1. Important Safety Information
Please read this manual carefully before installing or using your Glem Gas hob. Keep these instructions for future reference. Incorrect installation, adjustment, alteration, service, or maintenance can cause injury or property damage. Consult a qualified installer, service agency, or the gas supplier for assistance.
- Gas Safety: Ensure proper ventilation. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. If you smell gas, follow the instructions in the "Troubleshooting" section immediately.
- Electrical Safety: If the hob has electric ignition, ensure it is properly grounded. Do not operate the appliance with wet hands.
- Burn Hazard: The hob surface and surrounding areas become hot during use. Do not touch hot surfaces. Use oven mitts.
- Children Safety: Keep children away from the appliance during operation. Do not allow children to play with the controls.
- General Use: Use only for cooking purposes. Do not use as a space heater. Do not leave the appliance unattended during operation.
2. Product Overview
The Glem Gas GTL64IX is a 58.5 cm gas hob featuring four burners and convenient side controls. It is designed for efficient and reliable cooking.
Image: Top-down view of the Glem Gas 4-burner gas hob, showing the stainless steel surface, four burner grates, and control knobs located on the right side.
Image: Close-up view of the Glem Gas hob, highlighting the stainless steel finish, a burner with its black cap, and the metallic control knobs with flame indicators.
3. Installation and Setup
Installation of this gas hob must be carried out by a qualified and authorized technician in accordance with local regulations and standards. Improper installation can lead to hazards.
3.1 Unpacking
- Carefully remove the hob from its packaging.
- Check for any damage during transit. Report any damage to your supplier immediately.
- Ensure all components are present: hob unit, burner caps, burner grates, and instruction manual.
3.2 Dimensions and Cut-out
Refer to the diagram below for precise dimensions and the required cut-out size for installation into your countertop.
Image: Technical diagram showing the dimensions of the Glem Gas hob (58.5 cm width, 50 cm depth, 3 cm height) and the required countertop cut-out dimensions (56 cm width, 48 cm depth). All measurements are in centimeters.
- Product Dimensions: 58.5 cm (Width) x 50 cm (Depth) x 3 cm (Height)
- Cut-out Dimensions: 56 cm (Width) x 48 cm (Depth)
3.3 Gas Connection
The hob is designed for natural gas. Ensure the gas supply pressure is compatible with the appliance. A flexible gas hose or rigid pipe connection must be used according to local regulations. Always check for gas leaks after connection using a soapy water solution, never an open flame.
3.4 Electrical Connection (for Ignition)
If your model includes electric ignition, connect the power cord to a properly grounded electrical outlet. Ensure the voltage and frequency match the appliance's requirements (typically 220-240V, 50/60Hz).
4. Operating Instructions
This section describes how to safely and effectively use your Glem Gas hob.
4.1 Igniting a Burner
- Place a suitable cooking utensil on the burner grate.
- Push down and turn the corresponding control knob counter-clockwise to the maximum flame position (large flame symbol).
- Hold the knob down for a few seconds until the flame ignites and stabilizes. If the flame goes out, repeat the process.
- Once ignited, release the knob.
Image: Close-up view of the metallic control knobs on the Glem Gas hob, showing the symbols for ignition, maximum flame, and minimum flame settings.
Image: Close-up of a Glem Gas hob burner in operation, showing a stable blue flame indicating proper gas combustion.
4.2 Adjusting the Flame
After ignition, you can adjust the flame size by turning the control knob between the maximum and minimum flame positions (small flame symbol). For simmering, use the minimum flame setting.
4.3 Turning Off a Burner
To turn off a burner, turn the control knob clockwise until it clicks into the "off" position (dot symbol). Ensure the flame is completely extinguished.
5. Maintenance and Cleaning
Regular cleaning and maintenance will ensure the longevity and optimal performance of your hob.
5.1 General Cleaning
- Always ensure the hob is cool before cleaning.
- Use a soft cloth and mild detergent for the stainless steel surface. Avoid abrasive cleaners or scouring pads, which can scratch the surface.
- Wipe up spills immediately to prevent staining.
5.2 Cleaning Burner Components
Image: Close-up view of a Glem Gas hob burner with the grate removed, showing the burner cap and base, ready for cleaning.
- Remove the burner grates and burner caps when cool.
- Wash them with warm soapy water. For stubborn stains, a non-abrasive cleaner can be used.
- Ensure all parts are completely dry before reassembling them. Moisture can interfere with ignition.
- Periodically check the burner holes for blockages and clean them gently with a small brush if necessary.
6. Troubleshooting
If you encounter issues with your hob, refer to the following common problems and solutions before contacting service.
| Problem | Possible Cause | Solution |
|---|---|---|
| Burner does not ignite. | No gas supply, burner components wet or blocked, faulty igniter. | Check gas supply. Ensure burner caps and bases are dry and correctly positioned. Clean burner holes. If electric ignition, check power supply. |
| Flame is irregular or yellow. | Burner holes blocked, incorrect gas type, improper air mixture. | Clean burner holes. Ensure correct gas type is being used. Contact a qualified technician if the issue persists. |
| Smell of gas. | Gas leak. | Immediately turn off the gas supply. Open windows and doors for ventilation. Do not operate any electrical switches or appliances. Do not use an open flame. Contact your gas supplier or a qualified technician immediately. |
7. Specifications
Detailed technical specifications for the Glem Gas GTL64IX hob.
- Brand: Glem Gas
- Model: GTL64IX
- Product Dimensions: 50 x 58.5 x 3 cm (Depth x Width x Height)
- Weight: 8.12 Kilograms
- Installation Type: Built-in Hob
- Hob Type: Gas
- Number of Heating Elements/Burners: 4
- Color: Silver
- Fuel Type: Natural Gas
- Material: Stainless Steel
- Ignition System Type: Manual Gas Pilot Light
- Control Type: Knob
8. Warranty and Support
For warranty information, please refer to the warranty card included with your product or contact your retailer. For technical support or service, please contact Glem Gas customer service or an authorized service center. Ensure you have your model number (GTL64IX) and purchase date available when contacting support.
You can find more information on the official Glem Gas website or through your local distributor.
