Introduction
Thank you for choosing the CATA TF 2003 DURALUM 60 Extractor Hood. This manual provides essential information for the safe installation, operation, and maintenance of your new appliance. Please read it thoroughly before use and keep it for future reference.
Important Safety Information
WARNING: To reduce the risk of fire, electric shock, or injury, observe the following:
- Read all instructions carefully before installing or operating the appliance.
- Installation must be carried out by a qualified technician in accordance with local regulations.
- Ensure the power supply matches the voltage specified on the rating plate.
- Do not operate the hood if the power cord is damaged.
- Always disconnect the appliance from the power supply before cleaning or maintenance.
- This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety.
- Children should be supervised to ensure that they do not play with the appliance.
- There is a fire risk if cleaning is not carried out in accordance with the instructions.
- Do not flambé under the range hood.
- The air must not be discharged into a flue that is used for exhausting fumes from appliances burning gas or other fuels.
- Minimum distance between the hob and the lower part of the hood must be at least 65 cm.
Setup and Installation
The CATA TF 2003 DURALUM 60 is designed for integrated telescopic installation under a kitchen cabinet. It features an easy installation system.
Dimensions
Refer to the diagram below for precise measurements required for installation.
- Product Dimensions (Depth x Width x Height): 28 cm x 60 cm x 14 cm
- Air Outlet Diameter: 120 mm
Figure 1: Dimensional drawing of the extractor hood, indicating width, depth, height, and air outlet diameter.
Figure 2: Front view of the CATA TF 2003 DURALUM 60 extractor hood, showing the telescopic panel extended and LED lights.
Mounting
This hood is designed for under-cabinet mounting. Ensure the cabinet structure can support the weight of the hood. The system includes easy installation features. The air outlet is rectangular but comes with a round adapter.
Figure 3: Diagram illustrating the installation process of the extractor hood within a kitchen cabinet.
Operating Instructions
The CATA TF 2003 DURALUM 60 features mechanical controls for easy operation.
Power and Speed Control
The hood is equipped with a 100W tangential motor and offers 2 extraction speeds. The airflow can be regulated between 150 m³/h and 390 m³/h.
- Speed 1: Minimum power for light cooking, with a noise level of 45 dB(A).
- Speed 2: Maximum power for intensive cooking, with a noise level up to 57 dB(A).
Figure 4: Detail of the mechanical control switches for power and speed settings.
Lighting
The hood includes LED lighting to provide direct visibility over your cooking area. Use the dedicated switch to turn the lights on or off.
Figure 5: View of the hood's underside, highlighting the integrated LED lights and metallic grease filters.
Maintenance and Cleaning
Regular maintenance ensures optimal performance and longevity of your extractor hood.
Cleaning the Filters
The metallic grease filters are washable and dishwasher safe. It is recommended to clean them regularly, depending on usage, to maintain extraction efficiency.
- Ensure the hood is disconnected from the power supply.
- Remove the filters by releasing their locking mechanisms.
- Wash the filters by hand with hot soapy water or place them in a dishwasher.
- Allow filters to dry completely before re-installing.
Figure 6: Detail of the metallic grease filter, designed for easy removal and cleaning.
Cleaning the Exterior and Interior
The hood features a DURALUM anti-fingerprint stainless steel finish, making it easy to clean. The shielded interior also facilitates maintenance.
- Wipe exterior surfaces with a soft cloth and a mild, non-abrasive cleaner.
- For the interior, use a damp cloth to remove any grease buildup.
- Do not use abrasive products or corrosive detergents.
Troubleshooting
Before contacting customer service, please check the following common issues:
| Problem | Possible Cause | Solution |
|---|---|---|
| Hood does not turn on. | No power supply; power cord disconnected; fuse blown. | Check power connection; check circuit breaker/fuse box. |
| Low extraction power. | Grease filters are dirty; ducting is blocked or too long; telescopic panel not fully extended. | Clean or replace filters; check ducting for obstructions; ensure telescopic panel is fully extended during operation. |
| Excessive noise. | Loose components; improper installation; ducting issues. | Check for loose screws or parts; ensure proper installation; inspect ducting for vibrations or obstructions. |
| Lights not working. | Bulb faulty; electrical connection issue. | Replace LED bulb (if replaceable); check electrical connections. |
Technical Specifications
| Feature | Specification |
|---|---|
| Model Number | TF 2003 DURALUM 60 (02017305) |
| Brand | Cata |
| Material | Stainless Steel |
| Color | Inox |
| Dimensions (DxWxH) | 28 cm x 60 cm x 14 cm |
| Weight | 1 kg |
| Airflow Capacity | 390 m³/h (max) |
| Number of Speeds | 2 |
| Noise Level | 45 dB (min) - 57 dB (max) |
| Motor Power | 100 W |
| Total Power | 107 W |
| Voltage | 240 Volts |
| Frequency | 50 Hz |
| Lighting Type | LED |
| Control Type | Mechanical |
| Filter Type | Metallic (Washable) |
| Mounting Type | Under-cabinet mounting |
| Special Features | DURALUM anti-fingerprint finish, Easy installation system, Shielded interior |
Figure 7: Official product data sheet with detailed technical specifications.
Figure 8: Energy label indicating efficiency class C, annual energy consumption, and noise levels.
Warranty Information
This CATA TF 2003 DURALUM 60 Extractor Hood comes with a 3-year warranty from the date of purchase. Please retain your proof of purchase for any warranty claims. The availability of spare parts in the EU is guaranteed for 2 years.
Customer Support
For further assistance, technical support, or spare parts, please contact your local CATA service center or visit the official CATA website. You can also refer to the official CATA brand store on Amazon for more information: CATA Brand Store.
Additional documents, including a detailed installation manual and user manual in PDF format, are available:
