User Manual for MOOV models including: Rybit820-NA IOT-BOX, Rybit820-NA, IOT-BOX, BOX
MOOV TECHNOLOGY (S) PTE. LTD. RYBIT820 2BBXKRYBIT820 2BBXKRYBIT820 rybit820
File Info : application/pdf, 10 Pages, 236.46KB
DocumentDocumentMOOV IOT-BOX Rybit820-NA MOOV IOT-BOX User's Guide ModelRybit820-NA 1 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder. MOOV IOT-BOX Rybit820-NA Table of Contents 1. Introduction ------------------------------------------------------------------------------------------ 1 2. Safety Information ---------------------------------------------------------------------------------- 2 3. Product Features ----------------------------------------------------------------------------------- 3 4. Technical Specification --------------------------------------------------------------------------- 4 5. Caution ------------------------------------------------------------------------------------------------ 5 6. FCC Statement ------------------------------------------------------------------------------------- 6 7. Acronyms and Abbreviations -------------------------------------------------------------------- 7 2 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder. 1. Introduction MOOV IOT-BOX Rybit820-NA Rybit820-NA is designed for sharing and rental bike or ebike management system. Rybit820-NA supports wide range voltage input from 20 to 56V, integrated 4G LTE/3G UMTS WWAN communication system, GPS navigation system, Bluetooth 5.0 (Low Energy), high performance/low power consumption architecture, audio codec and speaker. In addition, MOOV provides a total solution from cloud management to diagnostic in every single unit and also supports locking management and BMS health check. Telemetry and Remote Control Through WWAN and BLE 5.0, you can easily accomplish telemetry, remote control, location acquisition, lock/unlock bike and BMS health checking. High-Accuracy Positioning and Navigation Integrated GNSS solution, built-in highly customized active ceramic GPS antenna and Qualcomm Gen8C GNSS solution to achieve high-accuracy positioning and navigation. HMI (Human Machine Interface) Integrated audio codec and speaker, allowing easily interact directly with users. Voice prompt files are stored in the flash memory, it can be updated via OTA service. Low Power Consumption Integrated deep power management, system will enter standby mode when service inactive automatically. System can be woken up from WWAN, BT, IMU, timer and button. It also built-in a backup battery to keep system alive when main battery pack was removed or damaged. OTA (Over-The-Air) Supporting OTA upgrade, including both full and delta method. Delta upgrade only needs to download difference portion, it can reduce transfer time and operation cost. 1 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder. 2. Safety Information MOOV IOT-BOX Rybit820-NA Read all safety warnings and all instructions. Failure to follow the warnings and instructions may result in electric shock, fire, and/or serious injury. Qualified Repair Service There are no user serviceable parts. Have the device serviced by a qualified repair person using only identical replacement parts. This will ensure that the safety of the device is maintained. Battery CAUTION: This device contains an internal Lithium battery. The battery can burst or explode, releasing hazardous chemicals. To reduce the risk of fire or burns, do not disassemble, crush, or puncture the device, and do not dispose of the device in fire or water. Radio Wave Propagation Due to the property of radio wave propagation, the WWAN and GPS in this device may not working properly in the tunnel or any other place where the radio signals are hard to receive. 2 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder. 3. Product Features 3.1 Power Source Rating Input voltage is 48V via 5 pins connector. MOOV IOT-BOX Rybit820-NA 3.2 Power-On IOT-Box will power on automatically during the power applied. 3.3 Standby and Wakeup Standby: No on-going housekeeping job and service inactive, the system will enter standby mode. Wakeup: Can be woken up by WWAN, BT, IMU, timer and button event. 3.4 Voice Prompt Integrated audio codec and speaker, allowing easily interact directly with users. Voice prompt files are stored in the flash memory, it can be updated via OTA service. 3.5 CAN Bus Integrated CAN Bus interface to communicate with motor controller, BMS, hub lock and battery lock. It can be recovered automatically or isolated failure node(s) during bus health/conditions change. 3.6 WWAN and BT 5.0 WWAN supports LTE Cat 1/B2 B4 B12, DL 10 Mbps, UL 5 Mbps. WCDMA/B2 B4 B5, DL 384 Kbps, UL 384 Kbps. Bluetooth 5.0 (Low Energy), 1 Mbps. 3.7 Backup Battery Built-in a 3.7V/3400mAh backup battery to keep system alive when main battery pack was removed or damaged. 3 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder. MOOV IOT-BOX Rybit820-NA 4. Technical Specification 4.1 Hardware Specification General Specifications Dimension: 85mm*45mm*40mm Weight: 250g Operating Temp: -10°C to +55°C Storage Temp: -20°C to +60°C Connectors: 5 pins (2 pins for power input, 2 pins for CAN bus and 1 pin for I/O) 4 pins (2 pins for LED and 2 pins for button) Electronic Specifications Input Voltage: 48V (typical) Backup Battery: 3.7V/3400mAh Speaker: 2W (Rating)100dB@10cm 1KHz Lock/Unlock duration: Depends on network condition, less than 5 secs typically Built-in IMU Sensor RF Module Rybit820-NA provides data communication between LTE-FDD and WCDMA networks, it also supports GNSS and BT5.0. Model LTE-FDD WCDMA Rybit820-NA B2/B4/B12 B2/B4/B5 GNSS YES BT 5.0 YES GNSS include GPS L1 Cold start positioning < 35s (open conditions) Hot start positioning < 1s (open conditions) Positioning accuracy < 5m (open conditions) BT5.0 support 2402~2480MHz bandwidth, output power is set to 0 dBm LTE-FDD: 23 dBm ±2.0dB (Power Class 3) WCDMA: 24 dBm +1/-3dB (Power Class 3) 4 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder. 5. Caution Risk of explosion if battery replaced by an incorrect type. Dispose of used batteries according to the instructions. MOOV IOT-BOX Rybit820-NA Please make sure the temperature for device will be -10 to 55°C. LTE-FDD: 23 dBm ±2 dB (Power Class 3) WCDMA: 24 dBm +1/-3dB (Power Class 3) 5 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder. 6. FCC Statement MOOV IOT-BOX Rybit820-NA This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures: - Reorient or relocate the receiving antenna. - Increase the separation between the equipment and receiver. - Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. - Consult the dealer or an experienced radio/TV technician for help. This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: 1. This device may not cause harmful interference. 2. This device must accept any interference received, including interference that may cause undesired operation. Any changes or modifications not expressly approved by the party responsible for compliance could void the user's authority to operate the equipment. FCC Radiation Exposure Statement This equipment complies with FCC radiation exposure limits set forth for an uncontrolled environment. This equipment should be installed and operated with a minimum distance of 20cm between the radiator and your body. 6 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder. MOOV IOT-BOX Rybit820-NA 7. Acronyms and Abbreviations ADC BT CE CMOS DC DL EIA EMC ESD FDD GPIO GPS GPRS I2C I2S LDO LED LTE NC PCB RTC SMT SPI TIS TRP Analog to Digital Converter Bluetooth European Conformity Complementary Metal Oxide Semiconductor Direct Current Downlink Electronic Industries Association Electromagnetic Compatibility Electro-Static Discharge Frequency Division Duplex General-Purpose I/O Global Positioning System General Packet Radio Service Inter Integrated Circuit Inter-IC Sound Low-Dropout Light Emitting Diode Long Term Evolution Not Connected Printed Circuit Board Real Time Clock Surface Mount Technology Serial Peripheral Interface Total Isotropic Sensitivity Total Radiated Power 7 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder. TVS UART UMTS USIM WWAN MOOV IOT-BOX Rybit820-NA Transient Voltage Suppressor Universal Asynchronous Receiver-Transmitter Universal Mobile Telecommunications System Universal Subscriber Identity Module Wireless Wide Area Network 8 Copyright © 2023 MOOV TECHNOLOGY (S) PTE. LTD. All rights reserved. Reproduction in whole or in part is prohibited without the prior written permission of the copyright holder.Microsoft Word for Microsoft 365