Instruction Manual for GE APPLIANES models including: PGS930, 30-Inch Smart Slide-In Gas Range
(A) Soft blue flames— Normal for natural gas (B) Yellow tips on outer cones— Normal for propane gas PROPANE CONVERSION INSTRUCTIONS 31-2000756 Rev. 0 05-20 GEA
Nov 6, 2020 —
C. Remove the propane orifices from the box provided. The propane orifices have the letter ³L严 on the top. To aid in identifying the proper location for ...
PROPANE CONVERSION INSTRUCTIONS
WARNING
Explosion Hazard
Death or serious injury can result from failure to follow
these instructions.
6HUYLFHE\DTXDOLILHGVHUYLFHWHFKQLFLDQRQO\
6KXWRIIJDVVXSSO\DQGGLVFRQQHFWSRZHUEHIRUHVHUYLFLQJ
5HFRQQHFWDOOJURXQGLQJGHYLFHVDIWHUVHUYLFH
· Replace all parts and panels before operating.
7KHSUHVVXUHUHJXODWRUDQGWKHEXUQHURUL¿FHVDUHVHWIRU natural gas. To use propane gas, the regulator and burner
RUL¿FHVPXVWEHFRQYHUWHG
WARNING
'RQRWRSHUDWHWKHFRRNWRSRURYHQ EXUQHUVRIWKLVUDQJHZKHQXVLQJSURSDQHERWWOHG JDV EHIRUHFRQYHUWLQJWKHSUHVVXUHUHJXODWRUDQGEXUQHURUL¿FHV for propane gas use. Failure to do so could cause high ÀDPHVDQGWR[LFIXPHVZKLFKFDQUHVXOWLQVHULRXVLQMXU\
7KHSURSDQHRUL¿FHVIRUWKHFRRNWRSEXUQHUVDUHVKLSSHGRQ the back of the range in the location shown.
3URSDQH&RQYHUVLRQ.LW
TOOLS REQUIRED:
· Adjustable wrench · Socket wrench with
1/2" socket and extension · 3KLOOLSVKHDGVFUHZGULYHU
· )ODWEODGHGVFUHZGULYHU EODGHDSSUR[LPDWHO\ ´DFURVV
· 1XWGULYHUV´´ or 7mm
To adjust your range for use with propane gas, follow these instructions:
1. Disconnect all electrical power, at the main circuit breaker or fuse box.
6KXWRWKHJDVVXSSO\WRWKHUDQJHE\FORVLQJWKHPDQXDO VKXWRYDOYH
CONVERTING THE PRESSURE REGULATOR
5HPRYHWKHGUDZHUDQGSDQHOEHKLQGGUDZHU7KHSUHVVXUH regulator is located in the lower, left hand rear corner of the UDQJHDVYLHZHGIURPWKHIURQW
3UHVVXUH5HJXODWRU
*DV9DOYH
1. Use an adjustable wrench to unscrew the hex-nut cap from the pressure regulator.
& RPSOHWHO\UHPRYHWKHSURWHFWLYHSODVWLFFDSRWKH threaded metal cap.
Rotate cap counter-
clockwise to loosen
NAT
PROPANE
Cap assembly
Regulator 7 XUQWKHPHWDOFDSVRWKHW\SHRIJDVEHLQJFRQYHUWHGWRLV
GLVSOD\HGDQGUHSODFHWKHSURWHFWLYHSODVWLFFRYHU 4. Screw the hex-nut cap back into the regulator.
(Do not over tighten)
CONVERTING THE COOKTOP BURNERS
$ 5HPRYHWKHWRSJUDWHVEXUQHUFDSVDQGEXUQHUKHDGV
',QVWDOOWKHSURSDQHRUL¿FHVLQWKHLUSUHFLVHORFDWLRQV
Propane Red/Yellow
Propane Orange/Light Blue
Propane Orange/Light Blue
Burner cap
Burner cap
Burner head
2UL¿FH located through this opening
Base
Round Burner Cap 5HPRYDEOH
3HUPDQHQW 2YDO%XUQHU&DSV 1RQ5HPRYDEOH
2UL¿FHV located through this opening
Burner cap
Burner head
2UL¿FH located through this opening
Base
Multi-ring
Dual oval burner
Round burner
% 8VLQJDPPRU´QXWGULYHUUHPRYHWKHWRSEXUQHU RUL¿FHV7KHVHPD\EHDFFHVVHGWKURXJKWKHEXUQHU opening in the base.
LR
RR
C1
C2
LF
RF
Propane Blue/Red
Propane None
Propane None
LF1
LF2
LFC
LF3
Propane None
Propane Orange/Silver
Propane None
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
&5HPRYHWKHSURSDQHRUL¿FHVIURPWKHER[SURYLGHG7KH SURSDQHRUL¿FHVKDYHWKHOHWWHU³/´RQWKHWRS To aid in identifying the proper location for the propane RUL¿FHVGXULQJFRQYHUVLRQIURP1DWXUDO*DVWR3URSDQH *DVFRORUFRGHVKDYHEHHQDGGHGWRWKHVLGHRUWRSRIWKH RUL¿FH6HHWKHFKDUWEHORZ(DFKRUL¿FHPD\DOVRVKRZD VHULHVRIHQJUDYHGPDUNV,,,,,, ORFDWHGRQWKHWRS
7RSUHYHQWOHDNDJHPDNHVXUHWKHRUL¿FHVSXGVDUHVHFXUHO\ screwed into the gas supply tubes. ( ,QVWDOOWKHROGRUL¿FHVSXGVLQWRWKHPHWDOER[RUEUDFNHW along with these instructions, and replace onto the back of the UDQJHIRUSRVVLEOHIXWXUHFRQYHUVLRQ
CHECK SURFACE BURNERS
95
Denotes 0.95mm Orifice size opening
Denotes LP (Propane)
III
BURNER OUTPUT RATINGS: BTU/HR
Propane Gas 10" W.C.P.
BTU ORIFICE BURNER RATE SIZE (in)
COLOR MARKING
/)
18,000
/)
N/A
0.027
None
/
/)
N/A
0.027
None
/
/)
N/A
0.027
None
/
/)&
N/A
0.016
None
/
/5
5,000
0.026
Red/Yellow
/
RF
15,000
0.045
2UDQJH6LOYHU
/
RR
9,500
0.0365
2UDQJH/LJKW%OXH
/
C
8,000
C1
9,500
0.0365
2UDQJH/LJKW%OXH
/
C2
6,800
0.030
Blue/Red
/
Broil
13,500
0.042
*UH\
/
Bake
16,000
0.047
Orange
0.047
3XVKDQGWXUQDNQREWRWKH/,7(SRVLWLRQ$FOLFNLQJVRXQG indicates proper operation of the ignition system. When lighting DQ\EXUQHUVSDUNVZLOODSSHDUDWDOOEXUQHUVEXWJDVÀRZV from only the one selected. Once air is purged from the supply line, burner should light within 4 seconds. After burner lights, URWDWHWKHNQRERXWRIWKH/,7(SRVLWLRQ7U\HDFKEXUQHULQ VXFFHVVLRQXQWLODOOEXUQHUVKDYHEHHQFKHFNHG Quality of Flames 'HWHUPLQHWKHTXDOLW\RIÀDPHVYLVXDOO\1RUPDOEXUQHUÀDPHV VKRXOGORRNOLNH$ RU%
(A) Soft blue flames-- Normal for natural gas
(B) Yellow tips on outer cones-- Normal for propane gas
/RQJEULJKW\HOORZÀDPHVDUHQRWQRUPDO1RUPDOÀDPHVPD\ show signs of an orange tint when well heated or signs of ÀLFNHULQJRUDQJHGXHWRSDUWLFOHVLQWKHJDVRUDLU
PROPANE CONVERSION INSTRUCTIONS 31-2000756 Rev. 0 05-20 GEA PGS930
CONVERTING THE OVEN BURNERS
NOTICE:
7KLVSURGXFWFDQQRWEHFRQYHUWHGWRSURSDQHE\DGMXVWLQJ WKHRYHQRUL¿FHV7KHRUL¿FHVPXVWEHUHSODFHGIRUSURSDQH
BAKE BURNER ORIFICE
/LIW Burner %DNH%XUQHU2UL¿FH
5 HPRYHRYHQUDFNVGRRUDQGRYHQERWWRP5HPRYHWKH 1/4" hex screws securing the bake burner.
7 KHEDNHEXUQHURUL¿FHLVRQWKHJDVYDOYHORFDWHGEHKLQG WKHZDUPLQJGUDZHU/LIWWKHEXUQHURWKHRUL¿FHDQGDSSO\ D´VRFNHWRQDQH[WHQVLRQWRWKHKH[EDVHRIWKHRUL¿FH RQWKHJDVYDOYH/RRVHQWKHRUL¿FHE\WXUQLQJFRXQWHU FORFNZLVHDQGUHPRYH
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
6 HOHFWWKHSURSDQHEDNHRUL¿FHIURPWKHNLWDQGLQVWDOOLWRQ WKHJDVYDOYH7LJKWHQXQWLOVQXJ
BROIL BURNER ORIFICE
Broil 2UL¿FH
2YHQ /LJKW
5 HPRYHWKH´KH[VFUHZVHFXULQJWKHEURLOEXUQHUDQG DOORZLWWRKDQJGRZQIUHHRIWKHEURLORUL¿FH
$ SSO\D´ZUHQFKWRWKHKH[EDVHRIWKHRUL¿FH/RRVHQ WKHRUL¿FHE\WXUQLQJFRXQWHUFORFNZLVHDQGUHPRYH
6 HOHFWWKHSURSDQHEURLORUL¿FHIURPWKHNLWDQGLQVWDOOLWRQ the broil elbow. Tighten until snug.
5 HSODFHWKHEURLOEXUQHURYHUWKHRUL¿FHDQGUHSODFHWKH screw securing the burner.
ADJUSTING AIR SHUTTER SETTINGS FOR OVEN BURNERS
ADJUSTING LOW FLAME SETTING ON COOKTOP BURNERS
7KHDLUVKXWWHUVVKRXOGEHWXUQHGWRWKHPDUNHGVHWWLQJV1*RU propane or set according to the following table.
BURNER Bake Broil
AIR SHUTTER SETTING FOR PROPANE
Full open 0.690"
AIR SHUTTER SETTING FOR NG
0.280" 0.690"
: LWKD3KLOOLSVKHDGVFUHZGULYHUORRVHQWKHVFUHZV securing the air shutter on the bake burner. Adjust the air
VKXWWHUWRWKHGLPHQVLRQJLYHQLQWKHDERYHWDEOH
2. Turn on the gas.
3. Turn on the electricity. 5HLQVWDOOWKHRYHQGRRU
Screw Air shutter
5. Turn on the bake burner.
2YHQEXUQHUÀDPHPXVWEHREVHUYHGZLWKWKHGRRUFORVHG WRSURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV
$ V\RXZDWFKWKHÀDPHZLWKWKHRYHQGRRUFORVHGFKHFN WKHIROORZLQJWKURXJKWKHRYHQGRRUZLQGRZ
D) RU1DWXUDO*DVLIWKHÀDPHVDUH\HOORZRSHQWKHDLU shutter more.
E,IWKHÀDPHVEORZDZD\RUÀXWWHUIURPWKHEXUQHUFORVH
the air shutter slightly.
7XUQEDNHEXUQHURDQGUHSHDWZLWKEURLOEXUQHU
WARNING
,I\RXDWWHPSWWRPHDVXUHWKHLQQHUFRQH RIWKHÀDPHSOHDVHXVHFDXWLRQEXUQVFRXOGUHVXOW
&KHFNLQJWKHÀDPHVL]H ,WVKRXOGEHDSSUR[LPDWHO\´
to 3/4" long for the bake and broil burners. The combustion quality of the EXUQHUÀDPHVQHHGVWREHGHWHUPLQHGYLVXDOO\ 127(,IEXUQHUÀDPHVORRNOLNH$ IXUWKHUDLUVKXWWHU adjustment to the bake buner is required. Normal EXUQHUÀDPHVVKRXOGORRNOLNH% RU& GHSHQGLQJ on the type of gas you use. With propane gas, some yellow tipping on the outer cones is normal.
(A) Yellow flames: Further Adjustment Required
(B) Yellow tips on outer cones: Normal for Propane Gas
/RZVHWWLQJDGMXVWPHQWVPXVWEHPDGHZLWKRWKHUEXUQHUVLQ
RSHUDWLRQRQDPHGLXPVHWWLQJ7KLVSURFHGXUHSUHYHQWVWKH
ORZÀDPHIURPEHLQJVHWWRRORZUHVXOWLQJLQWKHÀDPHEHLQJ
extinguished when other burners are turned on.
A. Turn on all surface burners to medium setting.
% 7XUQWKHNQRERQWKHEXUQHUEHLQJDGMXVWHGWR³/2´
& 5HPRYHWKHNQREDQGLQVHUWDVPDOOÀDWEODGHVFUHZGULYHU
LQWRWKHYDOYHVKDIWDQGRUVLGHDGMXVWPHQWVFUHZV DV
shown and turn clockwise to fully tighten down the bypass
VFUHZV 5HSHDWIRUDOOYDOYHV
' ,IÀDPHDSSHDUVWRRORZRUXQVWDEOHVORZO\WXUQE\SDVVVFUHZ FRXQWHUFORFNZLVHXQWLODVWDEOHÀDPHH[LVWVIRUHDFKEXUQHU Remember, other burners must be turned on to medium.
SPECIALTY BURNERS
Dual Oval Burner This burner should be properly adjusted
with both bypass screws completely screwed in.
Multi-Ring Burner±7KHRXWHUULQJRIÀDPHVVKRXOGEH
DGMXVWHGZLWKWKHNQREDWWKH0('
Burner Cap
by adjusting the set screw in the
Flames
FHQWHUYDOYHVKDIW7KHÀDPHVVKRXOG
be adjusted so that they barely curl
RYHUWKHWRSHGJHRIWKHEXUQHUFDS
7KHFHQWHUULQJRIÀDPHVVKRXOGEH
DGMXVWHGZLWKWKHNQREDWWKH/2
setting by adjusting the set screw to
WKHULJKWRIWKHYDOYHVKDIW
( $GGLWLRQDOO\IRUHDFKEXUQHUEHLQJDGMXVWHGTXLFNO\RSHQ
DQGFORVHWKHRYHQGRRUZKLOHREVHUYLQJÀDPH,IÀDPHLV
extinguished, continue adjusting bypass screw for a larger
ÀDPH5HSHDWGRRURSHQLQJVXQWLOÀDPHLVVWDEOH
F. Replace the knob.
Adjustment screw for outer ring
Adjustment screw for center ring
Adjustment screw for center ring
Adjustment screw for RYDOULQJV
Adjustment screws for multi-ring burner only
Adjustment screws for GXDORYDOEXUQHURQO\
(C) Soft blue flames: Normal for Natural Gas
)RUHLJQSDUWLFOHVLQWKHJDVOLQHPD\FDXVHDQRUDQJHÀDPHDW ¿UVWEXWWKLVZLOOVRRQGLVDSSHDU 9. When all adjustments are made and the results are
satisfactory:
a. Retighten the air shutter screws.
E5HSODFHWKHRYHQERWWRP c. Replace the storage drawer.
Center adjustment screw only for all other burners.
SPECIAL NOTE:
To convert the oven back to natural gas, reverse the instructions given in making propane adjustments.
NOTICE:
2QFHWKHFRQYHUVLRQLVFRPSOHWHDQGFRQ¿UPHG¿OORXW the propane sticker and include your name, organization
DQGGDWHFRQYHUVLRQZDVPDGH$SSO\WKHVWLFNHUWR the range near the regulator to alert others in the future
WKDWWKLVDSSOLDQFHKDVEHHQFRQYHUWHGWRSURSDQH,I FRQYHUWLQJEDFNWRQDWXUDOJDVIURPSURSDQHSOHDVH UHPRYHWKHVWLFNHUVRRWKHUVNQRZWKHDSSOLDQFHLVVHWWR use natural gas.
ADDITIONAL INFORMATION
BURNER OUTPUT RATINGS: BTU/HR
NG (Natural) Gas 5" W.C.P.
BURNER
/)
BTU RATE
21,000
ORIFICE SIZE (in)
COLOR MARKING
/)
N/A
0.045
None
114N
/)
N/A
0.045
None
114N
/)
N/A
0.045
None
114N
/)&
N/A
0.025
None
63N
/5
5,000
0.040
:KLWH3XUSOH
101N
RF
15,000
0.070
Brown
178N
RR
9,500
0.0555
Yellow
141N
C
8,000
C1
9,500
0.0555
Yellow
141N
C2
6,800
0.047
None
119N
Broil
16,500
0.071
Black/Blue
071N
Bake
16,000
0.070
None
50
198
N
III
Denotes 1.98mm Orifice size opening Denotes Natural Gas
PROPANE CONVERSION INSTRUCTIONS 31-2000756 Rev. 0 05-20 GEA PGS930
Adobe InDesign 15.0 (Windows) Acrobat Distiller 20.0 (Windows)