Installation Guide for HARMAN models including: 6.5 Inch Club Marine, 6.5 Inch, Club Marine, Marine
JBL Club Marine 12 Club Marine Series 12" 4-ohm marine subwoofer with built-in RGB LED lighting at Crutchfield
File Info : application/pdf, 5 Pages, 2.07MB
DocumentDocumentJBL Club 6.5", 8", 10", and 12" Marine Speaker Installation Guide EN Guide d'installation FR Guía de instalación ES RU JBL Club 6.5", 8", 10", and 12" Marine Speaker 83.7mm (3-5/16") THANK YOU FOR YOUR PURCHASE ... Your JBL product has been designed to provide you with the performance and ease of operation you would expect from JBL. EN ABOUT THE MANUAL This manual describes general installation guidelines. However, please note that proper installation of marine audio components requires qualified experience. If you do not have the knowledge and tools to successfully perform this installation, we strongly recommend consulting an authorized JBL dealer about your installation options. Keep all instructions and sales receipts for reference. WHAT'S IN THE BOX Club 6.5" and 8" speakers 2X 4X 2X 12X 12X 1X 2X 2X 2X 1X 169.5mm (6-3/4") 112.3mm (4-7/16") Club 8" speaker 225mm (8-7/8") 170mm (6-11/16") Club 10" speaker 273mm (10-3/4") 221.5mm (8-3/4") Club 12" speaker 325mm (12-13/16") 127.5mm (5-1/16") 154.5mm (6-1/16") 198.5mm (7-13/16") Club 10" and 12" speakers 1X 2X 1X 6X 6X 1X 1X 1X 2X 1X DIMENSIONS Club 6.5" speaker 178mm (7-1/64") 280mm (11-1/16") SPEAKER SIGNAL WIRING To send signal to the JBL marine speaker, connect the positive (+) and negative (-) speaker wires to the appropriate speaker outputs of your source unit or amplifier. Be sure to observe proper polarity. + +RGB 91mm (3-19/32") 65mm (2-9/16") 133mm _ (5-1/4") SPEAKER LED WIRING To provide power for the LEDs, plug the 24-gauge black (+), blue, green, and red LED wires from the speaker into the included female connector, then run the wires from the female connector to your compatible 12-volt power source or light controller (sold separately). If using a separate controller, be sure to connect each wire to the proper output. Blue Green Red To power source To speaker Black EN If hardwiring the LEDs directly to your power source, you can choose the color of the LEDs by connecting the black wire to the positive (+) terminal, and the appropriate R, G, and/or B single wire or combination of wires to the negative (-) terminal. There are 7 possible colors, depending on the wiring configuration you choose: Wire connected to positive (+12V) terminal Black Wire connected to negative (-) terminal Color produced Red Red Green Green Blue Blue Red + Green Yellow Red + Blue Purple Blue + Green Aquamarine Red + Blue + Green White APPLYING FOAM SEAL To help seal your installation against water, and to provide an airtight acoustic seal, apply the self-adhesive foam seal to the speaker frame. 2. Make sure that the sticker above the tweeter with the arrow and "TOP" printed on it is aligned with the arrow facing upward. This will ensure the speaker terminals are facing downwards to allow water to drain away from them, and that the grille orientation will be correct. Remove the sticker after speaker installation. ATTACHING THE GRILLE To attach either the white or grey grille, place it over the speaker at a slight angle and press down. Then twist it clockwise just a few degrees to lock into place. Make sure the JBL logo is at the bottom. MOUNTING THE CLUB 10" OR 12" IN AN ENCLOSURE The Club 10" and 12" subwoofers can be mounted in a free-air application, or in a sealed or ported subwoofer enclosure. MOUNTING THE SPEAKER 1. Use the included screws and drill bit to mount the speaker to the location. Use the included speed clips if necessary to provide a secure mount. NOTE: It might be necessary to drill new speaker-mounting holes at the mounting location. Use caution when cutting and using screws with fiberglass to prevent scratches and cracks. SEALED-BOX VOLUME (INCLUDES DRIVER DISPLACEMENT) EN VBOX Speaker size 10" 12" *Recommended Enclosure Size Free air 0.75 ft3 (21.2L)* 1.25 ft3 (35.4L) 2.25 ft3 (63.6L) 3 ft3 (85L) Free air 1.25 ft3 (35.4L) 1.74 ft3 (49.3L)* 2.25 ft3 (63.6L) 3 ft3 (85L) Tuning frequency 44.9Hz 61.8Hz* 55.6Hz 51.1Hz 49.6Hz 34.3Hz 56.5Hz 51.2Hz* 47.9Hz 44.9Hz VENTED-BOX VOLUME (INCLUDES DRIVER DISPLACEMENT) VBOX Speaker Enclosure Port size size length 1.18 ft3 (33.5L)* 9-7/8" (250mm)* 1.25 ft3 9-7/8" (35.4L) (250mm) 10" 2.25 ft3 11-13/16" (63.6L) (300mm) 3 ft3 (85L) 7-7/8" (200mm) Port diameter 3-1/16" (78mm)* 3-3/16" (81mm) 4-7/8" (123mm) 5-3/4" (146mm) Tuning frequency 34Hz* 34Hz 34Hz 34Hz Speaker Enclosure Port size size length 1.25 ft3 (35.4L) 11-13/16" (300mm) 2.25 ft3 11-13/16" (63.6L) (300mm) 12" 3 ft3 9-7/8" (85L) (250mm) 3.12 ft3 (88.5L)* 9-7/8" (250mm)* Port diameter 2-5/8" (66mm) 3-7/8" (97mm) 4-1/2" (113mm) 4-5/8" (117mm)* Tuning frequency 27.8Hz 27.8Hz 27.8Hz 27.8Hz* TECHNICAL DATA (CLUB 10" AND 12" SUBWOOFERS ONLY) THIELE-SMALL PARAMETERS Voice coil DC resistance: REVC (OHMs) Electrical inductance: LCES (mH) Driver radiating area: SD (CM2) Motor force factor: BL (TM) Compliance Volume: VAS (Liters) Suspension compliance: CMS (mm/N) Moving mass, air load: MMS (Grams) Moving mass, without MMD (Grams) air load: Free-air resonance: FS (Hz) Mechanical Q: QMS Electrical Q: QES Total Q: QTS SPL, 1W/1m @ 4ohm: Lm (dB) Club 10" Club 12" (250mm) (300mm) 3.47 3.23 20.34 320.47 12.505 18.9086 0.13 27.98 510.71 13.051 60.6378 0.164 96.45 89.967 131.368 118.327 44.9 6.983 0.603 0.555 86.57 34.3 9.373 0.537 0.508 88.6 SPECIFICATIONS Club 6.5" Continuous 75W power handling Peak power 225W handling Frequency 50Hz response 20kHz Nominal 4 Ohm impedance Sensitivity 92dB External diameter 178mm (7") Mounting cutout diameter 133mm (5-1/4") Total depth 91mm (3-19/32") Mounting depth 65mm (2-9/16") Club 8" 150W 450W 30Hz 20kHz 4 Ohm 92dB 225mm (8-7/8") 170mm (6-11/16") 112.3mm (4-7/16") 83.7mm (3-5/16") Club 10" 300W 900W 25Hz 500Hz 4 Ohm 89dB 273mm (10-3/4") 221.5mm (8-3/4") 169.5mm (6-3/4") 127.5mm (5-1/16") Club 12" 400W 1200W 25Hz 500Hz 4 Ohm 89dB 325mm (12-13/16") 280mm (11-1/16") 198.5mm (7-13/16") 154.5mm (6-1/16") Club 6,5" Club 8" Club 10" Club 12" 75 150 300 400 225 450 900 1200 50 20 30 20 25 500 25 500 4 4 4 4 92 92 89 89 178 (7") 225 273 325 (8-7/8") (10-3/4") (12-13/16") 133 170 221,5 280 (5-1/4") (6-11/16") (8-3/4") (11-1/16") RU 91 112,3 169,5 198,5 (3-19/32") (4-7/16") (6-3/4") (7-13/16") 65 83,7 127,5 154 (2-9/16") (3-5/16") (5-1/16") (6-1/16") : , , 06901 , ., 400, 1500 : OOO " ", , 127018, ., . , .12, . 1 : 1 : 3 : www.harman.com/ru : 8 (800) 700 0467 , : OOO " " , «-». , 2010 : 000000MY0000000, «M» - ( - , B - , C - ..) «Y» - (A - 2010, B - 2011, C - 2012 ..). HARMAN International Industries, Incorporated 8500 Balboa Boulevard, Northridge, CA 91329 USA www.jbl.com © 2022 HARMAN International Industries, Incorporated. All rights reserved. JBL is a trademark of HARMAN International Industries, Incorporated, registered in the United States and/or other countries. Features, specifications and appearance are subject to change without notice. CA_JBL Club Marine Speakers_OM_Global_SOP_V9