1. Introduction
Thank you for choosing the GGM Gastro AGG143END#07 ECO Refrigerated Display Case. This unit is designed for professional use in food preparation areas, offering efficient and hygienic storage for various ingredients. Featuring an ECO-friendly design, high-quality AISI 304 stainless steel construction, and precise temperature control, this display case ensures optimal food preservation.
This manual provides essential information for the safe and efficient installation, operation, and maintenance of your refrigerated display case. Please read it thoroughly before use and keep it for future reference.
Image 1.1: Front view of the GGM Gastro AGG143END#07 ECO Refrigerated Display Case.
2. Safety Instructions
To ensure safe operation and prevent damage, observe the following safety guidelines:
- Read all instructions before operating the appliance.
- Ensure the power supply matches the specifications (220-240V / 1N/PE / 50 Hz).
- Do not operate the appliance with a damaged power cord or plug.
- Keep the appliance away from heat sources and direct sunlight.
- Ensure adequate ventilation around the unit to prevent overheating.
- This appliance uses R600a refrigerant. Handle with care and ensure proper ventilation during maintenance or repair. Do not puncture the refrigerant circuit.
- Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.
- Only qualified personnel should perform repairs or maintenance.
- Clean the appliance regularly to maintain hygiene standards, especially when handling food.
3. Setup and Installation
3.1 Unpacking
Carefully remove the display case from its packaging. Inspect the unit for any damage incurred during transit. Report any damage to your supplier immediately.
3.2 Placement
- Place the unit on a stable, level surface to ensure proper drainage and operation.
- Allow sufficient space around the unit for air circulation (at least 10 cm on all sides, especially at the rear where the compressor is located).
- Avoid placing the unit near heat-emitting appliances or in direct sunlight, as this can affect cooling efficiency.
3.3 Electrical Connection
Connect the appliance to a grounded electrical outlet with the specified voltage and frequency: 220 - 240 Volt / 1N/PE / 50 Hz. Ensure the circuit can handle the unit's power consumption of 110 Watt.
3.4 Initial Cleaning
Before first use, clean the interior and exterior surfaces of the display case with a mild detergent and a soft cloth. Rinse thoroughly and dry completely.
Image 3.1: External dimensions of the refrigerated display case (1400mm L x 335mm D x 281mm H).
4. Operating Instructions
4.1 Powering On/Off
Plug the unit into the power outlet. The digital display will illuminate. To turn off, simply unplug the unit.
4.2 Temperature Regulation
The display case features a digital thermostat and electronic temperature regulation. The factory-set temperature range is 2 °C to 8 °C. Use the controls on the digital display to adjust the desired temperature within this range. Allow the unit to reach the set temperature before loading food.
4.3 Loading GN Containers
The unit is designed to accommodate 6 x GN 1/4 containers. Place the food items in the GN containers and then insert them into the refrigerated compartments. Ensure the food is pre-chilled to the desired temperature before placing it in the display case to maintain optimal cooling efficiency.
Image 4.1: Refrigerated display case loaded with various food items in GN containers.
5. Cleaning and Maintenance
Regular cleaning and maintenance are crucial for the hygiene and longevity of your display case.
5.1 Daily Cleaning
- Disconnect the unit from the power supply before cleaning.
- Remove all GN containers and food items.
- Clean the interior and exterior surfaces with a mild, food-safe detergent and a soft cloth.
- Rinse with clean water and dry thoroughly to prevent water spots and bacterial growth.
- Do not use abrasive cleaners, steel wool, or harsh chemicals, as these can damage the stainless steel finish.
5.2 Manual Defrosting
This unit features manual defrosting. When a significant layer of ice builds up on the cooling surfaces, disconnect the unit from power, remove all food, and allow the ice to melt naturally. Collect the defrost water and clean the interior thoroughly afterward.
Image 5.1: Interior view of the refrigerated display case with empty GN compartments, ready for cleaning.
6. Troubleshooting
Before contacting customer service, please check the following common issues:
| Problem | Possible Cause | Solution |
|---|---|---|
| Unit not cooling | Power cord unplugged; circuit breaker tripped; thermostat set too high; poor ventilation. | Check power connection; reset breaker; adjust thermostat; ensure adequate airflow. |
| Excessive noise | Unit not level; loose components; fan obstruction. | Adjust leveling feet; inspect for loose parts; clear fan area. |
| Temperature too high | Door/lid not closed properly; warm food loaded; excessive ambient temperature; dirty condenser. | Ensure lid is closed; pre-chill food; relocate unit if ambient is too high; clean condenser (professional service recommended). |
If the problem persists after attempting these solutions, please contact a qualified service technician.
7. Technical Specifications
| Feature | Specification |
|---|---|
| Model | AGG143END#07 |
| External Dimensions (L x D x H) | 1400 mm x 335 mm x 281 mm |
| Usable Volume | 40 Liters |
| Operating Noise Level | 55 dB |
| Power | 110 Watt |
| Electrical Connection | 220 - 240 Volt / 1N/PE / 50 Hz |
| Temperature Range | 2 °C to 8 °C |
| Refrigerant | R600a / 35 g (CFC-free) |
| Material | High-quality AISI 304 Stainless Steel (0.70 mm thickness) |
| Capacity | 6 x GN 1/4 containers (GN containers not included) |
| Refrigeration Type | Static Refrigeration |
| Defrost Type | Manual |
| Certifications | CE compliant, conforms to European food standards |
Image 7.1: ECO friendly refrigerant logo, highlighting environmental considerations.
8. Warranty Information
GGM Gastro products are manufactured to high-quality standards. For specific warranty terms and conditions, please refer to the warranty card included with your purchase or visit the official GGM Gastro website. Keep your proof of purchase for any warranty claims.
9. Customer Support
Should you require assistance, have questions about your product, or need to report a fault, please contact GGM Gastro customer support. Contact details can typically be found on the official GGM Gastro website or on your purchase documentation.
For online support and resources, please visit: www.ggmgastro.com
