KEVMOR CLEVER II Janser Gigant Stirring Station
Risk Assessment
Janser Gigant Stirring Station
Product: Janser Gigant Stirring Station
Location of Use: Construction sites, commercial flooring jobs, warehouse environments
Date of Assessment: 28/3/25
Assessor Name: Vincent Mort
Review Date: 28/3/26
Identify Hazards / Risky Activities
Step 1:
| Hazard | Description |
| Electrical hazard | Risk of electric shock from damaged cords or contact with wet surfaces |
| Manual handling strain | Injury risk when lifting heavy buckets, moving the unit, or handling material |
| Entanglement | Risk of clothing, hair, or fingers caught in the mixing paddle |
| Slips, trips, and falls | Wet or spilled material can create slippery surfaces |
| Dust inhalation | When pouring in dry compounds or during cleaning |
| Noise exposure | Potential hearing damage during prolonged use in enclosed spaces |
| Overexertion | Risk of fatigue or strain from repetitive use or prolonged operation |
Who Might Be Harmed and How
Step 2
| Person at Risk | How They Might Be Harmed |
| Operator | Electrical shock, strain, entanglement, hearing damage, dust exposure |
| Co-workers | Exposure to dust, slips from spilled material, tripping over cables |
| Maintenance crew | Exposure during cleaning or disassembly; potential for electric shock |
| Clean-up personnel | Risk of handling spills or waste without adequate protection |
Risk Evaluation & Precautions
Step 3
| Hazard | Risk Level | Precautions / Controls |
| Electrical hazard | Medium | Use RCD-protected outlets; inspect leads before use; avoid wet areas |
| Manual handling strain | Medium | Use lifting aids or team lift; avoid overfilling buckets; train on manual handling |
| Entanglement | High | Fit paddle guard; tie back hair; wear tight-fitting clothing; never reach inside when operating |
| Slips, trips, and falls | Medium | Keep work area clean; clean spills immediately; use non-slip mats if needed |
| Dust inhalation | Medium | Wear P2 mask when adding dry mix; operate in well ventilated area |
| Noise exposure | Low– Medium | Use hearing protection when in enclosed or echo-prone spaces |
| Overexertion | Medium | Rotate tasks to avoid fatigue; provide breaks |
Risk Management Plan
Step 4
Controls in Place:
- PPE Required: Safety boots, gloves, hearing protection, P2 mask, eye protection
- Pre-use Inspection: Check cables, plug, mixer arm, and paddle guard
- Training: All operators must be trained on setup, safe use, and emergency shut-off
- Operating Guidelines: Never leave unit running unattended; use only for intended materials
- Spill Response: Keep mop, bucket, and absorbent materials nearby for rapid clean-up
- Storage & Transport: Lock wheels when stationary; transport using proper lifting technique
Review and Update
Step 5
Review Triggers:
- Every 6 months or after a near miss/incident
- When the unit is replaced or upgraded
- If job site conditions change significantly
Next Review Date: 28/3/26
Documents / Resources
 |
KEVMOR CLEVER II Janser Gigant Stirring Station [pdf] Instructions CLEVER II Janser Gigant Stirring Station, CLEVER II, Janser Gigant Stirring Station, Gigant Stirring Station, Stirring Station |