Instruction Manual for POLAR models including: SRF-781HP, CD080-A, CD081-A, CD082-A, CD083-A, CD084-A, CD085-A, CD610-A, CD611-A, CD612-A, CD613-A, CD614-A, CD615-A, CD086-A, CD087-A, CD088-A, CB921-A, GL185-A, CD080-A Series Solid Door Upright Freezer, CD080-A Series, Solid Door Upright Freezer, Door Upright Freezer, Upright Freezer, Freezer
Panasonic Solid Door Upright Freezer 598L - SRF-781HP
Polar C-Series Upright Freezer Stainless Steel 600Ltr CD085-A
File Info : application/pdf, 10 Pages, 636.74KB
DocumentDocument600 / 400 / 150 litre series Refrigerators/Freezers Instruction manual Model: CD080-A/CD081-A/CD082-A/CD083-A/CD084-A/CD085-A/CD610-A/CD611-A/CD612-A/ CD613-A/CD614-A/CD615-A/CD086-A/CD087-A/CD088-A/CB921-A/GL185-A $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOEC EN Telephone Helpline: 1300225960 Safety Instructions · DO NOT allow oil or fat to · Position on a flat, stable come into contact with the surface. plastic components or door · A service agent/qualified seal. Clean immediately if technician should carry out contact occurs. installation and any repairs · DO NOT store products on if required. Do not remove top of the appliance. any components or service · Bottles that contain a high panels on this product. percentage of alcohol - In Queensland the must be sealed and placed service agent/qualified vertically in the refrigerator. technician MUST hold a · Always carry, store and Gas Work Authorisation or handle the appliance in a License for hydrocarbon vertical position and move refrigerants if the by holding the base of the appliance gas system is appliance. being opened or charged. · Always switch off and · Consult Local and National disconnect the power supply Standards to comply with the to the unit before cleaning. following: · Keep all packaging away - Health and Safety at Work from children. Dispose of Legislation the packaging in accordance - Fire Precautions with the regulations of local - Wiring Regulations authorities. - Building Regulations · If the power cord is damaged, · DO NOT use jet/pressure it must be replaced by a POLAR washers to clean the agent or a recommended appliance. qualified technician in order to · DO NOT use the appliance avoid a hazard. outside. · Children should be · DO NOT use this appliance supervised to ensure that to store medical supplies. they do not play with the appliance. 2 $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOEC Telephone Helpline: 1300225960 AENU · This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience or knowledge, unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety. · POLAR recommend that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity and Functional Testing. Caution Risk of Fire · Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance. Warning: Keep all ventilation openings clear of obstruction. Unit should not be boxed in without adequate ventilation. · To comply with AS/NZS 60079.10.1:2009: Ensure there are not sources of ignition in any area where refrigerant could gather in the event of a leak. · Electrical equipment should not be placed under the vent or where refrigerant could gather in the event of a leak. · Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer. · Warning: Do not damage the refrigerant circuit. · Warning: Do not use electrical appliances inside the food storage compartments of the appliance. Product Description · CD080-A - 150 litre Refrigerator · CD081-A - 140 litre Freezer · CD082-A - 400 litre Refrigerator · CD083-A - 365 litre Freezer · CD084-A - 600 litre Refrigerator · CD085-A - 600 litre Freezer · CD086-A - 150 litre Glass-Door Refrigerator · CD087-A - 400 litre Glass-Door Refrigerator · CD088-A - 600 litre Glass-Door Refrigerator · CD613-A - 365 litre Freezer · CD614-A - 600 litre Refrigerator · CD615-A - 600 litre Freezer · CD610-A - 150 litre Refrigerator · CD611-A - 140 litre Freezer · CD612-A - 400 litre Refrigerator · GL185-A - 522 litre Bakery Refrigerator · CB921-A - 365 litre Glass-Door Freezer 3 $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOEC EN Telephone Helpline: 1300225960 Introduction Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product. Pack Contents The following is included: · POLAR Refrigerator / Freezer · Shelves - Refrigerator only CD610-A/ CD080-A x 3/ CD086-A x 3 CD612-A/ CD082-A x 4 / CD087-A x 4 CD614-A x 4 / CD084-A / CD088-A x 4 · Tray Guides - Bakery refrigerator only GL185-A x 12 · Keys x 2 · Spacers x 2 · Instruction Manual POLAR prides itself on quality and service, ensuring that at the time of unpacking the contents are supplied fully functional and free of damage. Should you find any damage as a result of transit, please contact your POLAR dealer immediately. Installation Note: A bracket is used to support the door during transportation. On receipt please remove the bracket. Note: Not for use in vans or trailers, food trucks or similar vehicles. If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before operation. If in doubt allow to stand. 1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces. 2. To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between the unit and walls and other objects, with a minimum 20cm clearance on the top. NEVER LOCATE NEXT TO A HEAT SOURCE. Note: Before using the appliance for the first time, clean the shelves and interior with soapy water then dry well. The appliance is supplied with feet by default. However, castors can be supplied as an option from serial number range: 8128595-AU onwards. Reversing the door (Excluding model CB921-A) Depending on the location of the appliance, it may be necessary to change the direction the door opens by changing the side of the door handle. (Tip: Images in this section are for illustration only and may slightly differ from the actual appliance appearances.) To reverse the door handle: 1. The door handle is on the left side. Disassemble the right lower hinge. Door handle 4 $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOEC Telephone Helpline: 1300225960 AENU 2. Remove the door from the right upper hinge. Then remove the hinge sleeve from the door top. 4. Reverse the door and hang it onto the left upper hinge. Door handle 3. Remove the right upper hinge and install it on the left side. Afterwards, install the hinge sleeve onto the hinge. 5. Remove the pre-mounted screws on the left lower side. $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOEC 5 EN 6. Install the previously removed right lower hinge on the left side. Telephone Helpline: 1300225960 Operation Control Panel The control panel is located on the front of the appliance. 7. Secure the hinge in place using the previously removed screws. 8. Now the door handle is installed on the right side. Turn On 1. Close the door of the appliance. 2. Connect the appliance to a mains power supply. Set the Operating Temperature 1. Press the SET button for 3 seconds. The display will flash. 2. Press the or buttons to display the required temperature. 3. Press the SET button to store the temperature. Manual Defrost Press and hold the defrost button "aux" for 2 seconds to begin a manual defrost. The defrost light illuminates. Storing Food To get the best results from your POLAR appliance, follow these instructions: · Only store foodstuffs in the appliance when it has reached the correct operating temperature. · Do not place uncovered items as below inside the appliance, as this can lead to a damaged and leaking evaporator, and thus void your warranty: hot food, hot liquids, acidic fluids, acidic products. · Wrap or cover food where possible. · Do not obstruct the fans inside the appliance. · Avoid opening the doors for prolonged periods of time. Lock/Unlock the Doors · A lock is fitted to the doors to ensure foodstuffs are kept secure within your POLAR appliance. · Use the keys provided to lock/unlock the door. 6 $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOEC Telephone Helpline: 1300225960 AENU Cleaning, Care & Maintenance · Switch off and disconnect from the power supply before cleaning. · Clean the interior of the appliance as often as possible. · Do not use abrasive cleaning agents. These can leave harmful residues. · Clean the door seal with warm soapy water. · Always wipe dry after cleaning. · Do not allow water used in cleaning to run through the drain hole into the evaporation pan. · Take care when cleaning the rear of the appliance. Sharp edges can cut. Condensation and ice will form with frequent and prolonged opening of the doors. Operating outside of the recommend temperature range and placing next to a heat source will also increase the amount of ice and internal/external condensation. If external condensation occurs wipe the surface down with a cloth. Excessive ice will result in longer running times that will increase energy consumption and increase the deterioration of components. Cleaning the Condenser Periodically cleaning the condenser can extend the life of the appliance. POLAR recommend that a POLAR agent or qualified technician should clean the condenser. Troubleshooting A qualified technician must carry out repairs if required. Fault Probable Cause Solution The appliance is The unit is not switched on not working Check the unit is plugged in correctly and switched on Plug or lead is damaged Replace Plug or lead Mains power supply fault Check mains power supply The appliance Too much ice on the evaporator turns on, but the temperature is too Condenser blocked with dust high/low Doors are not shut properly Appliance is located near a heat source or air flow to the condenser is being interrupted Defrost the appliance Clean the condenser Check doors are shut and seals are not damaged Move the refrigerator to a more suitable location Ambient temperature is too high Increase ventilation or move appliance to a cooler position Unsuitable foodstuffs are being Remove any excessive hot foodstuffs or blockages stored in the appliance to the fan Appliance is overloaded Reduce the amount of food stored in the appliance The appliance is The appliance is not properly leaking water levelled Adjust the screw feet to level the appliance (if applicable) The discharge outlet is blocked Clear the discharge outlet 7 $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOEC EN Fault The appliance is leaking water The appliance is unusually loud The lamp does not illuminate Telephone Helpline: 1300225960 Probable Cause Solution Movement of water to the drain is Clear the floor of the appliance (if obstructed applicable) The water container is damaged Call POLAR agent or qualified Technician Loose nut/screw Check and tighten all nuts and screws The appliance has not been installed in a level or stable position Check installation position and change if necessary Lamp needing replacing Call POLAR agent or qualified Technician Technical Specifications Note: Due to our continuing program of research and development, the specifications herein may be subject to change without notice. Model Voltage Power Current Temperature Range CD610-A CD080-A CD611-A CD081-A 220240V~ 50Hz 100W 105W 0.7A 0.8A -2°C ~ +8°C -10°C ~ -25°C Gross Capacity (L) 150 Net usable capacity (L) Refrigerant Dimensions H x W x D mm Weight (kg) 64 R600a 855 x 600 x 44 595 140 78 R600a 855 x 600 x 44.5 595 CD612-A CD082-A 130W 0.8A -2°C ~ +8°C 400 238 R600a 1855 x 600 x 69 595 CD613-A CD083-A 150W 0.9A -10°C ~ -25°C 365 258 R600a 1855 x 600 x 71 595 CD614-A CD084-A 130W 0.9A -2°C ~ +8°C 600 419 R600a 1895 x 777 x 90 705 CD615-A CD085-A 300W 1.4A -10°C ~ -25°C 600 469 R600a 1890 x 777 x 94 705 GL185-A 130W 0.9A -2°C ~ +8°C 522 410 R600a 1720 x 777 x 90 725 CD086-A 105W 0.7A 2°C ~ 8°C 150 118 R600a 855 x 600 x 47 619 CD087-A 130W 0.8A 2°C ~ 8°C 400 246 R600a 1855 x 600 x 72 620 CD088-A 130W 0.9A 2°C ~ 8°C 600 414 R600a 1890 x 777 x 93 730 CB921-A 380W 2.5A -10°C ~ -25°C 365 340 R290 1855 x 600 x 76 620 Note: For optimal product performance and efficiency, please ensure to mind the net usable capacity (load limit) when filling. 8 $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOEC Telephone Helpline: 1300225960 AENU Electrical Wiring The plug is to be connected to a suitable mains socket. POLAR appliances are wired as follows: · Live wire (coloured brown) to terminal marked L · Neutral wire (coloured blue) to terminal marked N · Earth wire (coloured green/yellow) to terminal marked E This appliance must be earthed. If in doubt consult a qualified electrician. Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required they must be readily accessible. Compliance The WEEE logo on this product or its documentation indicates that the product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area. POLAR parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent, and federal authorities. POLAR products have been approved to carry the following symbol: All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR. Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to change specifications without notice. $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOEC 9 DocuSign Envelope ID: 16D88D10-7CC2-41A3-BAFE-78DCE2D74A26 DECLARATION OF CONFORMITY · Conformiteitsverklaring · Déclaration de conformité · Konformitätserklärung · Dichiarazione di conformità · · Declaración de conformidad Equipment Type · Uitrustingstype · Type d'équipement · Gerätetyp · Tipo di apparecchiatura · Tipo de equipo C-Series Fridge C-Series Freezer C-Series Display 1. Stainless Steel Under 7.Stainless Steel Under 13.White Under Counter Fridge Counter 150Ltr Counter 140Ltr 150Ltr 2. Stainless Steel Upright 8.Stainless Steel Upright 365Ltr 14.White Upright Fridge 400Ltr 400Ltr 9.Stainless Steel Upright 600Ltr 15.White Upright Fridge 600Ltr 3. Stainless Steel Upright 10.White Under Counter 16.White Upright Freezer 600Ltr 140Ltr 365Ltr 4. White Under Counter 11.White Upright 365Ltr 150Ltr 12.White Upright 600Ltr 5. White Upright 400Ltr 6. White Upright 600Ltr Application of Territory Legislation & Machinery Directive 2006/42/EC Council Directives(s) Supply of Machinery (Safety) Regulations 2008 Toepassing van Europese Richtlijn(en) · EN 60335-1:2012 +A11:2014 +A13:2017 +A1:2019 Application de la/des directive(s) du +A14:2019 +A2:2019* Conseil · Anwendbare EU-Richtlinie(n) · EN 60335-2-89:2010 +A1:2016 +A2:2017 Applicazione delle Direttive EN 62233:2008 · Aplicación de la(s) directiva(s) del Electro-Magnetic Compatibility (EMC) Directive consejo 2014/30/EU - recast of 2004/108/EC Electromagnetic Compatibility Regulations 2016 (S.I. 2016/1091) EN 55014-1: 2017 EN 55014-2:2015 EN 61000-3-2: 2014 EN 61000-3-3: 2013 Regulation (EU) 2015/1095 - Ecodesign professional refrigerators EN 16825: 2016 +A1:2019 Regulation (EU) 2019/2024 - Ecodesign direct sales refrigerators ISO 23953-2:2015 Restriction of Hazardous Substances Directive (RoHS) 2015/863 amending Annex II to Directive 2011/65/EU Restriction of the Use of Certain Hazardous *CB921 (&-E) EN60335-1:2012 +A11:2014 +A13:2017 only Substances in Electrical and Electronic Equipment Regulations 2012 (S.I. 2012/3032) Producer Name · Naam fabrikant · Nom du producteur · Name des Herstellers · Nome del produttore · Nombre del fabricante Model · Modèle · Modell · Modello · Modelo 1.CD080 7.CD081 13.CD086 2.CD082 8.CD083 14.CD087 3.CD084 9.CD085 15.CD088 4.CD610 10.CD611 16.CB921 5.CD612 11.CD613 6.CD614 12.CD615 (including -E & -A models) Electrical Safety IEC 60335-1:2010 +A1:2013 +A2:2016 IEC 60335-2-89:2010 +A1:2012 +A2:2015 Electromagnetic Compatibility EN 55014-1: 2017 EN 55014-2:2015 EN 61000-3-2: 2014 EN 61000-3-3: 2013 Polar I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s) and Standard(s). Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande Richtlijn(en) en Standaard(en). Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und Norm(en) entspricht. Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati. El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y estándar(es) arriba mencionadas. Date · Data · Date · Datum · Data · Fecha · Data Signature · Handtekening · Signature · Unterschrift Firma · Firma 21st April 2022 Full Name · Volledige naam · Nom et prénom · Vollständiger Name · Nome completo · Nombre completo Ashley Hooper Eoghan Donnellan Brendan Denmeade Position · Functie · Fonction · Position · Technical & Quality Qualifica · Posición Manager Commercial Manager/ Importer Commercial Manager/ Responsible Supplier Producer Address · Adres fabrikant · Adresse du producteur · Anschrift des Herstellers · Indirizzo del produttore · Dirección del fabricante Fourth Way, Avonmouth, Bristol, BS11 8TB United Kingdom Unit 9003, Blarney Bus. Park, Blarney, Co. Cork Ireland 15 Bagdally Road, Campbelltown NSW 2560 $%"UP$%"@$%"UP$%"@$#"@(-"@"@W@JOECmacOS Version 13.1 (Build 22C65) Quartz PDFContext Adobe InDesign 18.1 (Macintosh)