Installation Guide for LG models including: AKB74855311 Heating Configurator, AKB74855311, Heating Configurator
24 mag 2021 — The LG THERMA V R32 Monobloc is a fully packaged unit, where the indoor and outdoor units are combined as one module. This unit does not require refrigerant ...
May 24, 2021 · THERMA V's all in one concept and reduce weight allow for quicker and easier installations. • LG provides fully packaged THERMA V Monobloc : ...
File Info : application/pdf, 16 Pages, 14.80MB
DocumentDocumentEASY INSTALLATION & MAINTENANCE LG Heating Configurator * Applied model : R32 Series, R410A Split Hydro Box R32 IWT, R32 Hydrosplit will be supported within 2020. Easy Installation Setting and Commissioning · Based on installation site information, installers can prepare presetting with the LG heating configurator and save data into a memory card from the office. · Once on site, installers can simply insert memory card into the back of the remote control to activate configuration data. At Installer's Office At User's Home 042 Clip Type Connection for Easy Maintenance * Applied model : R32 Series, R410A Split Hydro Box · Easy access to water pump and strainer (front panel) · Clip type connection for components Back up Heater Flow Sensor No needs! Strainer Water Pump Clip Type Joint Flexible Refrigerant Piping Design * Applied model : R32 IWT, R32 Split, R410A Split, R410A IWT, High Temp. Long piping length and 3 Way piping enable flexible design and easy installation. Piping Capabilities 3 Way Piping · The pipes can be connected in 3 directions · Neat & easy installation by 3 Way piping Pipe length Max. 50m Elevation Max. 30m 043 ACCESSORIES THERMA V FEATURES THERMA V PRODUCTS INTRODUCTION PRODUCTS R32 MONOBLOC Excellent Performance & Efficiency R1 R32 Flash gas compressor refrigerant injection Wide operation range Black Fin heat exchanger Solar thermal User Convenience Energy state Intuitive interface LG ThinQ 2nd circuit Various control options 3rd party Energy Seasonal Low boiler monitoring auto mode noise mode Easy Installation & Maintenance All in one LG heating Clip configurator connection * Detailed description for each function is presented on page 26 ~ 43. Energy Labeling * 16kW 1Ø model. * A+++ to D scale. Refrigerant Pipe Monobloc Concept The LG THERMA V R32 Monobloc is a fully packaged unit, where the indoor and outdoor units are combined as one module. This unit does not require refrigerant piping work since the Monobloc's outdoor unit is connected exclusively to water piping. Further, hydronic components such as plate heat exchanger, expansion tank and water pump are included in the package. Hydronic components included in the Monobloc Outdoor Unit Indoor Unit 046 PHE Expansion Monobloc (plate heat exchanger) Tank A-Class Water Pump Capacity Range (Heating & Cooling) R32 Monobloc Capacity Range [kW] Heating Capacity Cooling Capacity 5 (5.5) (5.5) 7 (7.0) (7.0) 9 (9.0) (9.0) 12 (12.0) (12.0) 14 (14.0) (14.0) 16 (16.0) (16.0) Operation Range (Heating & Cooling) Ambient Temperature 50 70 40 48 60 30 35 50 20 10 5 40 0 30 -10 20 -20 -25 10 -30 0 (°C) (°C) Leaving Water Temperature 65 15 27 5 047 ACCESSORIES THERMA V PRODUCTS THERMA V FEATURES INTRODUCTION MONOBLOC PRODUCT FEATURES All in One Concept THERMA V's all in one concept and reduce weight allow for quicker and easier installations. · LG provides fully packaged THERMA V Monobloc : additional hydronic components are included in the package · Easier and quicker installation without refrigerant piping work Expansion Tank Air Vent Water Pump PHE Monobloc Strainer Flow Switch High Heating Performance even at Low Temperature The R32 Monobloc provides excellent heating performance especially at low ambient temperature. The heating capacity of THERMA V R32 Monobloc at low ambient temperature is 20% higher than the R410A Monobloc. Heating Capacity (kW) at OAT -7°CDB/ LWT 35°C R32 Monobloc R410A Monobloc 22.2% 22.7% 20.7% 12kW 14kW Note 1. LWT : Leaving Water Temperature, OAT : Outdoor Air Temperature 048 16kW Capacity (kW) High Energy Efficiency The energy label directive is a key factor in selecting a heating device in the European heating market. The R32 Monobloc type has an energy label rating (ErP) of A+++. SCOP SCOP 4.8 R32 Monobloc (rated) R410A Monobloc 4.6 4.45 (175) 4.45 (175) 4.45 (175) 4.45 (175) 4.45 (175) 4.45 (175) 4.4 4.2 4.07 (160) 3.96 (155) 4.0 4.10 (161) 4.23 (166) 4.24 (166) 4.17 (164) 3.8 5 7 9 12 14 *Test Condition Test procedure follows EN14825 (low temp.. average), based on the single phase model line-up. 16 Capacity (kW) Heating A+++ A++ A+ A B C D ErP Energy Labeling 55°C 35°C A++ A+ 55°C 35°C A+++ A++ R410A Monobloc Monobloc Reduced Noise Level THERMA V R32 Monobloc boasts reduced noise levels compared to previous generations as well as everyday environments. Sound Pressure Level Comparison 40dB(A) 50dB(A) 50dB(A) 52dB(A) 55dB(A) 75dB(A) Library Talking Monobloc (5 / 7 / 9kW) Monobloc (12 /14 /16kW) Office Subway 049 ACCESSORIES THERMA V PRODUCTS THERMA V FEATURES INTRODUCTION MONOBLOC PRODUCT SPECIFICATION R32 Monobloc HM051M U43 HM071M U43 HM091M U43 011-1W0243 EHPA for Austria, Switzerland and Germany 65°C A+++ Features · High energy efficiency (SCOP4.45/A+++) · Excellent performance at low ambient temperature (100% @ -7°C) · Wide operation range (ambient : -25 ~ 35°C / water side : 15 ~ 65°C) · R32 refrigerant with low GWP · R1 scroll compressor · Black Fin heat exchanger · LG ThinQ · KEYMARK/EHPA certification/MCS/Eurovent certification Model Line-up Category Unit 1 Phase Model 220 ~ 240V, 1Ø, 50Hz Monobloc Unit 5.5 HM051M U43 Model Name Capacity (kW) 7.0 HM071M U43 9.0 HM091M U43 Seasonal Energy Description Space Heating (according to EN14825) Average Climate Water Outlet 35°C Average Climate Water Outlet 55°C SCOP Seasonal Space Heating Efficiency (s) Seasonal Space Heating Eff. Class (A+++ to D scale) SCOP Seasonal Space Heating Efficiency (s) Seasonal Space Heating Eff. Class (A+++ to D scale) Unit W/W % % - HM051M U43 4.45 175 A+++ 3.12 122 A+ HM071M U43 4.45 175 A+++ 3.12 122 A+ HM091M U43 4.45 175 A+++ 3.12 122 A+ 050 Nominal Capacity and Nominal Power Input Description Nominal Capacity Heating Cooling Nominal Power Input Heating Cooling COP Heating EER Cooling OAT (DB) 7°C 7°C 2°C 35°C 35°C 7°C 7°C 2°C 35°C 35°C 7°C 7°C 2°C 35°C 35°C LWT (DB) 35°C 55°C 35°C 18°C 7°C 35°C 55°C 35°C 18°C 7°C 35°C 55°C 35°C 18°C 7°C Unit kW kW W/W W/W HM051M U43 5.50 5.50 3.30 5.50 5.50 1.22 2.04 0.94 1.20 1.96 4.50 2.70 3.52 4.60 2.80 HM071M U43 7.00 5.50 4.20 7.00 7.00 1.56 2.04 1.20 1.56 2.59 4.50 2.70 3.51 4.50 2.70 HM091M U43 9.00 5.50 5.40 9.00 9.00 2.15 2.04 1.54 2.14 3.46 4.18 2.70 3.50 4.20 2.60 Product Specification Technical Specification Water Side Operation Range (leaving water temperature) Piping Connections Heating Cooling DHW1) Water Circuit Min. ~ Max. Inlet Outlet Rated Water Flow Rate at LWT 35°C Operation Range (outdoor temp.) Heating Cooling Min. ~ Max. Refrigerant Side Compressor Quantity Type Type Refrigerant GWP (global warming potential) Precharged Amount t-CO2 eq Sound Power Level Heating Rated Sound Pressure Level (at 1m) Heating Rated Dimensions Unit W x H x D Weight Unit Voltage, Phase, Frequency Power Supply Rated Running Heating Current Cooling Recommended Circuit Breaker Wiring Connections Power Supply Cable (included earth, H07RN-F) Unit °CDB mm (inch) mm (inch) LPM °CDB EA g dB(A) dB(A) mm kg V, Ø, Hz A A A mm2 x cores HM051M U43 HM071M U43 HM091M U43 15 ~ 65 5 ~ 27 (16 ~ 27)2) 15 ~ 80 Male PT 25.4 (1) Male PT 25.4 (1) 15.81 20.12 25.87 -25 ~ 35 5 ~ 48 1 Hermetic Sealed Scroll R32 675 1,400 0.945 60 50 1,239 x 834 x 330 91.0 220 ~ 240, 1, 50 5.4 6.9 9.6 5.3 6.9 9.5 16 20 25 4.0 x 3C 1) DHW 58 ~ 80°C operating is available only when the booster heater is operating. 2) When fan coil unit not used. Note 1. Due to our policy of innovation some specifications may be changed without notification. 2. Wiring cable size must comply with the applicable local and national codes. And "Electric characteristics" chapter should be considered for electrical work and design. Especially the power cable and circuit breaker should be selected in accordance with that. 3. Sound pressure level is measured on the rated condition in the anechoic rooms by ISO 3745 standard. Sound power level is measured on the rated condition in the reverberation rooms by ISO 9614 standard. Therefore, these values can be increased owing to ambient conditions during operation. 4. Performances are accordance with EN14511 and reflect ErP testing conditions. Above gives the declared values at rated conditions acc. ErP regulation. For max. capacities, refer to performance data. · Rated running current : outdoor temp. 7°CDB / 6°CWB, LWT 35°C 5. This product contains fluorinated greenhouse gases. 051 ACCESSORIES THERMA V PRODUCTS THERMA V FEATURES INTRODUCTION MONOBLOC PRODUCT SPECIFICATION Performance Table for Heating Operaion Maximum Heating Capacity (Including Defrost Effect) HM051M U43 Outdoor Temperature -25°C DB -20°C DB -15°C DB -7°C DB -4°C DB -2°C DB 2°C DB 7°C DB 10°C DB 15°C DB 18°C DB 20°C DB 35°C DB LWT 30°C TC 3.79 4.22 4.66 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 LWT 35°C TC 3.67 4.09 4.52 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 LWT 40°C TC 3.54 3.96 4.38 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 LWT 45°C TC 3.42 3.83 4.25 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 LWT 50°C TC 3.70 4.11 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 LWT 55°C TC 3.97 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 LWT 60°C TC 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 LWT 65°C TC 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 5.50 HM071M U43 Outdoor Temperature -25°C DB -20°C DB -15°C DB -7°C DB -4°C DB -2°C DB 2°C DB 7°C DB 10°C DB 15°C DB 18°C DB 20°C DB 35°C DB LWT 30°C TC 4.82 5.38 5.93 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 LWT 35°C TC 4.67 5.21 5.76 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 LWT 40°C TC 4.51 5.05 5.58 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 LWT 45°C TC 4.36 4.88 5.41 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 LWT 50°C TC 4.72 5.23 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 LWT 55°C TC 5.06 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 LWT 60°C TC 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 LWT 65°C TC 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 7.00 HM091M U43 Outdoor Temperature -25°C DB -20°C DB -15°C DB -7°C DB -4°C DB -2°C DB 2°C DB 7°C DB 10°C DB 15°C DB 18°C DB 20°C DB 35°C DB LWT 30°C TC 6.20 6.91 7.63 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 LWT 35°C TC 6.00 6.70 7.40 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 LWT 40°C TC 5.80 6.49 7.18 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 LWT 45°C TC 5.60 6.28 6.95 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 LWT 50°C TC 6.06 6.73 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 LWT 55°C TC 6.50 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 LWT 60°C TC 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 Note 1. DB : Dry Bulb Temperature (°C), LWT : Leaving Water Temperature (°C), LPM : Liters Per Minute (/min), TC : Total Capacity (kW) 2. Direct interpolation is permissible. Do not extrapolate. 3. Measuring procedure follows EN-14511. · Rated values are based on standard conditions and it can be found on specifications. · Above table values may not be matched according to installation condition. Except for rated value, the performance is not guaranteed. · In accordance with the test standard (or nations), the rating will vary slightly. 4. The shaded areas are not guaranteed continuous operation. LWT 65°C TC 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 9.00 052 Performance Table for Cooling Operation Maximum Cooling Capacity HM051M U43 Outdoor Temperature 10°C DB LWT 7°C TC 5.16 20°C DB 5.29 30°C DB 5.43 35°C DB 5.50 40°C DB 5.57 45°C DB 5.64 LWT 10°C TC 5.65 5.59 5.53 5.50 5.50 5.50 LWT 13°C TC 6.14 5.89 5.63 5.50 5.43 5.36 LWT 15°C TC 6.47 6.08 5.69 5.50 5.38 5.27 LWT 18°C TC 6.96 6.38 5.79 5.50 5.31 5.13 HM071M U43 Outdoor Temperature 10°C DB LWT 7°C TC 6.56 20°C DB 6.74 30°C DB 6.91 35°C DB 7.00 40°C DB 7.09 45°C DB 7.18 LWT 10°C TC 7.19 7.11 7.04 7.00 7.00 7.00 LWT 13°C TC 7.82 7.49 7.16 7.00 6.91 6.82 LWT 15°C TC 8.24 7.74 7.25 7.00 6.85 6.70 LWT 18°C TC 8.86 8.12 7.37 7.00 6.76 6.53 HM091M U43 Outdoor Temperature 10°C DB LWT 7°C TC 8.44 20°C DB 8.66 30°C DB 8.89 35°C DB 9.00 40°C DB 9.11 45°C DB 9.23 LWT 10°C TC 9.24 9.15 9.05 9.00 9.00 9.00 LWT 13°C TC 10.05 9.63 9.21 9.00 8.89 8.77 LWT 15°C TC 10.59 9.95 9.32 9.00 8.81 8.62 LWT 18°C TC 11.40 10.44 9.48 9.00 8.70 8.39 LWT 20°C TC 7.29 6.58 5.86 5.50 5.27 5.04 LWT 20°C TC 9.28 8.37 7.46 7.00 6.70 6.41 LWT 20°C TC 11.93 10.76 9.59 9.00 8.62 8.24 LWT 22°C TC 7.62 6.77 5.92 5.50 5.22 4.94 LWT 22°C TC 9.70 8.62 7.54 7.00 6.65 6.29 LWT 22°C TC 12.47 11.08 9.69 9.00 8.54 8.09 Note 1. DB : Dry Bulb Temperature (°C), LWT : Leaving Water Temperature (°C), LPM : Liters Per Minute (/min), TC : Total Capacity (kW) 2. Direct interpolation is permissible. Do not extrapolate. 3. Measuring procedure follows EN-14511. · Rated values are based on standard conditions and it can be found on specifications. · Above table values may not be matched according to installation condition. Except for rated value, the performance is not guaranteed. · In accordance with the test standard (or nations), the rating will vary slightly. 053 ACCESSORIES THERMA V PRODUCTS THERMA V FEATURES INTRODUCTION INTRODUCTION THERMA V FEATURES MONOBLOC PRODUCT SPECIFICATION Drawings Category Unit 1 Phase Model 220 ~ 240V, 1Ø, 50Hz Monobloc Unit HM051M U43 HM071M U43 HM091M U43 5.5 HM051M U43 Model Name Capacity (kW) 7.0 HM071M U43 9.0 HM091M U43 [Unit : mm] [Unit : mm] THERMA V PRODUCTS ACCESSORIES Side View No. Part Name 1 Entering Water Pipe 2 Leaving Water Pipe 3 Strainer 4 Top Cover 5 Front Panel 6 Side Panel 7 Low Voltage 8 Unit Power 9 Water Pump 10 Plate Heat Exchanger 11 Pressure Gauge 12 Safety Valve 13 Indoor Control Box 14 Outdoor Control Box 3D View Description Male PT 1 inch Male PT 1 inch Filtering and stacking particles inside circulating water Accessory kit cables Outdoor entry power cable Heat exchange between refrigerant and water Indicates circulating water pressure Open at water pressure 3bar Indoor PCB and terminal blocks Outdoor PCB and terminal blocks 054 055 MONOBLOC PRODUCT SPECIFICATION R32 Monobloc HM121M U33 HM141M U33 HM161M U33 HM123M U33 HM143M U33 HM163M U33 65°C A+++ 011-1W0244 EHPA for Austria, Switzerland and Germany Features · High energy efficiency (SCOP 4.45 / A+++) · Excellent performance at low ambient temperature (100% @ -7°C) · Wide operation range (ambient : -25 ~ 35°C / water side : 15 ~ 65°C) · R32 refrigerant with low GWP · R1 scroll compressor · Black Fin heat exchanger · LG ThinQ · KEYMARK/EHPA1) certification/MCS/Eurovent certification 1) Approved model by EHPA : HM123M U33, HM143M U33, HM163M U33. Model Line-up Category Unit 1 Phase Model 220 ~ 240V, 1Ø, 50Hz 3 Phase Model 380 ~ 415V, 3Ø, 50Hz Monobloc Unit 12.0 HM121M U33 HM123M U33 Model Name Capacity (kW) 14.0 HM141M U33 HM143M U33 16.0 HM161M U33 HM163M U33 Seasonal Energy Description Space Heating (according to EN14825) Average Climate Water Outlet 35°C Average Climate Water Outlet 55°C SCOP Seasonal Space Heating Efficiency (s) Seasonal Space Heating Eff. Class (A+++ to D scale) SCOP Seasonal Space Heating Efficiency (s) Seasonal Space Heating Eff. Class (A+++ to D scale) Unit W/W % % - HM121M U33 HM123M U33 4.45 175 A+++ 3.18 124 A+ HM141M U33 HM143M U33 4.45 175 A+++ 3.18 124 A+ HM161M U33 HM163M U33 4.45 175 A+++ 3.18 124 A+ 056 Nominal Capacity and Nominal Power Input Description Nominal Capacity Heating Cooling Nominal Power Input Heating Cooling COP Heating EER Cooling OAT (DB) LWT (DB) 7°C 7°C 2°C 35°C 35°C 7°C 7°C 2°C 35°C 35°C 7°C 7°C 2°C 35°C 35°C 35°C 55°C 35°C 18°C 7°C 35°C 55°C 35°C 18°C 7°C 35°C 55°C 35°C 18°C 7°C Unit kW kW W/W W/W HM121M U33 HM123M U33 12.00 12.00 11.00 12.00 12.00 2.61 4.29 3.13 2.61 4.44 4.60 2.80 3.52 4.60 2.70 HM141M U33 HM143M U33 14.00 12.00 12.00 14.00 14.00 3.11 4.29 3.42 3.26 5.38 4.50 2.80 3.51 4.30 2.60 HM161M U33 HM163M U33 16.00 12.00 13.80 16.00 16.00 3.64 4.29 3.94 4.00 6.40 4.40 2.80 3.50 4.00 2.50 Product Specification Technical Specification Unit HM121M U33 HM141M U33 HM161M U33 HM123M U33 HM143M U33 HM163M U33 Water Side Operation Range (leaving water temperature) Heating Cooling DHW1) Piping Connections Water Circuit Min. ~ Max. °CDB Inlet Outlet mm (inch) mm (inch) 15 ~ 65 5 ~ 27 (16 ~ 27)2) 15 ~ 80 Male PT 25.4 (1) Male PT 25.4 (1) Rated Water Flow Rate at LWT 35°C LPM 34.50 40.25 46.00 34.50 40.25 46.00 Operation Range Heating (outdoor temp.) Cooling Min. ~ Max. °CDB -25 ~ 35 5 ~ 48 Quantity EA Compressor Refrigerant Type - Side Type - 1 Hermetic Sealed Scroll R32 Refrigerant GWP (global warming potential) - Precharged Amount g 675 2,400 Sound Power Level t-CO2 eq Heating Rated dB(A) 1.620 63 Sound Pressure Level (at 1m) Heating Rated dB(A) 52 Dimensions Unit W x H x D mm 1,239 x 1,380 x 330 Weight Unit kg 124.5 Voltage, Phase, Frequency V, Ø, Hz 220 ~ 240, 1, 50 380 ~ 415, 3, 50 Power Supply Rated Running Heating A 11.6 13.8 16.1 3.8 4.6 5.4 Current Cooling A 11.6 14.4 17.7 3.8 4.8 5.9 Wiring Connections Recommended Circuit Breaker Power Supply Cable (included earth, H07RN-F) A mm2 x cores 40 6.0 x 3C 16 4.0 x 5C 1) DHW 58 ~ 80°C operating is available only when the booster heater is operating. 2) When fan coil unit not used. Note 1. Due to our policy of innovation some specifications may be changed without notification. 2. Wiring cable size must comply with the applicable local and national codes. And "Electric characteristics" chapter should be considered for electrical work and design. Especially the power cable and circuit breaker should be selected in accordance with that. 3. Sound pressure level is measured on the rated condition in the anechoic rooms by ISO 3745 standard. Sound power level is measured on the rated condition in the reverberation rooms by ISO 9614 standard. Therefore, these values can be increased owing to ambient conditions during operation. 4. Performances are accordance with EN14511 and reflect ErP testing conditions. Above gives the declared values at rated conditions acc. ErP regulation. For max. capacities, refer to performance data. · Rated running current : outdoor temp. 7°CDB / 6°CWB, LWT 35°C 5. This product contains fluorinated greenhouse gases. 057 ACCESSORIES THERMA V PRODUCTS THERMA V FEATURES INTRODUCTION MONOBLOC PRODUCT SPECIFICATION Performance Table for Heating Operaion Maximum Heating Capacity (Including Defrost Effect) HM121M U33 / HM123M U33 Outdoor Temperature -25°C DB -20°C DB -15°C DB -7°C DB -4°C DB -2°C DB 2°C DB 7°C DB 10°C DB 15°C DB 18°C DB 20°C DB 35°C DB LWT 30°C TC 8.75 10.13 11.50 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 LWT 35°C TC 8.50 10.00 11.50 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 LWT 40°C TC 8.25 9.88 11.50 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 LWT 45°C TC 8.00 9.75 11.50 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 LWT 50°C TC 9.63 11.50 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 LWT 55°C TC - 11.50 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 LWT 60°C TC - 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 LWT 65°C TC - 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 12.00 HM141M U33 / HM143 U33 Outdoor Temperature -25°C DB -20°C DB -15°C DB -7°C DB -4°C DB -2°C DB 2°C DB 7°C DB 10°C DB 15°C DB 18°C DB 20°C DB 35°C DB LWT 30°C TC 9.25 10.63 12.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 LWT 35°C TC 9.00 10.50 12.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 LWT 40°C TC 8.75 10.38 12.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 LWT 45°C TC 8.50 10.25 12.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 LWT 50°C TC - 10.13 12.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 LWT 55°C TC - 12.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 LWT 60°C TC - 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 LWT 65°C TC - 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 14.00 HM161M U33 / HM163 U33 Outdoor Temperature -25°C DB -20°C DB -15°C DB -7°C DB -4°C DB -2°C DB 2°C DB 7°C DB 10°C DB 15°C DB 18°C DB 20°C DB 35°C DB LWT 30°C TC 10.50 12.30 14.10 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 LWT 35°C TC 10.00 11.75 13.50 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 LWT 40°C TC 9.50 11.44 13.38 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 LWT 45°C TC 9.00 11.13 13.25 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 LWT 50°C TC - 10.75 13.13 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 LWT 55°C TC - 13.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 LWT 60°C TC - 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 Note 1. DB : Dry Bulb Temperature (°C), LWT : Leaving Water Temperature (°C), LPM : Liters Per Minute (/min), TC : Total Capacity (kW) 2. Direct interpolation is permissible. Do not extrapolate. 3. Measuring procedure follows EN-14511. · Rated values are based on standard conditions and it can be found on specifications. · Above table values may not be matched according to installation condition. Except for rated value, the performance is not guaranteed. · In accordance with the test standard (or nations), the rating will vary slightly. 4. The shaded areas are not guaranteed continuous operation. LWT 65°C TC - 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 16.00 058 Performance Table for Cooling Operation Maximum Cooling Capacity HM121M U33 / HM123M U33 Outdoor Temperature 10°C DB LWT 7°C TC 11.25 LWT 10°C TC 12.33 20°C DB 11.55 12.20 30°C DB 11.85 12.07 35°C DB 12.00 12.00 40°C DB 12.15 12.00 45°C DB 12.30 12.00 LWT 13°C TC 13.40 12.84 12.28 12.00 11.85 11.69 LWT 15°C TC 14.12 13.27 12.42 12.00 11.75 11.49 LWT 18°C TC 15.20 13.92 12.64 12.00 11.59 11.19 HM141M U33 / HM143 U33 Outdoor Temperature 10°C DB LWT 7°C TC 13.13 LWT 10°C TC 14.38 20°C DB 13.48 14.23 30°C DB 13.83 14.08 35°C DB 14.00 14.00 40°C DB 14.18 14.00 45°C DB 14.35 14.00 LWT 13°C TC 15.64 14.98 14.33 14.00 13.82 13.64 LWT 15°C TC 16.47 15.48 14.49 14.00 13.70 13.41 LWT 18°C TC 17.73 16.24 14.75 14.00 13.53 13.05 HM161M U33 / HM163 U33 Outdoor Temperature 10°C DB LWT 7°C TC 15.00 LWT 10°C TC 16.43 20°C DB 15.40 16.26 30°C DB 15.80 16.09 35°C DB 16.00 16.00 40°C DB 16.20 16.00 45°C DB 16.40 16.00 LWT 13°C TC 17.87 17.12 16.37 16.00 15.80 15.59 LWT 15°C TC 18.83 17.70 16.57 16.00 15.66 15.32 LWT 18°C TC 20.26 18.56 16.85 16.00 15.46 14.92 LWT 20°C TC 15.91 14.35 12.78 12.00 11.49 10.99 LWT 20°C TC 18.57 16.74 14.91 14.00 13.41 12.82 LWT 20°C TC 21.22 19.13 17.04 16.00 15.32 14.65 LWT 22°C TC 16.63 14.78 12.93 12.00 11.39 10.78 LWT 22°C TC 19.40 17.24 15.08 14.00 13.29 12.58 LWT 22°C TC 22.17 19.70 17.23 16.00 15.19 14.38 Note 1. DB : Dry Bulb Temperature (°C), LWT : Leaving Water Temperature (°C), LPM : Liters Per Minute (/min), TC : Total Capacity (kW) 2. Direct interpolation is permissible. Do not extrapolate. 3. Measuring procedure follows EN-14511. · Rated values are based on standard conditions and it can be found on specifications. · Above table values may not be matched according to installation condition. Except for rated value, the performance is not guaranteed. · In accordance with the test standard (or nations), the rating will vary slightly. 059 ACCESSORIES THERMA V PRODUCTS THERMA V FEATURES INTRODUCTION INTRODUCTION THERMA V FEATURES MONOBLOC PRODUCT SPECIFICATION Drawings Category Unit 1 Phase Model 220 ~ 240V, 1Ø, 50Hz 3 Phase Model 380 ~ 415V, 3Ø, 50Hz Monobloc Unit 12.0 HM121M U33 HM123M U33 HM121M U33 / HM141M U33 / HM161M U33 HM123M U33 / HM143M U33 / HM163M U33 Model Name Capacity (kW) 14.0 HM141M U33 HM143M U33 16.0 HM161M U33 HM163M U33 [Unit : mm] [Unit : mm] THERMA V PRODUCTS ACCESSORIES Side View No. Part Name 1 Entering Water Pipe 2 Leaving Water Pipe 3 Strainer 4 Top Cover 5 Front Panel 6 Side Panel 7 Low Voltage 8 UNIT Power 9 Water Pump 10 Plate Heat Exchanger 11 Pressure Gauge 12 Safety Valve 13 Indoor Control Box 14 Outdoor Control Box 3D View Description Male PT 1 inch Male PT 1 inch Filtering and stacking particles inside circulating water Accessory kit cables Outdoor entry power cable Heat exchange between refrigerant and water Indicates circulating water pressure Open at water pressure 3bar Indoor PCB and terminal blocks Outdoor PCB and terminal blocks 060 061 INTRODUCTION MONOBLOC PRODUCT SPECIFICATION Electric Back up Heater HA031M E1 HA061M E1 HA063M E1 [Unit : mm] THERMA V FEATURES THERMA V PRODUCTS ACCESSORIES Product Specification Electrical Specification Unit Type - Number of Heating Coil EA Capacity Combination kW Back up Heater Operation Heating Steps Step Power Supply V, Ø, Hz Dimensions (W x H x D) mm Net Weight (unit) kg Wiring Power Supply Cable (included earth, H07RN-F) mm2 x cores Connections Communication Cable (H07RN-F) mm2 x cores HA031M E1 HA061M E1 Sheath 1 2 3.0 3.0 + 3.0 Automatic 1 2 220 ~ 240, 1, 50 210 x 607 x 217 13.0 13.8 1.5 x 3C 4.0 x 3C 0.75 x 2C 0.75 x 4C HA063M E1 3 2.0 + 2.0 + 2.0 1 380 ~ 415, 3, 50 14.1 2.5 x 4C 0.75 x 2C Note 1. Due to our policy of innovation some specifications may be changed without notification. 2. Wiring cable size must comply with the applicable local and national codes. And "Electric characteristics" chapter should be considered for electrical work and design. Especially the power cable and circuit breaker should be selected in accordance with that. 062 Side View Terminal #E/heater out sensor (S13) Terminal 2 Side View No. Part Name 1 Leaving Water Pipe 2 Entering Water Pipe 3 Control Box 4 Thermal Switch 5 Air Vent 6 Electric Heater 7 Back up Heater Outlet Sensor (S13) 3D View Description Male PT 1 inch Male PT 1 inch Circuit breaker, Magnetic switch, Terminal blocks Cut-off power input to E/heater at 90°C Air purging when charging water Refer the related information Connect to unit (heat pump) 063 ACCESSORIES ACCESSORIES Accessories Provided by LG Category Model Name Model Number Figure Applicable Product Relevant Function Purpose Feature Room Temperature Sensor PQRSTA0 All except for R410A IWT Room Temperature Based Control To detect room air temperature for room temperature based control · Max. wire length : 15m Sensors 2nd Circuit Thermistor PRSTAT5K10 Domestic Hot Water Sensor PHRSTA0 3 Way Valve OSHA-3V Valves Thermostatic Mixing Valve OSHA-MV OSHA-MV1 DHW Tanks Domestic Hot Water Tank (single coil) OSHW-200F OSHW-300F OSHW-500F Domestic Hot Water Tank (double coil) OSHW-300FD Domestic Hot Water Tank Kit Installation Kits PHLTA (1Ø, split) PHLTC (3Ø, split) PHLTB (monobloc) Solar Thermal Kit PHLLA All except for R410A IWT and High temp. 2nd Circuit (mixing circuit) To detect 2nd circuit temperature when using 2nd circuit function · 5k thermistor, 10m All except for IWT and High temp. models Domestic Hot Water Heating To detect DHW tank temperature · Included in PHLTA kit All except for IWT models Domestic Hot Water Heating To divert water flow between space heating and DHW heating · Size : DN 20 G 1" connection, male threaded Regardless of model Domestic Hot Water Supply To blend hot water with cold water for ensuring constant, safe shower and bath outlet temp. · Size : 3/4" DN20 male threaded · Size : 1" DN25 male threaded All except for IWT models All except for IWT and High temp. models Domestic Hot Water Heating All except for IWT and High temp. models Domestic Hot Water Heating To generate and store domestic hot water To operate with DHW tank · Storage volume : 200L, 300L, 500L · Type : Internal double coil · Material : Stainless steel · Capacity of booster heater : 2.4kW · Storage volume : 300L · Type : Internal double coil · Material : Stainless steel · Capacity of booster heater : 2.4kW · Parts included : DHW tank sensor (thermistor), Circuit breaker, Relay · Parts included : DHW tank sensor (thermistor), Circuit breaker, Relay, Multi harness All except for IWT, Hydrosplit and High temp. models Solar Thermal Heat Utilization To operate with solar thermal system · Length of thermistor : 12m · Size of tube connector (W x H x D) : 110 x 55 x 22 150 Category Model Name Model Number HA031M E1 Electric Installation Back Up Kits Heater HA061M E1 HA063M E1 Vessel Buffer Tank for Space Heating OSHB-40KT Expansion Vessel for DHW OSHE-12KT Extension Wire for Wire Remote Controller PZCWRC1 Extension Cable for Wi-Fi Modem PWYREW000 2 Remote Control Wire PZCWRC2 ETC PHDPB Drain Pan PHDPC Figure Applicable Product Relevant Function Purpose R32 Monobloc and R32 Silent Monobloc (HA063M E1 is not applicable for R32 Silent Monobloc) Capacity Back Up To supplement & Emergency insufficient Operation capacity Feature · Heater capacity : 3kW · Number of heating coil : 1EA (3.0kW) · Size (W x H x D) : 210 x 607 x 217 · Power : 220 ~ 240V, 1Ø · Heater capacity : 6kW · Number of heating coil : 2EA (3.0 + 3.0kW) · Size (W x H x D) : 210 x 607 x 217 · Power : 220 ~ 240V, 1Ø · Heater capacity : 6kW · Number of heating coil : 3EA (2.0 + 2.0 + 2.0kW) · Size (W x H x D) : 210 x 607 x 217 · Power : 380 ~ 415V, 3Ø R32 IWT - To provide the buffer volume of water to the heating circuit · Volume : 40L · Size (W x H x D) : 518 x 560 x 175 R32 IWT All except for R410A IWT All except for R410A IWT All except for R410A IWT model - - Wi-Fi Control via LG ThinQ 2 Remote Control To absorb the volume changes by temperature of water for the DHW circuit · Volume : 8L · Connection : 3/4" · Max. pressure : 10 bar · Size (W x H x D) : 416 x 238 x 502 To extend wire between wired remote controller and indoor unit · Length : 10m To extend wire between WI-Fi modem and indoor unit · Length : 10m To connect two remote controller on the one indoor unit · Length : 0.25m R32 Split, R410A Split R32 Hydrosplit Cooling Operation To collect condensed water in indoor unit - when cooling operation Cover Plate PDC-HK10 R32 Hydrosplit, R32 Split, R32 IWT, - R410A Split To fill the blank space of the indoor unit front panel when the remote - controller is relocated indoors. 151 ACCESSORIES THERMA V PRODUCTS THERMA V FEATURES INTRODUCTION ACCESSORIES Accessories Provided by LG Category Model Name Model Number Remote Controller Wired Remote Controller PREMTW101 AC Ez Touch PACEZA000 Figure Applicable Product Relevant Function Purpose All except for R410A IWT model 2 Remote Control To control AWHP using two remote controller (additional remote controller) Feature · New modern design 4.3 inch color LCD display · Information displayed with simple graphic, icon & text · Built-in temperature sensor · Size (W x H x D) : 120 x 120 x 16 · Extension cable (PZCWRC1, 10m) and 2 remote cable (PZCWRC2, 0.25m) are included · 5 inch color display · User-friendly control with iconographic interface (touch screen) · Max. 32 unit control · Total 200 schedule events (weekly / monthly / yearly / exception day) · Operation history · Remote controller lock (all, temp, mode) · PC access supported (IPv6 supported) · DI 1EA (emergency stop only) · Size (W x H x D) : 137 x 121 x 25 Central Controller AC Smart 5 PACS4B000 (Smart 4) PACS5A000 (Smart 5) All except for R410A IWT model Centralized Control To control AWHP using LG central controller · 10.2 inch color display · User-friendly control with iconographic interface (touch screen) · (Smart 4)_Max. IDU 32, (Smart 5)_Max. IDU 64 · Total 100 schedule events (weekly / monthly / yearly / exception day) · History / operation trend · Interlock with 3rd party equipment (ACS IO, ACU IO module is needed) · Error alarm by e-mail · Remote controller lock (all, temp, mode) · Map view (visual navigation) · Web access supported with HTML5 (PC, smartphone, tablet) · DI 2EA, DO 2EA · BACnet IP/ modbus TCP protocol support · Size (W x H x D) : 253.2 x 167.7 x 28.9 ACP 5 PACP4B000 (ACP4) PACP5A000 (ACP5) Gateway ACP Lonworks PLNWKB000 All except for R410A IWT model Centralized Control · Web access controller · Max. 128 unit control · Total 100 schedule events (weekly / monthly / yearly / exception day) · History / operation trend · Interlock with 3rd party equipment (ACS IO, ACU IO module is needed) · Error alarm by e-mail · Remote controller lock (all, temp, mode) · Map view (visual navigation) · DI 10EA, DO 4EA · BACnet IP/ modbus TCP protocol support · Size (W x H x D) : 270 x 155 x 65 To link with AWHP and other existing building control system · Web access controller · Max. 64 unit control · ACP function included · Lonworks protocol support · Size (W x H x D) : 270 x 155 x 65 152 Category Model Name Model Number Figure Applicable Product Relevant Function Purpose Feature Modbus RTU Gateway PMBUSB00A All except for R410A IWT model To communicate and control through the central controller (providing modbus RTU connection between AWHP and BMS) · Modbus RTU slave (RS485) / 9,600 bps · Size (W x H x D) : 53.6 x 89.7 x 60.7 · Max. 16 IDUs with single module / Max. 64 IDUs with 4 modules · Power : DC 12V Gateway PI485 Gateway PMNFP14A1 All except for R410A IWT model Centralized Control To communicate and control through the central controller (converting LG protocol to RS485 protocol) · 1 for each outdoor unit · Power : Supplied by outdoor unit PI485 Gateway PP485B00K Simple Dry Contact PDRYCB000 Dry Contact Dry Contact for Thermostat PDRYCB320 LG Wi-Fi Modem PWFMDD200 ETC Meter Interface PENKTH000 R410A IWT All except for R410A IWT model All except for R410A IWT model All except for R410A IWT model - Wi-Fi Control via LG ThinQ Energy Monitoring To communicate between outdoor unit and IWT type indoor unit · 1 for each outdoor unit · Power : Supplied by outdoor unit To connect between the AWHP and external devices to control various functions · 1 Set per 1 unit · 1 Input contact for turning on/off · Input power : 220 ~ 240V · 2 output contacts - Operation status - Error status · 1 Set per 1 unit · Non voltage or 12 ~ 24V · 8 digital input contacts for thermostat - On/off, operation mode, DHW heating - Emergency mode, silent mode · 2 Output contacts - Operation status - Error status To control AWHP via smartphone · Basic control function - On/off, operation mode, set temp - DHW heating and set temp · Weekly on/off schedule · Error status check · Frequency : 2.4GHz · IEEE 802.11b/g/n supported To measure production / consumption power · Energy meter interface to monitor Electricity and Heat energy - Max. 3 watt - Hour meter - Max. 1 heat meter - Pulse width : 40ms ~ 100ms · Modbus RTU comm. with THERMA V - 2 wire RS485 / 9600bps · Power : DC 12V · Size (W x H x D) : 54 x 90 x 61 2 Zone Valve Controller PZNVVB200 All except for R410A IWT model Zone Valve Control To control individual zone valves with room temperature sensor or room thermostat · Individual temperature setting possible. (to be set through wired remote control in room temperature input mode) · Room temperature detection (AI : 2 ports) · 3rd Party thermostat interlock input. (DI : 2 port) · Can read one DI or AI for each zone. · Maximum number of connections : Max. 4EA (expandable up to 8-zone) · Size (W x H x D) : 53.6 x 89.7 x 60.7 · Power : DC12V for module, AC24V for valve Note 1. PI485 Gateway (PMNFP14A1) should be installed on outdoor unit to use central controller. 153 ACCESSORIES THERMA V PRODUCTS THERMA V FEATURES INTRODUCTION ACCESSORIES LG Wi-Fi Modem PWFMDD200 ENCXLEU Access LG THERMA V anytime and from anywhere with Wi-Fi equipped device. LG's exclusive Home Appliances control app (LG ThinQ) is available. Simple operation for various functions. · On/off · Operation mode selection · Current temperature · Set temperature · On/off reservation scheduling · Energy monitoring · ESS monitoring · Silent mode reservation · Holiday mode · Quick DHW heating Model Name Size (mm) Interfaceable Products Connection Type Communication Frequency Wireless Standards Mobile Application Optional Extension Cable PWFMDD200 46 x 68 x 14 All THERMA V Line-ups except for R410A IWT Indoor Unit 1 : 1 2.4GHz IEEE 802.11b/g/n LG ThinQ (Android v4.1 (Jellybean) or higher, iPhone iOS 9.0 or higher) PWYREW000 (10m extension) Note 1. Functionality may be different according to each Indoor model. 2. User interface of application shall be revised for its design and contents improvement. 3. Application is optimized for smartphone use, so it may not be well functioning with tablet devices. - For the compatibility with indoor unit, please contact regional office. 154 Domestic Hot Water Tank OSHW-200F AEU OSHW-300F AEU OSHW-500F AEU OSHW-300FD AEU Double Coil Single Coil Domestic Hot Water Tank Water Volume Diameter General Characteristics Height Empty Weight Tank Materials Color Specification of Electric Back up Additional Electric Heater Power Supply Adjustable Thermostat Exchanger Type Specification of Heat Exchanger Material Exchanger Maximum Water Temp. Coil Surface Heat Pump Inlet Unit mm mm Kg W V, Ø, Hz °C °C m2 inch Heat Pump Outlet inch Water Connections Solar Inlet inch Solar Outlet inch City Water Inlet inch Hot Water Outlet inch Energy Efficiency Class (A+ to F scale) - Standing Heat Loss W OSHW-200F 200 640 1,350 61 STS : F18 Grey 2,400 230, 1, 50 (60) 0 ~ 90 Single STS : F18 90 2.3 1 BSP female 1 BSP female - - ¾ BSP male ¾ BSP female B 61 OSHW-300F 300 640 1,850 100 STS : F18 Grey 2,400 230, 1, 50 (60) 0 ~ 90 Single STS : F18 90 3.1 1 BSP female 1 BSP female - - ¾ BSP male 1 BSP female B 70 OSHW-500F 500 640 1,900 146 STS : F18 Grey 2,400 230, 1, 50 (60) 0 ~ 90 Single STS : F18 90 4.8 1 ¼ BSP female 1 ¼ BSP female - - 1 BSP male 1 BSP female B 83 OSHW-300FD 300 640 1,850 106 STS : F18 Grey 2,400 230, 1, 50 (60) 0 ~ 90 Double STS : F18 90 3.1 + 0.97 ¾ BSP female (upper coil) ¾ BSP female (upper coil) 1 BSP Female (lower coil) 1 BSP Female (lower coil) ¾ BSP male 1 BSP female B 70 Domestic Hot Water Tank Installation Kit Thermostatic Mixing Valve (3/4" DN20) Thermostatic Mixing Valve (1" DN25) 3 Way Valve Mandatory Optional Accessories PHLTA (1Ø, split), PHLTB (monobloc), PHLTC (3Ø, split) Optional Accessories OSHA-MV OSHA-MV1 OSHA-3V 155 ACCESSORIES THERMA V PRODUCTS THERMA V FEATURES INTRODUCTION INTRODUCTION THERMA V FEATURES ACCESSORIES Combined Test with DHW Tank LG has conducted a combination test of THERMA V with DHW tanks in accordance with EN16147 and obtained an ErP label for packages in order to cope with European nZEB regulations. · R32 Monobloc (5, 7, 9kW) + OSHW-200F · R32 Monobloc (12, 14, 16kW) + OSHW-200F · R32 Monobloc (5, 7, 9kW) + OSHW-300F · R32 Split Hydro Box (5, 7, 9kW) + OSHW-200F THERMA V PRODUCTS ACCESSORIES Model AWHP IDU ODU Tank Declared Load Profile Grade Average Climate Efficiency Annual Energy Consumption R32 Split (5,7,9kW) HN0916M NK4 HU051MR U44 HU071MR U44 HU091MR U44 OSHW-200F AEU L A+ 118% 865kWh R32 Monobloc (5,7,9kW) R32 Monobloc (12,14,16kW) R32 Monobloc (5,7,9kW) HM051M U43 HM071M U43 HM091M U43 HM121M U33 HM141M U33 HM161M U33 HM051M U43 HM071M U43 HM091M U43 OSHW-200F AEU L A+ 122% 839kWh OSHW-200F AEU L A 109% 940kWh OSHW-300F AEU XL A+ 134% 1,254kWh Energy Label 156 157Adobe InDesign 15.0 (Macintosh) GPL Ghostscript 9.27