CMA Dishmachines – Commercial Glass & Warewashing Equipment
CMA Dishmachines - Parts and Supplies | USA-CLEAN
Instruction Manual for CMA DISHMACHINES models including: H-1X, H-1X Undercounter Glass Washer, H-1X, Undercounter Glass Washer, Glass Washer, Washer
File Info : application/pdf, 16 Pages, 41.95MB
DocumentDocumentMODEL H-1X PARTS MANUAL Rev 1.00 12-15-23 CMA DISHMACHINES 12700 KNOTT AVENUE GARDEN GROVE, CALIFORNIA 92841 800-854-6417 FAX 714-895-2141 www.cmadishmachines.com Buy Parts TABLE OF CONTENTS MODEL CMA H-1X PARTS MANUAL Panels and Door ...........................................................................................................................4 Rear Plumbing ..............................................................................................................................5 Sump ............................................................................................................................................7 Booster .........................................................................................................................................6 Power Wiring Block ......................................................................................................................8 Control Panel................................................................................................................................9 Pump and Motor.........................................................................................................................10 Spray Arm Manifold....................................................................................................................11 Spray Arm Assembly ................................................................................................................12 Chemical Pumps.................................................................................................................13 &14 Optional Chemical Alarm............................................................................................................15 Dish Racks ..................................................................................................................................16 Buy Parts Parts Manual Initial Parts Kit P/N DESCRIPTION Qty 02107.65 Drain Pump 1 02107.73 Switch, Reed Aleph 1 02107.78 Heater, Wash Tank 1 02107.07 Heater, 5kW/220V 1 02107.08 Thermistor, Probe Assm 1 02103.19 Thermostat, High Limit 240f 1 02107.13 Valve, Water Inlet 220V H-1X Series 1 02107.06 Contactor, 3 Pole 220VAC Coil 1 02107.15 Switch, Rocker DPST 250V Neon 1 02107.21 Kit, Control Board 1 02103.51 Contact, Switch Momentary (N.O.) 1 02103.10 Pump Motor Assm, 220V 1 02107.39 Spray Arm, H-1X Complete Assembly 1 02107.33 End Cap, Spray Arm, H-1X 1 00415.20 Chemical Pump Assm 220V 1 02257.00 Squeeze Tube, Norprene 8" 1 MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 3 Panels and Door 1 18 1 14 15 20 12 17 16 1 14 2 1 4 5 5 3 19 14 20 20 12 13 13 12 8 5 12 10 47 12 11 9 4 ITEM NO. NO. REQ'D P/N 1 4 00940.50 2 1 02107.46 3 1 02107.47 4 4 02104.67 5 4 02107.48 6 2 00905.00 7 1 02107.50 8 2 02107.51 9 2 02107.52 10 1 02107.53 11 1 02107.54 DESCRIPTION Screw, Truss Slot SS 10-32x3/8" Panel, Rear Weldment, Base Foot, Adjusting Nut 1/4-20 WH Serrated SS Screw, 1/4-20x5/8" Truss SS Phil Panel, Front Cord Clip 5/8" Push Mount Screw, 8-32x3/8" Truss HD Handle, Door Weldment, Door MODEL H-1X PARTS MANUAL Rev. 1.00 6 ITEM NO. NO. REQ'D P/N 12 4 02107.55 13 2 02107.56 14 2 02107.57 15 2 02107.58 16 4 13822.00 17 1 02107.59 18 1 02107.60 19 1 02107.61 20 2 02107.62 --- 1 02107.63 --- 1 02107.64 Buy Parts DESCRIPTION Screw, RH Hex SS 1/4-20x5/16" Hinge, Door Bracket, Door Hinge Receiver Rail, Tray Nut, Acorn 1/4-20 Weldment, Wash Tank Panel, Top Gasket, Door 23-5/8" Lg Gray Silicon Plate, Locking Hinge Assm, Door Incl #9, 10 & 11 Assm, Door Incl #9, 10, 11, 12, 13 Page 4 Rear Plumbing 16 15 22 21 20 24 23 27 15 19 18 17 11 25 14 4 7 4 3 2 1 4 13 8 6 57 12 25 9 11 10 ITEM NO. NO. REQ'D P/N 1 1 02104.06 2 2 02103.16 3 1 02107.65 4 3 03101.00 5 5 00912.00 6 1 02107.66 7 5 00924.00 8 2 02107.67 9 A/R 02107.68 10 1 03101.47 11 2 N/A 12 1 02107.69 13 1 02107.70 14 A/R 02107.71 DESCRIPTION Bracket, Drain Pump Bolt, Hex Flange 1/4-20 x 3/8 SS Drain Pump Clamp, Hose Gear Nut, 1/4-20 W/ Nylon Insert SS Hose, Drain Pump 1/4" SS Washer Washer 17/64 x 1/2 x 0.32 14S Hose, Rubber 1/2"ID x 0.84"OD Clamp, SS Gear Min 1/2" Clamp, Double Conduit Gasket, Inlet Chute Chute, Inlet Hose, 5/8"ID x 1"OD PVC Braided MODEL H-1X PARTS MANUAL Rev. 1.00 ITEM NO. NO. REQ'D P/N 15 2 03101.00 16 1 02106.19 17 A/R 02107.72 18 1 02107.73 19 2 02103.27 20 1 N/A 21 1 N/A 22 1 N/A 23 1 N/A 24 1 N/A 25 3 00725.40 26 2 02107.74 27 1 02106.50 Buy Parts DESCRIPTION Clamp, Hose Gear SS 3/4-1 1/2" #16 Drain Hose Conduit 1/2" Switch, Reed Aleph Nut, Grip 6-32 W/ Nylon Insert Anti Siphon Body Washer, Silicon 7/8"IDx1-5/16ODx1/16 Ball 3/8" Diameter SS O-Ring 5/16"ID x 9/16"OD x 1/8" Anti Siphon Valve Nut Clamp, EMT 1/2" Screw, #8x1/2" Self Tapping Anti Siphon Valve Assm Page 5 Sump 1 2 3 4 5 6 7 8 9 12 10 11 13 ITEM NO. NO. REQ'D P/N 1 1 02107.75 2 1 02107.76 3 1 02107.77 4 1 02107.78 5 1 02107.79 6 1 02107.80 7 1 02104.21 DESCRIPTION Scrap Screen Pump Suction Ring Gasket, Upper Sump Heater, Wash Tank Sump Bowl Locknut 1/2" NPT NP O-Ring MODEL H-1X PARTS MANUAL Rev. 1.00 ITEM NO. NO. REQ'D P/N 8 1 02107.81 9 1 02107.08 10 12 02107.83 11 12 00912.00 12 1 02107.84 13 1 02107.85 DESCRIPTION Adaptor, Thermistor Thermistor Washer 17/64"x1/2"x0.32 14S Nut, 1/4-20 W/Nylon Insert SS Gasket, Lower Sump Pump Suction Elbow Buy Parts Page 6 Booster 10 10 8 11 12 5 9 5 2 1 3 4 7 6 15 5 14 13 ITEM NO. NO. REQ'D P/N 1 1 02107.07 2 1 02107.08 3 1 02103.14 4 1 02106.01 5 1 02103.21 6 1 02107.09 7 2 02103.16 8 2 00965.00 DESCRIPTION Heater, 5kW/220V Thermistor Gasket Booster, Welded ASSM Clamp, SS Gear-Min. 1/2" Plug, 1/8 Hex Countersunk SS Bolt, Hex Flange, 1/4-20x3/8" SS Nut, Grip 6-32 W/Nylon Insert SS ITEM NO. NO. REQ'D P/N 9 1 02103.19 10 A/R 03107.50 11 2 02107.08 12 1 02107.11 13 2 02107.12 14 1 02107.13 15 1 N/A DESCRIPTION Thermostat, High Limit 240f Hose, Rubber 1/2"x0.84" OD Thermistor Tee, Rinse Screw, M4x12MM SS Extra Wide Phil. Valve, Water Inlet 220V H-1X Series Hose, 1/2" MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 7 Power Wiring Box 8 2 10 1 4 12 11 3 13 5 7 6 9 8 ITEM NO. NO. REQ'D P/N 1 1 02106.02 2 1 02106.03 3 1 02106.04 4 2 00421.51 5 1 13426.50 6 1 00905.82 7 1 02106.05 DESCRIPTION Label, Connection Box Cover, Box Wiring Box, Wiring Screw, 6-32 X 1/4" Lug, Ground Screw, 1/4-20 X 3/8" Block, Terminal 4-Pole MODEL H-1X PARTS MANUAL Rev. 1.00 ITEM NO. NO. REQ'D P/N 8 2 00940.50 9 1 02106.15 10 1 02107.06 11 2 00940.00 12 1 02107.86 13 1 43078.01 DESCRIPTION Screw, 10-32 X 3/8" Truss Head Bushing, Strain Relief, Small Contactor, 3-Pole 220VAC Coil Screw, 10-32 X 1/4" Relay, DPDT, 30A, 220VAC Coil Label, Ground Buy Parts Page 8 Control Panel 4 1 2 3 10 11 16 15 16 5 7 8 9 5 7 4 17 16 17 16 6 10 12 3 ITEM NO. 1 2 3 4 5 6 7 8 9 10 NO. REQ'D 1 2 2 2 4 1 2 2 1 1 P/N 02107.15 02107.16 02103.58 02107.17 02104.91 02107.19 02104.68 02107.20 02107.21 00911.10 DESCRIPTION Switch, Rocker DPST 250V Neon Label, Facia H-1X Gasket, Steam Standoff, LED Display Board Screw, 6-18x1/4" Panhead Phil SS Panel, Facia H-1X Nut, 10-32 Screw, #8 x 3/8" Kit, Control Board Screw, 8-32x3/8 Truss HD ITEM NO. 11 12 13 14 15 16 17 ------- NO. REQ'D 1 1 1 1 1 4 2 1 1 1 P/N 02103.57 02103.51 02103.52 02103.53 03485.00 04086.00 03801.00 02107.22 02107.23 02107.10 DESCRIPTION Prime Switch Contact, Switch Momentary (N.O.) Housing, Push Button Switch Push Button, Green Switch Guard #10 Washer 10-32 Lock Nut Harness, Switch - NOT SHOWN Harness, Sensor - NOT SHOWN Harness, Main - NOT SHOWN MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 9 Pump and Motor 10 12 9 8 5 4 3 7 6 2 15 11 13 14 1 ITEM NO. 1 2 3 4 5 6 7 8 9 NO. REQ'D 9 1 1 1 1 1 1 1 1 P/N 02103.01 02103.02 02107.01 02103.04 02103.05 02107.02 02103.07 02103.30 02107.03 DESCRIPTION Screw, M4, Phil, Pan Head Impeller Housing Cover Nut, M6 (Left-hand thread) 1/4" Lock Washer 17/64" Plain Washer Impeller Pump Seal Pump Gasket Pump Backing Plate ITEM NO. NO. REQ'D P/N 10 9 02103.08 11 1 02103.10 12 1 02103.37 13 1 02103.11 14 1 02107.04 15 2 02107.05 *** 02103.10 DESCRIPTION Nut, M4 Pump Motor Assm, 220V Motor Fan Cover Capacitor, 16 F Wash Pump Bracket Bolt, Hex Flange 1/4-20 X 3/8" SST Motor unavailable as separate part MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 10 Spray Arm Manifold 1 2 3 4 6 5 7 8 7 9 12 12 6 1 10 11 13 ITEM NO. NO. REQ'D P/N 1 2 03101.00 2 2 00912.00 3 1 02107.40 4 4 02103.88 5 4 00914.00 6 1 02103.83 7 2 02107.39 8 1 02103.81 9 1 02107.42 10 1 02107.43 11 1 02107.44 12 4 02104.10 13 1 02107.45 DESCRIPTION Clamp, Hose Gear Hose 1-1/2" SS Nut, Hex SS 1/4-20 Nylon Insert Hub, Upper Spray Arm Washer, Nylite Bolt 1/4-20 x 3/4" Hex Head O-Ring, 2-1/8"OD x 1-3/4"ID x 3/16" Spray Arm, H-1X Complete Assembly Hose, Upper Spray Arm Hub, Lower Spray Arm Manifold, Pump Hose, Pump Discharge Clamp, Hose Gear 1x13/16" - 2x3/4" SS Hose, Pump Suction MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 11 Spray Arm Assembly 1 2 9 8 8 3 The number of dots on the nozzles correspond to the port in which it is assembled. The ports are keyed for the matching nozzle. Do not force a nozzle into the incorrect port. 1 DOT 2 DOTS 4 8 8 5 10 11 12 11 13 3 DOTS 6 7 8 8 9 4 DOTS 5 DOTS ITEM NO. NO. REQ'D P/N 1 1 N/A 2 1 N/A 3 2 02107.39 4 1 N/A 5 4 02107.29 6 4 N/A 7 1 N/A 8 8 02107.32 DESCRIPTION Nozzle 1, Spray Arm, H-1X Nozzle 2, Spray Arm, H-1X Spray Arm, H-1X Complete Nozzle 3, Spray Arm, H-1X Washer, Bearing Spray Arm, H-1X Nozzle 4, Spray Arm, H-1X Nozzle 5, Spray Arm, H-1X O-Ring, Nozzle Spray Arm, H-1X ITEM NO. NO. REQ'D P/N 9 16 02107.33 10 2 02107.34 11 4 02107.35 12 2 02107.36 13 4 02107.37 --- -- 02107.38 DESCRIPTION End Cap, Spray Arm, H-1X Shaft, Spray Arm, H-1X Bearing, Spray Arm, H-1X Bearing, Housing Spray Arm, H-1X Nut, Bearing Spray Arm, H-1X H-1X Nozzle Kit (Incl #1, 2, 4 & 6-9) MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 12 Chemical Pumps 1 1 2 4 3 ITEM NO. NO. REQ'D P/N DESCRIPTION 1 2 02103.21 Clamp, SS Gear-Min 1/2" 2 A/R 03107.50 Hose, Rubber 1/2"x0.84" OD Rinse 3 1 02107.14 Bracket, Chemical Pump, H-1X 4 2 00415.20 Chemical Pump Assm, 220V MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 13 Chemical Pumps 8 7 10a 10 6 9 12 11 5 14 5 13 13 ITEM NO. NO. REQ'D P/N 1 2 02104.47 2 2 02104.48 3 1 43078.05 3a 1 43078.08 4 A/R 02104.37 5 4 00931.00 6 2 02257.00 7 8 00911.00 8 2 00418.00 9 2 00419.00 10 4 00919.00 10a 2 00918.10 11 2 00417.10 12 2 00416.20 13 4 00448.00 14 4 02104.52 DESCRIPTION Strainer Tube Stiffener, 1/2"ID x 11-7/8" Label, Detergent Label, Rinse Hose, 1/4"ID x 3/8"OD 4.5" Nylon Cable Tie Squeeze Tube Norprene 8" Screw, 8-32x1/2" Panhead Peristaltic Pump Cover Peristaltic Pump Rotor Screw, 10-32 x 1-1/2" Panhead Screw, 10-32 x 1-1/2" Flathead Peristaltic Pump Block (Black) Peristaltic Pump Motor 220V/60Hz Barrel Connector, Male Barb 4 3 3a 2 1 MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 14 Optional Chemical Alarm Parts Manual Part Number 12508.00 ITEM NO. NO. REQ'D P/N 1 3 00400.00 2 1 00401.00 3 1 00402.00 4 1 00406.00 5 1 00435.00 6 1 00521.00 7 1 00531.00 DESCRIPTION Conduit, 3/8" Sealtite S.T. 3/8" Straight Connector S.T. 90 Degree 3/8" Connector Control Box Light, .5" Diameter, Red Squeeze Tube, 8" Wire, 18 Gauge, Orange, 6 ft. Wire, 18 Gauge, White, 6 ft. ITEM NO. NO. REQ'D P/N 8 5 00931.00 9 1 12510.00 10 1 12511.00 11 1 12512.00 12 4 40126.10 13 4 40127.00 14 1 00426.00 DESCRIPTION Wire Tie, Small Sanitizer Alarm Box Assembly Sanitizer Low Level Vacuum Switch Sanitizer Alarm Buzzer, 120 Volts #10 x 3/4" Sheet metal Screw Wall Anchors Y Hose Connector, 3/16" MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 15 Dish Racks 1 2 ITEM NO. NO. REQ'D P/N 1 1 12960.01 2 1 12960.03 DESCRIPTION Dish Rack, Flat Dish Rack, Peg MODEL H-1X PARTS MANUAL Rev. 1.00 Buy Parts Page 16