GERMAN POOL GP30-2 Built in Gas Cooking Range User Manual

User Manual for GERMAN POOL models including: GP30-2 Built in Gas Cooking Range, GP30-2, Built in Gas Cooking Range, Gas Cooking Range, Cooking Range, Range

Built-in Gas Cooking Range

File Info : application/pdf, 24 Pages, 2.17MB

gc-gp13 p1 p2

B3ui6lt-0in°GMasuCl toi -oOkisncgi lRl aatnigoen

GP13-P1-LG/TG F aGnP13R-HP2S--L1G2/T6G

Online Warranty Registration
Please read these instructions and warranty information carefully before use and keep them handy for future reference.
USER MANUAL
P.1

Table of Contents

Warnings & Safety Precautions

Product Structure

Installation Instructions

Operation Instructions

Cleaning & Maintenance

Troubleshooting

Technical Specification

Warranty Terms & Conditions

P.2

Warnings & Safety Precautions
WARNING! · Read all instructions carefully before using this product. · This product is not intended for use by children or persons with reduced physical, sensory
or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of this product by a person responsible for their safety. · Mind your children and DO NOT let children play with this product. · Cleaning and user maintenance shall not be made by children without supervision. · Check the "Gas type", "Gas working pressure", "Rated heat input" indicated on the rating label before using this product. · This product is for domestic indoor use only. · If the gas connection piping is damaged, it must be replaced by the manufacturer, its service agent or similarly qualified persons in order to avoid hazards.
· Make sure the ignition knob is at "" position and the gas cooker has completely cooled down
before cleaning and maintenance. · Contact German Pool authorized service technician for repair or maintenance of this product.
Notice Before Use Important For safety purposes, you should read the instructions carefully before using the appliance for the first time. Save the instructions for future reference. The appliance is designed for domestic use and may only be installed and operated in accordance with these instructions for use. 1. The cooking range must be installed by registered gas installers. 2. Ensure that the cooking range is used with good ventilation. Environment with insufficient oxygen
should be avoided. 3. This built-in range is to be used for cooking only. DO NOT dry towels, clothes etc. over it. 4. During long period of use, open window or exhaust fan to ensure good ventilation.
5. Check that all control knobs have been set to "" position after use.
6. If the flame is blown out during use, the safety valve will cut off gas supply. Ignite again after at least 1 minute.
7. Take extra care when cooking oil or fat. High temperature of oil or fat may cause fire hazard. 8. To avoid hazard, DO NOT use spray or compressed gas when the cooking range is in use. 9. After ignition, check if the flame is even and normal. Before removing cookware away from the
flame, always set to small flame or "" position.
10. To avoid damage to the cooking range, DO NOT place any hot mat between the range rack and the utensil.
11. DO NOT use burner rack other than the one provided. Otherwise, it will cause overheat to the range surface.
12. DO NOT use over-size or over-weight utensils. Or it will cause excessive heat to be reflected back onto the range surface.
13. Place the utensil steadily on the range rack. DO NOT tilt the utensil.
P.3

Warnings & Safety Precautions
14. Contact German Pool Customer Service and Repair Centre for repair and parts replacement. During guarantee period, German Pool resrves the right to charge for spare parts and service fees if the damage is caused by misuse or improper installation.
15. When installing built-in gas hob on top of stove cabinet, please check that there is provision for ventilation at the cabinet to ensure proper operation of the gas hob.
16. DO NOT store any flammable materials, sprays or pressurised containers inside the stove cabinet. 17. The panel of this built-in hob is made of tempered glass which is safer than normal glass for this
application. However, the following safety precautions for using built-in hob with glass top panel should also be noted in order to prevent the glass top panel from breaking: I. Clean the burner assembly frequently to maintain a clear gas passage on the flame distributor.
Clean and tidy up the flame distributor after spillage of food and liquid once the burner assembly cooled down. II. Turn off the gas appliance immediately if abnormal noise propagates from the gas appliance and contact gas supply company or gas hob importer for inspection. III. DO NOT use oversized utensils for cooking, utensil size should be less than 34cm. IV. DO NOT impact the glass surface with hard objects or place heavy objects on the glass surface. V. Maximum load weight for this gas hob is 10kg. 18. DO NOT leave the gas stove unattended while cooking.
P.4

Product Structure

GP13-P1-TG/GP13-P1-LG

Gas Inlet Joint Glass Panel Burner Head

GP13-P2-TG/GP13-P2-LG

Turn Knob Main Unit Battery Box (bottom of unit)
Gas Inlet Joint
Glass Panel Rear Hob
Front Hob Turn Knob (Rear Hob) Turn Knob (Front Hob) Main Unit Battery Box (bottom of unit)

Flame Sensor Sparker Flame Cap (Small) Flame Cap (Large) Drip Pan Burner Rack
Flane Sensor Burner Cap Burner Head Drip Pan Burner Rack Sparker

P.5

Installation Instructions
WARNING! The gas cooking range must be installed by registered gas installers (RGI). Otherwise, German Pool will not be held responsible for any damages.
Attention: · The use of a gas-cooking appliance produces heat and moisture. Please ensure that the kitchen
is well ventilated. It is recommended to keep natural ventilation windows open or install a mechanical ventilation device (exhaust fan or range hood). For prolonged intensive use of the appliance, additional ventilation is required, for example opening windows or doors, or increasing the level of mechanical ventilation where present. · Install the built-in hob in a well ventilated room and keep it away from any combustible or inflammable objects such as paper or oil. · Place the built-in hob on a stable and level surface. · If the unit is to be installed close to combustible surroundings (such as wooden walls, wooden shelves), it should be installed at least 15 cm (6") from the side walls. The unit should be installed with a distance of at least 15 cm away from surrounding combustible materials. · Leave at least 25 mm (1") gap between the underside of the cooking range and the countertop/ cabinet shelf board below. · External gas governor is not required.
I. Room Ventilation The kitchen should have no less than 20m³ air volume for regular gas combustion and be kept well ventilated at all time. Air must be able to naturally flow through the permanent opening in the walls (eg. windows and doors) of the room. These openings must be able to vent the fumes outdoors and their openings must be at least 100cm², and ensure that they should never be blocked. Indirect ventilation by air drawn from an adjacent room is also permitted, in strict compliance with any local regulation in force.
II. Gas Ventilation
Attention: According to the Gas Safety Ordinance of Hong Kong, any gas installation works including the installation of appliances and connection tubing, must be undertaken by registered gas installers (RGI) who are registered for that appropriate classes and be employed by registered gas contractors. Before connecting the appliance, check that the specifications on the data label affixed to the underside of the hob correspond to those of the gas and electricity mains in the house. A label on the appliance indicates the regulating conditions: Type of gas and working pressure. Gas connection must comply with the pertinent standards and provisions in force. The size of the gas inlet is ½ inch.
P.6

Installation Instructions

A. LPG Connection
· Tubing connection: please use approved tubing made of rubber, parts and gas cock bearing
EMSD approval marking (eg. EMSD APPROVAL GTXXXX), or other appropriate methods accepted by EMSD, for connecting from ½ inch B.S.P. thread at the back of the unit to the gas supply point. · Stainless steel braided flexible hose connection: please use approved stainless steel braided flexible tubing, parts and gas cock bearing EMSD approval marking (eg. EMSD APPROVAL GTXXXX), or other appropriate methods accepted by EMSD, for connecting from ½ inch B.S.P. thread at the back of the unit to the gas supply point.
B. Towngas Connection Please use approved stainless steel braided flexible tubing and gas cock bearing EMSD approval marking (eg. EMSD APPROVAL GTXXXX), or other appropriate methods accepted by EMSD, for connecting from ½ inch B.S.P. thread at the back of the unit to the gas supply point.

III. Cut-out Dimensions
Model No.
GP13-P1-TG GP13-P1-LG

Wmm 265

Dmm 490

GP13-P2-TG GP13-P2-LG

265

490

Counter Top

W D
Venting Grille

P.7

Installation Instructions

IV. Correct Position of Burner Rack & Burner Cap Make sure that the following parts are fitted properly before use.

A. Burner Rack Fit burner rack onto Drip Pan (Fig. 1). DO NOT tilt the placement, otherwise it will cause the fire to be abnormal.

Burner Rack Drip Pan

Glass Panel

Fig.1 B. Burner Head Install the Burner Cap and Burner Ring onto Burner Head (Fig.2), DO NOT tilt or leave a gap during installation (Fig.3). If either is incorrectly placed, using the cooking range may cause the burner head to deform, or the glass may break, or increase the risk of releasing carbon monoxide (CO).

Burner Ring

Burner Cap

Burner Head GP13-P1-TG/GP13-P1-LG

Burner Head

Fig.2

GP13-P2-TG/GP13-P2-LG

Fig.3 P.8

Operation Instructions

WARNING! All cooking ranges must be installed, tuned and connected by registered gas installers. DO NOT install or repair the cooking range yourself. DO NOT use additional fitting, such as aluminium foil. DO NOT clean the top of the sensor with a hard brush or sharp object, as they may damage the sensor.

1. While pushing the control knob, turn it to the left (towards the " " position) slowly until you hear a `clicking' sound. Electronic spark will ignite burners. Release your hand after confirming the burners are ignited. The hob has automatic continuous ignition function, DO NOT continue
pushing the control knob after ignition. `Click' sound and spark will stop automatically after 6-8
seconds. 2. If the flame goes out when you release your hand, repeat the ignition procedure again but try
releasing your hand slowly. 3. Turn Control Knob to adjust flame to desirable setting.
4. Turn the Control Knob slowly to adjust the flame intensity between "" and " ". (Fig.4).
5. If the flame extinguishes during use, the safety device will automatically shut off the gas supply.
When this happens, turn the Ignition Control Knob knob to "" position. 6. Turning the knob backwards to the "" position will extinguish the burner.(Fig.5)

Ignition

Extinguish

(Fig.4)

(Fig.5)

Note: · When operating at low flame, DO NOT open the cabinet door beneath the cooking range in a quick
motion, otherwise the flame may be extinguished by air draft. · When decreasing flame power from maximum to medium, if flame of the outer ring burner
becomes unstable (weak or extinguished), increase the flame power until flame of outer ring burner is stable, or simply decrease flame power by using only the inner burner ring. · When the cooking range has been operating for 30 minutes, the glass panel and control knobs may become hot due to the heat from the flame. When using the control knobs, please use a moist towel to cool down before usage. · A soft pop sound may be generated when the flame is extinguished, due to instant combustion of gas remaining in the burner. This is a normal phenomenon.
P.9

Operation Instructions
Flame Failure Safety Device · If the flame extinguishes during use, the automatic flame failure safety device will shut off gas
supply to the cooking range. When this happens, turn the knob to "" position.
· The safety sensor is very delicate DO NOT use hard brushes or rough cleaning pads when cleaning it.
· Aeration is preset at factory. DO NOT attempt to adjust it.
Cleaning & Maintenance
WARNING! DO NOT clean the unit when it is hot. Wait until the cooker range has completely cooled down before cleaning. Cleaning The Cooker Range · Wipe the glass panel with a soft damp cloth and mild detergent. · Wash the burner racks and burner heads with warm water and detergent.
WARNING! Clean the burner assembly frequently to maintain a clear gas passage on the flame distributor. Clean and tidy up the flame distributor after spillage of food and liquid once the burner assembly cooled down. Changing The Battery · Battery Box is located on the underside of the product. Open the door of battery box and change
the battery (DC1.5V). · Ensure polarity connection ("+" and " -") of the battery is correct.
P.10

Troubleshooting

Problem

Possible cause
Gas valve not open or gas is used up
Air in the gas tubing

No ignition

Gas hose is bent Injector is clogged

Gas smell

Ignition plug has soot or is in wrong position Flame holes of burner cap are blocked by water or filth Gas tubing has aged
Main fire of burner not lighted Valve leak

Gas pressure too low

Ports of burner cap are clogged Weak flame Air hole is not properly adjusted

Solution Open gas valve or change gas supply
Prolong ignition time and repeatedly ignite till air is vented out
Straighten gas hose
Contact Customer Service & Repair Centre or registered gas installer (RGI) to clear blockage Contact Customer Service & Repair Centre or RGI to clear or adjust the plug Clean and dry burner cap
Contact Customer Service & Repair Centre or RGI to change a new gas tubing Re-ignite after the gas has dispersed Contact Customer Service & Repair Centre or RGI to change a new valve Contact Customer Service & Repair Centre or RGI to check gas supply or whether gas regulator is clogged Clean ports
Contact Customer Service & Repair Centre or RGI to re-adjust air hole for proper air flow

WARNING! If the cooking range still fails to ignite after following the above suggested solutions, DO NOT attempt to ignite by other means. Please contact German Pool Customer Service & Repair Centre.

P.11

Technical Specification

Model Gas Type

GP13-P1-TG H.K. Towngas

GP13-P1-LG H.K. LP Gas

GP13-P2-TG H.K. Towngas

GP13-P2-LG H.K. LP Gas

Gas Working Pressure

1500 Pa

2900 Pa

1500 Pa

2900 Pa

Power

6.0kW

5.0kW

2.5/1.3kW

1.8/1.1kW

Ignition Method Safety Device Product Dimensions

Instant Ignition Delay Technology

Yes

(H) 125 (W) 290 (D) 515 mm

(H) 115 (W) 290 (D) 515 mm

Weight

5.8 kg

5.7 kg

· Specification is subject to change without prior notice. · If there is any inconsistency or ambiguity between the English version and the Chinese version,
the Chinese version shall prevail. · Refer to www.germanpool.com for the most updated version of the User Manual.

P.12

P.13

· ·
· · ·
· ·

·
·
1. 2. 3. 4.
5.
6. 7. 8. 9. 10. 11. 12. 13. 14.
15. 16. 17.
: .
. . 34cm . . 10 18.
P.14

GP13-P1-TG/GP13-P1-LG

GP13-P2-TG/GP13-P2-LG

()

() () ()

() ()

P.15

·
· · · ()15(6) 15 · 25(1) ·
I. 20m³ 100c
II.
·
·
½
A. · (EMSD
APPROVAL GTXXXX) · (EMSD APPROVAL GTXXXX) ½B.S.P.
B. (EMSD APPROVAL GTXXXX) ½B.S.P.
P.16

III .
GP13-P1-TG GP13-P1-LG GP13-P2-TG GP13-P2-LG

265
265

490
490

P.17

IV.
A. (1)

1
B. (2) (3)

GP13-P1-TG/GP13-P1-LG

GP13-P2-TG/GP13-P2-LG

3 P.18

1. ( )

68
2.
3.
4. " " (4) 5.

6. (5)

·
30

· ·

P.19

· · · · · · (1.5) ·
P.20

P.21

()

GP13-P1-TG

GP13-P1-LG

GP13-P2-TG

GP13-P2-LG

1500 Pa

2900 Pa

1500 Pa

2900 Pa

6.0kW

5.0kW

2.5/1.3kW

1.8/1.1kW

125 x 290 x 515

115 x 290 x 515

5.8 kg

5.7 kg

· · · www.germanpool.com

P.22

()

Warranty Terms & Conditions
Under normal operations, the product will gurantee a 1-year full warranty provided by German Pool (effective from the date of purchase).

*
1) VIP

* This warranty is not valid until customer registration information is received by our Service Centre within 10 days of purchase via one of the following means:
1) Visit our VIP App and register online: (Scan the QR Code on the right)

2) www.germanpool.com/warranty
3)

2) Visit our website and register online: www.germanpool.com/warranty
3) Complete the attached Warranty Card and mail it back to our Customer Service Centre.

Please fill out the form below. This information and the original purchase invoice will be required for any repairs. Warranty will be invalidated if information provided is found to be inaccurate.
Model No. : GP13-P1-TG GP13-P1-LG GP13-P2-TG GP13-P2-LG

Serial No. : Purchased From :

Invoice No. : Purchase Date :

1.
2. - - () -
3. - - - -
4.
5.

1. Customer who fails to present original purchase invoice will not be eligible for free warranty service.
2. Customer should always follow the operating instructions. This warranty does not apply to: - labour costs for on-site installation, check-up, repair, replacement of parts and other transportation costs; - damages caused by accidents of any kind (including material transfer and others); - operating failures resulting from applying incorrect voltage, improper usage, and unauthorized installations or repairs.
3. This warranty is invalid if: - the purchase invoice is modified by an unauthorized party; - the product is used for any commercial or industrial purposes; - the product is repaired or modified by unauthorized personnel, or unauthorized parts are installed; - the serial number is modified, damaged or removed from the product.
4. German Pool will, at its discretion, repair or replace any defective part.
5. This warranty will be void if there is any transfer of ownership from the original purchaser.

Customer Service & Repair Centre

Hong Kong

Macau

59 B +852 2773 2888 +852 2356 9798 repairs@germanpool.com

() UnitB,G/F,SunshineKowloonBay

5151A Cargo Centre, 59 Tai Yip Street,

+853 2875 2699 +853 2875 2661

Kowloon, Hong Kong Tel : +852 2773 2888 Fax : +852 2356 9798

Email : repairs@germanpool.com

A, 1 Andar, Mei Kui Kuong Cheong Fase 2, No.515 Avenida Do Conselheiro Borja Macau Tel : +853 2875 2699 Fax : +853 2875 2661

This warranty is valid only in Hong Kong and Macau P.23

German Pool (Hong Kong) Limited

HONG KONG TOP BRAND TEN YEAR ACHIEVEMENTAWARD
© All rights reserved. Copying, reproducing or using the contents of this manual is not allowed without prior authorization from German Pool, violators will be prosecuted.

www.germanpool.com

P.24

GP13-P1_P2_M_24(2)

References

Adobe PDF Library 17.0 Adobe InDesign 19.4 (Windows)