Introduction
Thank you for purchasing the Commercial Cool CCR45B Compact Refrigerator and Freezer. This manual provides essential information for the safe installation, operation, and maintenance of your appliance. Please read these instructions thoroughly before use and retain them for future reference.
Important Safety Instructions
To reduce the risk of fire, electric shock, or injury when using your refrigerator, follow these basic precautions:
- Read all instructions before using the appliance.
- DANGER: Risk of child entrapment. Before you throw away your old refrigerator or freezer, take off the doors. Leave the shelves in place so that children may not easily climb inside.
- Never clean refrigerator parts with flammable fluids. The fumes can create a fire hazard or explosion.
- Do not store or use gasoline or any other flammable vapors and liquids in the vicinity of this or any other refrigerator. The fumes can create a fire hazard or explosion.
- Unplug the refrigerator before cleaning or making any repairs.
- Ensure the appliance is properly grounded.
- Do not use electrical appliances inside the food storage compartments unless they are of the type recommended by the manufacturer.
- This appliance uses R600a refrigerant. Handle with care.
Product Overview
The Commercial Cool CCR45B is a compact single-door refrigerator with a dedicated freezer compartment, designed for efficient cooling in smaller spaces.
Figure 1: Exterior view of the Commercial Cool CCR45B compact refrigerator. This image shows the sleek black finish and recessed door handle.
Figure 2: Interior view of the Commercial Cool CCR45B compact refrigerator. The image displays the adjustable glass shelves, door storage, and the top-mounted freezer compartment.
Key Features:
- 4.5 Cubic Feet Capacity
- 3 Full-width Slide-out Glass Shelves
- Door Storage for Cans and Tall Bottles
- Half-width Freezer Compartment with Ice Cube Tray
- Recessed Door Handle
- Adjustable Leveling Legs
- Manual Defrost System
- Reversible Door Hinges
Installation and Setup
1. Unpacking
Carefully remove all packaging materials, including the foam base and adhesive tape. Inspect the refrigerator for any damage. Keep packaging materials out of reach of children.
2. Location
- Place the refrigerator on a flat, solid surface strong enough to support it when fully loaded.
- Allow at least 5 inches (12.7 cm) of space between the back and sides of the refrigerator and any adjacent walls to ensure proper air circulation.
- Avoid placing the appliance in direct sunlight or near heat sources (e.g., stove, heater).
- Ensure the electrical outlet is easily accessible.
3. Leveling the Refrigerator
Your refrigerator has adjustable leveling legs. Turn the leveling legs clockwise to raise the refrigerator or counter-clockwise to lower it. Ensure the refrigerator is level to prevent vibrations and ensure proper door sealing.
4. Door Reversal (Optional)
The door hinges are reversible, allowing the door to open from either the left or right side. Refer to the detailed instructions in the full PDF manual for this procedure, as it involves removing and reattaching hardware.
5. Initial Power-On
After positioning and leveling, plug the refrigerator into a dedicated 120V AC outlet. Allow the appliance to stand for at least 2-4 hours before loading food to allow the refrigerant to settle and the interior to cool down.
Operating Instructions
1. Temperature Control
The refrigerator's temperature is controlled by a thermostat dial located inside the fresh food compartment. Settings range from '0' (OFF) to '7' (COLDEST). A setting of '4' is generally recommended for normal use.
Figure 3: Close-up of the internal thermostat dial. The dial allows adjustment of the cooling intensity from 0 to 7.
- Turn the dial towards '7' for colder temperatures.
- Turn the dial towards '1' for warmer temperatures.
- '0' turns off the cooling function, but the appliance remains powered.
2. Food Storage
Arrange food items to allow for proper air circulation. Avoid overcrowding the shelves.
Figure 4: The door features a dedicated compartment designed to securely hold 2-liter bottles and other tall items.
Figure 5: Integrated can storage racks on the door, designed to hold up to 5 standard beverage cans for easy access.
3. Freezer Compartment
The half-width freezer compartment is suitable for storing small frozen items and making ice. An ice cube tray is included.
Figure 6: The compact freezer compartment, shown here storing a small frozen pizza, is ideal for limited frozen storage needs.
4. Adjustable Shelves
The glass shelves can be adjusted to different heights to accommodate various item sizes. To adjust, carefully lift the shelf and slide it out, then reposition it on the desired support rails.
Care and Maintenance
1. Cleaning
- Always unplug the refrigerator before cleaning.
- Wash the interior with a warm water and baking soda solution (2 tablespoons of baking soda to 1 quart of water).
- Clean the door gasket with mild soap and water to ensure a proper seal.
- Wipe the exterior with a mild detergent and warm water, then dry thoroughly.
- Do not use harsh chemicals, abrasive cleaners, or scouring pads.
2. Manual Defrosting
This refrigerator features a manual defrost system. Frost will accumulate on the freezer compartment walls. When frost buildup reaches approximately 1/4 inch (0.6 cm) thick, defrost the unit:
- Turn the thermostat to '0' (OFF) and unplug the unit.
- Remove all food from the refrigerator and freezer compartments.
- Leave the door open to allow frost to melt naturally. Place towels at the bottom to absorb water.
- Once defrosted, clean and dry the interior thoroughly.
- Plug the unit back in and reset the thermostat. Allow it to cool for a few hours before returning food.
Do not use sharp objects or heating devices to remove frost, as this can damage the cooling system.
3. Power Outage
In case of a power outage, keep the refrigerator door closed to maintain internal temperature for as long as possible. Avoid opening the door unnecessarily.
4. Moving the Refrigerator
When moving the appliance, secure all loose items inside. Transport the unit in an upright position if possible. After moving, allow it to stand for at least 2-4 hours before plugging it in.
Troubleshooting Guide
Before contacting customer service, review this section for common issues and solutions.
| Problem | Possible Cause | Solution |
|---|---|---|
| Refrigerator does not operate. | Not plugged in; circuit breaker tripped; thermostat set to '0'. | Ensure plug is secure; check circuit breaker; reset thermostat to a higher setting. |
| Temperature is too warm. | Thermostat set too low; door opened too frequently; warm food placed inside; poor air circulation. | Adjust thermostat to a colder setting; minimize door openings; allow hot food to cool before storing; ensure adequate clearance around the unit. |
| Temperature is too cold. | Thermostat set too high. | Adjust thermostat to a warmer setting. |
| Excessive frost buildup in freezer. | Door not sealed properly; frequent door openings; high humidity. | Check door gasket for damage or obstruction; ensure door is fully closed; perform manual defrost. |
| Unusual noises. | Unit not level; items vibrating inside; normal compressor operation. | Adjust leveling legs; reposition items inside; gurgling or humming sounds are normal. |
Product Specifications
Below are the technical specifications for the Commercial Cool CCR45B model:
| Feature | Detail |
|---|---|
| Brand Name | Commercial Cool |
| Model Info | CCR45B |
| Item Weight | 54 pounds |
| Product Dimensions | 20.3 x 22.25 x 32.1 inches (D x W x H) |
| Capacity | 4.5 Cubic Feet |
| Annual Energy Consumption | 253 Kilowatt Hours Per Year |
| Refrigerator Fresh Food Capacity | 3.8 Cubic Feet |
| Freezer Capacity | 0.4 Cubic Feet |
| Installation Type | Freestanding |
| Form Factor | Compact |
| Special Features | Adjustable Shelves |
| Color | Black |
| Voltage | 120 Volts |
| Defrost System | Manual |
| Door Hinges | Reversible |
| Shelf Type | Glass shelves, recessed |
| Number of Shelves | 3 |
| Material Type | Aluminum |
| Included Components | 4.5 Cu. Ft. Mini Fridge |
Figure 7: Dimensional drawing of the Commercial Cool CCR45B, showing height (32.1"), width (22.25"), and depth (20.3").
Figure 8: U.S. Government EnergyGuide label for the Commercial Cool CCR45B, indicating an estimated yearly energy cost of $30 and 253 kWh annual electricity use.
Warranty and Customer Support
For warranty information or technical assistance, please refer to the warranty card included with your product or visit the official Commercial Cool website. You can also find additional support and product information by visiting the Commercial Cool Store on Amazon.
