Instruction Manual for LIGHTLAND models including: RM0831MC-A-L Rishang CCT 10Wm 900Lm 27005700K, RM0831MC-A-L, Rishang CCT 10Wm 900Lm 27005700K, 10Wm 900Lm 27005700K, 900Lm 27005700K, 27005700K
RM0831MC-A-L Rishang CCT 10W/m 900Lm 2700/5700K
Linear Lighting RM0831MC-A-L 544 Chips/m-24V-8mm COB Dimmable White Flexible Strip (Double wires solution) Technical Application Guide Version: 7.0 Issued on: Feb 2nd , 2024 RM0831MC-A-L 544 Chips/m-24V-8mm COB Dimmable White Flexible Strip 544 Chips/m-24V-8mm COB 10W/m Dimmable White Flexible LED Strips, constant voltage. Suitable for furniture or other decorative lighting application. COB Dimmable white dot-free broad beam angle · The chip is directly welded on the FPC, with a simple structure and high reliability. · Large beam angle, up to 135 °. · Good heat dissipation, low light attenuation, and long lifespan. · Anti-vulcanization and anti-oxidation. · Small wafer size. FPC Pure copper flexible printed circuit board, reliable quality. ADHESIVE TAPE High thermal conductivity and resistance to harsh environments for easy and robust mounting. Reliability Category IP grade test Safety test Environmental test Item Waterproof test Reference Standards GB/T 4208IEC 60529 Dustproof test Flame retardant test Hi-Low temperature cycle test Thermal shock Hi-temperature storage test Low-temperature storage test Hi-temperature & HiHumidity Life UV test GB/T 4208IEC 60529 GB7000.1IEC 6059801 GB/T 2423.22IEC 60068-2-14 GB/T 2423.22IEC 60068-2-14 GB/T 2423.3IEC 60068-2-78 GB/T 2423.1IEC 60068-2-1 GB/T 2423.2IEC 60068-2-2 GB/T 16422.3ISO 4892-3 Test Conditions 25±2 @65%RH 25±2 @65%RH 25±2 @65%RH -40@30mins 25@5mins 85@30mins 25@5mins -40@30mins; 168 hours -4070 100 circles Ta=80 Ta=-40 Ta=70 @ RH=90% 50±3,10±5%RH,Exposed at radiation 5 hours, spaying water 1 hour in 20±3,4 circles Result IP20 IP65 IP67 Pass Pass Pass Pass Pass Pass Pass Copyright RISHANGOPTOELECTRONICS CO.,LTD. All Rights Reserved Rev: 7.0 RM0831MC-A-L 544 Chips/m-24V-8mm COB Dimmable White Flexible Strip 544 Chips/m-24V- 8mm 2700K ~ 5700K year warranty P/N RM0831MC-A-L Dimensions (L x W x H) 5000*8*1.7mm 196.9*0.31*0.07inch Cutting unit (L2) 29.4mm 1.16inch Number of Chips 544 /m 166/ft Unit: mm[inch] A: 8 [0.31] L1: 29.4 [1.16] Protection Level Protection Level: Available IP 20 Nonprotective IP 54 Silicone Spray IP 54 Gel Coating IP 65 Silicone Spray IP 65 Silicone Tube IP 67 Silicone Filling IP 68 Silicone Extrusion Basic Parameters P/N LED Color CCT (K) WL (nm) Working current (mA) Power (W/m) CRI Beam Angle(°) Luminous Flux Lm/m Luminous Efficacy Lm/W Working voltage (V DC) 1m[39.37in] 1m[39.37i n] Warm white 2700 >90 135° 750 75 RM0831MC- A-L Cool white 5700 >90 135° 900 90 24 417 10 24 417 10 P/N Qty (m/reel) RM0831MC-A-L 5 Qty (m/carton) 500 Total Qty (m) 500 Total weight (Kg) 11.5 (lb) 25.35 length (mm) (inch) 425 16.73 Outer carton width (mm) (inch) 325 12.79 height (mm) (inch) 325 12.79 P/N IP Grade Operating Temperature () ( ) Storage Temperature () ( ) Standard length (m) (inch) Max. cascading length (m) (inch) Chip Qty (pcs) Weight (g/m) (lb/m) RM0831MC-A-L IP20 -25~ -13~ -25~ -13~ 5 196.9 5 196.9 544 19 +60 +140 +70 +158 0.042 Copyright RISHANGOPTOELECTRONICS CO.,LTD. All Rights Reserved Rev: 7.0 RM0831MC-A-L 544 Chips/m-24V-8mm COB Dimmable White Flexible Strip Profile Drawings Unit: mm [inch] Light Distribution WARM WHITE AVERAGE BEAM ANGLE(50%): 136.2 DEG Optional Parts: COLD WHITE AVERAGE BEAM ANGLE(50%): 134.6 DEG Category Part Name Figure Specifications/Description Article Number Color IP Grade Snap-fit joints Snap-fit joints Connector Connector Terminal Connector Connector Connector Snap-fit joints /23.5*4*2mm/QJ-KZ-10 (equipped with screws) 207-076 / / 10mm width, single color, IP20 COB strips/ board-board connector /13.5*11.5*4.9mm/PVC/HR-S-SC-2PIN- 1CN-07208 / / 10MM-A 10mm width, single color, IP20 COB strips/cable-board connector/13.5*11.5*5.7mm/PVC/HR-S-SC- 1CN-07207 / / 2PIN-10MM-D Connector /cable-cable /25*6.7*6.65mm/1P/QJXC-JXD-D1 1CN-07065 / / Connector / cable-cable /25*10.6*6.65mm/2P/QJ-XC-JXD-H2 1CN-07066 / / Connector Connector / cable-cable /25*12.8*6.65mm/1P/QJ-XC-JXD-T1/ 1CN-07067 / / Connector Connector / cable-cable /28.6*16.6*6.65mm/2P/QJ-XC-JXD-T2/ 1CN-07068 / / Connector Connector / cable-cable /22*9.5*6mm/2P/QJXC-JXD-D2/ 1CN-07069 / / Copyright RISHANGOPTOELECTRONICS CO.,LTD. All Rights Reserved Notes / / / / / / / / Rev: 7.0 RM0831MC-A-L 544 Chips/m-24V-8mm COB Dimmable White Flexible Strip Packaging Diagram Reel the LED strip Connection Instruction Put into the antistatic bag Seal the carton Power Adapter AC INPUT:220V DC OUTPUT:24V Dual-color temperature dimmer Parts & Tools The positive terminal is red wire, negative terminals are white and yellow in sequence. MAX5m Led Strip Installation Steps Electrical Drill & Drilling bit Scissor Make sure the mounting surface is clean before installation. Calculate the needed length and cut off the extra length along the cutting mark if necessary. If wires are needed, please weld them at the next location with a printed mark. While sticking strips, peel off the release paper of the tape step by step. Don't peel off all at a time to avoid getting your strip in a mess. Notes: No pressing the LED! Copyright RISHANGOPTOELECTRONICS CO.,LTD. All Rights Reserved Rev: 7.0 RM0831MC-A-L 544 Chips/m-24V-8mm COB Dimmable White Flexible Strip Installation Steps Stick Mylar tape to isolate the cutting position from the bottom of profile inner slot to avoid short-circuit. Installation Attention The installation at the corner is shown as the figure. Notes: No bending it into right angle; No twisting it to stick on the mounting surface. Connect strip wires to the output terminal of the power supply, and dispose with waterproof, insulation, short-circuit, and anticorrosion protection at wire joints and cut section of your strip (if any). Do not twist the strip. Do not wind the strip with a diameter <5cm. Copyright RISHANGOPTOELECTRONICS CO.,LTD. All Rights Reserved Rev: 7.0 RM0831MC-A-L 544 Chips/m-24V-8mm COB Dimmable White Flexible Strip Troubleshooting Malfunctions All LEDs Stopped Working Part of LEDs Stopped Working LEDs Too Weak or Uneven LEDs Flickering Possible Causes Solutions The power supply did not connect to power grid. Power on. Broken-circuit or Short-circuit. The wires of strips connect to the power supply terminal reversely. Part of power supplies have output failure. Part of wires of strips have breakdown. Reverse connection of polarity. Overloaded power supply. Troubleshoot the problems and power on again. Check the connection and ensure the polarity of the wires is connected correctly. Check the power supply system. Correct connection. Replace it with a powerful one. Excessive power loss of the circuit or the power loss of each circuit differs a lot. Excessive cascading qty in series. Exposed or loose joints of wires. Failures in power supply. Ensure working voltage of strips is within±5%V of rated voltage. 1. Shorten the length of wires between the first strip and power supply or replaced with wires with larger diameter. 2. Ensure the cascading qty of each circuit does not exceed the allowed range and is well distributed. Adjust the cascading qty for strip to ensure the qty for each electrical circuit is within the maximum cascading qty. Find out and tackle malfunction immediately. Replace it with a new one. Declaration · If the external flexible cable is damaged, please replace it from its manufacturer, service agent, or qualified person to avoid a hazard. · For the specific installation and cautions, please refer to the user manual. · The given data in this specification is based on our standard product. There may exist slight difference compared with actual products. · All Illustrations in this specification are for reference only. · This product is subject to change or modification without prior notice. · RISHANG OPTOELECTRONICS CO., LTD. Reserves the right of a final explanation for this specification. Revision History Version V7.0 Revised by Wei Fan Song Copyright RISHANGOPTOELECTRONICS CO.,LTD. Revised item first release Release date Feb.2.2024 All Rights Reserved Rev: 7.0WPS 演示