Viking Range, LLC
Instruction Manual for Lynx models including: LIJPB Insulated Jacket for LPB Side Burner, LIJPB, Insulated Jacket for LPB Side Burner, Jacket for LPB Side Burner, Side Burner
LIJPB by Lynx - Insulated Jacket for LPB Side Burner (LIJPB) | Keith's Appliances
LIJPB by Lynx - Insulated Jacket for LPB | Top Line Appliance Center
File Info : application/pdf, 8 Pages, 117.95KB
DocumentDocumentInstallation MANUAL Insulated Jacket For Outdoor Products VIJ5301 VIJ5361 VIJ5421 VIJ5541 VIJSB2 VIJPB LIJ27 LIJ30 LIJ36 LIJ42 LIJ54 LIJSB2 LIJPB 1 IMPORTANT: Before you build the frame, you must take into consideration the total weight of the liner, grill and any finishing materials. Refer to the cutout dimension table for the proper framing dimensions for the insulation jacket. Determine the entry point for both the gas inlet and electrical connections. Make the 4" square holes for gas and electrical connections (rear or bottom access) based on your requirements. Note: that the electrical connections are located on the left side and the gas connections are located on the right side. A Carpenter's "spirit level" should be used to assure that the framing is level, both front to back and side to side. Note: Never under any circumstance should you install the transformer or run a quick disconnect hose inbetween the grill and the inside of the insulating jacket. Liner Installation Position the liner into the frame. No part of the combustible enclosure can protrude above the top surface or in front of the face surface of the liner. Shim the liner if necessary. Cutout Dimensions Model LIJ27 VIJ5301 / LIJ30 VIJ5361 / LIJ36 VIJ5421 / LIJ42 VIJ5541 / LIJ54 VIJSB2 / LIJSB2 VIJPB / LIJPB A B 33" (83.8 cm) 5" (12.7 cm) 36" (91.4 cm) 5" (12.7 cm) 42" (106.7 cm) 5" (12.7 cm) 48" (121.9 cm) 5" (12.7 cm) 60" (152.4 cm) 5" (12.7 cm) 15 ½" (39.4 cm) 3 ½" (8.9 cm) 26 ¼" (68.0 cm) 5 3/8" (13.7 cm) C 23 ¾" (60.3 cm) 26 ½" (67.3 cm) 23 ¾" (60.3 cm) 26 ½" (67.3 cm) 26 ½" (67.3 cm) 26 ½" (67.3 cm) 23 7/8" (62.7 cm) D E F 4 ½" (11.4 cm) 3" (7.6 cm) 11 5/8" (29.5 cm) 4 ½" (11.4 cm) 3" (7.6 cm) 11 5/8" (29.5 cm) 4 ½" (11.4 cm) 3" (7.6 cm) 11 5/8" (29.5 cm) 4 ½" (11.4 cm) 3" (7.6 cm) 11 5/8" (29.5 cm) 4 ½" (11.4 cm) 3" (7.6 cm) 11 5/8" (29.5 cm) 4 ¾" (12.1 cm) 3 1/8" (8.0 cm) 11 5/8" (29.5 cm) 4 ¾" (12.1 cm) 3 1/8" (8.0 cm) 11 5/8" (29.5 cm) 4" square holes for gas and electrical A C connections (rear or bottom access). Make these holes in the frame based on your requirements B D E F 2 Grill Installation Use the proper equipment to support the grill. Place the grill into the liner and engage it over the liner lip across the back and sides. The liner is designed to support the grill without additional fasteners. If desired any gap remaining between the liner and the combustible enclosure may be filled with a non-combustible sealant or caulk. WARNING The regulator to be installed outside the insulating jacket. It can be positioned anywhere in the gas supply line between the grill and the shuto valve. Gas tubing should never be installed within the insulated jacket. After installing grill to the insulated jacket, replace the 2 screws on both side of the grill with the included 1" screws, one screw at a time. This is to straighten out the sides of the insulated jacket and reduce the gap to the cabinet. 3 Insulated Jacket Dimensions LIJ27 3-1/4" (8.3 cm) 26-1/4" (66.7 cm) TOP VIEW 32-3/4" (83.2 cm) 3-1/4" (8.3 cm) 26-3/8" (67.0 cm) 3-1/4" (8.3 cm) 11-5/8" (29.5 cm) 26-1/4" (66.7 cm) FRONT VIEW 32-3/4" (83.2 cm) 3-1/4" (8.3 cm) 25" (63.5 cm) 13/16" (2.1 cm) SIDEVIEW 26-3/8" (67.0 cm) 1-3/8" (3.5 cm) 11-5/8" (29.5 cm) VIJ5301 / LIJ30 3-1/4" (8.3 cm) 29-1/4" (74.3 cm) TOP VIEW 35-3/4" (90.8 cm) 3-1/4" (8.3 cm) 26-3/8" (67.0 cm) 3-1/4" (8.3 cm) 11-5/8" (29.5 cm) 29-1/4" (74.3 cm) FRONT VIEW 35-3/4" (90.8 cm) 3-1/4" (8.3 cm) 25" (63.5 cm) 13/16" (2.1 cm) SIDEVIEW 26-3/8" (67.0 cm) 4 1-3/8" (3.5 cm) 11-5/8" (29.5 cm) VIJ5361 / LIJ36 3-1/4" (8.3 cm) 35-1/4" (89.5 cm) TOP VIEW 41-3/4" (106.0 cm) 3-1/4" (8.3 cm) 23-5/8" (60.0 cm) 3-1/4" (8.3 cm) 11-5/8" (29.5 cm) 35-1/4" (89.5 cm) FRONT VIEW 41-3/4" (106.0 cm) 3-1/4" (8.3 cm) 13/16" (2.1 cm) 22-1/4" (56.5 cm) SIDEVIEW 23-5/8" (60.0 cm) 1-3/8" (3.5 cm) 11-5/8" (29.5 cm) VIJ5421 / LIJ42 3-1/4" (8.3 cm) 41-1/4" TOP VIEW (104.8 cm) 47-3/4" (121.3 cm) 3-1/4" (8.3 cm) 26-3/8" (67.0 cm) 3-1/4" (8.3 cm) 11-5/8" (29.5 cm) 41-1/4" (104.8 cm) FRONT VIEW 47-3/4" (121.3 cm) 3-1/4" (8.3 cm) 13/16" (2.1 cm) 5 25" (63.5 cm) SIDEVIEW 26-3/8" (67.0 cm) 1-3/8" (3.5 cm) 11-5/8" (29.5 cm) VIJ5541 / LIJ54 3-1/4" (8.3 cm) 53-1/4" (135.3 cm) TOP VIEW 59-3/4" (151.89 cm) 3-1/4" (8.3 cm) 26-3/8" (67.0 cm) 3-1/4" (8.3 cm) 11-5/8" (29.5 cm) 53-1/4" (135.3 cm) FRONT VIEW 59-3/4" (151.89 cm) 3-1/4" (8.3 cm) 13/16" (2.1 cm) 25" (63.5 cm) SIDEVIEW 26-3/8" (67.0 cm) 1-3/8" (3.5 cm) 11-5/8" (29.5 cm) 6 VIJSB2 / LIJSB2 15-1/4" (38.7 cm) 26-3/8" (67.0 cm) TOP VIEW 1-1/4" (3.2 cm) 12-3/4" (32.4 cm) 1-1/4" (3.2 cm) 11-1/4" (28.6 cm) FRONT VIEW 1-1/8" (2.9 cm) VIJPB / LIJPB 15-1/4" (38.7 cm) 23-3/4" (60.3 cm) 25-1/8" (63.8 cm) SIDEVIEW 26-3/8" (67.0 cm) 26" (66.0 cm) TOP VIEW 13/16" (2.1 cm) 11-5/8" (29.5 cm) 3-1/4" (8.3 cm) 19-1/2" (49.5 cm) 3-1/4" (8.3 cm) 11-1/4" (28.6 cm) FRONT VIEW 1-1/8" (2.9 cm) 19-1/2" (49.5 cm) 7 22-1/2" (57.2 cm) SIDEVIEW 23-3/4" (60.3 cm) 13/16" (2.1 cm) 11-5/8" (29.5 cm) Viking Range, LLC 111 Front Street Greenwood, Mississippi 38930 USA (662) 455-1200 For product information, call 1-888-(845-4641) or visit our web site at vikingrange.com 072267-000D EN (011524)