperature.
  3. Press the SET button to store the temperature.

Manual Defrost:

  • Press and hold thePOLAR-CU636-Countertop-Display-Fridge-FIG-2 button for 6 seconds to begin automatic defrost. The defrost light illuminates.
  • The defrost cycle will end automatically.

Storing Food
To get the best results from your POLAR appliance, follow these instructions:

  • Only store foodstuffs in the appliance when it has reached the correct operating temperature.
  • Do not place uncovered hot food or liquids (like acidic fluids) inside the appliance (as it can damage the evaporator).
  • Wrap or cover food where possible.
  • Do not obstruct the fans inside the appliance.
  • Avoid opening the doors for prolonged periods of time.

Cleaning, Care & Maintenance

  • Switch off and disconnect from the power supply before cleaning.
  • The doors can be removed for ease of cleaning.
  • Clean the interior of the appliance as often as possible.
  • Do not use abrasive cleaning agents. These can leave harmful residues.
  • Clean the door seal with warm soapy water.
  • Always wipe dry after cleaning.
  • Do not allow water used in cleaning to run through the drain hole into the evaporation pan.

Condensation and ice will form with frequent and prolonged opening of the doors.
Operating outside of the recommended temperature range and placing next to a heat source will also increase the amount of ice and internal/external condensation.
If external condensation occurs wipe the surface down with a cloth.
Excessive ice will result in longer running times that will increase energy consumption and increase the deterioration of components.

Replacing the Interior Lamp
WARNING: Allow the lamp to cool before replacing. The lamp remains hot immediately after use.

  1. Turn Off and disconnect the appliance from the mains power supply.
  2. Remove the lamp by twisting it from the lamp sockets.
  3. Insert the new lamp and twist into place.

Cleaning the Condenser

  • Periodically cleaning the condenser can extend the life of the appliance.
  • POLAR recommends that a POLAR agent or qualified technician clean the condenser.

Technical Specifications

Note: Due to our continuing program of research and development, the specifications herein may be subject to change without notice.

 

Model

 

Voltage

Power (W) Current (A) Temperature Range Net usable capacity (Litres)  

Refrigerant

Dimensions H x W x D mm Weight (kg)
CU636 CU637 220-240V~

50Hz

195 1.5 2-10°C 64 L R600a 687 x 705 x

472

39

Note: For optimal product performance and efficiency, please ensure the net usable capacity (load limit) when filling.

Impact of temperature settings on food waste:

In order to reduce food waste from decomposition or dehydration, this appliance should be operated in its designated operating range.

The optimum temperature for food storage: 6°C

To order spare parts please contact your Polar Stockist:

https://www.polar-refrigerator.com/stockist

POLAR-CU636-Countertop-Display-Fridge-FIG-4
Minimum period of spare parts to be available:

Door handles, door hinges, knobs, dials and buttons, door gaskets, peripheral trays, baskets and racks for storage, as appropriate to the appliance, will be made available to both end users and professional users for a minimum of eight years after the last unit of the model is placed on the market. A broader selection of parts will also be made available to Professional users for this period.

Model information can be found on the product database:

https://eprel.ec.europa.eu/screen/product/refrigeratingappliancesdirectsalesfunction

POLAR-CU636-Countertop-Display-Fridge-FIG-5
Model information can be found on the product:

The Model Identifier can usually be found on the inside wall and on the reverse of the unit.

Note: Polar offers a 2-year minimum warranty, please contact the authorized representative for more details.

Troubleshooting

  • A qualified technician must carry out repairs if required.
Fault Probable Cause Solution
The appliance is not working The unit is not switched on Check unit is plugged in correctly and switched on
Plug or lead is damaged Replace Plug or lead
The fuse in the plug has blown Replace the fuse
The mains power supply fault Check the mains power supply
The appliance turns on, but the temperature is too high/ low Too much ice on the condenser Defrost the appliance
Condenser blocked with dust Consult a qualified Technician
Doors are not shut properly Check doors are shut and seals are not damaged
The appliance is located near a heat source, in the direct sunlight or airflow to the condenser is being interrupted Move the refrigerator to a more suitable location
The ambient temperature is too high Increase ventilation or move the appliance to a cooler position
Unsuitable foodstuffs are being stored in the appliance Remove any excessive hot foodstuffs or blockages to fan
Appliance is overloaded Reduce the amount of food stored in the appliance
Factory default parameters adjusted Consult a qualified Technician
The appliance is leaking water The appliance is not properly leveled Adjust the screw feet to level the appliance (if applicable)
The appliance is unusually loud Loose screw/nut Check and tighten all nuts and screws
The appliance has not been installed in a level or stable position Check installation position and change if necessary
The display lamp does not illuminate Lamp needs replacing Consult a qualified Technician
The light not turned on Ensure the Light button has been pressed properly
The door does not shut Dirt/obstacle in runners Clean runners
Error code EE4 •     Restricted Airflow

•     Blocked Condenser

•     Increase airflow

•     Consult a qualified Technician

Electrical Wiring

POLAR appliances are supplied with a 3-pin BS1363 plug and lead.
The plug is to be connected to a suitable main socket.
POLAR appliances are wired as follows:

  • Live wire (colored brown) to the terminal marked L
  • Neutral wire (colored blue) to the terminal marked N
  • Earth wire (colored green/yellow) to the terminal marked E

This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required, they must be readily accessible.POLAR-CU636-Countertop-Display-Fridge-FIG-6

Disposal

  • EU regulations require refrigeration products to be disposed of by specialist companies who remove or recycle all gasses, metal and plastic components.
  • Consult your local waste collection authority regarding the disposal of your appliance. Local authorities are not obliged to dispose of commercial refrigeration equipment but may be able to offer advice on how to dispose of the equipment locally.
  • Alternatively, call the POLAR helpline for details of national disposal companies within the EU.

Compliance

  • The WEEE logo on this product or its documentation indicates that the product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area.POLAR-CU636-Countertop-Display-Fridge-FIG-7
  • POLAR parts have undergone strict product testing to comply with regulatory standards and specifications set by international, independent, and federal authorities.
  • POLAR products have been approved to carry the following symbol:

POLAR-CU636-Countertop-Display-Fridge-FIG-8

All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserves the right to change specifications without notice.

DECLARATION OF CONFORMITY

POLAR-CU636-Countertop-Display-Fridge-FIG-9 POLAR-CU636-Countertop-Display-Fridge-FIG-10

CONTACT

UK +44 (0)845 146 2887
Eire
NL 040 – 2628080
FR 01 60 34 28 80
BE-NL 0800-29129
BE-FR 0800-29229
DE 0800 – 1860806
IT N/A
ES 901-100 133

POLAR-CU636-Countertop-Display-Fridge-FIG-11

Documents / Resources

POLAR CU636 Countertop Display Fridge [pdf] User Manual
CU636 Countertop Display Fridge, CU636, Countertop Display Fridge, Display Fridge, Fridge

References

Leave a comment

Your email address will not be published. Required fields are marked *