Manuals+

Mercedes-Benz Sprinter Fuse Assignment Supplement

Symbols

  • ⚠️ DANGER: Danger due to not observing the warning notices. Warning notices draw your attention to hazards that may endanger your health or life, or the health or life of others. Observe the warning notices.
  • ? ENVIRONMENTAL NOTE: Environmental damage due to failure to observe environmental notes. Environmental notes include information on environmentally responsible behavior or environmentally responsible disposal. Observe environmental notes.
  • ❗ NOTE: Damage to property due to failure to observe notes on material damage. Notes on material damage inform you of risks which may lead to your vehicle being damaged. Observe notes on material damage.
  • ℹ️ Information: These symbols indicate useful instructions or further information that could be helpful to you.
    • → Instructions: Further information on a topic (page)
    • Display: Display in the multifunction display/media display
    • Display: Display in the taximeter
    • ➡️: Highest menu level to be selected in the multimedia system
    • ➡️: Corresponding submenus to be selected in the multimedia system
    • ➡️: Indicates a cause

Fuses/Relays in the Front-Passenger Footwell

Fuse Assignment

No.ConsumerFuse rating
MF1
15-1Engine control unit5 A
15-1Common Powertrain Module (CPC)5 A
15-1ESP® control unit5 A
15-1All-wheel drive control unit5 A
15-1Retarder5 A
MF2
15-1Air suspension5 A
15-2Feedback cable, terminal 15 relay5 A
15-2Headlamp range control, halogen headlamp5 A
15-2Tachograph TCO5 A
MF3
30-TMultifunction camera7.5 A
30-TTachograph TCO7.5 A
30-TDIN slot connection, roof7.5 A
30-TTerminal 15, undervoltage relay7.5 A
30-TInstrument cluster7.5 A
30-TCentral oil pump7.5 A
S9
1Unassigned
2Common Powertrain Module (CPC)10 A
3Engine control unit OM642/OM651/M27410 A
4DIN slot, cockpit7.5 A
5Common Powertrain Module (CPC)10 A
6Radiator fan (not for OM654)5 A
S10
7Automatic transmission30 A
8Body controller30 A
9Body controller30 A
10Heating, SCR catalytic converter30 A
11Overhead control panel (standard)10 A
Overhead control panel, Cab Chassis10 A
S11
Overhead control panel (high)15 A
12Pump, SCR catalytic converter15 A
S12
13Automatic transmission NAT 360 A
14ESP® valves (Premium), vehicles with electric parking brake40 A
ESP® valves (Standard)25 A
S13
16ESP® pump60 A
S14
17Body controller30 A
18Body controller30 A
19D+, body manufacturer10 A
20Co-driver's door control unit25 A
21Driver's door control unit25 A
22Air suspension (LFA) control unit10 A
S15
23Blower control unit25 A
24USB charging socket (cockpit), USB charging socket (stowage compartment), 115/230V converter socket7.5 A
25Cigarette lighter socket, center console15 A
26Information panel socket15 A
27Converter socket, 115 V/230 V25 A
S16
28Radio pre-installation, cargo liftgate, voltage converter antenna, 115/230V converter socket for vehicles with auxiliary battery7.5 A
30-1Unassigned
30-2Unassigned
30-3Central locking5 A
30-4Anti-theft alarm system (ATA)5 A
30-5Unassigned
30-6Electronic ignition lock control unit10 A
S17
31Actuation, terminal 15-II relay25 A
S18
32Unassigned
S19
33Voltage dip sensor (SEB)5 A
34Electrics for body interior lighting10 A
S1
35Advanced Caravaning Unit (ACU)7.5 A
S2
36Air conditioning control panel5 A
37Electric Steering Wheel Locking (ESTL)5 A
38Steering Column Switch Module (SCSM)10 A
39Radio antenna, navigation system, two-way radio10 A
S3
40Rotating beacon5 A
41Radio multimedia system (C5/NTG6)/radio pre-installation25 A
S4
42Unassigned
S5
43Unassigned
44Multimedia system control panel5 A
45Charger bracket, Wireless Mobile Interface (WMI)5 A
46Multimedia connection unit (MMI)7.5 A
47Hermes (UMTS/LTE communication module)5 A
48Telestart stationary heating5 A
49Central display5 A
S6
50Additional headlamp, left (platform body manufacturer)5 A
51Auxiliary headlamp, right (platform body manufacturer)5 A
52Control unit, airbag7.5 A
53Diagnostics5 A
54Relay supply5 A
55TS engine (diesel), engine control unit (OM651)7.5 A
S7
57Soot particulate sensor, NOx sensor15 A

Relay Assignment

No.ConsumerFuse rating
58Soot particulate sensor (not for OM654)10 A
58Engine, exhaust gas recirculation (EGR) (OM642/OM651)10 A
Engine (not for OM654)15 A
59NOx sensor before/after catalytic converter (not for OM654)10 A
60Lambda sensor7.5 A
61M274 engine10 A
Engine (OM642/OM651)7.5 A
62Engine control unit (not for OM654)15 A
63Engine control unit20 A
63Engine (M274)20 A
Engine (not for OM654)25 A
S8
64Body controller30 A
65Body controller30 A
66Roof ventilator15 A
67Control unit for fuel measurement (FSCM)25 A
68LED headlamp, right15 A
69LED headlamp, left15 A
H2
70Windshield wipers30 A

Fuses on the Outside of the Driver's Seat Base

Fuse Assignment

No.DesignationPermissible current intensity
R1Reserve30 A
R2Terminal 87, engine50 A
R3Terminal 87, Common Powertrain Module CPC30 A
R4Terminal 15-I40 A
R5Windshield wipers on/off40 A
R6Reserve40 A
R7Windshield wipers fast/slow40 A
R8Terminal 50, starter40 A
R9Terminal 15R (vehicles without additional battery)50 A
R10Terminal 15-II30 A
R11Terminal 15R (vehicles with additional battery)50 A

Fuse block F55/1

No.ConsumerFuse rating
1Additional turn signal lamp10 A
2Rear window wiper, right15 A
3All-wheel drive30 A
4Terminal strip for electrical connection (body manufacturer)25 A

Fuse block F55/2

No.ConsumerFuse rating
5Driver's seat adjustment control unit25 A
Driver's seat heating control unit
6Driver lumbar support10 A
Co-driver's lumbar support
7Co-driver's seat adjustment control unit25 A
Co-driver's seat heating control unit (double jump seat)
8Tire pressure monitor5 A
Motion detector and tire pressure monitoring system
9Parking Assist5 A
Rear view camera (RVC)

Fuse block F55/2

No.ConsumerFuse rating
10Trailer coupling, right (trailer socket)25 A
11Trailer coupling control unit15 A
12Trailer coupling, left (trailer socket)25 A
13Trailer coupling control unit15 A
14Multi Purpose Module (MPM) (body manufacturer interface)25 A
15Multi Purpose Module (MPM) (body manufacturer interface)25 A
16Rear compartment blower25 A
17Auxiliary heating (water heating)20 A
18Automatic transmission, auxiliary oil pump15 A

Fuse block F55/3

No.ConsumerFuse rating
19Auxiliary heating, Terminal 15 on auxiliary battery15 A
20Auxiliary battery voltage measurement5 A
21Rear window heater, left15 A
22Rear window heater, right15 A
23Cargo liftgate/dumper vehicle (pre-installation)7.5 A
24Terminal strip for electrical connection (body manufacturer)15 A
25Roof ventilator relay5 A
26Special signal, cockpit body manufacturer7.5 A
27Rear window heater30 A

Fuse block F55/4

No.ConsumerFuse rating
28Sliding door, left15 A
Electric sliding door, left30 A
29Sliding door, right15 A
Electric sliding door, right30 A
30Antenna switch box5 A
31Automatic transmission7.5 A
32Automatic transmission10 A
33Brake booster30 A
34Siren relay15 A
Pre-installation for camper van30 A

Fuse block F55/5

No.ConsumerFuse rating
35Rotating beacon with siren15 A
Pre-installation for camper van30 A
36Pre-installation for camper van30 A

Fuse block F55/5

No.ConsumerFuse rating
37Electrical step, left10 A
38Electrical step, right10 A
39Warning buzzer, electrical step, left/right5 A
40Automatic transmission (NAT2)10 A
41Terminal 15, special signal, cockpit body manufacturer5 A
42Rear view camera (RVC)5 A
Inside rearview mirror (rear view camera display)
43Socket, cab15 A

Fuse block F55/6

No.ConsumerFuse rating
44Socket, D-pillar, left15 A
45Socket, D-pillar, right15 A

Fuse block F55/6

No.ConsumerFuse rating
51USB port, wiper, front left7.5 A
USB port, wiper, front left (with sliding door, left)5 A
52USB port, wiper, front right7.5 A
USB port, wiper, front right (with sliding door, right)5 A

Fuses/Relays in the Base of the Driver's Seat and in the Battery Box

Fuse Assignment

Additional fuses/relays are located in the seat base of the driver's seat:

  • for the windshield heater
  • for other vehicle components, such as power-steering pumps, auxiliary battery, battery cut-off relays and PTC heater boosters

From the body manufacturers for retarders, cargo liftgate, hydraulic pump and dumper vehicle.

ℹ️ Always have the fuses/relays in the seat base replaced at a qualified specialist workshop.

Fuse block F150/1 (MFB-1) in the battery box

No.ConsumerFuse rating
1Battery sensor
2UnassignedMIDI
3Main fuse box (MFB-2)Busbar
4Power Distribution Center terminal 30 (F30-1 - F30-6)50 A
5PTC heater booster125 A
No.ConsumerFuse rating
5Power Distribution Center (PDC), FB-P175 A
6Glow output stage (GZE)80 A
7Radiator fan (not for OM654)40 A
Engine radiator fan70 A
Radiator fan (not for OM654)80 A
8Camper van main fuses100 A
9Unassigned
10Air-conditioning system, rear compartment100 A
Air-conditioning system, rear compartment50 A
Air-conditioning system, rear compartment25 A
11Auxiliary battery/battery cut-off relay150 A
Retarder without auxiliary battery100 A

Fuse block F150/4 (MFB-2)

No.ConsumerFuse rating
1Terminal 30T, fuse box, seat base of driver's seat (F55/1 - F55/6)125 A
2Electric steering125 A
3Alternator300 A
Alternator400 A
4External power supply

Fuse block F150/5 (MFB-ZB)

No.ConsumerFuse rating
1Retarder100 A
2Cargo liftgate/dumper vehicle (pre-installation)250 A
3Auxiliary battery
No.ConsumerFuse rating
4Battery cutoff relay150 A
5Sockets, converter60 A
6Auxiliary heating25 A

K100 Relay Carrier

Individual fuses F59/1 and F59/2

No.ConsumerFuse rating
1Windshield heater, left40 A
2Windshield heater, right40 A

Supplementary relay, bottom

No.Designation
1Windshield heater
2Terminal 15
3Rear window heater
4Sockets, rear
5Interior lamp

Supplementary relay, top

No.Designation
6Free
7Free
8Free
9Free
10Free

Mini-relay

No.Designation
11Free
12Free
13Free
14Free
15Rear window wiper, right
16Terminal strip body manufacturer
17Switch, reverse warning device
18Roof ventilator
19Auxiliary oil pump
20Electrical step, right 1
21Electrical step, right 2
22Electrical step, left 1
23Electrical step, left 2
24Siren
25Rotating beacon with siren
26Cargo liftgate

Auxiliary battery relay

Auxiliary battery

Publication Details

Internet:

  • http://www.mercedes-benz.com
  • http://www.mbusa.com (USA only)
  • https://www.freightlinersprinterusa.com
  • http://www.mercedes-benz.ca (Canada only)

Vehicle manufacturer: Daimler AG, Mercedesstraße 137, 70327 Stuttgart, Germany

Vehicle dealer (USA): Daimler VANS USA, LLC, One Mercedes-Benz Drive, Sandy Springs, GA 30328, http://www.mbusa.com (USA only), www.mbsprinterusa.com, Customer Assistance Center: 1-877-762-8267

Vehicle dealer (Canada): Mercedes-Benz Canada, Inc., 98 Vanderhoof Avenue, Toronto, ON M4G 4C9, http://www.mercedes-benz.ca (Canada only), Customer Relations Department: 1-800-387-0100

PDF preview unavailable. Download the PDF instead.

MY19-MB-Fuse-Allocation AH XSL Formatter V6.4 MR1 for Windows (x64) : 6.4.3.27525 (2017/01/23 10:11JST) OneVision PDFengine (Windows 64bit Build 25.092.S)

Related Documents

Preview Mercedes-Benz Sprinter Fuse Allocation Supplement
Official fuse and relay allocation guide for the Mercedes-Benz Sprinter, detailing fuse box locations, fuse functions, and electrical system components. Essential technical information for Sprinter owners and technicians.
Preview Mercedes-Benz Fuse Allocation and Ratings Guide
A comprehensive guide detailing fuse allocation, locations, ratings, and colors for Mercedes-Benz vehicles, including specific information for engine compartment, cockpit, and boot fuse boxes.
Preview Mercedes-Benz Sprinter: Engaging Park Position P - Operating Instructions Supplement
This document provides supplementary operating instructions for the Mercedes-Benz Sprinter, detailing how to engage the park position 'P' for the automatic transmission. It covers essential steps and conditions for safe and proper vehicle operation.
Preview The History of Gasoline Engines at Mercedes-Benz: A Comprehensive Overview
Explore the rich history of gasoline engine development at Mercedes-Benz, from the pioneering inventions of Daimler and Benz to modern advancements in automotive technology. This document details key milestones, engine innovations, and influential models that shaped the automotive industry.
Preview Mercedes-Benz Sprinter 907 Body and Equipment Guideline MY2023
This official guideline from Mercedes-Benz provides essential technical information and safety directives for upfitters and converters modifying the Sprinter 907 model year 2023. It details requirements for compliant and safe vehicle alterations.
Preview Supplemental Body and Equipment Guideline for eSprinter
This document provides a supplemental guideline for the Mercedes-Benz eSprinter, Model Series 907. It covers essential information for body and equipment modifications, operational safety, technical specifications, and design considerations for upfitters and service professionals.
Preview Mercedes-Benz Sprinter: Керівництво з експлуатації
Посібник користувача для Mercedes-Benz Sprinter, що охоплює експлуатацію, функції, технічні характеристики та обслуговування.
Preview Mercedes-Benz Sprinter Maintenance Booklet
Comprehensive maintenance guide for the Mercedes-Benz Sprinter van, covering service schedules, regular checks, and important information for vehicle owners.