Introduction
This manual provides essential information for the safe and efficient operation of your NOMAD CR50X 12/24V Integrated Refrigerator. Designed for campervans, motorhomes, and boats, the CR50X offers reliable cooling and freezing capabilities with advanced features like a digital control panel, night mode, reversible door, and robust battery protection.
Please read this manual thoroughly before installation and use to ensure optimal performance and longevity of your appliance.
Safety Instructions
- Ensure the appliance is connected to a 12V or 24V DC power supply only.
- Do not block ventilation openings.
- Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
- Do not damage the refrigerant circuit.
- Do not use electrical appliances inside the food storage compartments of the appliance, unless they are of the type recommended by the manufacturer.
- Keep the appliance away from direct heat sources and direct sunlight.
- This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety.
- Children should be supervised to ensure that they do not play with the appliance.
Setup
Unpacking and Inspection
Carefully remove the refrigerator from its packaging. Inspect the unit for any signs of damage during transit. Report any damage to your supplier immediately. The package should contain the NOMAD CR50X RV Fridge unit.
Placement and Ventilation
The CR50X is designed for built-in installation. Ensure adequate ventilation around the unit to allow for proper heat dissipation. Refer to the dimensions for precise fitting:
- Product Dimensions: 380mm (W) x 494mm (D) x 532mm (H)
Door Reversibility and Installation
The CR50X features a reversible door, allowing it to open from either the left or right side to suit your installation needs. Instructions for reversing the door can be found in the detailed installation guide (not included in this general manual, refer to product packaging or manufacturer's website).
Electrical Connection
Connect the refrigerator to a stable 12V or 24V DC power source. Ensure the wiring is correctly sized for the current draw (5 amps at 12V / 2.5 amps at 24V). The unit is equipped with a 3-level battery protection system to prevent deep discharge of your leisure battery.
- High Mode: Disconnects at higher voltage to protect battery for longer.
- Medium Mode: Standard protection.
- Low Mode: Allows for deeper discharge, suitable for robust battery systems.
Select the appropriate battery protection level based on your battery type and usage requirements.
Operating Instructions
Digital Control Panel
The CR50X features a soft-touch digital control panel for precise temperature management.
- Power Button: Press and hold to turn the unit ON/OFF.
- Temperature Adjustment: Use the '+' and '-' buttons to set the desired temperature. The display will show the current and target temperatures.
- Settings Button (Gear Icon): Access advanced settings, including battery protection level and night mode.
- Night Mode: Activates a quieter operation mode, ideal for sleeping.
Temperature Range
The refrigerator compartment operates between 0-8°C (32-46°F), and the freezer compartment between -12 to -20°C (10 to -4°F).
Maintenance
Cleaning
- Always disconnect the power before cleaning.
- Clean the interior and exterior with a damp cloth and mild detergent. Avoid abrasive cleaners or solvents.
- Regularly clean the condenser coils (located at the back or bottom) to ensure efficient operation. Use a soft brush or vacuum cleaner.
- Wipe down door seals regularly to maintain a tight seal.
Defrosting
The CR50X features a manual defrost system. When ice buildup in the freezer compartment exceeds a few millimeters, defrost the unit:
- Turn off the refrigerator and disconnect it from the power supply.
- Remove all food items and place them in a cooler.
- Leave the door open to allow ice to melt naturally. You can place towels at the bottom to absorb water.
- Do not use sharp objects or heating devices to speed up defrosting, as this can damage the unit.
- Once defrosted, clean and dry the interior thoroughly before reconnecting power and returning food.
Long-Term Storage
If the refrigerator will not be used for an extended period, clean it thoroughly, leave the door slightly ajar to prevent odors and mold, and disconnect it from the power supply.
Troubleshooting
| Problem | Possible Cause | Solution |
|---|---|---|
| Refrigerator not cooling | No power; Temperature setting too high; Poor ventilation; Door not closed properly. | Check power connection and fuse; Adjust temperature setting lower; Ensure adequate airflow around the unit; Check door seal and ensure it's fully closed. |
| Unit is noisy | Unit not level; Objects vibrating against the unit; Compressor noise (normal). | Ensure the unit is on a stable, level surface; Remove any objects touching the unit; Some compressor noise is normal, especially when starting. |
| Excessive ice buildup | Door left open frequently; High humidity; Faulty door seal. | Minimize door openings; Ensure door is fully closed; Check and clean door seal, replace if damaged; Defrost the unit manually. |
| Digital display not working | Power issue; Control panel malfunction. | Check power supply; Try turning the unit off and on again; If problem persists, contact customer support. |
Specifications
For detailed technical specifications, please refer to the table below or visit the official product page: NOMAD CR50X Technical Data
| Feature | Detail |
|---|---|
| Brand | Nomad |
| Model | CR50X |
| Product Dimensions (W x D x H) | 380 x 494 x 532 mm |
| Item Weight | 14.6 kg |
| Total Capacity | 43.4 litres |
| Refrigerator Capacity | 40.2 litres |
| Freezer Capacity | 3.2 litres |
| Voltage | 12V / 24V DC |
| Rated Power | 60 Watts |
| Rated Current (12V / 24V) | 5 amps / 2.5 amps |
| Annual Energy Consumption | 74 kWh/annum |
| Noise Level | ≤45dB |
| Refrigerant | R600a Isobutane (12g) |
| Defrost System | Manual |
| Door Orientation | Reversible |
| Special Features | 3-Layer Battery Protection System, Digital Control Panel, Night Mode |
| Installation Type | Built-In |
| Certifications | CE/TUV/SGS |
Warranty and Support
Your NOMAD CR50X refrigerator comes with a manufacturer's warranty. Please refer to the warranty card included with your purchase or visit the official Nomad website for detailed warranty terms and conditions.
For technical assistance, troubleshooting not covered in this manual, or warranty claims, please contact Nomad customer support through their official website or the retailer from whom you purchased the product.
