Outdoor Storage Shelter & Living NZ | Shop Online Trade Tested
User Manual for trade tested models including: 938680 Fridge Freezer Bottom Mount, 938680, Fridge Freezer Bottom Mount, Freezer Bottom Mount, Bottom Mount
File Info : application/pdf, 20 Pages, 2.20MB
DocumentDocumentFRIDGE FREEZER BOTTOM MOUNT 323L STAINLESS STEEL
Product code: 938680 User manual
www.tradetested.co.nz
0800 800 880
support@tradetested.co.nz
!
"
"
#
$
%
$%
#
&
'
'
1
'
$
%
'
(%
'
$)*++%
'
&
&
,
-
&
. &
. &
. &
&
,
$
%
/
1
2
1
2
(%
(%
2
7
8
/
, /
8
'
9
"
'
!
-
-!
,
'
'
!
&
!
(%
&
!
!
(% ,
)
'
!! !
(%
(%
3
'
4 '
4
5
(% )
0%
(% !
0% &
3
5
'
)
,/
;
$
& %
8
,
/
/
!"
'
. '
. 8
$ %.
$ %. '
$ %/
. '
$ %
. '
.
4
!
<
,
/
3
/
7
'
'
('
0"
5
2YHUYLHZ
FridgeShelves Crisper Cover
Crisper Fresh convertible box
Freezer Drawers
Leveling Feet
Note: Above picture is for reference only. Real appliance probably is different.
6
Fridge Balconies
,QVWDOODWLRQ
SpaceRequirement
y Select a location without direct exposure to sunlight; y Select a location with enough space for the refrigerator doors to open
easily; y Select a location with level (or nearly level) flooring; y Allow sufficient space to install the refrigerator on a flat surface; y Allow clearance to the right, left, back and top when installing. This
will help reduce power consumption and keep your energy bills lower. y Keep at lest 50mm gap at two sides and back.
Positioning
Install this appliance at a location where the ambient temperature corresponds to the climate class indicated on the rating plate of the appliance:
Climate class SN N ST T
Ambient temperature +10oC to +32oC +16oC to +32oC +16oC to +38oC +16oC to +43oC
Location
The appliance should be installed well away from sources of heat such as radiators, boilers, direct sunlight etc. Ensure that air can circulate freely around the back of the cabinet. To ensure best performance, if the appliance is positioned below an overhanging wall unit, the minimum distance between the top of the cabinet and the wall unit must be at least 100 mm. Ideally, however, the appliance should not be positioned below overhanging wall units. Accurate leveling is ensured by one or more adjustable feet at the base of the cabinet.
Warning! It must be possible to disconnect the appliance from the mains power supply; the plug must therefore be easily accessible after installation.
Electrical connection
Before plugging in, ensure that the voltage and frequency shown on the rating plate correspond to your domestic power supply. The appliance must be earthed. The power supply cable plug is provided with a contact for this purpose. If the domestic power supply socket is not earthed, connect the appliance to a separate earth in compliance with current regulations, consulting a qualified electrician. The manufacturer declines all responsibility if the above safety precautions are not observed. This appliance complies with the E.E.C. Directives.
7
,QVWDOODWLRQ
Door Reversibility
%HIRUH UHYHUVLQJ WKH GRRU SOHDVH EH SUHSDUHG EHORZ WRROV DQG PDWHULDO VWUDLJKW VFUHZGULYHU FURVV VFUHZGULYHU VSDQQHU DQG WKH FRPSRQHQWV LQFOXGHG LQ WKH SRO\ EDJ
/HIW 'RRU +LQJH &RYHU [
Left Aid-Closer on Upper Door x 1 Left Aid-Closer on Lower Door x 1
8nscrew top hinge cover and disconnect connectors of door switch and harness.
2.Unscrew top hinge
3.Remove the pin with a screwdriver and filp the hinge bracket. Then refit the pin to hinge bracket
VO screw
screw
8
,QVWDOODWLRQ
4.Move door switch from right hinge cover to left hinge cover in accessary bag.
5.Detach cover in top of upper door and move harness from right side to left side, then replace the cover.
6.Move top left cover to right side
7. Take off the upper door, take out the screw from the middle hinge by cross screwdriver, then take off the lower door.
9
,QVWDOODWLRQ
8 .
9. Unscrew bottom hinge. Then remove the adjustable feet from both side.
10. Unscrew and remove the bottom hinge pin, turn the bracket over and replace it.
unscrew
screw
10
,QVWDOODWLRQ
11.Refit the bracket fitting the bottom hinge pin. Replace both adjustable feet. 12.Remove aid-closers from bottom of upper and lower doors, then take new aid-closers from
accessary bag and install them to left side.
13.Detach the Fridge and the Freezer door gaskets and then attach them after rotating.
11
,QVWDOODWLRQ
14. Install the lower door, adjust and fix the middle hinge onto the cabinet.
15.Replace upper door, please ensure the door align with the cabinet to make sure door gasket seal the cabinet tightly. Then connect door with cabinet by tightly fixed top hinge.
16.Connect harnesses from door and cabinet. Then replace top hinge cover. Before screw the cover, connect terminals of door switch.
12
,QVWDOODWLRQ
6SDFH5HTXLUHPHQW
y Keep enough space of door open. y Keep at least 50mm gap at two sides.
1071NN
/HYHOOLQJWKHXQLW
To do this adjust the two levelling feet at front of the unit.
If the unit is not level, the doors and magnetic seal alignments will not be covered properly.
1007NN
13
8VHULQWHUIDFH
Using the Control Panel
1
2
3
4
5
6
A
B C
1.1 BUTTON OPERATION
A.Temperature Control of Fridge Compartment B.Temperature Control of Freezer Compartment C.Mode / Locking / Unlocking
1.2 LED DISPLAY
1.Temperature of Fridge Comparment 2.Temperature of Freezer Comparment 3.ECO Mode 4.Holiday Mode 5.Super Mode 6.Locking / Unlocking
2.0 OPERATING CONDITION
a.The control panel is 100% lit up for 3 seconds, which operates exactly as per the setting (mode and temperature) before the poweroff. The system will be automatically locked 25 seconds after the last button operation. After locking, the light of the panel would be out 2 minutes after the last button operation.
b.Both preset temperatures of fridge compartemnt and freezer compartment would be shown on the display.
2.1 DISPLAY
2.1.1The panel will be lit up for 2 minutes once the door of fridge compartment is opened.
14
8VHULQWHUIDFH
2.1.2 The panel will be lit up by any button operation whereas the light would be out 2 minutes after the last operation.
2.1.3 Display during normal operation
Temperature Display of the Fridge Compartment: Indicatingthe temperature of the
current setting. Temperature Display of the Freezer Compartment: Indicating the temperature of the current setting.
3.0 ILLUSTION OF THE BUTTON
3.1 Temperature Control of the Fridge Compartment Temperature Control of the Fridge Compartment: This button is workable both in User Defined Mode as well as Super Mode. After entering the temperature control of the fridge compartment, this button flashes. By touching the key consecutively, the temperature would change in a circle of "2°C, 3°C, 4°C, 5°C, 6°C, 7°C, 8°C, after which 5-second flashing means the selection of temperature is settled.
3.2 Temperature Control of the Freezer Compartment This button is workable both in User Defined Mode as well as Holiday Mode. After entering the temperature control of the freezer compartment, the button flashes. By touching the button consecutively, the temperature would change in a circle from -14°C to -22°C, after which a 5-second flashing means the selection of temperature is settled.
3.3 Mode
By touching this button consecutively, the operation mode of the refrigerator will change in a circle of "ECO Mode-Holiday Mode-Super Mode-User Defined Mode. A 5-second flashing means the selection of temperature is settled
3.4 Press Button Short beep after per press button All buttons will only valid under unlock mode.
3.5 Lock / Unlock Press MODE button and hold for 3 seconds to lock other two buttons, then the LOCK icon will be at lock situation after a beep. To unlock, press MODE button and hold for 3 seconds, then LOCK icon will be at unlock situation after a beep. In unlock situation, all buttons are workable. If no any operation in 25 seconds, the display will be locked automatically. Keep press "MODE" button to unlock the display.
15
8VHULQWHUIDFH
4.0 ECO mode
Press MODE bottom to choose ECO mode. After 5 seconds of flash, ECO icon will keep bright and ECO mode is confirmed. In ECO mode, the refrigerator will automatically set temperature of fridge compartment at 5°C, as temperature of freezer compartment at -18°C. Except MODE button, other buttons will not response any press. Press MODE button to exit ECO mode.
4.1 Holiday Mode
Press MODE button to choose Holiday mode. After 5 seconds of flash, Holiday mode icon will keep bright and Holiday mode is confirmed. In Holiday mode, temperature of fridge will be set at 17°C. "FRIDGE" button will not response any press. Press "MODE" button to exit Holiday mode.
4.2 Super mode
Press MODE button to select Super mode. And it will be confirmed after 5 seconds of flash of Super icon. In Super mode, "FREEZER" button will not response any press. To exit Super mode, - Adjust mode by MODE button, - Or after 50 hours of Super mode, the refrigerator will automatically stop it and enter to
previous setting. Helpful hint: If you plan to freeze a large number food in one time, please set Super mode 24 hours ahead. Warning: In Super mode, the refrigerator will work hard. So the noise of refrigerator will be slightly higher than normal running.
5.0 Door Open Alarm
If fridge (upper) door keeps open for 60 seconds, periodical alarm will be arisen until the door is closed.
16
'DLO\8VH
First use
Cleaning the interior
Before using the appliance for the first time, wash the interior and all internal accessories with lukewarm water and some neutral soap so as to remove the typical smell of a brand new product, then dry thoroughly.
Important! Do not use detergents or abrasive powders, as these will damage the finish.
Daily use
Freezing fresh food
y The freezer compartment is suitable for freezing fresh food and storing frozen and deep-frozen food for a long time.
y Place the fresh food to be frozen in the bottom compartment. y The maximum amount of food that can be frozen in 24 hours is specified on the rating plate. y The freezing process lasts 24 hours: during this period do not add other food to be frozen.
Storing frozen food
When first starting-up or after a period out of use. Before putting the product in the compartment let the appliance run at least 2 hours on the higher settings. Important! In the event of accidental defrosting, for example the power has been off for longer than the value shown in the technical characteristics chart under "rising time", the defrosted food must be consumed quickly or cooked immediately and then re-frozen (after cooked).
Thawing
Deep-frozen or frozen food, prior to be used, can be thawed in the freezer compartment or at room temperature, depending on the time available for this operation. Small pieces may even be cooked still frozen, directly from the freezer. In this case, cooking will take longer.
Helpful hints and tips
Hints for freezing
To help you make the most of the freezing process, here are some important hints: y the maximum quantity of food which can be frozen in 24 hrs. is shown on the rating plate; y the freezing process takes 24 hours. No further food to be frozen should be added during this period; y only freeze top quality, fresh and thoroughly cleaned, foodstuffs; y prepare food in small portions to enable it to be rapidly and completely frozen and to make it possible
subsequently to thaw only the quantity required; y wrap up the food in aluminium foil or polythene and make sure that the packages are airtight; y do not allow fresh, unfrozen food to touch food which is already frozen, thus avoiding a rise in
temperature of the latter; y lean foods store better and longer than fatty ones; salt reduces the storage life of food; y water ices, if consumed immediately after removal from the freezer compartment, can possibly cause
the skin to be freeze burnt; y it is advisable to show the freezing in date on each individual pack to enable you removal from the
freezer compartment, can possibly cause the skin to be freeze burnt; y it is advisable to show the freezing in date on each individual pack to enable you to keep tab of the
storage time.
Hints for storage of frozen food
To obtain the best performance from this appliance, you should: make sure that the commercially frozen foodstuffs were adequately stored by the retailer; be sure that frozen foodstuffs are transferred from the food store to the freezer in the shortest possible time; not open the door frequently or leave it open longer than absolutely necessary. Once defrosted, food deteriorates rapidly and cannot be refrozen. Do not exceed the storage period indicated by the food manufacture.
Hints for fresh food refrigeration
To obtain the best performance: y Do not store warm food or evaporating liquids in the refrigerator y Do cover or wrap the food, particularly if it has a strong flavour
17
'DLO\8VH
Hints for refrigeration
Useful hints: y Make (all types): wrap in polythene bags and place on the glass shelves above the vegetable drawer. y For safety, store in this way only one or two days at the most. y Cooked foods, cold dishes, etc...: these should be covered and may be placed on any shelf. y Fruit and vegetables: these should be thoroughly cleaned and placed in the special drawer(s) provided. y butter and cheese: these should be placed in special airtight containers or wrapped in aluminum foil or
polythene bags to exclude as much air as possible. y Milk bottle: these should have a cap and should be stored in the balconies on the door. y Bananas, potatoes, onions and garlic, if not packed, must not be kept in the fridge.
Fresh Zone Temperature Control
y 7HPSHUDWXUH RI WKH IUHVK FDQ EH DGMXVWHG DFFRUGLQJ WR WKH W\SH RI VWRUDJH IRRG y 3XVK WKH NQRE XSZDUG IURP WKH ERWWRP WHPSHUDWXUH LQ WKH IUHVK ]RQH ZLOO EH JUDGXDOO\ GHFUHDVHG y :KHQ WKH NQRE LV SODFHG DW WKH &5,63(5 SRVLWLRQ WKH IUHVK ]RQH FDQ EH IXQFWLRQHG DV D
FULVSHU ]RQH DQG PDLQWDLQ WKH DSSURSULDWH WHPSHUDWXUH DQG KXPLGLW\ IRU IUXLWV DQG YHJHWDEOH y :KHQ WKH NQRE LV SODFHG DW WKH &+,//(5 SRVLWLRQ LW LV VXLWDEOH IRU VKRUWWHUP VWRUDJH RI ILVK RU RWKHU
IUHVK IRRG 7KH IRRG ZLOO NHHS IUHVK EXW QRW IUR]HQ ZKLFK PDNHV LW WKH EHVW FKRLFH IRU VWRULQJ IUHVK IRRG y 7LSV :KHQ \RX FKRRVH &+,//(5 IXQFWLRQ LW LV UHFRPPHQGHG WR VHW WKH UHIULJHUDWRU WHPSHUDWXUH
EHORZ & DQG SUHVHUYHG OHDGWLPH QR PRUH WKDQ GD\V LQ RUGHU WR NHHS WKH EHVW IUHVKQHVV
Cleaning
For hygienic reasons the appliance interior, including interior accessories, should be cleaned regularly. Caution! The appliance may not be connected to the mains during cleaning. Danger of electrical shock! Before cleaning switch the appliance off and remove the plug from the mains, or switch off or turn out the circuit breaker or fuse. Never clean the appliance with a steam cleaner. Moisture could accumulate in electrical components, danger of electrical shock! Hot vapors can lead to the damage of plastic parts. The appliance must be dry before it is placed back into service.
Important! Ethereal oils and organic solvents can attack plastic parts, e.g. lemon juice or the juice form orange peel, butyric acid, cleanser that contain acetic acid. y Do not allow such substances to come into contact the appliance parts. y Do not use any abrasive cleaners y Remove the food from the freezer. Store them in a cool place, well covered. y Switch the appliance off and remove the plug from the mains, or switch off or turn out the circuit breaker
of fuse. y Clean the appliance and the interior accessories with a cloth and lukewarm water. After cleaning wipe
with fresh water and rub dry. y After everything is dry place appliance back into service.
18
'DLO\8VH
;
<9
.
Troubleshooting
Caution! Before troubleshooting, disconnect the power supply. Only a qualified electrician of competent person must do the troubleshooting that is not in this manual. Important! There are some sounds during normal use (compressor, refrigerant circulation).
Problem
Appliance dose not work
Appliance freezes or cools too much
The food is not frozen enough.
Heavy build up of frost on the door seal.
Unusual noises
Possible cause
Solution
Mains plug is not plugged in or is loose
Fuse has blown or is defective
Socket is defective
Temperature is set too cold or the appliance runs at Super modes. Temperature is not properly adjusted. Door was open for an extended period. A large quantity of warm food was placed in the appliance within the last 24 hours. The appliance is near a heat source.
Door seal is not air tight.
Appliance is not level.
Insert mains plug.
Check fuse, replace if necessary.
Mains malfunctions are to be corrected by an electrician.
Turn the temperature regulator to a warmer setting temporarily.
Please look in the initial Temperature Setting section. Open the door only as long as necessary.
Turn the temperature regulation to a colder setting temporarily.
Please look in the installation location section. Carefully warm the leaking sections of the door seal with a hair dryer (on a cool setting). At the same time shape the warmed door seal by hand such that it sits correctly.
Re-adjust the feet.
The appliance is touching the wall or other objects.
A component, e.g. a pipe, on the rear of the appliance is touching another part of the appliance or the wall.
Move the appliance slightly.
If necessary, carefully bend the component out of the way.
*
,A
If the malfunction shows again, contact the Service Center. These data are necessary to help you quickly and correctly. Write the necessary data here, refer to the rating plate.
19