Introduction
This official owner's manual provides comprehensive information for the maintenance and operation of your 2001 Harley Davidson FLT motorcycle. It contains essential details to ensure proper care and safe use of your vehicle.
Refer to this manual for guidance on various aspects of your motorcycle, from basic operation to routine maintenance procedures.
Image: Front cover of the official 2001 Harley Davidson FLT Motorcycle Owners Manual. This manual details all necessary information for operating and maintaining the motorcycle.
Setup and Pre-Operation Checks
Before each ride, perform the following checks to ensure safe operation:
- Tire Pressure: Verify tire pressure is at recommended levels. Refer to the tire pressure label on your motorcycle or in the specifications section.
- Fluid Levels: Check engine oil, primary chaincase lubricant, and transmission fluid levels. Top up if necessary.
- Brakes: Inspect front and rear brake fluid levels and ensure proper brake lever/pedal free play.
- Lights and Signals: Confirm all lights (headlight, taillight, turn signals) and the horn are functioning correctly.
- Controls: Ensure throttle, clutch, and brake controls operate smoothly and return freely.
Operating Instructions
Familiarize yourself with the motorcycle's controls and operating procedures before riding.
Starting the Engine
- Ensure the transmission is in neutral.
- Turn the ignition switch to the "IGNITION" position.
- Pull the choke knob out if the engine is cold.
- Press the start button. Release immediately once the engine starts.
- Allow the engine to warm up before riding. Push the choke knob in as the engine warms.
Shifting Gears
The FLT model features a foot-operated gear shift lever. Shift up by lifting the lever and down by pressing it. Always use the clutch when shifting gears.
Braking
Use both front and rear brakes simultaneously for optimal stopping power. Apply brakes smoothly and progressively.
Maintenance Schedule
Regular maintenance is crucial for the longevity and performance of your Harley Davidson FLT motorcycle. Adhere to the recommended service intervals.
| Service Item | Interval | Action |
|---|---|---|
| Engine Oil & Filter | Every 2,500 miles or 6 months | Replace |
| Spark Plugs | Every 5,000 miles or 12 months | Inspect/Replace |
| Primary Chain Adjustment | Every 2,500 miles | Inspect/Adjust |
| Brake Fluid | Every 2 years | Replace |
Note: This is a general guide. Always refer to the detailed maintenance schedule within the full owner's manual for specific procedures and intervals.
Troubleshooting Common Issues
This section addresses common operational issues you might encounter and provides basic troubleshooting steps.
Engine Will Not Start
- Battery: Check battery terminals for corrosion and ensure the battery is charged.
- Fuel: Verify there is sufficient fuel in the tank and the fuel valve is open.
- Kill Switch: Ensure the engine stop switch is in the "RUN" position.
- Neutral Safety Switch: Confirm the transmission is in neutral or the clutch lever is pulled in.
Poor Engine Performance
- Air Filter: Inspect the air filter for clogging and clean or replace if necessary.
- Spark Plugs: Check spark plugs for fouling or wear.
- Fuel System: Ensure fuel lines are not kinked and the fuel filter is clean.
For complex issues, it is recommended to consult a certified Harley Davidson service technician.
Specifications
Key specifications for the 2001 Harley Davidson FLT motorcycle:
- Model: FLT Series
- Engine Type: Twin Cam 88 (specific displacement may vary by sub-model)
- Transmission: 5-speed
- Fuel Capacity: Approximately 5 gallons (18.9 liters)
- Weight: Refer to specific sub-model documentation for exact curb weight.
- Tire Sizes: Front and rear tire sizes are specified on the tire pressure label.
Detailed specifications for your specific FLT sub-model can be found in the complete owner's manual.
Warranty Information
This manual itself does not contain specific warranty details for the motorcycle. For information regarding the original manufacturer's warranty for your 2001 Harley Davidson FLT motorcycle, please refer to the separate warranty booklet provided at the time of purchase or contact an authorized Harley Davidson dealership.
Support and Service
For technical assistance, genuine Harley Davidson parts, or professional service, please contact an authorized Harley Davidson dealership. They have trained technicians and specialized tools to service your motorcycle correctly.
You can locate your nearest authorized dealer by visiting the official Harley Davidson website or by consulting your local directory.
