Freightliner M2 106 Specification Proposal
Prepared for: Scott Staniszewski, Alamo Group Super Products, 17000 W Cleveland, New Berlin, WI 53151, Phone: 2627847100
Prepared by: Tony Bodway, TRUCK COUNTRY OF WISCONSIN, INC., 2222 WEST RYAN ROAD, OAK CREEK, WI 53154, Phone: 414-761-3384
Date: May 31, 2018
Vehicle Configuration
| Data Code | Description | Weight Front | Weight Rear |
|---|---|---|---|
| PRL-10M | M2 PRL-10M (EFF:02/11/15) | ||
| DRL-006 | SPECPRO21 DATA RELEASE VER 006 | ||
| 001-172 | M2 106 CONVENTIONAL CHASSIS | ||
| 004-219 | 2019 MODEL YEAR SPECIFIED | ||
| 002-004 | SET BACK AXLE - TRUCK | ||
| 019-002 | STRAIGHT TRUCK PROVISION | ||
| 003-001 | LH PRIMARY STEERING LOCATION | ||
| AF3-2AY | SUPER PRODUCTS | ||
| AF7-99D | EXPECTED BODY/PAYLOAD CG HEIGHT ABOVE FRAME "XX" INCHES : 32.0 in | ||
| 101-21Y | CUM B6.7 325 HP @ 2400 RPM, 2600 GOV, 750 LB/FT @ 1800 RPM |
General Service
- AA1-002: TRUCK CONFIGURATION
- AA6-001: DOMICILED, USA 50 STATES (INCLUDING CALIFORNIA AND CARB OPT-IN STATES)
- A85-010: UTILITY/REPAIR/MAINTENANCE SERVICE
- A84-1UT: UTILITY BUSINESS SEGMENT
- AA4-002: LIQUID BULK COMMODITY
- AA5-002: TERRAIN/DUTY: 100% (ALL) OF THE TIME, IN TRANSIT, IS SPENT ON PAVED ROADS
- AB1-008: MAXIMUM 8% EXPECTED GRADE
- AB5-001: SMOOTH CONCRETE OR ASPHALT PAVEMENT - MOST SEVERE IN-TRANSIT (BETWEEN SITES) ROAD SURFACE
- 995-091: MEDIUM TRUCK WARRANTY
- A66-99D: EXPECTED FRONT AXLE(S) LOAD : 13000.0 lbs
- A68-99D: EXPECTED REAR DRIVE AXLE(S) LOAD : 20000.0 lbs
- A63-99D: EXPECTED GROSS VEHICLE WEIGHT CAPACITY : 33000.0 lbs
Truck Service
- AA3-034: SEWER/INDUSTRIAL VACUUM BODY
Engine
Electronic Parameters
- 79A-070: 70 MPH ROAD SPEED LIMIT
- 79B-000: CRUISE CONTROL SPEED LIMIT SAME AS ROAD SPEED LIMIT
- 79K-015: PTO MODE ENGINE RPM LIMIT - 2100 RPM
- 79M-001: PTO MODE BRAKE OVERRIDE - SERVICE BRAKE APPLIED
- 79P-002: PTO RPM WITH CRUISE SET SWITCH - 700 RPM
- 79Q-003: PTO RPM WITH CRUISE RESUME SWITCH - 800 RPM
- 79S-009: PTO MODE CANCEL VEHICLE SPEED - 0 MPH
- 79U-007: PTO GOVERNOR RAMP RATE - 250 RPM PER SECOND
- 79V-001: ENABLE REGENERATION IN PTO MODE
- 80G-002: PTO MINIMUM RPM - 700
- 80J-001: REGEN INHIBIT SPEED THRESHOLD - 0 MPH
Engine Equipment
- 99C-017: 2016 ONBOARD DIAGNOSTICS/2010 EPA/CARB/FINAL GHG17 CONFIGURATION
- 99D-011: 2008 CARB EMISSION CERTIFICATION - CLEAN IDLE (INCLUDES 6X4 INCH LABEL ON LOWER FORWARD CORNER OF DRIVER DOOR)
- 13E-001: STANDARD OIL PAN
- 105-001: ENGINE MOUNTED OIL CHECK AND FILL
- 133-004: ONE PIECE VALVE COVER
- 014-099: SIDE OF HOOD AIR INTAKE WITH FIREWALL MOUNTED DONALDSON AIR CLEANER
- 124-1D7: DR 12V 160 AMP 28-SI QUADRAMOUNT PAD ALTERNATOR WITH REMOTE BATTERY VOLT SENSE
- 292-098: (2) ALLIANCE MODEL 1231XOE, GROUP 31, 12 VOLT MAINTENANCE FREE 2250 CCA THREADED STUD BATTERIES
- 290-017: BATTERY BOX FRAME MOUNTED
- 281-001: STANDARD BATTERY JUMPERS
Chassis Components
Battery and Electrical
- 282-001: SINGLE BATTERY BOX FRAME MOUNTED LH SIDE UNDER CAB
- 291-017: WIRE GROUND RETURN FOR BATTERY CABLES WITH ADDITIONAL FRAME GROUND RETURN
- 289-001: NON-POLISHED BATTERY BOX COVER
- 87P-001: CAB AUXILIARY POWER CABLE
- 33M-001: AUXILIARY POWER NET DISTRIBUTION BLOCK FOR BODY BUILDER USE
- 293-058: POSITIVE LOAD DISCONNECT WITH CAB MOUNTED CONTROL SWITCH MOUNTED OUTBOARD DRIVER SEAT
- 284-045: (2) 12 VOLT POWER RECEPTACLES MOUNTED IN DASH
- 280-007: 12V NEGATIVE GROUND ELECTRICAL SYSTEM
- 324-011: DOME DOOR ACTIVATED LH AND RH, DUAL READING LIGHTS, FORWARD CAB ROOF
- 655-001: CAB DOOR LATCHES WITH MANUAL DOOR LOCKS
Air Compressor and System
- 107-032: CUMMINS TURBOCHARGED 18.7 CFM AIR COMPRESSOR WITH INTERNAL SAFETY VALVE
- 108-002: STANDARD MECHANICAL AIR COMPRESSOR GOVERNOR
- 131-013: AIR COMPRESSOR DISCHARGE LINE
- 152-041: ELECTRONIC ENGINE INTEGRAL SHUTDOWN PROTECTION SYSTEM
- 490-100: WABCO 4S/4M ABS WITHOUT TRACTION CONTROL
- 412-001: STANDARD BRAKE SYSTEM VALVES
- 46D-002: STANDARD AIR SYSTEM PRESSURE PROTECTION SYSTEM
- 413-002: STD U.S. FRONT BRAKE VALVE
- 432-003: RELAY VALVE WITH 5-8 PSI CRACK PRESSURE, NO REAR PROPORTIONING VALVE
- 480-083: WABCO SS-1200 PLUS AIR DRYER WITH INTEGRAL AIR GOVERNOR AND HEATER
- 483-004: WABCO OIL COALESCING FILTER FOR AIR DRYER
- 479-012: AIR DRYER MOUNTED UNDER HOOD
- 460-093: STEEL AIR BRAKE RESERVOIRS; CUSTOMER ACCEPTS TANKS MOUNTED PERPENDICULAR TO RAIL
- 477-001: PULL CABLE ON WET TANK, PETCOCK DRAIN VALVES ON ALL OTHER AIR TANKS
Aftertreatment and Exhaust
- 016-1C2: RH OUTBOARD UNDER STEP MOUNTED HORIZONTAL AFTERTREATMENT SYSTEM ASSEMBLY WITH RH B-PILLAR MOUNTED VERTICAL TAILPIPE
- 28F-007: ENGINE AFTERTREATMENT DEVICE, AUTOMATIC OVER THE ROAD ACTIVE REGENERATION AND DASH MOUNTED SINGLE REGENERATION REQUEST/INHIBIT SWITCH
- 239-200: INTEGRATED STACK AND B-PILLAR PIPE WITH MINIMUM STACK PROTRUSION ABOVE CAB
- 237-1CR: RH CURVED VERTICAL TAILPIPE B-PILLAR MOUNTED ROUTED FROM STEP
- 23U-001: 6 GALLON DIESEL EXHAUST FLUID TANK
- 30N-003: 100 PERCENT DIESEL EXHAUST FLUID FILL
- 43X-002: LH MEDIUM DUTY STANDARD DIESEL EXHAUST FLUID TANK LOCATION
- 23Y-002: DIESEL EXHAUST FLUID PUMP MOUNTED AFT OF DIESEL EXHAUST FLUID TANK
- 43Y-001: STANDARD DIESEL EXHAUST FLUID TANK CAP
- 242-011: ALUMINUM AFTERTREATMENT DEVICE/MUFFLER/TAILPIPE SHIELD(S)
Cooling and Fuel System
- 118-001: FULL FLOW OIL FILTER
- 266-101: 900 SQUARE INCH ALUMINUM RADIATOR
- 103-039: ANTIFREEZE TO -34F, OAT (NITRITE AND SILICATE FREE) EXTENDED LIFE COOLANT
- 171-007: GATES BLUE STRIPE COOLANT HOSES OR EQUIVALENT
- 172-001: CONSTANT TENSION HOSE CLAMPS FOR COOLANT HOSES
- 270-016: RADIATOR DRAIN VALVE
- 168-002: LOWER RADIATOR GUARD
- 138-010: PHILLIPS-TEMRO 750 WATT/115 VOLT BLOCK HEATER
- 140-053: BLACK PLASTIC ENGINE HEATER RECEPTACLE MOUNTED UNDER LH DOOR
- 134-001: ALUMINUM FLYWHEEL HOUSING
- 132-004: ELECTRIC GRID AIR INTAKE WARMER
- 155-057: DELCO 12V 29MT STARTER WITH INTEGRATED MAGNETIC SWITCH
- 218-005: RECTANGULAR FUEL TANK(S)
- 215-005: PLAIN ALUMINUM/PAINTED STEEL FUEL/HYDRAULIC TANK(S) WITH PAINTED BANDS
- 212-007: FUEL TANK(S) FORWARD
- 664-001: PLAIN STEP FINISH
- 205-001: FUEL TANK CAP(S)
- 122-1J1: DETROIT FUEL/WATER SEPARATOR WITH WATER IN FUEL SENSOR, HAND PRIMER AND 12 VOLT PREHEATER
- 216-020: EQUIFLO INBOARD FUEL SYSTEM
- 11F-998: NO NATURAL GAS VEHICLE FUEL TANK VENT LINE/STACK
- 202-016: HIGH TEMPERATURE REINFORCED NYLON FUEL LINE
- 170-015: STANDARD HEATER PLUMBING
- 724-001: AUXILIARY HEATER PLUMBING
- 130-033: DENSO HEAVY DUTY AIR CONDITIONER COMPRESSOR
- 702-002: BINARY CONTROL, R-134A
- 739-033: STANDARD INSULATION
Fan and Air Intake
- 273-035: HORTON HT650 FRONTAL AIR ON/OFF ENGINE FAN CLUTCH
- 276-001: AUTOMATIC FAN CONTROL WITHOUT DASH SWITCH, NON ENGINE MOUNTED
- 014-099: SIDE OF HOOD AIR INTAKE WITH FIREWALL MOUNTED DONALDSON AIR CLEANER
Fuel Filter
- 110-003: CUMMINS SPIN ON FUEL FILTER
Transmission
Transmission
- 342-582: ALLISON 3000 RDS AUTOMATIC TRANSMISSION WITH PTO PROVISION
Transmission Equipment
- 343-339: ALLISON VOCATIONAL PACKAGE 223 - AVAILABLE ON 3000/4000 PRODUCT FAMILIES WITH VOCATIONAL MODELS RDS, HS, MH AND TRV
- 84B-012: ALLISON VOCATIONAL RATING FOR ON/OFF HIGHWAY APPLICATIONS AVAILABLE WITH ALL PRODUCT FAMILIES
- 84C-023: PRIMARY MODE GEARS, LOWEST GEAR 1, START GEAR 1, HIGHEST GEAR 6, AVAILABLE FOR 3000/4000 PRODUCT FAMILIES ONLY
- 84D-023: SECONDARY MODE GEARS, LOWEST GEAR 1, START GEAR 1, HIGHEST GEAR 6, AVAILABLE FOR 3000/4000 PRODUCT FAMILIES ONLY
- 84E-000: PRIMARY SHIFT SCHEDULE RECOMMENDED BY DTNA AND ALLISON, THIS DEFINED BY ENGINE AND VOCATIONAL USAGE
- 84F-000: SECONDARY SHIFT SCHEDULE RECOMMENDED BY DTNA AND ALLISON, THIS DEFINED BY ENGINE AND VOCATIONAL USAGE
- 84G-000: PRIMARY SHIFT SPEED RECOMMENDED BY DTNA AND ALLISON, THIS DEFINED BY ENGINE AND VOCATIONAL USAGE
- 84H-000: SECONDARY SHIFT SPEED RECOMMENDED BY DTNA AND ALLISON, THIS DEFINED BY ENGINE AND VOCATIONAL USAGE
- 84L-010: DISABLE - LOAD BASED SHIFT SCHEDULE, DISABLE - VEHICLE ACCELERATION CONTROL
- 84N-000: NEUTRAL AT STOP - DISABLED, FUELSENSE - DISABLED
- 84U-000: DRIVER SWITCH INPUT - DEFAULT - NO SWITCHES
- 353-038: MARKER LAMP CONNECTION FOR BODY BUILDERS
- 34C-001: ELECTRONIC TRANSMISSION CUSTOMER ACCESS CONNECTOR FIREWALL MOUNTED
- 362-807: CUSTOMER INSTALLED MUNCIE CS41 SERIES PTO
- 363-001: PTO MOUNTING, LH SIDE OF MAIN TRANSMISSION
- 341-018: MAGNETIC PLUGS, ENGINE DRAIN, TRANSMISSION DRAIN, AXLE(S) FILL AND DRAIN
- 345-003: PUSH BUTTON ELECTRONIC SHIFT CONTROL, DASH MOUNTED
- 97G-004: TRANSMISSION PROGNOSTICS - ENABLED 2013
- 370-015: WATER TO OIL TRANSMISSION COOLER, IN RADIATOR END TANK
- 346-003: TRANSMISSION OIL CHECK AND FILL WITH ELECTRONIC OIL LEVEL CHECK
- 35T-001: SYNTHETIC TRANSMISSION FLUID (TES-295 COMPLIANT)
Front Axle and Equipment
- 400-1EA: DETROIT DA-F-13.0-3 13,000# FF1 71.5 KPI/3.74 DROP SINGLE FRONT AXLE
- 402-020: MERITOR 15X4 Q+ CAM FRONT BRAKES
- 403-002: NON-ASBESTOS FRONT BRAKE LINING
- 419-023: CONMET CAST IRON FRONT BRAKE DRUMS
- 409-006: FRONT OIL SEALS
- 408-001: VENTED FRONT HUB CAPS WITH WINDOW, CENTER AND SIDE PLUGS - OIL
- 416-022: STANDARD SPINDLE NUTS FOR ALL AXLES
- 405-002: MERITOR AUTOMATIC FRONT SLACK ADJUSTERS
- 536-050: TRW THP-60 POWER STEERING
- 539-003: POWER STEERING PUMP
Front Suspension
- 534-015: 2 QUART SEE THROUGH POWER STEERING RESERVOIR
- 40T-001: ORGANIC SAE 80/90 FRONT AXLE LUBE
- 620-1D8: 13,300# TAPERLEAF FRONT SUSPENSION
- 619-005: MAINTENANCE FREE RUBBER BUSHINGS - FRONT SUSPENSION
- 62H-012: FRONT SUSPENSION WITH LEFT HAND AND RIGHT HAND OFFSET SHACKLE BRACKETS
- 410-001: FRONT SHOCK ABSORBERS
Rear Axle and Equipment
- 420-1G7: DETROIT DA-RS-20.0-4 20,000# R-SERIES SINGLE REAR AXLE
- 421-556: 5.56 REAR AXLE RATIO
- 424-001: IRON REAR AXLE CARRIER WITH STANDARD AXLE HOUSING
- 386-073: MXL 17T MERITOR EXTENDED LUBE MAIN DRIVELINE WITH HALF ROUND YOKES
- 2 PIECE DRIVELINE
- 423-020: MERITOR 16.5X7 Q+ CAST SPIDER CAM REAR BRAKES, DOUBLE ANCHOR, FABRICATED SHOES
- 433-002: NON-ASBESTOS REAR BRAKE LINING
- 434-005: BRAKE CAMS AND CHAMBERS ON FORWARD SIDE OF DRIVE AXLE(S) WITH AUXILIARY SUPPORT BRACKETS
- 451-023: CONMET CAST IRON REAR BRAKE DRUMS
- 440-006: REAR OIL SEALS
- 426-100: WABCO TRISTOP D LONGSTROKE 1-DRIVE AXLE SPRING PARKING CHAMBERS
- 428-002: MERITOR AUTOMATIC REAR SLACK ADJUSTERS
- 41T-001: ORGANIC SAE 80/90 REAR AXLE LUBE
Rear Suspension
- 622-284: AIRLINER 21,000# REAR SUSPENSION
- 621-007: AIRLINER HIGH POSITION RIDE HEIGHT
- 431-001: STANDARD AXLE SEATS IN AXLE CLAMP GROUP
- 888-050: IGNITION CONTROLLED ELECTRIC DUMP SWITCH FOR AIR SUSPENSION WITH GAUGE
Brake System
- 018-002: AIR BRAKE PACKAGE
- 871-001: REINFORCED NYLON, FABRIC BRAID AND WIRE BRAID CHASSIS AIR LINES
- 904-001: FIBER BRAID PARKING BRAKE HOSE
- 722-002: TRIANGULAR REFLECTORS WITHOUT FLARES
Trailer Connections
- 296-027: PRIMARY CONNECTOR/RECEPTACLE WIRED FOR COMBINATION STOP/TURN, CENTER PIN POWERED THROUGH IGNITION WITH STOP SIGNAL PREWIRE PACKAGE
- 297-041: SAE J560 7-WAY PRIMARY CABLE RECEPTACLE MOUNTED END OF FRAME WITH 36" ADDITIONAL CABLE AT REAR CROSSMEMBER
- 335-004: UPGRADED CHASSIS MULTIPLEXING UNIT
- 32A-002: UPGRADED BULKHEAD MULTIPLEXING UNIT
Wheelbase & Frame
- 545-487: 4875MM (192 INCH) WHEELBASE
- 546-101: 11/32X3-1/2X10-15/16 INCH STEEL FRAME (8.73MMX277.8MM/0.344X10.94 INCH) 120KSI
- 552-134: 1050MM (41 INCH) REAR FRAME OVERHANG
- 55W-004: FRAME OVERHANG RANGE: 41 INCH TO 50 INCH
- AC8-99D: CALC'D BACK OF CAB TO REAR SUSP C/L (CA) : 126.45 in
- AE8-99D: CALCULATED EFFECTIVE BACK OF CAB TO REAR SUSPENSION C/L (CA) : 123.45 in
- AE4-99D: CALC'D FRAME LENGTH - OVERALL : 262.39
- AM6-99D: CALC'D SPACE AVAILABLE FOR DECKPLATE : 126.45 in
- FSS-0LH: CALCULATED FRAME SPACE LH SIDE : 95.23 in
- FSS-0RH: CALCULATED FRAME SPACE RH SIDE : 106.81 in
- 553-001: SQUARE END OF FRAME
- 550-001: FRONT CLOSING CROSSMEMBER
- 559-001: STANDARD WEIGHT ENGINE CROSSMEMBER
- 561-001: STANDARD CROSSMEMBER BACK OF TRANSMISSION
- 562-001: STANDARD MIDSHIP #1 CROSSMEMBER(S)
- 563-001: CROSSMEMBER-MIDSHIP #2 MOUNT 41" AFT OF MIDSHIP #1
- 572-001: STANDARD REARMOST CROSSMEMBER
- 565-001: STANDARD SUSPENSION CROSSMEMBER
Chassis Equipment
- 556-1AP: THREE-PIECE 14 INCH PAINTED STEEL BUMPER WITH COLLAPSIBLE ENDS
- 558-001: FRONT TOW HOOKS - FRAME MOUNTED
- 574-001: BUMPER MOUNTING FOR SINGLE LICENSE PLATE
- 586-024: FENDER AND FRONT OF HOOD MOUNTED FRONT MUDFLAPS
- 551-007: GRADE 8 THREADED HEX HEADED FRAME FASTENERS
Fuel Tanks
- 204-219: 70 GALLON/264 LITER RECTANGULAR ALUMINUM FUEL TANK - LH
Tires
- 093-2C7: HANKOOK DL11 11R22.5 16 PLY RADIAL FRONT TIRES
- 094-2C6: HANKOOK DL11 11R22.5 14 PLY RADIAL REAR TIRES
Hubs
- 418-060: CONMET PRESET PLUS PREMIUM IRON FRONT HUBS
- 450-060: CONMET PRESET PLUS PREMIUM IRON REAR HUBS
Wheels
- 502-1EF: ALCOA LVL ONE 88367X 22.5X8.25 10-HUB PILOT 5.79 INSET ALUMINUM DISC FRONT WHEELS
- 505-1EF: ALCOA LVL ONE 88367X 22.5X8.25 10-HUB PILOT ALUMINUM DISC REAR WHEELS
- 524-001: POLISHED FRONT WHEELS; OUTSIDE ONLY
- 525-001: POLISHED REAR WHEELS; OUTSIDE OF OUTER WHEELS ONLY
- 496-011: FRONT WHEEL MOUNTING NUTS
- 497-011: REAR WHEEL MOUNTING NUTS
Cab Exterior
- 829-071: 106 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CAB
- 650-008: AIR CAB MOUNTING
- 678-001: LH AND RH GRAB HANDLES
- 646-023: HOOD MOUNTED CHROMED PLASTIC GRILLE
- 65X-003: CHROME HOOD MOUNTED AIR INTAKE GRILLE
- 644-004: FIBERGLASS HOOD
- 727-1AF: SINGLE 14 INCH ROUND HADLEY AIR HORN UNDER LH DECK
- 726-001: SINGLE ELECTRIC HORN
- 728-001: SINGLE HORN SHIELD
- 657-1CV: DOOR LOCKS AND IGNITION SWITCH KEYED THE SAME WITH (4) KEYS
- 575-001: REAR LICENSE PLATE MOUNT END OF FRAME
- 312-038: INTEGRAL HEADLIGHT/MARKER ASSEMBLY WITH CHROME BEZEL
- 302-047: LED AERODYNAMIC MARKER LIGHTS
- 294-090: OMIT STOP/TAIL/BACKUP LIGHTS AND PROVIDE WIRING FOR COMBINED STOP/TURN LIGHTS TO FOUR FEET BEYOND END OF FRAME
- 300-015: STANDARD FRONT TURN SIGNAL LAMPS
- 744-1BM: DUAL WEST COAST BRIGHT FINISH HEATED MIRRORS
- 797-001: DOOR MOUNTED MIRRORS
- 796-001: 102 INCH EQUIPMENT WIDTH
- 743-204: LH AND RH 8 INCH BRIGHT FINISH CONVEX MIRRORS MOUNTED UNDER PRIMARY MIRRORS
- 729-001: STANDARD SIDE/REAR REFLECTORS
- 768-043: 63X14 INCH TINTED REAR WINDOW
- 661-003: TINTED DOOR GLASS LH AND RH WITH TINTED NON-OPERATING WING WINDOWS
- 654-003: MANUAL DOOR WINDOW REGULATORS
- 663-013: TINTED WINDSHIELD
- 659-019: 2 GALLON WINDSHIELD WASHER RESERVOIR WITHOUT FLUID LEVEL INDICATOR, FRAME MOUNTED
Cab Interior
- 707-1AM: OPAL GRAY CLOTH INTERIOR
- 706-013: MOLDED PLASTIC DOOR PANEL
- 708-013: MOLDED PLASTIC DOOR PANEL
- 772-006: BLACK MATS WITH SINGLE INSULATION
- 691-008: FORWARD ROOF MOUNTED CONSOLE WITH UPPER STORAGE COMPARTMENTS WITHOUT NETTING
- 694-010: IN DASH STORAGE BIN
- 696-012: CENTER STORAGE CONSOLE MOUNTED ON BACKWALL
- 693-008: PLASTIC MANIFEST BOX - LH AND RH DOORS
- 742-007: (2) CUP HOLDERS LH AND RH DASH
- 680-006: GRAY/CHARCOAL FLAT DASH
- 720-003: 5 LB. FIRE EXTINGUISHER
- 700-002: HEATER, DEFROSTER AND AIR CONDITIONER
- 701-001: STANDARD HVAC DUCTING
- 703-005: MAIN HVAC CONTROLS WITH RECIRCULATION SWITCH
- 689-803: PREP KIT FOR CUSTOMER INSTALLED AUXILIARY HEATER, PLUMBING FROM ENGINE TO BACK OF CAB WITH SHUTOFF VALVES
- 170-015: STANDARD HEATER PLUMBING
- 724-001: AUXILIARY HEATER PLUMBING
- 130-033: DENSO HEAVY DUTY AIR CONDITIONER COMPRESSOR
- 702-002: BINARY CONTROL, R-134A
- 739-033: STANDARD INSULATION
- 285-013: SOLID-STATE CIRCUIT PROTECTION AND FUSES
- 758-014: BLACK CORDURA PLUS CLOTH DRIVER SEAT COVER
- 761-014: BLACK CORDURA PLUS CLOTH PASSENGER SEAT COVER
- 763-102: HIGH VISIBILITY ORANGE SEAT BELTS
- 532-001: FIXED STEERING COLUMN
- 540-015: 4-SPOKE 18 INCH (450MM) STEERING WHEEL
- 765-002: DRIVER AND PASSENGER INTERIOR SUN VISORS
Instruments & Controls
- 732-004: GRAY DRIVER INSTRUMENT PANEL
- 734-004: GRAY CENTER INSTRUMENT PANEL
- 87L-001: ENGINE REMOTE INTERFACE WITH PARK BRAKE INTERLOCK
- 870-001: BLACK GAUGE BEZELS
- 486-001: LOW AIR PRESSURE INDICATOR LIGHT AND AUDIBLE ALARM
- 840-002: 2 INCH PRIMARY AND SECONDARY AIR PRESSURE GAUGES
- 198-025: INTAKE MOUNTED AIR RESTRICTION INDICATOR WITHOUT GRADUATIONS
- 149-013: ELECTRONIC CRUISE CONTROL WITH SWITCHES IN LH SWITCH PANEL
- 156-007: KEY OPERATED IGNITION SWITCH AND INTEGRAL START POSITION; 4 POSITION OFF/RUN/START/ACCESSORY
- 811-042: ICU3S, 132X48 DISPLAY WITH DIAGNOSTICS, 28 LED WARNING LAMPS AND DATA LINKED
- 160-038: HEAVY DUTY ONBOARD DIAGNOSTICS INTERFACE CONNECTOR LOCATED BELOW LH DASH
- 844-001: 2 INCH ELECTRIC FUEL GAUGE
- 148-073: ENGINE REMOTE INTERFACE FOR REMOTE THROTTLE
- 163-004: ENGINE REMOTE INTERFACE CONNECTOR IN ENGINE COMPARTMENT
- 856-001: ELECTRICAL ENGINE COOLANT TEMPERATURE GAUGE
- 864-001: 2 INCH TRANSMISSION OIL TEMPERATURE GAUGE
- 830-017: ENGINE AND TRIP HOUR METERS INTEGRAL WITHIN DRIVER DISPLAY
- 372-051: CUSTOMER FURNISHED AND INSTALLED PTO CONTROLS
- 852-002: ELECTRIC ENGINE OIL PRESSURE GAUGE
Dimensions
A diagram shows a truck with various dimensions labeled:
Overall Length: 274 in
Wheelbase: 192 in
Cab to Front Axle: 41 in
Cab to Rear Axle (approx): 192 in
Cab Height: 106 in BBC
Frame Overhang (Rear): 41 in
Cab Width: 106 in BBC
Engine Hood Height: 67.52 in
Front Bumper to Back of Cab: 123 in
Cab to Frame Clearance: 39.94 in
Cab to Frame Clearance (Front): 41 in
Cab to Frame Clearance (Rear): 41 in
Cab to Frame Clearance (Mid): 3 in
Vehicle Specifications Summary - Dimensions
- Model: M2106
- Wheelbase: 4875MM (192 INCH)
- Rear Frame Overhang: 1050MM (41 INCH)
- Fifth Wheel: NO FIFTH WHEEL
- Mounting Location: NO FIFTH WHEEL LOCATION
- Maximum Forward Position: 0
- Maximum Rearward Position: 0
- Amount of Slide Travel: 0
- Slide Increment: 0
- Desired Slide Position: 0.0
- Cab Size: 106 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CAB
- Sleeper: NO SLEEPER BOX/SLEEPERCAB
- Exhaust System: RH OUTBOARD UNDER STEP MOUNTED HORIZONTAL AFTERTREATMENT SYSTEM ASSEMBLY WITH RH B-PILLAR MOUNTED VERTICAL TAILPIPE
Table Summary - Dimensions
| Item | Description / Value |
|---|---|
| Wheelbase | 4875MM (192 INCH) WHEELBASE |
| Frame Rails | 11/32X3-1/2X10-15/16 INCH STEEL FRAME (8.73MMX277.8MM/0.344X10.94 INCH) 120KSI |
| Yield Strength (psi) | 120000 |
| Section Modulus - per rail (cu. in.) | 16.98 |
| Frame RBM - per rail (lbf-in) | 2037600 |
| Inner Frame Reinforcement | NO INNER FRAME REINFORCEMENT |
| Outer Frame Reinforcement | NO OUTER FRAME REINFORCEMENT |
Turning Radius
A graphic illustrates turning radius data. It suggests the data is for comparison and actual measurements may vary. Key figures include:
| Measurement | Value | Tolerance |
|---|---|---|
| Wall to Wall Diameter | 53.3 ft | +/-3.0 |
| Curb to Curb Diameter | 51.6 ft | +/-3.0 |
| Turning Radius | 25.3 ft | +/-1.5 |
Vehicle Specifications Summary - Turning Radius
- Model: M2106
- Cab Size: 106 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CAB
- Wheelbase: 4875MM (192 INCH)
- Front Tires: HANKOOK DL11 11R22.5 16 PLY RADIAL FRONT TIRES
- Width: 11.1 in
- Front Axle: DETROIT DA-F-13.0-3 13,000# FF1 71.5 KPI/3.74 DROP SINGLE FRONT AXLE
- Kingpin Intersection: 71.5 in
- Bumper: THREE-PIECE 14 INCH PAINTED STEEL BUMPER WITH COLLAPSIBLE ENDS
- Width: 93.5 in
- Bumper Miter to Front Axle: 21.458 in
- Primary Steering Location: LH PRIMARY STEERING LOCATION
- Steering Gear: TRW THP-60 POWER STEERING
- Dual Steering Gear: NONE
- Ram: NONE
- Rear Axle: DETROIT DA-RS-20.0-4 20,000# R-SERIES SINGLE REAR AXLE
- Axle Spacing: NO AXLE SPACING
Weight Summary
| Weight Front | Weight Rear | Total Weight | |
|---|---|---|---|
| Factory Weight | 6332 lbs | 3618 lbs | 9950 lbs |
| Total Weight | 6332 lbs | 3618 lbs | 9950 lbs |
Note: Weights shown are estimates only. For critical weight information, contact Customer Application Engineering.
Certification / Compliance
- 996-001: U.S. FMVSS CERTIFICATION, EXCEPT SALES CABS AND GLIDER KITS
Sales Programs
- NO SALES PROGRAMS HAVE BEEN SELECTED
