GATEWAY
Model Number: CE-IMX8-01
Operational description
The gateway is used for connecting cargo and load handling solutions to cloud services. Rugged low power gateway is designed for installation operating in worldwide environmental conditions.
TECHNICAL SPECIFICATIONS
PERFORMANCE
NXP i.MX 8M Nano, 1200 MHZ
1GB RAM
8GB eMMC
INTERFACES
1 x 10/100 Mbit Ethernet
1 x CAN 2.0b, (split termination and selectable 120Ω termination. Support listen only mode)
1 x 1-wire
1 x LC Interface, Isolated
ANALOG
2 x analog inputs, selectable as 0…10V or
4-20mA.
DIGITAL
3 x GPI
4 x GPO, non-regulated 500mA
POWER
1 x DC in, 12/24V (8-32VDCwide range)
SENSOR
Accelerometer and Gyro
WAKE-UP
Always: Ignition
Configurable : Accelerometer, RTC, GPI1
CONNECTORS
Main Connector : 1 x 35Pin AMPSEAL
LTE : 2 x FAKRA D coding
GPS: 1 x FAKRA C coding
WIFI/BT: 1 x FAKRA I coding
TEMPERATURE
Operating : -40C to + 80C
INGRESS PROTECTION
HIAB submerge test compliant
HIAB clean water test compliant
HIAB aggressive water test comliant
VIBRATION
HIAB random vibration test compliant
Bromma random vibration test compliant
HIAB shock test compliant
ELECTRICAL PROTECTION
All IO, except USB, withstand fault condition to GND or system input voltage
ISO 7637-2
Pulse 1, 2a, 2b, 3a, 3b, 4, 5a
MECHANICAL DIMENSIONS
Weight: 1000g
MOUNTING:
- Use 4 pieces M4 screws and washers for installation
- The connectors must be facing downwards
RADIO TECHNOLOGIES AND OUTPUT POWER
Code G
Modules used:
WLAN/Bluetooth: Murata LBEE5CJ1XK-687
https://www.murata.com/products/productdata/8813653590046/type1xk.pdf
Note: 5GHz WLAN not used, see table below.
Cellular: Quectel EG21-G
https://fcc.report/FCC-ID/XMR201906EG21G/4310708.pdf
| Radio | Frequency (GHz) | Max output power (dBm) | Antenna* Gain (dBi) | EIRP (dBm) | Note |
| WLAN | 2400 | 19,0 | 2,15 | 21,15 | |
| Bluetooth 5.2 | 2400 | 6,3 | 2,15 | 8,45 | |
| GSM | 850 | 33,0 | 4,50 | 37,50 | +/-2dB |
| GSM | 900 | 33,0 | 4,50 | 37,50 | +/-2dB |
| GSM | 1800 | 30,0 | 5,00 | 35,00 | +/-2dB |
| GSM | 1900 | 30,0 | 5,00 | 35,00 | +/-2dB |
| Band | |||||
| WCDMA | B1 | 24,0 | 4,50 | 28,50 | +1/-3dB |
| WCDMA | B2 | 24,0 | 5,00 | 29,00 | +1/-3dB |
| WCDMA | B4 | 24,0 | 4,00 | 28,00 | +1/-3dB |
| WCDMA | B5 | 24,0 | 4,50 | 28,50 | +1/-3dB |
| WCDMA | B6 | 24,0 | 4,50 | 28,50 | +1/-3dB |
| WCDMA | B8 | 24,0 | 4,50 | 28,50 | +1/-3dB |
| WCDMA | B19 | 24,0 | 4,50 | 28,50 | +1/-3dB |
| LTE-FDD | B1 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-FDD | B2 | 23,0 | 5,00 | 28,00 | +/-2dB |
| LTE-FDD | B3 | 23,0 | 5,00 | 28,00 | +/-2dB |
| LTE-FDD | B4 | 23,0 | 5,00 | 28,00 | +/-2dB |
| LTE-FDD | B5 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-FDD | B7 | 23,0 | 3,50 | 26,50 | +/-2dB |
| LTE-FDD | B8 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-FDD | B12 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-FDD | B13 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-FDD | B18 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-FDD | B19 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-FDD | B20 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-FDD | B25 | 23,0 | 5,00 | 28,00 | +/-2dB |
| LTE-FDD | B26 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-FDD | B28 | 23,0 | 4,50 | 27,50 | +/-2dB |
| LTE-TDD | B38 | 23,0 | 3,00 | 26,00 | +/-2dB |
| LTE-TDD | B39 | 23,0 | 4,00 | 27,00 | +/-2dB |
| LTE-TDD | B40 | 23,0 | 3,00 | 26,00 | +/-2dB |
| LTE-TDD | B41 | 23,0 | 3,00 | 26,00 | +/-2dB |
| Technology | |||||
| GNSS | GPS | ||||
| GNSS | GLONASS | ||||
| GNSS | BeiDou | ||||
| GNSS | Galileo | ||||
| GNSS | QZSS |
.* Smarteq: AllDisc Combi GNSS WiFi
WARNING
HOT SURFACE
DO NOT TOUCH
Safety Warning: This equipment is intended for installation in a Restricted Access Location only.
FCC & IC notice
- Any changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate this equipment.
- This equipment should be installed and operated with minimum distance 20cm between the radiator & your body.
- The FCC part 15.19 statement: This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.
- The ISED RSS-Gen statement:
This device contains licence-exempt transmitter(s)/receiver(s) that comply with Innovation, Science and Economic Development Canada’s licence-exempt RSS(s).
Operation is subject to the following two conditions:
1. This device may not cause interference.
2. This device must accept any interference, including interference that may cause undesired operation of the device.
CE Marking
For the Cargotec Gateway, the CE mark is affixed to the equipment and its packaging
WEEE compliance
- Natural resources were used in the production of this equipment.
- This equipment may contain hazardous substances that could impact the health of the environment.
- In order to avoid harm to the environment and consumption of natural resources, we encourage you to use appropriate take-back systems when disposing of this equipment.
- The appropriate take-back systems will reuse or recycle most of the materials of this equipment in a way that will not harm the environment.
- The crossed-out wheeled bin symbol (in accordance with European Standard EN 50419) invites you to use those take-back systems and advises you not to combine the material with refuse destined for a land fill.
- If you need more information on collection, re-use and recycling systems, please contact your local or regional waste administration.
- Please contact Cargotech for specific information on the environmental performance of our products.
Cargotec Oyj
Porkkalankatu 5, 00180 Helsinki, Finland
Documents / Resources
 |
CARGOTEC CE-IMX8-01 Rugged Low Power Gateway [pdf] Instruction Manual CE-IMX8-01, CE-IMX8-01 Rugged Low Power Gateway, Rugged Low Power Gateway, Low Power Gateway, Power Gateway, Gateway |