Homepage - Polar Refrigeration
Instruction Manual for POLAR models including: GE580-A, GE581-A, GM813-A, GM814-A, GE580 Series Display Cooler, GE580 Series, GE580 Series Cooler, Display Cooler, Cooler
Jul 10, 2024 — Instruction manual. GE580-A GE581-A GM813-A GM814-A A5 v3 20240710 1. 2024/7/10 08:44. Page 2. 2. EN. Telephone Helpline: 1300225960. Safety Instructions.
8 nov 2024 — Instruction manual. GE580-A GE581-A GM813-A GM814-A A5 v3 20241108 1. 2024/11/8 16:42. Page 2. 2. EN. Telephone Helpline: 1300225960. Safety Instructions.
File Info : application/pdf, 8 Pages, 1.00MB
DocumentDocumentDisplay Cooler Instruction manual Model: GE580-A/GE581-A/GM813-A/GM814-A (&"@(&"@(."@(."@"@W@JOEC EN Telephone Helpline: 1300225960 Safety Instructions · Never tilt the appliance more · Position on a flat, stable than 45° from the vertical. surface. · Not suitable for outdoor use. · A service agent/qualified · Keep all packaging away technician should carry out from children. Dispose of installation and any repairs the packaging in accordance if required. Do not remove with the regulations of local any components or service authorities. panels on this product. · If the power cord is - In Queensland the damaged, it must be service agent/qualified replaced by a POLAR agent technician MUST hold a or a recommended qualified Gas Work Authorisation or technician in order to avoid a License for hydrocarbon hazard. refrigerants if the · This appliance is not appliance gas system is intended for use by persons being opened or charged. (including children) with · Consult Local and National reduced physical, sensory or Standards to comply with the mental capabilities, or lack following: of experience or knowledge, - Health and Safety at Work unless they have been given Legislation supervision or instruction - Fire Precautions concerning the use of the - Wiring Regulations appliance by a person - Building Regulations responsible for their safety. · DO NOT immerse in water, · Children should be or use steam/jet washers to supervised to ensure that clean the unit. they do not play with the · DO NOT cover the appliance appliance. when it is operating. · Always carry, store and handle appliance in a vertical position. 2 (&"@(&"@(."@(."@"@W@JOEC Telephone Helpline: 1300225960 AENU · Polar recommend that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity and Functional Testing. Warning: Risk of Fire · Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance. Warning: Keep all ventilation openings clear of obstruction. Unit should not be boxed in without adequate ventilation. · To comply with AS/NZS 60079.10.1:2009: Ensure there are not sources of ignition in any area where refrigerant could gather in the event of a leak. · Electrical equipment should not be placed under the vent or where refrigerant could gather in the event of a leak. · Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer. · Warning: Do not damage the refrigerant circuit. · Warning: Do not use electrical appliances inside the food storage compartments of the appliance. Pack Contents The following is included: · Display Cooler · Instruction manual POLAR prides itself on quality and service, ensuring that at the time of unpacking the contents are supplied fully functional and free of damage. Should you find any damage as a result of transit, please contact your POLAR dealer immediately. Installation Note: Not for use in vans or trailers, food trucks or similar vehicles. If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before operation. If in doubt allow to stand. 1. Remove the appliance from the packaging and the protective film from all surfaces. 2. Avoid positioning the cooler in direct sunlight or damp areas. 3. To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between the unit and walls and other objects, with a minimum 20cm clearance on the top. NEVER LOCATE NEXT TO A HEAT SOURCE. 4. Set the brakes on the castors to keep the appliance in position. Note: Before using the appliance for the first time, clean the shelves and interior with soapy water then dry well. 3 (&"@(&"@(."@(."@"@W@JOEC EN Telephone Helpline: 1300225960 Operation Turn On 1. Close the doors of the appliance. 2. Connect the appliance to a mains power supply. 3. Turn the light switches On [I] or Off [O] as desired. Control Panel Manual Defrost The appliance will automatically run a defrost cycle every 4 hours. To manually defrost the appliance: Press and hold the defrost button " " for 2 seconds to begin a manual defrost. The defrost light illuminates. Cleaning, Care & Maintenance · Switch off and disconnect from the power supply before cleaning. · Clean the interior of the appliance as often as possible. · Do not use abrasive cleaning agents. These can leave harmful residues. · Always wipe dry after cleaning. · If left unused for any length of time, store the appliance with the door ajar. Set the Operating Temperature 1. Hold the SET button for 3 seconds. The display will flash. 2. Press the or buttons to display the required temperature. 3. Press the SET button to store the temperature. Condensation and ice will form with frequent and prolonged opening of the doors. Operating outside of the recommend temperature range and placing next to a heat source will also increase the amount of ice and internal/external condensation. If external condensation occurs wipe the surface down with a cloth. Excessive ice will result in longer running times that will increase energy consumption and increase the deterioration of components. Troubleshooting A qualified technician must carry out repairs if required. Fault The appliance is not working Appliance is noisy or works intermittently Cooler cabinet is not cold enough Condensation Probable Cause Solution The unit is not switched on Check unit is plugged in correctly and switched on Plug or lead is damaged Replace Plug or lead Mains power supply fault Check mains power supply Appliance is not level Check installation position and change if necessary The appliance is touching a neighbouring object Check installation position and change if necessary Temperature set incorrectly Check temperature and reset if necessary External environment may require colder temperature Check temperature and reset if necessary The door is opened too often Only open when necessary Door seal is worn Replace the seal Condensation may occur when the humidity is high and water particles in the air contact with cold surfaces. This is normal, just wipe away with a dry cloth 4 (&"@(&"@(."@(."@"@W@JOEC Telephone Helpline: 1300225960 AENU Technical Specifications Note: Due to our continuous improvement process, the product specifications are subject to change without notice. Model Voltage Power Current Temp. Range Refrigerant Dimensions H x W x D mm Weight (kg) Shelf load (Max.) GE580-A GM813-A GE581-A GM814-A 220240V~ 50Hz 500W 500W 3.4A 2°C-10°C 3.4A 2°C-10°C R290 R290 2068 x 1200 160 x 728 2068 x 1200 155 x 715 30kg 30kg Electrical Wiring The plug is to be connected to a suitable mains socket. This appliance is wired as follows: · Live wire (coloured brown) to terminal marked L · Neutral wire (coloured blue) to terminal marked N · Earth wire (coloured green/yellow) to terminal marked E The appliances must be earthed. If in doubt consult a qualified electrician. Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required they must be readily accessible. Compliance The product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area. POLAR parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent, and federal authorities. POLAR products have been approved to carry the following symbol: All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR. Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to change specifications without notice. 5 (&"@(&"@(."@(."@"@W@JOEC DocuSign Envelope ID: 014ADB22-F3C3-41A4-BB61-879CD5B6457F DECLARATION OF CONFORMITY · Conformiteitsverklaring · Déclaration de conformité · Konformitätserklärung · Dichiarazione di conformità · · Declaración de conformidad Equipment Type · Uitrustingstype · Type d'équipement · Gerätetyp · Tipo di apparecchiatura · Tipo de equipo Chilled Display refrigerator: 'G SERIES' Upright Display Cooler with Light Box 950L- Hinged Door 'G SERIES' Upright Display Cooler with Light Box 950L - Sliding Door 'G SERIES' Upright Display Cooler with Light Box Hinged Door - Black 'G SERIES' Upright Display Cooler with Light Box Sliding Door - Black Application of Territory Legislation & Machinery Directive 2006/42/EC Council Directives(s) Supply of Machinery (Safety) Regulations 2008 Toepassing van Europese Richtlijn(en) · (BS) EN 60335-1:2012 +A11:2014 +A13:2017 Application de la/des directive(s) du (BS) EN 60335-2-89:2010 +A1:2016 +A2:2017 Conseil · Anwendbare EU-Richtlinie(n) (BS) EN 62233:2008 · Applicazione delle Direttive · Aplicación de la(s) directiva(s) del Electro-Magnetic Compatibility (EMC) Directive consejo 2014/30/EU - recast of 2004/108/EC Electromagnetic Compatibility Regulations 2016 (S.I. 2016/1091) (BS) EN 55014-1:2017 (BS) EN 55014-2:2015 (BS) EN 61000-3-2:2014 (BS) EN 61000-3-3:2013 Model · Modèle · Modell · Modello · Modelo GE580 (-E & -A) GE581 (-E & -A) GM813 (-E & -A) GM814 (-E & -A) Electrical Safety IEC 60335-1:2010 +A1:2013 +A2:2016 IEC 60335-2-89:2010 +A12012 +A2:2015 EN 62233:2008 Electromagnetic Compatibility EN 55014-1:2017 EN 55014-2:2015 EN 61000-3-2:2014 EN 61000-3-3:2013 Ecodesign energy-related products Directive 2009/125/EC; Regulation (EU) 2019/2024 - Ecodesign direct sales refrigerators ISO 23953-2:2015 Restriction of Hazardous Substances Directive (RoHS) 2015/863 amending Annex II to Directive 2011/65/EU Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment Regulations 2012 (S.I. 2012/3032) Manufacturer Name · Naam fabrikant · Nom du producteur · Name des Herstellers · Nome del produttore · Nombre del fabricante Polar I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s) and Standard(s). Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande Richtlijn(en) en Standaard(en). Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und Norm(en) entspricht. Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati. El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y estándar(es) arriba mencionadas. Date · Data · Date · Datum · Data · Fecha · Data Signature · Handtekening · Signature · Unterschrift Firma · Firma 30th August 2022 Full Name · Volledige naam · Nom et prénom · Vollständiger Name · Nome completo · Nombre completo Ashley Hooper Eoghan Donnellan Brendan Denmeade Position · Functie · Fonction · Position · Qualifica · Posición Manufacturer Address · Adres fabrikant · Adresse du producteur · Anschrift des Herstellers · Indirizzo del produttore · Dirección del fabricante Group Head of Product Quality and Compliance Fourth Way, Avonmouth, Bristol, BS11 8TB United Kingdom Commercial Manager/ Importer Unit 9003, Blarney Business Park, Blarney, Co. Cork Ireland Commercial Manager/ Responsible Supplier 15 Bagdally Road, Campbelltown NSW 2560 (&"@(&"@(."@(."@"@W@JOEC (&"@(&"@(."@(."@"@W@JOEC http://www.polar-refrigerator.com/ GE580-A_GE581-A_GM813-A_GM814-A_A5_v3_2024/07/10 (&"@(&"@(."@(."@"@W@JOEC