Introduction
This manual provides detailed instructions for the installation, operation, and maintenance of your Nicor 17504 6-inch Recessed Lighting Baffle Trim. This product is designed to enhance your lighting setup by providing an attractive and functional finish for 6-inch recessed housings. It features durable steel construction and an open aperture for even light distribution.
Important Safety Information
Please read all instructions carefully before installation. Failure to do so may result in electric shock, fire, or other hazards that could cause injury or property damage. Always consult a qualified electrician if you are unsure about any part of the installation process.
- Disconnect power at the circuit breaker before installation or servicing.
- Ensure all electrical connections comply with local codes and ordinances, as well as the National Electric Code (NEC).
- Do not install this product in wet locations unless specifically rated for such use. This trim is rated for outdoor covered patios.
- Use only with compatible 6-inch recessed housings.
- Do not exceed the maximum wattage rating of 75 Watts for the light bulb.
Package Contents
Verify that all components are present before beginning installation.
- 1 x Nicor 17504 6-inch Recessed Baffle Trim (Black baffle with White trim ring)
- 2 x Coil Springs (pre-attached to the trim)
Note: Light bulbs and recessed housing are not included and must be purchased separately.
Setup and Installation
The Nicor 17504 trim is designed for easy installation into existing or new 6-inch recessed housings.
Tools Required (Not Included):
- Light bulb (PAR30 or BR30, up to 75W)
- Recessed housing (6-inch compatible)
Installation Steps:
- Turn Off Power: Before starting, ensure the power to the recessed lighting circuit is turned off at the circuit breaker to prevent electrical shock.
- Prepare Housing: If installing into a new housing, ensure it is properly installed and wired according to its own instructions and local electrical codes. If replacing an old trim, carefully remove the old trim and bulb.
- Insert Light Bulb: Screw the appropriate PAR30 or BR30 light bulb (up to 75W) into the socket within the recessed housing.
- Attach Trim: Locate the coil springs on the Nicor 17504 trim. Align these springs with the spring receptacles inside the 6-inch recessed housing.
- Secure Trim: Gently push the trim upwards into the recessed housing until the springs fully engage and hold the trim flush against the ceiling. Ensure the trim ring is evenly seated.
- Restore Power: Once the trim is securely in place, turn the power back on at the circuit breaker. Test the light to ensure proper operation.
Image: The Nicor 17504 trim shown installed within a standard 6-inch recessed lighting housing. This illustrates how the trim fits flush with the ceiling.
Image: An illustrative diagram detailing the relationship between the recessed housing, the Nicor 17504 trim, and the light bulb. The housing is installed in the ceiling, the trim fits below it, and the light bulb screws into the housing's socket.
Operating Instructions
The Nicor 17504 is a passive trim component. Its operation is directly tied to the light bulb and the recessed housing it is installed in. Once installed, the trim functions by directing the light from the bulb through its open aperture, providing a finished look to your recessed lighting fixture.
- To turn the light on or off, use the wall switch connected to the recessed lighting circuit.
- To change the light bulb, carefully pull down the trim to disengage the coil springs, unscrew the old bulb, replace with a new one (observing wattage limits), and re-install the trim.
Maintenance
The Nicor 17504 recessed baffle trim requires minimal maintenance.
- Cleaning: To clean the trim, ensure power is off at the circuit breaker. Use a soft, dry, or slightly damp cloth to wipe down the surface. Do not use abrasive cleaners or solvents, as these may damage the finish.
- Inspection: Periodically inspect the trim for any signs of damage or loose connections. If any issues are found, disconnect power and address them promptly.
Troubleshooting
If you encounter issues with your Nicor 17504 trim, consider the following common solutions:
| Problem | Possible Cause | Solution |
|---|---|---|
| Trim does not sit flush with ceiling. | Springs not fully engaged or misaligned. | Gently pull down the trim and re-align the coil springs with the housing receptacles. Push firmly until the trim snaps into place. |
| Light not turning on after trim installation. | Power off, faulty bulb, or incorrect wiring of housing. | Check circuit breaker. Ensure light bulb is screwed in tightly and is functional. Verify housing wiring is correct (consult an electrician if unsure). |
| Trim appears loose. | Springs not properly secured or damaged. | Remove trim and inspect springs for damage. Re-install, ensuring springs are fully engaged. If springs are damaged, contact Nicor support for replacement parts. |
Specifications
| Feature | Detail |
|---|---|
| Model Number | 17504 |
| Brand | Nicor |
| Product Type | Recessed Lighting Baffle Trim |
| Size | 6 Inches (for 6-inch recessed housings) |
| Color | Black baffle with White trim ring |
| Material | Metal (Durable Steel Construction) |
| Compatible Bulb Types | PAR30 or BR30 |
| Max Wattage | 75 Watts |
| Product Dimensions (W x H) | 7.1" x 2.5" |
| Aperture Diameter | 6 Inches |
| Item Weight | 4 ounces |
| Indoor/Outdoor Usage | Outdoor (Covered Patios) |
Image: A technical drawing illustrating the key dimensions of the Nicor 17504 recessed lighting trim, including its 7.1-inch overall diameter, 6-inch aperture, and 2.5-inch height.
Image: A clear front view of the Nicor 17504 recessed lighting baffle trim, showcasing its black baffle interior and white outer trim ring.
Image: A view of the Nicor 17504 trim from the top-rear, showing the two coil springs used for installation into the recessed housing.
Image: A side profile view of the Nicor 17504 trim, highlighting its compact 2.5-inch height.
Warranty and Support
Warranty: The Nicor 17504 Recessed Lighting Baffle Trim is protected by Nicor's 1-year limited warranty. This warranty covers defects in materials and workmanship under normal use.
Customer Support: For technical assistance, warranty claims, or to inquire about replacement parts, please contact Nicor customer service. Refer to the official Nicor website or product packaging for the most current contact information.
You can also visit the Nicor Store on Amazon for more product information and support resources.
