TDC USA INC
Installation Guide for Gazebo models including: Outdoor, 2-Tier Folding Pop Up, Folding Pop Up, Pop Up
INSTRUCTION MANUALS – TDC USA INC
File Info : application/pdf, 12 Pages, 764.01KB
DocumentDocument2-Tier Folding Gazebo Steel Frame with Powder Coating Assembly Instructions Made in China The owner's manual contains important safety information as well as assembly, use and maintenance instructions. Keep the packaging and bags away from children and dispose of all packaging properly before use. Keep this manual for future reference. PLEASE DO NOT RETURN THIS PRODUCT TO THE STORE We will be happy to correct any problems that you may have, or answer any of your questions regarding the purchase of this product. Please contact us at our Toll Free customer service number 1-800-599-8898 for any assistance and replacement parts. Thank You. Dist. by TDC USA, Inc. Fairfield, NJ 07004 ©2022 All Rights Reserved. Made in China Item 80808 (beige); 88938 (blue); 88939 (green) www.tdcusainc.com Warnings 3 WARNING! · Keep all children and pets away from assembly area. Children and pets should be supervised when they are in the area of the product construction. · Some parts may contain sharp edges. When assembling and using this product, basic safety precautions should always be. · Please read all the instructions and warnings before assembling. In order to make the whole product adjust to the best, please install all the screws on the product and tighten all the screws after adjusting the product which can stand on the floor even. Not intended for commercial use. · Check all bolts for tightness before use. · IMPORTANT - check and tighten bolts often to keep them secure · Read all the instructions before assembly. Failure to do so may result in faulty assembly and potential injury! Assemble product on a soft, non-abrasive surface such as a carpet or cardboard to avoid damaging · CHOKING HAZARD - Small parts. Not suitable for children under 36 months. The product contains small parts, keep children away when assembling. · ADULT ASSEMBLY REQUIRED. Always remove protective material and poly bags and dispose before assembly. Assembly Instructions/Parts 4 Please read, and follow the instructions within this manual before using this gazebo for the first time. Please review the diagram on page 9 to familiarize yourself with descriptions of the individual parts that make up the gazebo frame. Be careful not to pinch fingers or hands in moving parts when opening or closing this gazebo. Do not use excessive force during any part of set up. Do not use this gazebo in strong wind and rain. Wind and rain can damage the canopy, metal parts of the frame, and could result in injury to you and others. The gazebo is designed to provide shade from the sun only. The canopy is not waterproof, and not intended to be used when raining. Water will sit easily on the canopy fabric, and the weight of the water will severely damage metal parts of the frame. When raining or windy, or expecting rain, wind, snow, or other stormy conditions, close the gazebo as instructed within this manual, and stow it away out of the elements. This gazebo is not a permanent structure, and is intended to be taken down when not in use. This gazebo is not intended to be anchored to a patio deck or concrete surface. Please take a moment to review the Limited Warranty policy found on page 10. A (x1) Folding Gazebo (Canopy & Frame) B (x12) Stakes C (x4) Rope D (x1) Carry Bag Folding Gazebo Instructions 5 Before starting, find a level work space with sufficient room to open this 10 foot by 10 foot gazebo. NOTICE: Please read all instructions to avoid damaging parts to the gazebo frame. Do not use excessive force when opening the gazebo. It is recommended to have four people to open this gazebo each time it is to be used. Step 1: For your convenience, the canopy comes preinstalled over the gazebo frame. Make sure all fasteners at the tops of each telescopic leg is secured to the fasteners found on the inside-corners of the canopy, and that the fastening straps are secured around the crossbeams. Folding Gazebo Instructions 6 Step 2: With one person at each corner, each holding a collapsed telescopic leg, gently pull the legs/corners out, while each person gradually walks backwards. Each person should try to open their corner at a similar pace to those who are helping. If anyone meets resistance while opening the frame, do not continue to pull it open further (this could damage individual parts). When resistance is met, each person should stop pulling, begin stepping inward to close their corner some. Once everyone has taken a step or two inward to close the gazebo some, continue trying to open the gazebo again. With each leg/corner pulled out, lift up on sliding leg hinges (see pg. 9 for part descriptions) on each telescopic leg until they are pulled over the above pushpins, and are locked in place. With each sliding leg hinge locked in place, this will fully extend the crossbeams, straighten out the ribs underneath the canopy, and the canopy itself. Folding Gazebo Instructions 7 Fig. 2 Fig. 1 Step 3: With each person holding a collapsed telescopic leg in hand, lift the gazebo off the ground, and pull the lower half of each leg out of the upper half, until the lower halves can't go any further, and is locked in place. Place the hooks at the four ends of the canopy fabric intended to cover the legs into the designated eyelets at the bottom of each leg. Insert Stakes (B) through designated eyelets on foot paddles of telescopic legs, see Fig. 1. Use a hammer (not included) to gentle tap the Stakes (B) in place, securing the frame to the ground. Tie one end of each Rope (C) to loops found at the corners of the canopy. Tie the opposite ends of Rope (C) to the remaining Stakes (B). Pull these Stakes (B) with Ropes (C) so that the rope is taut, and gently hammer these stakes in the ground, see Fig. 2. Disassembly Instructions 8 Please review the diagram on page 9 to familiarize yourself with part descriptions of the individual parts that make up the gazebo frame. NOTICE: Please read instructions below to avoid damaging parts to the gazebo frame. Do not use excessive force when closing the gazebo. 1. Remove Ropes (C) and Stakes (B) that tie down each corner of the gazebo. 2. Remove Stakes (B) securing each telescopic leg to the ground. 3. Unhook ends of the canopy fabric that extends down the length of each telescopic leg from the leg itself. 4. Collapse each telescopic leg by depressing the push-pins, and pushing the bottom half of the legs into the upper half. Be careful not to pinch fingers or hands in moving parts. 5. Depress push-pins within the sliding leg hinges at the top of telescopic legs, and push the hinges down to the bottom of collapsed telescopic legs. 6. With one person at each corner holding a collapsed telescopic leg, begin stepping inward to close the gazebo frame at the same pace. If anyone meets resistance while closing the frame, everyone should take a step or two outward to open the frame some before trying to close it again. 7. Carefully place the closed Folding Gazebo (A) in its Carrying Bag (D). WARNING Keep all flame and heat sources away from this tent fabric. This tent is made with fabric that meets CPAI-84 specifications for flame resistance. It is not fire proof. The fabric will burn if left in continuous contact with any flame source. The application of any foreign substance to the tent fabric may render the flame-resistant properties ineffective. Folding Gazebo Diagram 9 Please review the diagram below to familiarize yourself with part descriptions. When needing assistance from our customer support team, please use these descriptions to help identify what concerns you are having with any part to this Folding Gazebo. lower rib corner connector rib joint upper rib rib extension two tier rib top canopy connector main canopy connector two tier bracket sliding leg hinge telescopic leg crossbeam foot paddle Limited Warranty 10 LIMITED WARRANTY Please contact our service hotline by phone, email, or fax when needing assistance with assembly or with faulty parts. This allows us to provide support in the event of possible operator errors. All furniture manufactured and sold by TDC USA, Inc. is warranted to the original purchaser against defects in workmanship and materials. If a product manufactured by TDC fails during the first year from date of purchase under the terms of our limited warranty, TDC will replace the item at no charge. After one year, it will be the original purchases' responsibility to pay for freight and packing. TDC reserves the right, in the case of discontinued or out of production models, to replace with an item of similar quality. (Glass breakage is not warranted.) NOTE: You must retain original receipt to obtain warranty! FRAMES: Frames are warranted against defects in materials and workmanship from the date of original purchase. Damage to frames or welds due to commercial use, improper assembly, exposure to water and sub-freezing temperatures, and/or abuse are not covered. FABRIC: Fabric on cushions, slings, and umbrellas is warranted against separation at the seams. Fading, mildew, and/or discoloration due to exposure to elements, chemicals, and spills are not covered. POWDER COAT AND/OR PAINT: The finish is warranted against blistering, peeling, or cracking. Fading resulting from exposure to the elements, chemicals, and spills are not covered. Scratches and chips due to normal wear and use are not covered. FREIGHT & PACKING: TDC will be responsible for shipping, handling, and packaging charges for all valid warranty claims. CARE & MAINTENANCE: Be careful to never allow water build up in fames as this will cause corrosion and freeze damage in cold climates. Wash all frames with a solution of mild soap and water. Rinse will clean water and dry with a soft absorbent cloth towel. Frames can be treated with a liquid wax for maximum protection against UV rays and/or salty damp air. If your set includes cushions, slings, and/or an umbrella, they may be cleaned be hand with a solution of soap and water with a clean water rinse. Limited Warranty 11 LIMITED WARRANTY EXCLUSIONS: · Damage caused by acts of nature · Wind damage · Failure caused by unreasonable, unanticipated, or abusive use · Failure caused by a lack of reasonable and necessary care and maintenance · Normal fade of fabrics, upholstery, or woven materials · Glass table tops · Bursting or cracking of tubing due to exposure to water and freezing temperatures · Changes in wood color due to the natural aging of the wood A sales receipt must be provided to validate 1-Year Limited Warranty. Customer Service: Monday - Friday · 9:00 am - 5:00 pm Phone: 800-599-8898 Email: support@tdcusainc.com TDC USA, Inc. 5 Industrial Rd, STE 1 Fairfield, NJ 07004-3017 2-Tier Folding Gazebo Steel Frame with Powder Coating Dist. by TDC USA, Inc. Fairfield, NJ 07004 ©2022 All Rights Reserved. Made in China. Item #80808 (beige); #88938 (blue); #88939 (green) Questions and Comments 1-800-599-8898 (9 am - 5 pm EST) www.tdcusainc.com